Abstract
A novel butanol fermentation process was developed in which sweet sorghum bagasse (SSB) was pretreated using liquid hot water (LHW) pretreatment technique followed by enzymatic hydrolysis and butanol (acetone butanol ethanol (ABE)) fermentation. A pretreatment temperature of 200 °C resulted in the generation of a hydrolyzate that inhibited butanol fermentation. When SSB pretreatment temperature was decreased to 190 °C (0-min holding time), the hydrolyzate was successfully fermented without inhibition and an ABE productivity of 0.51 g L−1 h−1 was achieved which is comparable to the 0.49 g L−1 h−1 observed in the control fermentation where glucose was used as a feedstock. These results are based on the use of 86 g L−1 SSB solid loadings in the pretreatment reactors. We were also able to increase SSB solid loadings from 120 to 200 g L−1 in the pretreatment step (190 °C) followed by hydrolysis and butanol fermentation. As pretreatment solid loadings increased, ABE yield remained in the range of 0.38–0.46. In these studies, a maximum ABE concentration of 16.88 g L−1 was achieved. Using the LHW pretreatment technique, 88.40–96.00 % of polymeric sugars (cellulose + hemicellulose) were released in the SSB hydrolyzate. The LHW pretreatment technique does not require chemical additions and is environmentally friendly, and the hydrolyzate can be used successfully for butanol fermentation.
Similar content being viewed by others
References
Anon (2006) “BP, DuPont to develop biofuels”, article in “Feedstuffs” June 26 issue: p. 20
Anon (2006) “DuPont and BP will produce butanol for motor fuel”, article in “Industrial Bioprocessing”, July issue: 28(7)
Jones DT, Woods DR (1986) Acetone-butanol fermentation revisited. Microbiol Rev 50:484–524
Qureshi N, Maddox IS (1992) Application of novel technology to the ABE fermentation process: an economic analysis. Appl Biochem Biotechnol 34:441–448
Maddox IS, Qureshi N, Gutierrez NA (1993) Utilization of whey and process technology by clostridia. In: Woods DR (ed) The clostridia and biotechnology. Butterworth Heinemann, Boston, pp. 343–369
Ennis BM, Maddox IS (1987) The effect of pH and lactose concentration on solvent production from whey permeate using Clostridium acetobutylicum. Biotechnol Bioeng 29:329–334
Venkataramanan KP, Scholz C (2014) Integrated production of butanol from glycerol. In: Qureshi N, Hodge DB, Vertes AA (eds) Biorefineries: integrated biochemical processes for liquid biofuels. Elsevier, Amsterdam, pp. 225–233
Jesse T, Ezeji TC, Qureshi N, Blaschek HP (2002) Production of butanol from starch-based waste packing peanuts and agricultural waste. J Ind Microbiol Biotechnol 29:117–123
Qureshi N, Lolas A, Blaschek HP (2001) Soy molasses as fermentation substrate for production of butanol using Clostridium beijerinckii BA101. J Ind Microbiol Biotechnol 26:290–295
Huang H, Singh V, Qureshi N (2015) Butanol production from food waste: a novel process for producing sustainable energy and reducing environmental pollution. Biotechnol Biofuels 8:147,1–12
Claassen PA, Budde MA, Lopez-Contreras AM (2000) Acetone, butanol and ethanol production from domestic organic waste by solventogenic clostridia. J Mol Microbiol Biotechnol 2:39–44
Comwien J, Boonvithaya N, Chulaliksananukul W, Glinwong C (2015) Direct production of butanol and ethanol from cane sugar factory wastewater and cellulosic ethanol plant wastewater by Clostridium beijerinckii CG1. Energy Procedia 79:556–561
Qureshi N, Liu S, Ezeji TC (2013) Cellulosic butanol production from agricultural biomass residues: recent advances in technology. In: Lee JW (ed) Advanced biofuels and Bioproducts. Springer Science + Business Media, LLC, pp. 247–265
Qureshi N, Saha BC, Dien B, Hector R, Cotta MA (2010) Production of butanol (a biofuel) from agricultural residues: I—use of barley straw hydrolysate. Biomass Bioenergy 34:559–565
Qureshi N, Saha BC, Cotta MA, Singh V (2013) An economic evaluation of biological conversion of wheat straw to ethanol. Energy Convers Manag 65:456–462
Sipos B, Reczey J, Somorai Z, Kadar Z, Diemes D, Reczey K (2009) Sweet sorghum as feedstock for ethanol production: enzymatic hydrolysis of steam-pretreated bagasse. Appl Biochem Biotechnol 153:151–162
Gnansounou E, Dauriat A, Wayman CE (2005) Refining sweet sorghum to ethanol and sugar: economic trade-offs in the context of North China. Bioresour Technol 96:985–1002
Liu X, Lu M, Ai N, Yu F, Ji J (2012) Kinetic model analysis of dilute sulfuric acid-catalyzed hemicellulose hydrolysis in sweet sorghum bagasse for xylose production. Ind Crop Prod 38:81–86
Qureshi N, Manderson GJ (1995) Bioconversion of renewable resources into ethanol: an economic evaluation of selected hydrolysis, fermentation, and membrane technologies. Energy Sources 17:241–265
Singh V, Johnston DB, Rausch KD, Tumbleson ME (2010) Improvement in corn to ethanol production technology using Saccharomyces cerevisiae. In: Vertes A, Qureshi N, Blaschek HP, Yukawa H (eds) Biomass to biofuels: strategies for global industries. John Wiley & Sons, Chichester, pp. 187–198
Qureshi N, Singh V (2014) Process economics of renewable biorefineries: butanol and ethanol production in integrated bioprocesses from lignocellulosics and other industrial by-products. In: Qureshi N, Hodge DB, Vertes AA (eds) Biorefineries: integrated biochemical processes for liquid biofuels. Elsevier, Amsterdam, pp. 237–254
Marlatt JA, Datta R (1986) Acetone-butanol fermentation process development and economic evaluation. Biotechnol Prog 2:23–28
Corn News & Future Prices (2016) Current news on corn crops, corn prices & futures and production. Website: http://www.agweb.com/crops/corn/. Accessed 5 Jan)
Saha BC, Nichols NN, Cotta MA (2011) Ethanol production from wheat straw by recombinant Escherichia coli strain FBR5 at high solid loading. Bioresour Technol 102:10892–10897
Marchal R, Ropars M, Vandecasteele JP (1984) Direct conversion of alkali-pretreated straw using simultaneous enzymatic hydrolysis and acetone-butanol fermentation. Biotechnol Lett 6:523–528
Saha BC, Cotta MA (2006) Ethanol production from alkaline peroxide pretreated enzymatically saccharified wheat straw. Biotechnol Prog 22:449–453
Ezeji T, Blaschek HP (2008) Fermentation of dried distillers’ grains and soluble (DDGS) hydrolysate to solvents and value-added products by solventogenic clostridia. Bioresour Technol 99:5232–5242
Li B-Z, Balan V, Yuan Y-J, Dale BE (2010) Process optimization to convert forage and sweet sorghum bagasse to ethanol based on ammonia fiber (AFEX) pretreatment. Bioresour Technol 101:1285–1292
Dien BS, O’Bryan PJ, Hector RE, Iten LB, Mitchell RB, Qureshi N, Sarath G, Vogel KP, Cotta MA (2013) Conversion of switchgrass to ethanol using dilute ammonium hydroxide pretreatment: influence of ecotype and harvest maturity. Environ Technol 34:1837–1848
Shah MM, Lee YY (1992) Simultaneous saccharification and extractive fermentation for acetone/butanol production from pretreated hardwood. Appl Biochem Biotechnol 34(35):557–568
Qureshi N, Saha BC, Hector RE, Dien B, Hughes SR, Liu S, Iten L, Bowman MJ, Sarath G, Cotta MA (2010) Production of butanol (a biofuel) from agricultural residues: II-use of corn Stover and switchgrass hydrolysates. Biomass Bioenergy 34:566–571
Qureshi N, Blaschek HP (1999) Butanol recovery from model solution/fermentation broth by pervaporation: evaluation of membrane performance. Biomass Bioenergy 17:175–184
Avci A, Saha BC, Kennedy GJ, Cotta MA (2013) Dilute sulfuric acid pretreatment of corn Stover for enzymatic hydrolysis and efficient ethanol production by recombinant Escherichia coli FBR5 without detoxification. Bioresour Technol 142:312–319
Saha BC, Qureshi N, Kennedy GJ, Cotta MA (2015) Enhancement of xylose utilization from corn Stover by a recombinant Escherichia coli strain for ethanol production. Bioresour Technol 190:182–188
Ezeji TC, Qureshi N, Blaschek HP (2007) Butanol production from agricultural residues: impact of degradation products on Clostridium beijerinckii growth and butanol fermentation. Biotechnol Bioeng 97:1460–1469
Qureshi N, Maddox IS (1991) Integration of continuous production and recovery of solvents from whey permeate: use of immobilized cells of Clostridium acetobutylicum in fluidized bed bioreactor coupled with gas stripping. Bioprocess Eng 6:63–69
Ezeji TC, Qureshi N, Blaschek HP (2013) Microbial production of a biofuel (acetone-butanol-ethanol) in a continuous bioreactor: impact of bleed and simultaneous product removal. Bioprocess Biosyst Eng 36:109–116
Afschar AS, Biebl H, Schaller K, Schugerl K (1985) Production of acetone and butanol by Clostridium acetobutylicum in continuous culture with cell recycle. Appl Microbiol Biotechnol 22:394–398
Cheryan M (1986) Ultrafiltration handbook. Technomic Press Lancaster, PA
Qureshi N (2009) Solvent (acetone-butanol, AB) production. In: Schaechter M (ed) Encyclopedia of microbiology. Elsevier Ltd., Oxford, pp. 512–528
Huang W-C, Ramey DE, Yang S-T (2004) Continuous production of butanol by Clostridium acetobutylicum immobilized in a fibrous bed bioreactor. Appl Biochem Biotechnol 113-116:887–898
Dogaris I, Gkounta O, Mamma D (2012) Bioconversion of dilute-acid pretreatment sorghum bagasse to ethanol by Neurospora crassa. Appl Microbiol Biotechnol 95:541–550
Zhang J, Ma X, Yu J, Zhang X, Tan T (2011) The effects of four different pretreatments on enzymatic hydrolysis of sweet sorghum bagasse. Bioresour Technol 102:4585–4589
Shen F, Zhong Y, Saddler JN, Liu R (2011) Relatively high-substrate consistency hydrolysis of steam-pretreated sweet sorghum bagasse at relatively low cellulose loading. Appl Biochem Biotechnol 165:1024–1036
Wu L, Arakane M, Ike M, Wada M, Takai T, Gua M, Tokuyasu K (2011) Low temperature alkali pretreatment for improving enzymatic digestibility of sweet sorghum bagaasse for ethanol production. Bioresour Technol 102:4793–4799
Li J, Li S, Han B, Yu M, Li G, Jiang Y (2013) A novel cost-effective technology to convert sucrose and homocelluloses in sweet sorghum stalks into ethanol. Biotechnol Biofuels 6:174
Yu J, Zhang T, Zhong J, Zhang X, Tan T (2012) Biorefinery of sweet sorghum stem. Biotechnol Adv 30:811–816
Matsakas L, Christakopoulos P (2013) Fermentation of liquefacted hydrothermally pretreated sweet sorghum bagasse to ethanol at high-solids content. Bioresour Technol 127:202–208
Shen F, Saddler JN, Liu R, Lin L, Deng S, Zhang Y, Yang G, Xiao H, Li Y (2011) Evaluation of steam pretreatment on sweet sorghum bagasse for enzymatic hydrolysis and bioethanol production. Carbohydr Polym 86:1542–1548
Cai D, Zhang T, Zheng J, Chang Z, Wang Z, Qin P, Tan T-W (2013) Biobutanol from sweet sorghum bagasse hydrolysate by a hybrid pervaporation process. Bioresour Technol 145:97–102
Parekh SR, Parekh RS, Wayman M (1988) Ethanol and butanol production by fermentation of enzymatically saccharified SO2-prehydrolyzed lignocellulosics. Enzym Microb Technol 10:660–668
Soni BK, Das K, Ghose TK (1982) Bioconversion of agro-wastes into acetone butanol. Biotechnol Lett 4:19–22
Qureshi N, Ebener J, Ezeji TC, Dien B, Cotta MA, Blaschek HP (2008) Butanol production by Clostridium Beijerinckii BA101 part I: use of acid and enzyme hydrolysed corn fiber. Bioresour Technol 99:5915–5922
Qureshi N, Saha BC, Cotta MA (2007) Butanol production from wheat straw hydrolysate using Clostridium beijerinckii. Bioprocess Biosyst Eng 30:419–427
Qureshi N, Singh V, Liu S, Ezeji TC, Saha BC, Cotta MA (2014) Process integration for simultaneous saccharification, fermentation, and recovery (SSFR): production of butanol from corn Stover using Clostridium beijerinckii P260. Bioresour Technol 154:222–228
Maddox IS (1989) The acetone-butanol-ethanol fermentation: recent progress in technology. Biotechnol Genet Eng Rev 7:189–220
Dürre P (1998) New insights and novel developments in clostridial acetone/butanol/isopropanol fermentation. Appl Microbiol Biotechnol 49:639–648
Zverlov VV, Berezina O, Velikodvorskaya GA, Schwart WH (2006) Bacterial acetone and butanol production by industrial fermentation in the soviet union: use of hydrolyzed agricultural waste for biorefinery. Appl Microbiol Biotechnol 71:587–597
Acknowledgments
N. Qureshi would like to thank Professor David Jones (Otago University, Dunedin, New Zealand) for his generous gift of Clostridium beijerinckii P260. NQ would also like to thank Gregory Kennedy (US Department of Agriculture, Agricultural Research Service, National Center for Agricultural Utilization Research, Peoria, IL, USA) for analyzing SSB hydrolyzate samples for sugar estimation.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Ethical Standards
This work does not involve use of human subjects or animals.
Conflict of Interests
The authors do not have any conflict of interests.
Additional information
Mention of trade names or commercial products in this article is solely for the purpose of providing scientific information and does not imply recommendation or endorsement by the United States Department of Agriculture. USDA is an equal opportunity provider and employer.
Rights and permissions
About this article
Cite this article
Qureshi, N., Liu, S., Hughes, S. et al. Cellulosic Butanol (ABE) Biofuel Production from Sweet Sorghum Bagasse (SSB): Impact of Hot Water Pretreatment and Solid Loadings on Fermentation Employing Clostridium beijerinckii P260. Bioenerg. Res. 9, 1167–1179 (2016). https://doi.org/10.1007/s12155-016-9761-z
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12155-016-9761-z