Abstract
Low-expression levels remain a challenge in the quest to use the small laccase (rSLAC) as a viable catalyst. In this study, a recombinant Pichia pastoris strain (rSLAC-GAP-AOX) producing rSLAC under both AOX and GAP promoters (located in two different plasmids) was generated and cultivated in the presence of methanol and mixed feed (methanol:glycerol). Induction with methanol resulted in a maximum laccase activity of 1200 U/L for rSLAC-GAP-AOX which was approximately 2.4-fold higher than rSLAC-AOX and 5.1-fold higher than rSLAC-GAP. The addition of methanol:glycerol in a stoichiometric ratio of 9:1 consistently improved biomass and led to a 1.5-fold increase in rSLAC production as compared to induction with methanol alone. The rSLAC removed 95% of 5 mg/L ciprofloxacin (CIP) and 99% of 100 mg/L tetracycline (TC) in the presence of a mediator. Removal of TC resulted in complete elimination of antibacterial activity while up to 48% reduction in antibacterial activity was observed when CIP was removed. Overall, the present study highlights the effectiveness of a double promoter system in enhancing SLAC production.
Similar content being viewed by others
References
Antošová Z, Sychrová H (2016) Yeast hosts for the production of recombinant laccases: a review. Mol Biotechnol 58:93–116. https://doi.org/10.1007/s12033-015-9910-1
Becker D, Varela Della Giustina S, Rodriguez-Mozaz S et al (2016) Removal of antibiotics in wastewater by enzymatic treatment with fungal laccase – degradation of compounds does not always eliminate toxicity. Bioresour Technol 219:500–509. https://doi.org/10.1016/j.biortech.2016.08.004
Cámara E, Landes N, Albiol J et al (2017) Increased dosage of AOX1 promoter-regulated expression cassettes leads to transcription attenuation of the methanol metabolism in Pichia pastoris. Sci Rep 7:1–16. https://doi.org/10.1038/srep44302
Canales C, Altamirano C, Berrios J (2018) The growth of Pichia pastoris Mut+ on methanol–glycerol mixtures fits to interactive dual-limited kinetics: model development and application to optimised fed-batch operation for heterologous protein production. Bioprocess Biosyst Eng 41:1827–1838. https://doi.org/10.1007/s00449-018-2005-1
Cereghino GPL, Cereghino JL, Ilgen C, Cregg JM (2002) Production of recombinant proteins in fermenter cultures of the yeast Pichia pastoris. Curr Opin Biotechnol 13:329–332. https://doi.org/10.1016/S0958166902003300
Chen B, Xu W, Pan X, Lu L (2015) A novel non-blue laccase from Bacillus amyloliquefaciens: Secretory expression and characterization. Int J Biol Macromol 76:39–44. https://doi.org/10.1016/j.ijbiomac.2015.02.019
Cruz-Morató C, Ferrando-Climent L, Rodriguez-Mozaz S et al (2013) Degradation of pharmaceuticals in non-sterile urban wastewater by Trametes versicolor in a fluidized bed bioreactor. Water Res 47:5200–5210. https://doi.org/10.1016/j.watres.2013.06.007
Cruz-Morató C, Lucas D, Llorca M et al (2014) Hospital wastewater treatment by fungal bioreactor: removal efficiency for pharmaceuticals and endocrine disruptor compounds. Sci Total Environ 493:365–376. https://doi.org/10.1016/j.scitotenv.2014.05.117
De Bel E, Dewulf J, De Witte B et al (2009) Influence of pH on the sonolysis of ciprofloxacin: Biodegradability, ecotoxicity and antibiotic activity of its degradation products. Chemosphere 77:291–295. https://doi.org/10.1016/j.chemosphere.2009.07.033
De Cazes M, Belleville MP, Petit E et al (2014) Design and optimization of an enzymatic membrane reactor for tetracycline degradation. Catal Today 236:146–152. https://doi.org/10.1016/j.cattod.2014.02.051
De Lima Perini J, e Silva B, Tonetti A, Nogueira R (2017) Photo-Fenton degradation of the pharmaceuticals ciprofloxacin and fluoxetine after anaerobic pre-treatment of hospital effluent. Environ Sci Pollut Res 24:6233–6240. https://doi.org/10.1007/s11356-016-7416-4
Deblonde T, Cossu-leguille C, Hartemann P (2015) Emerging pollutants in wastewater: a review of the literature. Int J Hyg Environ Health 214:442–448. https://doi.org/10.1016/j.ijheh.2011.08.002
Dubé E, Shareck F, Hurtubise Y et al (2008) Homologous cloning, expression, and characterisation of a laccase from Streptomyces coelicolor and enzymatic decolourisation of an indigo dye. Appl Microbiol Biotechnol 79:597–603. https://doi.org/10.1007/s00253-008-1475-5
Fan L, Zhao M, Wang Y (2015) Expression of CotA laccase in Pichia pastoris and its electrocatalytic sensing application for hydrogen peroxide. Appl Microbiol Biotechnol 99:9483–9493. https://doi.org/10.1007/s00253-015-6720-0
Gidijala L, Uthoff S, Kampen SJ et al (2018) Presence of protein production enhancers results in significantly higher methanol-induced protein production in Pichia pastoris. Microb Cell Fact 17:1–11. https://doi.org/10.1186/s12934-018-0961-4
Hellwig S, Emde F, Raven NPG et al (2001) Analysis of single-chain antibody production in Pichia pastoris using on-line methanol control in fed-batch and mixed-feed fermentations. Biotechnol Bioeng 74:344–352. https://doi.org/10.1002/bit.1125
Holmes WJ, Darby RAJ, Wilks MDB et al (2009) Developing a scalable model of recombinant protein yield from Pichia pastoris: the influence of culture conditions, biomass and induction regime. Microb Cell Fact 8:1–14. https://doi.org/10.1186/1475-2859-8-35
Inan M, Chiruvolu V, Eskridge KM et al (1999) Optimization of temperature-glycerol-pH conditions for a fed-batch fermentation process for recombinant hookworm (Ancylostoma caninum) anticoagulant peptide (AcAP-5) production by Pichia pastoris. Enzyme Microb Technol 24:438–445. https://doi.org/10.1016/S0141-0229(98)00161-6
Jin X, Yu X, Zhu G et al (2016) Conditions optimizing and application of laccase-mediator system (LMS) for the laccase-catalyzed pesticide degradation. Sci Rep 6:1–7. https://doi.org/10.1038/srep35787
Karbalaei M, Rezaee SA, Farsiani H (2020) Pichia pastoris: a highly successful expression system for optimal synthesis of heterologous proteins. J Cell Physiol 235:5867–5881. https://doi.org/10.1002/jcp.29583
Kazemali MR, Majidzadeh K, Sardari S et al (2016) Enhanced truncated-t-PA (CT-b) expression in high-cell-density fed-batch cultures of Pichia pastoris through optimization of a mixed feeding strategy by response surface methodology. Bioprocess Biosyst Eng 39:565–573. https://doi.org/10.1007/s00449-016-1538-4
Krapac IG, Koike S, Meyer MT et al (2005) Long-term monitoring of the occurrence of antibiotic residues and antibiotic resistance in groundwater near swine confinement facilities. Rep CSREES Proj 35(2001):102–10774
Kusari S, Prabhakaran D, Lamshöft M, Spiteller M (2009) In vitro residual anti-bacterial activity of difloxacin, sarafloxacin and their photoproducts after photolysis in water. Environ Pollut 157:2722–2730. https://doi.org/10.1016/j.envpol.2009.04.033
Lien L, Hoa N, Chuc N et al (2016) Antibiotics in wastewater of a rural and an urban hospital before and after wastewater treatment, and the relationship with antibiotic use — a one year study from Vietnam. Int J Environ Res Public Health 13:588. https://doi.org/10.3390/ijerph13060588
Lindsey M, Meyer M, Thurman E (2001) Analysis of trace levels of sulfonamide and tetracycline antimicrobials in groundwater and surface water using solid-phase extraction and liquid chromatography/mass spectrometry. Anal Chem 73:4640–4646
Liu WC, Inwood S, Gong T et al (2019) Fed-batch high-cell-density fermentation strategies for Pichia pastoris growth and production. Crit Rev Biotechnol 39:258–271. https://doi.org/10.1080/07388551.2018.1554620
Looser V, Bruhlmann B, Bumbak F et al (2014) Cultivation strategies to enhance productivity of Pichia pastoris: a review. Biotechnol Adv 33:1177–1193. https://doi.org/10.1016/j.biotechadv.2015.05.008
Lu L, Wang TN, Xu TF et al (2013) Cloning and expression of thermo-alkali-stable laccase of Bacillus licheniformis in Pichia pastoris and its characterization. Bioresour Technol 134:81–86. https://doi.org/10.1016/j.biortech.2013.02.015
Majumdar S, Lukk T, Solbiati JO et al (2014) Roles of small laccases from Streptomyces in lignin degradation. Biochemistry 53(24):4047–4058
Marco-Urrea E, Pérez-Trujillo M, Vicent T, Caminal G (2009) Ability of white-rot fungi to remove selected pharmaceuticals and identification of degradation products of ibuprofen by Trametes versicolor. Chemosphere 74:765–772. https://doi.org/10.1016/j.chemosphere.2008.10.040
McGrew JT, Leiske D, Dell B et al (1997) Expression of trimeric CD40 ligand in Pichia pastoris: use of a rapid method to detect high-level expressing transformants. Gene 187:193–200. https://doi.org/10.1016/S0378-1119(96)00747-0
Murugesan K, Chang YY, Kim YM, et al (2010) Enhanced transformation of triclosan by laccase in the presence of redox mediators. Water Res 44:298-308.
Öztürk S, Ergün BG, Çalık P (2017) Double promoter expression systems for recombinant protein production by industrial microorganisms. Appl Microbiol Biotechnol 101:7459–7475. https://doi.org/10.1007/s00253-017-8487-y
Pan LJ, Li J, Li CX et al (2018) Study of ciprofloxacin biodegradation by a Thermus sp. isolated from pharmaceutical sludge. J Hazard Mater 343:59–67. https://doi.org/10.1016/j.jhazmat.2017.09.009
Panula-Perälä J, Vasala A, Karhunen J et al (2014) Small-scale slow glucose feed cultivation of Pichia pastoris without repression of AOX1 promoter: Towards high throughput cultivations. Bioprocess Biosyst Eng 37:1261–1269. https://doi.org/10.1007/s00449-013-1098-9
Parashar D, Satyanarayana T (2016) Enhancing the production of recombinant acidic α-amylase and phytase in Pichia pastoris under dual promoters [constitutive (GAP) and inducible (AOX)] in mixed fed batch high cell density cultivation. Process Biochem 51:1315–1322. https://doi.org/10.1016/j.procbio.2016.07.027
Paul T, Dodd MC, Strathmann TJ (2010) Photolytic and photocatalytic decomposition of aqueous ciprofloxacin: Transformation products and residual antibacterial activity. Water Res 44:3121–3132. https://doi.org/10.1016/j.watres.2010.03.002
Pena A, Paulo M, Silva LJG et al (2010) Tetracycline antibiotics in hospital and municipal wastewaters : a pilot study in Portugal. Anal Bioanal Chem 396:2929–2936. https://doi.org/10.1007/s00216-010-3581-3
Soden DM, O’Callaghan J, Dobson ADW (2002) Molecular cloning of a laccase isozyme gene from Pleurotus sajor-caju and expression in the heterologous Pichia pastoris host. Microbiology 148:4003–4014. https://doi.org/10.1099/00221287-148-12-4003
Sprenger M, Fukuda K (2016) New mechanisms, new worries. Science 351(80):1263–1264. https://doi.org/10.1126/science.aad9450
Sturini M, Speltini A, Maraschi F et al (2012) Photodegradation of fluoroquinolones in surface water and antimicrobial activity of the photoproducts. Water Res 46:5575–5582. https://doi.org/10.1016/j.watres.2012.07.043
Suda T, Hata T, Kawai S et al (2012) Treatment of tetracycline antibiotics by laccase in the presence of 1-hydroxybenzotriazole. Bioresour Technol 103:498–501. https://doi.org/10.1016/j.biortech.2011.10.041
Sun K, Huang Q, Li S (2017) Transformation and toxicity evaluation of tetracycline in humic acid solution by laccase coupled with 1-hydroxybenzotriazole. J Hazard Mater 331:182–188. https://doi.org/10.1016/j.jhazmat.2017.02.058
Wang J, Lu L, Feng F (2017) Combined strategies for improving production of a thermo-alkali stable laccase in Pichia pastoris. Electron J Biotechnol 28:7–13. https://doi.org/10.1016/j.ejbt.2017.04.002
Wang TN, Lu L, Wang JY et al (2015) Enhanced expression of an industry applicable CotA laccase from Bacillus subtilis in Pichia pastoris by non-repressing carbon sources together with pH adjustment: recombinant enzyme characterization and dye decolorization. Process Biochem 50:97–103. https://doi.org/10.1016/j.procbio.2014.10.009
Wang Y, Wang Z, Xu Q et al (2009) Lowering induction temperature for enhanced production of polygalacturonate lyase in recombinant Pichia pastoris. Process Biochem 44:949–954. https://doi.org/10.1016/j.procbio.2009.04.019
Woo JH, Liu YY, Stavrou S, Neville DM (2004) Increasing secretion of a bivalent anti-T-cell immunotoxin by Pichia pastoris. Appl Environ Microbiol 70:3370–3376. https://doi.org/10.1128/AEM.70.6.3370-3376.2004
Wu JM, Lin JC, Chieng LL et al (2003) Combined use of GAP and AOX1 promoter to enhance the expression of human granulocyte-macrophage colony-stimulating factor in Pichia pastoris. Enzyme Microb Technol 33:453–459. https://doi.org/10.1016/S0141-0229(03)00147-9
Xia J, Wang Q, Luo Q et al (2019) Secretory expression and optimization of Bacillus pumilus CotA-laccase mutant GWLF in Pichia pastoris and its mechanism on Evans blue degradation. Process Biochem 78:33–41. https://doi.org/10.1016/j.procbio.2018.12.034
Yadav D, Ranjan B, Mchunu N et al (2018) Secretory expression of recombinant small laccase from Streptomyces coelicolor A3(2) in Pichia pastoris. Int J Biol Macromol 108:642–649. https://doi.org/10.1016/j.ijbiomac.2017.11.169
Yadav D, Ranjan B, Mchunu N et al (2021) Enzymatic treatment of phenolic pollutants by a small laccase immobilized on APTES-functionalised magnetic nanoparticles. 3 Biotech 11(6):1–12
Yang J, Lin Y, Yang X et al (2017) Degradation of tetracycline by immobilized laccase and the proposed transformation pathway. J Hazard Mater 322:525–531. https://doi.org/10.1016/j.jhazmat.2016.10.019
Yang Z, Zhang Z (2018) Engineering strategies for enhanced production of protein and bio-products in Pichia pastoris: a review. Biotechnol Adv 36:182–195. https://doi.org/10.1016/j.biotechadv.2017.11.002
Yu Y, Liu Z, Chen M et al (2020) Enhancing the expression of recombinant κ-carrageenase in Pichia pastoris using dual promoters, co-expressing chaperones and transcription factors. Biocatal Biotransformation 38:104–113. https://doi.org/10.1080/10242422.2019.1655001
Zhang W, Hywood Potter KJ, Plantz BA et al (2003) Pichia pastoris fermentation with mixed-feeds of glycerol and methanol: growth kinetics and production improvement. J Ind Microbiol Biotechnol 30:210–215. https://doi.org/10.1007/s10295-003-0035-3
Zhang XX, Zhang T (2011) Occurrence, abundance, and diversity of tetracycline resistance genes in 15 sewage treatment plants across china and other global locations. Environ Sci Technol 45:2598–2604. https://doi.org/10.1021/es103672x
Zhong Y, Yang L, Guo Y et al (2014) High-temperature cultivation of recombinant Pichia pastoris increases endoplasmic reticulum stress and decreases production of human interleukin-10. Microb Cell Fact 13:1–10. https://doi.org/10.1186/s12934-014-0163-7
Funding
The National Research Foundation (South Africa) provided financial support (Grant 105889 and 112099). Financial support was received from the Council of Scientific and Industrial Research (CSIR) for student (Deepti Yadav) scholarship.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Ethical approval
This article does not contain any studies with human participants or animals performed by any of the authors.
Disclaimer
Any opinion, findings and conclusions or recommendations expressed in this material are those of the authors, and therefore, the NRF does not accept any liability in regard thereto.
Conflict of interest
The authors declare no competing interests.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary information
Below is the link to the electronic supplementary material.
Rights and permissions
About this article
Cite this article
Yadav, D., Ranjan, B., Mchunu, N. et al. Enhancing the expression of recombinant small laccase in Pichia pastoris by a double promoter system and application in antibiotics degradation. Folia Microbiol 66, 917–930 (2021). https://doi.org/10.1007/s12223-021-00894-w
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12223-021-00894-w