Abstract
The properties of aluminum foil treated with titanium ions in the application to the destruction of prometryn are considered. The samples were obtained by ion bombardment (titanium ions in a nitrogen plasma) of aluminum at energies of 20 keV. The composition of samples surface and the effect of calcination temperature and process duration were determined by XRD, SEM and EDXS. The depth distribution of ions was simulated using the RIO software. It is shown that ionic implantation leads to the formation nanoscale layer of the implant on the surface aluminum foil. Increasing the calcination temperature and its duration changes the sample’s activity and can be explained by the influence of the ratio between the nitride, oxynitride and oxide phases of titanium. The formation and decomposition of these phases on the surface explains the appearance of the maximum activity in the decomposition of prometryn under ultraviolet irradiation for all samples. Thus, the use of the obtained samples for neutralizing herbicides (for example, prometryn) under ultraviolet irradiation is promising and relevant.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Abd-Elsalam KA, Zahid M (2021) Nanomaterials for detection, degradation, and adsorption of pesticides from water and wastewater. Aquananotechnology 15:325–346. https://doi.org/10.1016/B978-0-12-821141-0.00003-3
Ang YS, Tinia IMG, Suraya AR (2010) Immobilisation of titanium dioxide onto supporting materials in heterogeneous photocatalysis. A review. Appl Catal A General. 389:1–8. https://doi.org/10.1016/j.apcata.2010.08.053
Ayieko CO, Musembi RJ, Ogacho AA et al (2015) Controlled texturing of aluminum sheet for solar energy applications. Adv Mater Phys Chem 5:458–466. https://doi.org/10.4236/ampc.2015.511046
Borio O, Gawlik BM, Bellobono IR et al (1998) Photooxidation of prometryn and prometon in aqueous solution by hydrogen peroxide on photocatalytic membranes immobilising titanium dioxide. Chemosphere 37:975–989. https://doi.org/10.1016/S0045-6535(98)00099-X
Chena J, Li Y, Li Z et al (2004) Production of COx-free hydrogen and nanocarbon by direct decomposition of undiluted methane on Ni–Cu–alumina catalysts. Appl Catal A 269:179–186. https://doi.org/10.1016/j.apcata.2004.04.016
Cheng H, Zhang R, Chen G (2021) Sorption of four s-triazine herbicides on natural zeolite and clay mineral materials with microporosity. Fundam Res 1(3):285–295. https://doi.org/10.1016/j.fmre.2021.03.004
Chen-Yan Hu, Zhang J-C, Lin Y-L et al (2021) Degradation kinetics of prometryn and formation of disinfection by-products during chlorination. Chemosphere 276:130089. https://doi.org/10.1016/j.chemosphere.2021.130089
Czeppe T., Korznikova E, Ozga P., et al. Composition and Microstructure of the AlMultilayer Graphene Composites Achieved by the Intensive Deformation Acta Physica Polonica Seriesa
Đikić D (2014) Prometryn. encyclopedia of toxicology, 3rd edn. Academic Press, Cambridge
Dlamini MC, Maubane-Nkadimeng MS, Moma JA (2021) The use of TiO2/clay heterostructures in the photocatalytic remediation of water containing organic pollutants: a review. J Environ Chem Eng 9:106546. https://doi.org/10.1016/j.jece.2021.106546
Durme JV, Dewulf J, Leys C et al (2008) Combining non-thermal plasma with heterogeneous catalysis in waste gas treatment: a review. Appl Catal B 78:324–333. https://doi.org/10.1016/j.apcatb.2007.09.035
Evgenidou E, Bizani E, Christophoridis C et al (2007) Heterogeneous photocatalytic degradation of prometryn in aqueous solutions under UV–Vis irradiation. Chemosphere 68:1877–1882. https://doi.org/10.1016/j.chemosphere.2007.03.012
Fenoll J, Hellín P, Martínez CM et al (2012) Semiconductor-sensitized photodegradation of s-triazine and chloroacetanilide herbicides in leaching water using TiO2 and ZnO as catalyst under natural sunlight. J Photochem Photobiol, A 238:81–87. https://doi.org/10.1016/j.jphotochem.2012.04.017
Gusain R, Gupta K, Joshi P et al (2019) Adsorptive removal and photocatalytic degradation of organic pollutants using metal oxides and their composites: a comprehensive review. Adv Coll Interface Sci 272:102009. https://doi.org/10.1016/j.cis.2019.102009
Hiroshi I, Yuka W, Kazuhito H (2003) Carbon-doped anatase TiO2 powders as a visible-light sensitive photocatalyst. Chem Lett 32(8):772–773. https://doi.org/10.1246/cl.2003.772
Honcharov V, Zazhigalov V, Sawlowicz Z et al (2017) Structural, catalytic, and thermal properties of stainless steel with nanoscale metal surface layer. In: Fesenko O, Yatsenko L (eds) Nanophysics, nanomaterials, interface studies, and applications, vol 195. Springer, Cham, pp 355–364
June KT, Jeong-Gil K, Ho-Young L et al (2014) Modification of optical and mechanical surface properties of sputter-deposited aluminum thin films through ion implantation. Int J Precis Eng Manuf 15(5):889–894. https://doi.org/10.1007/s12541-014-0413-y
Kalin BA (2001) Radiatsionno-puchkovyye tekhnologii obrabotki konstruktsionnykh materialov. Fiz Khim Obrab Mater 4:5–16
Lin X, Rong F, Fu D, Yuan C (2012) Enhanced photocatalytic activity of fluorine doped TiO2 by loaded with Ag for degradation of organic pollutants. Powder Tech 219:173–178. https://doi.org/10.1016/j.powtec.2011.12.037
Liu CJ, Vissokov G, Jang BWL (2002) Catalyst preparation using plasma technologies. Catal Today 72:173–184. https://doi.org/10.1016/S0920-5861(01)00491-6
Magali BK, Sven GJ (1996) A review of the use of plasma techniques in catalyst preparation and catalytic reactions. Appl Catal A 147:1–21
Malato S, Fernandez-Ibanez P, Maldonado, et al (2009) Decontamination and disinfection of water by solar photocatalysis: recent overview and trends. Catal Today 147:1–59. https://doi.org/10.1016/j.cattod.2009.06.018
Rachel A, Subrahmanyan M, Boule P (2002) Comparison of photocatalytic efficiencies of TiO2 in suspended and immobilised form for photocatalytic degradation of nitrobenzenesulfonic acids. Appl Catal B Environm 37:301–308. https://doi.org/10.1016/S0926-3373(02)00007-3
Rana AK, Mishra YK, Gupta VK et al (2021) Sustainable materials in the removal of pesticides from contaminated water: perspective on macro to nanoscale cellulose. Sci Total Environ 797:149129. https://doi.org/10.1016/j.scitotenv.2021.149129
Rubira RJG, Furini LN, Constantino CJL et al (2021) SERS detection of prometryn herbicide based on its optimized adsorption on Ag nanoparticles. Vib Spectrosc 114:103245. https://doi.org/10.1016/j.vibspec.2021.103245
Sanzhak O, Goncharov V, Azimov F et al (2018) Preparation of new photocatalytic materials using ion implantation method. Mol Cryst Liq Cryst 671(1):156–163. https://doi.org/10.1080/15421406.2018.1542098
Sanzhak OV, Brazhnyk DV, Honcharov VV et al (2020) Ti-implanted nanoscale layers for the chloramphenicol photocatalytic decomposition. In: Fesenko O, Yatsenko L (eds) Nanomaterials and Nanocomposites, Nanostructure Surfaces, and Their Application, vol 263. Springer, Cham, pp 103–105
Thompson TL, Yates JT (2006) Surface science studies of the pho-toactivation of TiO2 new photochemical processes. Chem Rev 106:4428–4453. https://doi.org/10.1021/cr050172k
Wang H, Zhang S, Yu D et al (2011) Surface modification of (Tb, Dy)Fe2 alloy by nitrogen ion implantation. J Rare Earths 29(9):878–882. https://doi.org/10.1016/s1002-0721(10)60559-5
Wang Z, Sun X, Shaoguo Ru et al (2022) Effects of co-exposure of the triazine herbicides atrazine, prometryn and terbutryn on Phaeodactylum tricornutum photosynthesis and nutritional. Sci Total Environ 807:150609. https://doi.org/10.1016/j.scitotenv.2021.150609
Zazhigalov VA, Honcharov VV (2014) Formirovaniye nanorazmernogo pokrytiya na stali 12H18N10T pri ionnoy implantatsii. Metallofiz Noveishie Tekhnol 6(36):757–766
Zazhigalov VA, Honcharov VV, Bacherikova IV, Socha R, Gurgul J (2018) Formation of nanodimension layer of catalytically active metals on stainless stail surface by ionic implantation. Theor Experim Chem 34(2):128–137. https://doi.org/10.1007/978-3-030-74741-1
Acknowledgements
The investigations were realized with the partial financial support of NAS of Ukraine Fundamental Programme “Fine Chemicals”, Project 20-(14-16).
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
Sanzhak O.V., Brazhnyk D.V. , Kiziun O.V., Honcharov V.V., Zazhigalov V.A declare that they have no competing interests.
Informed consent
The authors confirm independence from the sponsors; the content of the article has not been influenced by the sponsors. Informed consent was taken.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Sanzhak, O.V., Brazhnyk, D.V., Kiziun, O.V. et al. Photocatalytic destruction of prometryn on Ti-containing aluminum foil nanocomposites. Appl Nanosci 13, 4913–4919 (2023). https://doi.org/10.1007/s13204-022-02649-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13204-022-02649-6