Abstract
The initiation and propagation of localized corrosion induced by typical composite inclusions in OCTG (oil country tubular goods) steels were investigated by continuous immersion test combining SEM-EDS detection and theoretical calculation. Localized corrosion induced by inclusions with spinel covered by calcium aluminate and CaS initiated at the dissolution of calcium aluminate and CaS. Most of spinel parts remained intact but would drop off, and fewer spinel were found dissolved. The reason for localized corrosion induced by inclusions in OCTG was discussed in the view of galvanic corrosion and chemical dissolution. The energy band structure of inclusions and potential difference between the inclusions and the Fe matrix was estimated based on first principles. The chemical dissolution of steel matrix and inclusions were analyzed based on thermodynamic calculation. The calculated results were in good agreement with experimental results. A schematic diagram of mechanism for localized corrosion induced by Mg–Ca–Al–O/S complex inclusions in OCTG steel was established.
Similar content being viewed by others
References
P. Tang: World Metals, 2014.
L.I. He-Lin, J.I. Ling-Kang, and L.H. Xie: J. Hebei Univ. Sci. Technol., 2006, vol. 27(1), pp. 1–5.
Y. Zhou: Steel Rolling., 2007, vol. 24(3), pp. 25–9.
H. Li, W. Tian, and X. Kuang: Steel Pipe., 2010, vol. 9(1), pp. 1–7.
H. Li, L. Han, and W. Zhang: Steel Pipe., 2009, vol. 38(1), pp. 1–9.
J. Fang, Y.H. Li, K.Y. Xie, X.Y. Zou, M.X. Zhou, and Z.X. Yuan: Appl. Mech. Mater., 2011, vol. 7(71–78), pp. 837–41.
B. Zhang, J. Wang, B. Wu, X.W. Guo, Y.J. Wang, and D. Chen: Nat. Commun., 2018, vol. 9(1), pp. 2559–68.
W. Tai and M. Chen: Corros. Sci., 2000, vol. 42, pp. 545–59.
Z. Szklarska-smialowska: Corrosion., 1972, vol. 28(10), pp. 388–96.
S. Zheng, C. Li, Y. Qi, L. Chen, and C. Chen: Corros. Sci., 2013, vol. 67(Supplement C), pp. 20–31.
L. Yue, L. Wang, and J. Han: J. Rare Earth., 2010, vol. 28(6), pp. 952–6.
I.I. Reformatskaya, I.G. Rodionova, Y.A. Beilin, L.A. Nisel’Son, and A.N. Podobaev: Prot. Met., 2004, vol. 405(5), pp. 447–52.
G. Wranglen: Corros. Sci., 1974, vol. 14(5), pp. 331–49.
C. Liu, R.I. Reynier, D. Zhang, Z. Liu, A. Lutz, and F. Zhang: Corros. Sci., 2018, vol. 138, pp. 96–104.
T.Y. Jin and Y.F. Cheng: Corros. Sci., 2011, vol. 53(2), pp. 850–3.
T. Wijesinghe and D.J. Blackwood: Corros. Sci., 2007, vol. 49(4), pp. 1755–64.
J. Yan, T. Li, Z. Shang, and H. Guo: Mater Charact., 2019, https://doi.org/10.1016/j.matchar.2019.109944.
C. Man, C. Dong, K. Xiao, Q. Yu, and X. Li: Corrosion (Houston, TX)., 2017, vol. 74(4), pp. 312–25.
R. Avci, B.H. Davis, M.L. Wolfenden, I.B. Beech, and K. Lucas: Corros. Sci., 2013, vol. 76, pp. 267–74.
J. Torkkeli, T. Saukkonen, and H. Hanninen: Corros. Sci., 2015, vol. 96, pp. 14–22.
X. Zhang, W. Wei, L. Cheng, J. Liu, K. Wu, and M. Liu: Appl. Surf. Sci., 2019, vol. 475, pp. 83–93.
Y. Li, J. Liu, Y. Deng, X. Han, W. Hu, and C. Zhong: J. Alloys Compd., 2016, vol. 673, pp. 28–37.
C. Liu, Z. Jiang, J. Zhao, X. Cheng, Z. Liu, and D. Zhang: Corros. Sci., 2020, vol. 166, pp. 108463.1-108463.10.
C. Liu, X. Li, R.I. Revilla, T. Sun, and X. Li: Corros. Sci., 2021, https://doi.org/10.1016/j.corsci.2020.109150.
M. Rohwerder and F. Turcu: Electrochim. Acta., 2008, vol. 53(2), pp. 290–9.
C. Liu, R.I. Revilla, D.Z. Liu, X. Li, and H. Terryn: Corros. Sci., 2017, vol. 129, pp. 82–90.
Y. Hou, G. Xiong, L. Liu, G. Li, and M. Guo: Scripta Mater., 2020, vol. 177, pp. 151–6.
S.J. Zheng, Y.J. Wang, B. Zhang, Y.L. Zhu, C. Liu, and P. Hu: Acta Mater., 2010, vol. 58(15), pp. 5070–85.
H. Ma, X.Q. Chen, R. Li, S. Wang, J. Dong, and W. Ke: Acta Mater., 2017, vol. 130, pp. 137–46.
J. Stewart and D.E. Williams: Corros. Sci., 1992, vol. 33(3), pp. 457–74.
C. Liu: Initiation Mechanism of Micro/Nano Corrosion in Q460NH Steel and Targeted Optimization, University of Science and Technology Beijing, Beijing, 2019.
S. Yang, M. Zhao, J. Feng, J. Li, and C. Liu: High Temp. Mater. Process., 2018, vol. 37, pp. 1007–16.
F. Ai, X. Xu, Y. Chen, B. Zhong, L. Li, and P. Gao: Corros. Protect., 2012, vol. 33(5), pp. 422–5.
K. Xu and B.G. Thomas: Metall. Mater. Trans. A., 2012, vol. 43A(3), pp. 1079–96.
G. Yang and X. Wang: Trans. Iron Steel Inst. Jpn., 2015, vol. 55(1), pp. 126–33.
P.E. Blöchl: Phys. Rev. B., 1994, vol. 50(24), pp. 17953–79.
J.P. Perdew, K. Burke, and M. Ernzerhof: Phys. Rev. Lett., 1997, vol. 78(7), art. no. 1396.
R.N. Lee and H.E. Farnsworth: Surf. Sci., 1965, vol. 3(5), pp. 461–79.
E.P. Yelsukov, E.V. Voronina, and V.A. Barinov: J. Magn. Magn Mater., 1992, vol. 115, pp. 271–80.
T.V. Dunaitseva, L.B. Romanovskii, E.G. Potap, and V.A. Perepelitsyn: Inorg. Mater., 1990, vol. 26, pp. 2301–2.
A. Jain, S.P. Ong, G. Hautier, W. Chen, W.D. Richards, and S. Dacek: APL Mater., 2013, https://doi.org/10.1063/1.4812323.
Y. Hou, T. Li, G. Li, and C. Cheng: Micron., 2019, https://doi.org/10.1016/j.micron.2019.102820.
D.P. Ji, Q. Zhu, and S.Q. Wang: Surf. Sci., 2016, vol. 651, pp. 137–46.
Y. Cao, G. Li, Y. Hou, N. Moelans, and M. Guo: Physica B., 2019, vol. 558, pp. 10–9.
Y. Hou, J. Wang, L. Liu, G. Li, and D. Zhai: Micron., 2020, https://doi.org/10.1016/j.micron.2020.102898.
K. Fushimi and M. Seo: J. Electrochem. Soc., 2001, vol. 148(11), pp. 31–9.
W. Batista, A.M.T. Louvisse, O.R. Mattos, and L. Sathler: Corros. Sci., 1988, vol. 28(8), pp. 759–68.
Acknowledgments
This research is supported by the National Science Foundation of China (Nos. 51804086 and 52064011) and National Natural Science Foundation of Guizhou Province (Grant No. [2019]1086). Additionally, this project is supported by the Program Foundation for Talents of Education Department of Guizhou Province (Grant No. Qian Jiao He [2018]105). This research is supported by the high-performance computing platform of Guizhou University.
Conflict of interest
On behalf of all authors, the corresponding author states that there is no conflict of interest.
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Manuscript submitted August 12, 2021; accepted October 23, 2021.
Rights and permissions
About this article
Cite this article
Wang, L., Li, Y., Yang, S. et al. Study on Localized Corrosion Induced by Non-metallic Inclusions in OCTG Steel. Metall Mater Trans B 53, 1212–1223 (2022). https://doi.org/10.1007/s11663-021-02366-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11663-021-02366-5