Abstract
A simple method for the controllable hydrothermal synthesis of nanocrystalline anatase TiO2 (nc-TiO2) particles involving the selection of suitable organic alkali peptizing agents is reported. A dye-sensitized solar cell (DSSC) with square-like nc-TiO2 particles with side lengths about 8–13 nm—prepared using tetraethylammonium hydroxide (TEAOH)—in the photoelectrode showed higher photovoltaic performance than two other DSSCs with square-like nc-TiO2 particles with side lengths about 7–10 nm—prepared using tetrabutylammonium hydroxide—or elongated nc-TiO2 particles with lengths about 18–35 nm and width about 10–18 nm—prepared using tetramethylammonium hydroxide (TMAOH)—in the photoelectrodes. When a scattering layer prepared from sub-micron size spheres or cone-like nc-TiO2 particles—synthesized using a higher concentration of TMAOH—was added on top of the photoelectrode fabricated from nc-TiO2 synthesized with TEAOH, the energy conversion efficiency of the DSSC was markedly increased from 6.77% to 8.18%.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
O’Regan B, Grätzel M. A low-cost, high-efficiency solar cell based on dye-sensitized colloidal TiO2 films. Nature, 2010, 353: 737–740
Barbé CJ, Arendse F, Comte P, Jirousek M, Lenzmann F, Grätzel M. Nanocrystalline titanium oxide electrodes for photovoltaic applications. J Am Ceram Soc, 1997, 80: 3157–3171
Ito S, Murakami T, Comte P, Liska P, Grätzel C, Nazeeruddin M, Grätzel M. Fabrication of thin film dye sensitized solar cells with solar to electric power conversion efficiency over 10%. Thin Solid Films, 2008, 516: 4613–4619
Zhao Y, Zhai J, Tan S, Wang L, Jiang L, Zhu D. TiO2 micro/nano-composite structured electrodes for quasi-solid-state dye-sensitized solar cells. Nanotechnology, 2006, 17: 2090–2097
Wu J, Hao S, Lin J, Huang M, Huang Y, Lan Z, Li P. Crystal morphology of anatase titania nanocrystals used in dye-sensitized solar cells. Cryst Growth Des, 2008, 8: 247–252
Li J, Yu Y, Lin J, Chen Q, Li J, Xu D. Controllable synthesis of TiO2 single crystals with tunable shapes using ammonium-exchanged titanate nanowires as precursors used in dye-sensitized solar cells. Cryst Growth Des, 2010, 10: 2111–2115
Yang J, Mei S, Ferreira JMF. Hydrothermal processing of nanocrystalline anatase films from tetraethylammonium hydroxide peptized titania sols. J Eur Ceram Soc, 2004, 24: 335–339
Burnside SD, Shklover V, Barbé C, Comte P, Arendse F, Brooks K, Grätzel M. Self-organization of TiO2 nanoparticles in thin films. Chem Mater, 1998, 10: 2419–2425
Yang J, Mei S, Ferreira JMF. Hydrothermal synthesis of well-dispersed TiO2 nano-crystals. J Am Ceram Soc, 2002, 83: 1361–1368
Yang J, Mei S, Ferreira JMF. Hydrothermal synthesis of nanosized titania powders: Influence of peptization and peptizing agents on the crystalline phases and phase transitions. J Mater Res, 2000, 17: 2197–2200
Liu G, Sun C, Yang H, Smith SC, Wang L, Lu GQ, Cheng HM. Nanosized anatase TiO2 single crystals for enhanced photocatalytic activity. Chem Commun, 2009, 46: 755–757
Li G, Sun C, Li L, Boerio-Goates J, Woodfield BF. High purity anatase TiO2 nanocrystals: Near room-temperature synthesis, grain growth kinetics, and surface hydration chemistry. J Am Chem Soc, 2005, 127: 8659–8666
Menzies DB, Dai Q, Bourgeois L, Caruso RA, Cheng YB, Simon GP, Spiccia L. Modification of mesoporous TiO2 electrodes by surface treatment with titanium(IV), indium(III) and zirconium(IV) oxide precursors: Preparation, characterization and photovoltaic performance in dye-sensitized nanocrystalline solar cells. Nanotechnology, 2007, 18: 125608–125619
Jiu J, Isoda S, Motonari A, Wang H. Dye-sensitized solar cell based on nanocrystalline TiO2 with 3–10 nm in diameter. J Mater Sci: Mater Electron, 2007, 18: 593–597
Koo HJ, Park J, Yoo B, Yoo K, Kim K, Park NG. Size-dependent scattering efficiency in dye-sensitized solar cell. Inorg Chim Acta, 2008, 361: 677–683
Wang ZS, Kawauchi H, Kashima T, Arakawa H. Significant influence of TiO2 photoelectrode morphology on the energy conversion efficiency of N719 dye-sensitized solar cell. Coord Chem Rev, 2004, 248: 1381–1389
Ma BB, Gao R, Wang LD, Zhu YF, Shi YT, Geng Y, Dong HP, Qiu Y. Recent progress in interface modification for dye-sensitized solar cells. Sci China Chem, 2010, 53: 1669–1678
Chiba Y, Islam A, Komiya R, Koide N, Han L. Conversion efficiency of 10.8 % by a dye-sensitized solar cell using a TiO2 electrode with high haze. Appl Phys Lett, 2006, 88: 223505–223508
Qiu Y, Chen W, Yang S. Double-layered photoanodes from variable-size anatase TiO2 nanospindles: A candidate for high-efficiency dye-sensitized solar cells. Angew Chem Int Edit, 2010, 46: 3675–3679
Pichot F, Gregg BA. The photovoltage-determining mechanism in dye-sensitized solar cells. J Phys Chem B, 2000, 104: 6–10
Author information
Authors and Affiliations
Corresponding authors
Rights and permissions
About this article
Cite this article
Lan, Z., Wu, J., Lin, J. et al. Controllable hydrothermal synthesis of nanocrystal TiO2 particles and their use in dye-sensitized solar cells. Sci. China Chem. 55, 1308–1313 (2012). https://doi.org/10.1007/s11426-012-4638-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11426-012-4638-2