Abstract
Tomato is a potentially valuable source of bioactive compounds such as lycopene. The degradation/isomerization rate of lycopene can be highly enhanced by the drying process of tomato pulps. In this study, the dehydrated tomatoes by osmotic solutions were processed by drying methods of hot air (HA), vacuum-assisted hot air (VA-HA), sun-assisted hot air (SA-HA), and microwave-assisted hot air (MA-HA). The lycopene content and color characteristics (L*, a*, b*, and ∆E values) of the dried samples to determine the favorable processing were analyzed using HPLC and Hunter-Lab colorimeter systems, respectively. Results showed that the osmotic pretreatment with a significant decrease in drying time led to a better-preserved color by reducing the degradation rate of lycopene. The samples processed with MA-HA showed the highest drying rate with a drying time of 150 min (p < 0.05). The tomatoes dried with MA-HA contained the lowest lycopene content (174.9 mg/100 g) due to serious damage to the cell wall. HA and SA-HA drying methods resulted in a similar lycopene content (1191.1 and 1287.3 mg/100 g, respectively), while the color values of samples dried by SA-HA were undesirable compared to HA ones (a*/b* = 1.36 and 3.09, respectively). A significantly negative association between lycopene content and ∆E value for osmo-dehydrated samples dried by the different methods was found (p < 0.01; r2 = 0.756–0.906). It seems that the choice of appropriate drying method accompanied by the osmotic dehydration can maintain the color of dried samples with a low degradation rate of lycopene.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
An K, Tang D, Wu J, Fu M, Wen J, Xiao G, Xu Y (2019) Comparison of pulsed vacuum and ultrasound osmotic dehydration on drying of Chinese ginger (Zingiber officinale Roscoe): drying characteristics, antioxidant capacity, and volatile profiles. Food Sci Nutr 7:2537–2545
Ashraf W, Latif A, Lianfu Z, Jian Z, Chenqiang W, Rehman A, Hussain A, Siddiquy M, Karim A (2020) Technological advancement in the processing of lycopene: a review. Food Rev Int 22:1–27
Bahaabad GA, Gharibzahedi SMT, Esmaiili M, Alizadeh M (2014) Response surface modeling for optimization of textural and color characteristics of dried grapes. Int J Food Eng 10:493–502
Bicacic D, Swarts J, Luterotti S, Pietraperzia G, Doka O, Rooij H (2004) Direct quantification of lycopene in products derived from thermally processed tomatoes: optothermal window as a selective, sensitive, and accurate analytical method without the need for preparatory steps. J Anal Chem 76:5203–5207
Chen J, Shi J, Xue SJ, Ma Y (2009) Comparison of lycopene stability in water- and oil-based food model systems under thermal- and light-irradiation treatments. LWT Food Sci Technol 42:740–747
Contreras C, Martın-Esparza C, Chiralt ME, Martınez-Navarrete AN (2008) Influence of microwave application on convective drying: effects on drying kinetics, and optical and mechanical properties of apple and strawberry. J Food Eng 88:55–64
Corrêa JLG, Viana AD, de Mendonça KS, Justus A (2016) Optimization of pulsed vacuum osmotic dehydration of sliced tomato. Drying and energy technologies. Springer, Cham, pp 207–228
de Mendonça KS, Corrêa JL, de Jesus Junqueira JR, Cirillo MA, Figueira FV, Carvalho EE (2017) Influences of convective and vacuum drying on the quality attributes of osmo-dried pequi (Caryocar brasiliense Camb.) slices. Food Chem 224:212–218
Dermesonlouoglou EK, Giannakourou MC, Taoukis PS (2007) Kinetic modeling of the degradation of quality of osmo-dehydrofrozen tomatoes during storage. J Food Chem 103:985–993
Dorouzi M, Mortezapour H, Akhavan HR, Moghaddam AG (2018) Tomato slices drying in a liquid desiccant-assisted solar dryer coupled with a photovoltaic-thermal regeneration system. Sol Energy 162:364–371
Heredia A, Peinado I, Rosa E, Andrés A (2010) Effect of osmotic pre-treatment and microwave heating on lycopene degradation and isomerization in cherry tomato. J Food Chem 123:92–98
Ishida BK, Chapman MH (2012) Effects of a hydrodynamic process on extraction of carotenoids from tomato. J Food Chem 132:1156–1160
Jayathunge KG, Stratakos AC, Cregenzán-Albertia O, Grant IR, Lyng J, Koidis A (2017) Enhancing the lycopene in vitro bioaccessibility of tomato juice synergistically applying thermal and non-thermal processing technologies. Food Chem 221:698–705
Khubber S, Chaturvedi K, Gharibzahedi SMT, Cruz RM, Lorenzo JM, Gehlot R, Barba FJ (2020) Non-conventional osmotic solutes (honey and glycerol) improve mass transfer and extend shelf life of hot-air dried red carrots: kinetics, quality, bioactivity, microstructure, and storage stability. LWT 131:109764
Kroehnke J, Szadzińska J, Radziejewska-Kubzdela E, Biegańska-Marecik R, Musielak G, Mierzwa D (2021) Osmotic dehydration and convective drying of kiwifruit (Actinidia deliciosa)—the influence of ultrasound on process kinetics and product quality. Ultrason Sonochem 71:105377
Lavelli V, Torresani MC (2011) Modeling the stability of lycopene-rich by-products of tomato processing. J Food Chem 125:529–535
Mayer-Miebach E, Behsnilian D, Regier M, Schuchmann HD (2005) Thermal processing of carrots: lycopene stability and isomerisation with regard to antioxidant potential. J Food Res Int 38:1103–1108
Mokhtar WM, Ghawi SK, Niranjan K (2019) Dehydration of potato slices following brief dipping in osmotic solutions: effect of conditions and understanding the mechanism of water loss. Dry Technol 37:885–895
Muratore G, Rizzo V, Licciardello F, Maccarone E (2008) Partial dehydration of cherry tomato at different temperature and nutritional quality of the products. J Food Chem 111:887–891
Nowacka M, Dadan M, Tylewicz U (2021) Current applications of ultrasound in fruit and vegetables osmotic dehydration processes. Appl Sci 11:1269
Obajemihi OI, Olaoye JO, Ojediran JO, Cheng JH, Sun DW (2020) Model development and optimization of process conditions for color properties of tomato in a hot-air convective dryer using Box-Behnken design. J Food Process Preserv 44:e14771
Pérez-Conesa D, García-Alonso J, García-Valverde V, Iniesta MD, Jacob K, Sánchez-Siles LM, Ros G, Periago MJ (2009) Changes in bioactive compounds and antioxidant activity using homogenization and thermal processing of tomato puree. Innov Food Sci Emerg Technol 10:179–188
Prithani R, Dash KK (2020) Mass transfer modelling in ultrasound assisted osmotic dehydration of kiwi fruit. Innov Food Sci Emerg Technol 64:102407
Ramya V, Jain NK (2017) A review on osmotic dehydration of fruits and vegetables: an integrated approach. J Food Process Eng 40(3):e12440
Shi J, Maguer ML, Kakuda Y, Liptay A, Niekamp F (1999) Lycopene degradation and isomerization in tomato dehydration. J Food Res Int 32:15–21
Shi J, Dai Y, Kakuda Y, Mittal G, Xue SJ (2008) Effect of heating and exposure to light on the stability of lycopene in tomato puree. Food Control 19:514–520
Saini RK, Bekhit AA, Renegasamy KRR, Keum YS (2020) Chemical stability of lycopene in processed products: a review of the effects of processing methods and modern preservation strategies. J Agric Food Chem 68:712–726
Tan S, Ke Z, Chai D, Miao Y, Luo K, Li W (2021) Lycopene, polyphenols and antioxidant activities of three characteristic tomato cultivars subjected to two drying methods. Food Chem 338:128062
Toor RK, Savage GP (2006) Effect of semi-drying on the antioxidant components of tomatoes. Food Chem 94:90–97
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Tahmasebi, M., Emam-Djomeh, Z. Lycopene degradation and color characteristics of fresh and processed tomatoes under the different drying methods: a comparative study. Chem. Pap. 75, 3617–3623 (2021). https://doi.org/10.1007/s11696-021-01611-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11696-021-01611-0