Abstract
The profile of reducing sugars developed during each stage of the postharvest of cocoa beans is an important quality index; these sugars are found to be one of the main precursors of flavor and neoformed compounds. However, its quantification after extraction from different parts of the bean is a challenge due to the complexity of the matrix. The primary aim of this study was to track the formation of reducing sugars and mannitol in samples obtained from various steps of the fermentation and drying processes of cocoa beans by validating a rapid matrix-corrected chromatographic method utilizing a corona-charged aerosol detector for improved sensitivity. The analytes were extracted from ground cocoa beans by solid phase extraction without a defatting step (20 mg raw fermented and 10 mg dried). The experimental variables influencing the effective detection were evaluated at different temperatures and signal filtering levels. Method validation studies showed an average recovery between 77.8 and 120% for fermented cocoa and between 79.6 and 117.7% for dried cocoa. A linear response was achieved for fructose, glucose, sucrose, and mannitol for a concentration range of 0.1–40 mg/L, and maltose showed linearity in the range of 0.1–70 mg/L. Regression coefficients (R) were 0.9991, 0.9993, 0.9992, 0.9995 and 0.9994, respectively. This method was successfully applied to a clone mix of cocoa from Antioquia, Colombia, to confirm the hydrolysis reaction of sucrose into glucose and fructose during fermentation and drying. A quality indicator of an efficient postharvest process in this study was determined to be a glucose percentage of 0.66% w/w and a fructose percentage of 1.46% w/w, which were higher than the values reported by other studies.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Araujo QR, Fernandes CAF, Ribeiro DO et al (2014) Cocoa quality index—a proposal. Food Control 46:49–54. https://doi.org/10.1016/j.foodcont.2014.05.003
Badui Dergal S (2006) Química de los alimentos, Cuarta. Pearson Educación de México, S.A. de C.V., Naucalpan de Juárez, Cuarta
Bello Gil D, Carrera Bocourt E, Díaz Maqueira Y (2006) Determinación de azúcares reductores totales en jugos mezclados de caña de azúcar utilizando el método del ácido 3,5 dinitrosalicílico. IICIDCA Sobre los Deriv la Caña Azúcar XL:45–50
Bedoya C (2016) Metodologías para el análisis bromatológico, físico y químico del cacao fermentado y seco, dentro del marco normativo internacional. Corporación Universitaria Lasallista
Calull M, Marcé RM, Borrull F (1992) Determination of carboxylic acids, sugars, glycerol and ethanol in wine and grape must by ion-exchange high-performance liquid chromatography with refractive index detection. J Chromatogr A 590:215–222. https://doi.org/10.1016/0021-9673(92)85384-6
Counet C, Ouwerx C, Rosoux D, Collin S (2004) Relationship between procyanidin and flavor contents of cocoa liquors from different origins. J Agric Food Chem 52:6243–6249. https://doi.org/10.1021/jf040105b
Crafack M, Keul H, Eskildsen CE et al (2014) Impact of starter cultures and fermentation techniques on the volatile aroma and sensory profile of chocolate. Food Res Int 63:306–316. https://doi.org/10.1016/j.foodres.2014.04.032
Magalhães I, Gabriela M, Miguel P, Ferreira W, Ribeiro D, Freitas R (2013) Microbial succession and the dynamics of metabolites and sugars during the fermentation of three different cocoa (Theobroma cacao L.) hybrids. Food Res Int 54:9–17. https://doi.org/10.1016/j.foodres.2013.06.001
de Oliveira TB, Rogero MM, Genovese MI (2015) Poliphenolic-rich extracts from cocoa (Theobroma cacao L.) and cupuassu (Theobroma grandiflorum Willd. Ex Spreng. K. Shum) liquors: a comparison of metabolic effects in high-fat fed rats. PharmaNutrition 3:20–28. https://doi.org/10.1016/j.phanu.2015.01.002
Dionex TS (2013) Charged aerosol detectors. Corona Veo RS. Operating Instructions, Bartlesville
European Comission Directorate-General for Health and Food Safety (2015) SANTE/11945/2015. Guidance document on analytical quality control and method validation procedures for pesticides residues analysis in food and feed. Leg Deposit, pp 1–42
Frauendorfer F, Schieberle P (2006) Identification of the key aroma compounds in cocoa powder based on molecular sensory correlations. J Agric Food Chem 54:5521–5529. https://doi.org/10.1021/jf060728k
Frauendorfer F, Schieberle P (2008) Changes in key aroma compounds of Criollo cocoa beans during roasting. J Agric Food Chem 56:10244–10251. https://doi.org/10.1021/jf802098f
Gil M, Orrego F, Cadena E et al (2016) Effect of pectin lyase enzyme on fermentation and drying of cocoa (Theobroma cacao L.): an alternative to improve raw material in the industry of chocolate. Food Nutr Sci 3:215–226. https://doi.org/10.4236/fns.2016.74023
International Cocoa Organization (2014) The cocoa market situation. Economic committee. In: EC/4/2. International Cocoa Organization, Wembley, pp 1–18
International Conference on Harmonisation Harmonized Tripartite Guideline (2005) Validation of analytical procedure: text and methodologies. Q2(R1)
Ioannone F, Di Mattia CD, De Gregorio M et al (2015) Flavanols, proanthocyanidins and antioxidant activity changes during cocoa (Theobroma cacao L.) roasting as affected by temperature and time of processing. Food Chem 174:256–262. https://doi.org/10.1016/j.foodchem.2014.11.019
Jinap MS, Nazamid S, Jamilah B (2002) Activation of remaining key enzymes in dried under-fermented cocoa beans and its effect on aroma precursor formation. Food Chem 78:407–417. https://doi.org/10.1016/S0308-8146(02)00120-6
Kongor JE, Hinneh M, Van de Walle D et al (2016) Factors influencing quality variation in cocoa (Theobroma cacao) bean flavour profile—a review. Food Res Int 82:44–52. https://doi.org/10.1016/j.foodres.2016.01.012
Krähmer A, Engel A, Kadow D et al (2015) Fast and neat—determination of biochemical quality parameters in cocoa using near infrared spectroscopy. Food Chem 181:152–159. https://doi.org/10.1016/j.foodchem.2015.02.084
Lacerda Ramos C, Ribeiro Dias D, da Cruz Gabriela, Pedrozo Miguel M, Freitas Schwan R (2014) UFLA CA11 inoculation on microbial communities and volatile compounds of cocoa fermentation. Food Res Int 64:908–918. https://doi.org/10.1016/j.foodres.2014.08.033
Lefeber T, Gobert W, Vrancken G, Camu N, De Vuyst L (2011) Dynamics and species diversity of communities of lactic acid bacteria and acetic acid bacteria during spontaneous cocoa bean fermentations in vessels. Food Microbiol 28:457–464. https://doi.org/10.1016/j.fm.2010.10.010
Ma C, Sun Z, Chen C et al (2014) Simultaneous separation and determination of fructose, sorbitol, glucose and sucrose in fruits by HPLC-ELSD. Food Chem 145:784–788. https://doi.org/10.1016/j.foodchem.2013.08.135
Magnusson LE, Risley DS, Koropchak JA (2015) Aerosol-based detectors for liquid chromatography. J Chromatogr A 1421:68–81. https://doi.org/10.1016/j.chroma.2015.07.045
María C, Carles C, Gregorio E et al (2001) Métodos en Bioanálisis. In: Validación de Métodos Analíticos, pp 209–248
Márquez Sillero I (2014) Nuevas aplicaciones de detectores analíticos no convencionales basados en procesos de ionización. Universidad de Córdoba, Córdoba
Márquez-Sillero I, Cárdenas S, Valcárcel M (2013) Comparison of two evaporative universal detectors for the determination of sugars in food samples by liquid chromatography. Microchem J 110:629–635. https://doi.org/10.1016/j.microc.2013.07.008
Niquet-Léridon C, Tessier FJ (2011) Quantification of Nε-carboxymethyl-lysine in selected chocolate-flavoured drink mixes using high-performance liquid chromatography–linear ion trap tandem mass spectrometry. Food Chem 126:655–663. https://doi.org/10.1016/j.foodchem.2010.10.111
Official Methods of Analysis (2012) Cacao bean its products. In: Official methods of analysis of AOAC international, 19th edn. Gaithersburg, pp 1–17
Patras MA, Milev BP, Vrancken G, Kuhnert N (2014) Identification of novel cocoa flavonoids from raw fermented cocoa beans by HPLC-MSn. Food Res Int 63:353–359. https://doi.org/10.1016/j.foodres.2014.05.031
Rodriguez-Campos J, Escalona-Buendía HB, Orozco-Avila I et al (2011) Dynamics of volatile and non-volatile compounds in cocoa (Theobroma cacao L.) during fermentation and drying processes using principal components analysis. Food Res Int 44:250–258. https://doi.org/10.1016/j.foodres.2010.10.028
Saltini R, Akkerman R, Frosch S (2013) Optimizing chocolate production through traceability: a review of the influence of farming practices on cocoa bean quality. Food Control 29:167–187. https://doi.org/10.1016/j.foodcont.2012.05.054
Sandhya MVS, Yallappa BS, Varadaraj MC et al (2016) Inoculum of the starter consortia and interactive metabolic process in enhancing quality of cocoa bean (Theobroma cacao) fermentation. LWT Food Sci Technol 65:731–738. https://doi.org/10.1016/j.lwt.2015.09.002
Sarriá B, Martínez-López S, Sierra-Cinos JL et al (2015) Effects of bioactive constituents in functional cocoa products on cardiovascular health in humans. Food Chem 174:214–218. https://doi.org/10.1016/j.foodchem.2014.11.004
Schwan RF (2015) Cocoa and coffee fermentations. CRC Press, Boca Ratón
Teye E, Huang X, Sam-Amoah LK et al (2015) Estimating cocoa bean parameters by FT-NIRS and chemometrics analysis. Food Chem 176:403–410. https://doi.org/10.1016/j.foodchem.2014.12.042
Vázquez-Ovando A, Molina-Freaner F, Nuñez-Farfán J et al (2015) Classification of cacao beans (Theobroma cacao L.) of southern Mexico based on chemometric analysis with multivariate approach. Eur Food Res Technol 240:1117–1128. https://doi.org/10.1007/s00217-015-2415-0
Acknowledgements
Program: “Promotion of the cultivation of special cocoa in the Department of Antioquia.” Financed by Government of Antioquia—Secretary of Agriculture and Rural Development, through Science and Technology Fund (General System of Royalties) (Contracts 4600003348 and 4600003895). Scholarship for the academic formation of doctorate students supported by Colciencias-Colfuturo and Universidad Nacional de Colombia (No. 647-2015)
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Gil, M., Llano, S., Jaramillo, Y. et al. Matrix effect on quantification of sugars and mannitol developed during the postharvest of cocoa: an alternative method for traceability of aroma precursors by liquid chromatography with an evaporative detector. J Food Sci Technol 57, 210–221 (2020). https://doi.org/10.1007/s13197-019-04049-1
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13197-019-04049-1