Abstract
Two Co-free multi-principal-element alloys (MPEAs), viz. single-phase face-centered cubic (FCC) Fe30Ni30Mn30Cr10 and (Fe30Ni30Mn30Cr10)94Ti2Al4 (all in atomic percent) with FCC matrix containing Ni-Ti-Al enriched L12 (ordered FCC) secondary phase (γ′), have been developed and investigated. The alloys were ion irradiated at 300°C and 500°C to peak damage of 120 displacements per atom (dpa). Compared with the (Fe30Ni30Mn30Cr10)94Ti2Al4 alloy, in the Fe30Ni30Mn30Cr10 alloy, the dislocation loops were smaller, with a higher number density. The difference in loop size between the two MPEAs was attributed to the addition of Ti to the matrix, which was anticipated to lower the stacking fault energy and stabilize the faulted Frank loops. The γ′ phase showed good stability under irradiation, with no new γ′ precipitation or growth in existing precipitates. Both alloys showed similar irradiation-induced hardening at 300°C, but the (Fe30Ni30Mn30Cr10)94Ti2Al4 alloy exhibited lower irradiation-induced hardening at 500°C compared with the Fe30Ni30Mn30Cr10 alloy.
Similar content being viewed by others
References
S.J. Zinkle and G.S. Was, Acta Mater. 61, 735 (2013).
S.J. Zinkle, Advanced irradiation-resistant materials for generation IV nuclear reactors (Amsterdam: Elsevier Ltd, 2016).
M.H. Tsai and J.W. Yeh, Mater. Res. Lett. 2, 107 (2014).
D.B. Miracle and O.N. Senkov, Acta Mater. 122, 448 (2017).
Y. Shi, B. Yang, and P. Liaw, Metals (Basel) 7, 43 (2017).
Y. Zhang, T.T. Zuo, Z. Tang, M.C. Gao, K.A. Dahmen, P.K. Liaw, and Z.P. Lu, Prog. Mater Sci. 61, 1 (2014).
M.R. He, S. Wang, K. Jin, H. Bei, K. Yasuda, S. Matsumura, K. Higashida, and I.M. Robertson, Scr. Mater. 125, 5 (2016).
N.A.P.K. Kumar, C. Li, K.J. Leonard, H. Bei, and S.J. Zinkle, Acta Mater. 113, 230 (2016).
W.Y. Chen, X. Liu, Y. Chen, J.W. Yeh, K.K. Tseng, and K. Natesan, J. Nucl. Mater. 510, 421 (2018).
F. Granberg, K. Nordlund, M.W. Ullah, K. Jin, C. Lu, H. Bei, L.M. Wang, F. Djurabekova, W.J. Weber, and Y. Zhang, Phys. Rev. Lett. 116, 1 (2016).
D.S. Aidhy, C. Lu, K. Jin, H. Bei, Y. Zhang, L. Wang, and W.J. Weber, Acta Mater. 99, 69 (2015).
J.Y. He, H. Wang, H.L. Huang, X.D. Xu, M.W. Chen, Y. Wu, X.J. Liu, T.G. Nieh, K. An, and Z.P. Lu, Acta Mater. 102, 187 (2016).
Z. Fu, L. Jiang, J.L. Wardini, B.E. MacDonald, H. Wen, W. Xiong, D. Zhang, Y. Zhou, T.J. Rupert, W. Chen, and E.J. Lavernia, Sci. Adv. 4, eaat8712 (2018).
T. Murakumo, T. Kobayashi, Y. Koizumi, and H. Harada, Acta Mater. 52, 3737 (2004).
Y.Q. Chen, E. Francis, J. Robson, M. Preuss, and S.J. Haigh, Acta Mater. 85, 199 (2015).
Y. Wu, W.H. Liu, X.L. Wang, D. Ma, A.D. Stoica, T.G. Nieh, Z.B. He, and Z.P. Lu, Appl. Phys. Lett. 104, 051910 (2014).
F. Otto, A. Dlouhý, C. Somsen, H. Bei, G. Eggeler, and E.P. George, Acta Mater. 61, 5743 (2013).
B. Gludovatz, A. Hohenwarter, D. Catoor, E.H. Chang, E.P. George, and R.O. Ritchie, Science 345, 1153 (2014).
T. Yang, S. Xia, S. Liu, C. Wang, S. Liu, Y. Fang, Y. Zhang, J. Xue, S. Yan, and Y. Wang, Sci. Rep. 6, 1 (2016).
S.Q. Xia, X. Yang, T.F. Yang, S. Liu, and Y. Zhang, JOM 67, 2340 (2015).
B. Kombaiah, K. Jin, H. Bei, P.D. Edmondson, and Y. Zhang, Mater. Des. 160, 1208 (2018).
J.F. Ziegler, M.D. Ziegler, and J.P. Biersack, Nucl. Instrum. Methods Phys. Res. Sect. B 268, 1818 (2010).
R.E. Stoller, M.B. Toloczko, G.S. Was, A.G. Certain, S. Dwaraknath, and F.A. Garner, Nucl. Instrum. Methods Phys. Res. Sect. B 310, 75 (2013).
W.J. Weber and Y. Zhang, Curr. Opin. Solid State Mater. Sci. 0, 100757 (2019).
D.J. Edwards, E.P. Simonen, and S.M. Bruemmer, J. Nucl. Mater. 317, 13 (2003).
B.H. Sencer, G.S. Was, M. Sagisaka, Y. Isobe, G.M. Bond, and F.A. Garner, J. Nucl. Mater. 323, 18 (2003).
P. Hosemann, D. Kiener, Y. Wang, and S.A. Maloy, J. Nucl. Mater. 425, 136 (2012).
J.G. Gigax, E. Aydogan, T. Chen, D. Chen, L. Shao, Y. Wu, W.Y. Lo, Y. Yang, and F.A. Garner, J. Nucl. Mater. 465, 343 (2015).
T. Yang, S. Xia, W. Guo, R. Hu, J.D. Poplawsky, G. Sha, Y. Fang, Z. Yan, C. Wang, C. Li, Y. Zhang, S.J. Zinkle, and Y. Wang, Scr. Mater. 144, 31 (2018).
D. Chen, Y. Tong, J. Wang, B. Han, Y.L. Zhao, F. He, and J.J. Kai, J. Nucl. Mater. 510, 187 (2018).
D.L. Douglass, G. Thomas, and W.R. Roser, Corrosion 20, 15t (1964).
A. Das, Metall. Mater. Trans. A Phys. Metall. Mater. Sci. 47, 748 (2016).
B. Wu, W. Chen, Z. Jiang, Z. Chen, and Z. Fu, Mater. Sci. Eng. A 676, 492 (2016).
P. Yu, Y. Zhuang, J.-P. Chou, J. Wei, Y.-C. Lo, and A. Hu, Sci. Rep. 9, 10940 (2019).
T. Toyama, Y. Nozawa, W. Van Renterghem, Y. Matsukawa, M. Hatakeyama, Y. Nagai, A. Al Mazouzi, and S. Van Dyck, J. Nucl. Mater. 425, 71 (2012).
M. Nastar and F. Soisson, Radiation-induced segregation (Amsterdam: Elsevier, 2012).
Y. Ma, B. Jiang, C. Li, Q. Wang, C. Dong, P.K. Liaw, F. Xu, and L. Sun, Metals (Basel). 7, 57 (2017).
Y.Y. Zhao, H.W. Chen, Z.P. Lu, and T.G. Nieh, Acta Mater. 147, 184 (2018).
D. Chen, F. He, B. Han, Q. Wu, Y. Tong, Y. Zhao, Z. Wang, J. Wang, and J. Jung Kai, Intermetallics 110, 106476 (2019).
Acknowledgements
This research was financially supported by the .S Department of Energy, Office of Nuclear Energy through the Nuclear Science User Facilities (NSUF)—Rapid Turnabout Experiment (RTE) Program (Award No. 17-865). Partial support for Andrew Hoffman, Hans Pommerenke, and Haiming Wen came from the US Nuclear Regulatory Commission (NRC) Faculty Development Program (Award No. NRC 31310018M0044). Nathan Curtis and Victor DeLibera are thanked for their assistance with sample preparation.
Author information
Authors and Affiliations
Corresponding authors
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Hoffman, A., He, L., Luebbe, M. et al. Effects of Al and Ti Additions on Irradiation Behavior of FeMnNiCr Multi-Principal-Element Alloy. JOM 72, 150–159 (2020). https://doi.org/10.1007/s11837-019-03871-4
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11837-019-03871-4