Abstract
Venerupis philippinarum shells (VPSs), which are composed mainly of CaCO3, have been considered for use as a fluoride adsorbent because of their high Ca content and low processing cost and the opportunity for waste reuse. VPSs were calcined at various temperatures (100, 300, 500, 700, 800, and 900 °C), and those calcined at 800 °C (VPS-800) and 900 °C showed the highest fluoride adsorption capacity. As the calcination temperature increased, the CaCO3 in the VPSs changed to CaO and Ca(OH)2, and the solubility of Ca increased owing to a change in crystalline phase, enabling fluoride adsorption by the VPSs. The adsorption of fluoride by VPS-800 followed the Freundlich equilibrium model and pseudo-second-order kinetic model, and the maximum fluorine adsorption capacity was 301.87 mg/g. The maximum adsorption efficiency at an adsorbent dose of 5 g/L in a 700 mg/L fluoride solution was 99.5%. The enthalpy and entropy were 34.76 kJ/mol and 140.13 J/mol‧K, respectively, and the change in the Gibbs free energy was negative at all reaction temperatures. Fluoride adsorption by VPS-800 was favored at low pH (pH 3), and it was slightly affected by pH at pH 5–11. The anion competition effect followed the order HPO42− > HCO3− > SO42− > Cl−. VPS-800 is an eco-friendly adsorbent obtained by simple heat treatment of waste and is effective in removing fluoride.
Graphical abstract
Similar content being viewed by others
Data Availability
All data generated or analyzed during this study are included in this published article.
The datasets used and/or analyzed during the current study are available from the corresponding author on reasonable request.
References
Ajenifuja, E., Ajao, J. A., & Ajayi, E. O. B. (2017). Adsorption isotherm studies of Cu (II) and Co (II) in high concentration aqueous solutions on photocatalytically modified diatomaceous ceramic adsorbents. Applied Water Science, 7(7), 3793–3801. https://doi.org/10.1007/s13201-017-0527-3
Akpotu, S. O., Lawal, I. A., Moodley, B., & Ofomaja, A. E. (2020). Covalently linked graphene oxide/reduced graphene oxide-methoxylether polyethylene glycol functionalised silica for scavenging of estrogen: Adsorption performance and mechanism. Chemosphere, 246, 125729. https://doi.org/10.1016/j.chemosphere.2019.125729
Amor, Z., Bariou, B., Mameri, N., Taky, M., Nicolas, S., & Elmidaoui, A. (2001). Fluoride removal from brackish water by electrodialysis. Desalination, 133(3), 215–223. https://doi.org/10.1016/S0011-9164(01)00102-3
Anastopoulos, I., & Kyzas, G. Z. (2016). Are the thermodynamic parameters correctly estimated in liquid-phase adsorption phenomena? Journal of Molecular Liquids, 218, 174–185. https://doi.org/10.1016/j.molliq.2016.02.059
Argun, M. E., Dursun, S., Karatas, M., & Gürü, M. (2008). Activation of pine cone using Fenton oxidation for Cd (II) and Pb (II) removal. Bioresource Technology, 99(18), 8691–8698. https://doi.org/10.1016/j.biortech.2008.04.014
Ayoob, S., & Gupta, A. K. (2006). Fluoride in drinking water: A review on the status and stress effects. Critical Reviews in Environmental Science and Technology, 36(6), 433–487. https://doi.org/10.1080/10643380600678112
Bae, H., Im, J., Joo, S., Cho, B., & Kim, T. (2021). The Effects of Temperature and Salinity Stressors on the Survival, Condition and Valve Closure of the Manila Clam, Venerupis philippinarum in a Holding Facility. Journal of Marine Science and Engineering, 9(7), 754. https://doi.org/10.3390/jmse9070754
Banihashemi, A., Javanbakht, V., & Mohammadifard, H. (2021). Calcium carbonate nanoparticles fabricated by a facile method based on the colloidal gas aphrons for removal of fluoride ions from aqueous solutions. Materials Chemistry and Physics, 258, 123934. https://doi.org/10.1016/j.matchemphys.2020.123934
Baral, S. S., Das, S. N., & Rath, P. (2006). Hexavalent chromium removal from aqueous solution by adsorption on treated sawdust. Biochemical Engineering Journal, 31(3), 216–222. https://doi.org/10.1016/j.bej.2006.08.003
Budyanto, S., Kuo, Y. L., & Liu, J. C. (2015). Adsorption and precipitation of fluoride on calcite nanoparticles: A spectroscopic study. Separation and Purification Technology, 150, 325–331. https://doi.org/10.1016/j.seppur.2015.07.016
Cengeloglu, Y., Tor, A., Ersoz, M., & Arslan, G. (2006). Removal of nitrate from aqueous solution by using red mud. Separation and Purification Technology, 51(3), 374–378. https://doi.org/10.1016/j.seppur.2006.02.020
Choi, M. Y., Lee, J. I., Lee, C. G., & Park, S. J. (2021). Feasibility of using calcined Patinopecten yessoensis shells for fluoride removal and investigation of the fluoride removal mechanism. Desalination and Water Treatment, 233, 292–302. https://doi.org/10.5004/dwt.2021.27551
Dayananda, D., Sarva, V. R., Prasad, S. V., Arunachalam, J., & Ghosh, N. N. (2014). Preparation of CaO loaded mesoporous Al2O3: Efficient adsorbent for fluoride removal from water. Chemical Engineering Journal, 248, 430–439. https://doi.org/10.1016/j.cej.2014.03.064
de Luna, M. S., Ascione, C., Santillo, C., Verdolotti, L., Lavorgna, M., Buonocore, G. G., Castaldo, R., Filippone, G., & Ambrosio, L. (2019). Optimization of dye adsorption capacity and mechanical strength of chitosan aerogels through crosslinking strategy and graphene oxide addition. Carbohydrate Polymers, 211, 195–203. https://doi.org/10.1016/j.carbpol.2019.02.002
Dhillon, A., Nair, M., Bhargava, S. K., & Kumar, D. (2015). Excellent fluoride decontamination and antibacterial efficacy of Fe–Ca–Zr hybrid metal oxide nanomaterial. Journal of Colloid and Interface Science, 457, 289–297. https://doi.org/10.1016/j.jcis.2015.06.045
Dhillon, A., Prasad, S., & Kumar, D. (2017). Recent advances and spectroscopic perspectives in fluoride removal. Applied Spectroscopy Reviews, 52(3), 175–230. https://doi.org/10.1080/05704928.2016.1213737
Drouiche, N., Aoudj, S., Hecini, M., Ghaffour, N., Lounici, H., & Mameri, N. (2009). Study on the treatment of photovoltaic wastewater using electrocoagulation: Fluoride removal with aluminium electrodes—Characteristics of products. Journal of Hazardous Materials, 169(1–3), 65–69. https://doi.org/10.1016/j.jhazmat.2009.03.073
Eskandarpour, A., Onyango, M. S., Ochieng, A., & Asai, S. (2008). Removal of fluoride ions from aqueous solution at low pH using schwertmannite. Journal of Hazardous Materials, 152(2), 571–579. https://doi.org/10.1016/j.jhazmat.2007.07.020
Fan, X., Parker, D. J., & Smith, M. D. (2003). Adsorption kinetics of fluoride on low cost materials. Water Research, 37(20), 4929–4937. https://doi.org/10.1016/j.watres.2003.08.014
Fan, S., Wang, Y., Wang, Z., Tang, J., Tang, J., & Li, X. (2017). Removal of methylene blue from aqueous solution by sewage sludge-derived biochar: Adsorption kinetics, equilibrium, thermodynamics and mechanism. Journal of Environmental Chemical Engineering, 5(1), 601–611. https://doi.org/10.1016/j.jhazmat.2007.07.020
Fawell, J., Bailey, K., Chilton, J., Dahi, E., Fewtrell, F., & Magara, Y. (2006). Fluoride in drinking water. World Health Organization.
Fito, J., Tefera, N., & Van Hulle, S. W. (2017). Adsorption of distillery spent wash on activated bagasse fly ash: Kinetics and thermodynamics. Journal of Environmental Chemical Engineering, 5(6), 5381–5388. https://doi.org/10.1016/j.jece.2017.10.009
Freundlich, H. M. F. (1906). Uber die adsorption in losungen. Zeitschrift Für Physikalische Chemie, 57, 385–470. https://doi.org/10.1515/zpch-1907-5723
Gao, S., Cui, J., & Wei, Z. (2009). Study on the fluoride adsorption of various apatite materials in aqueous solution. Journal of Fluorine Chemistry, 130(11), 1035–1041. https://doi.org/10.1016/j.jfluchem.2009.09.004
Goh, K. H., & Lim, T. T. (2004). Geochemistry of inorganic arsenic and selenium in a tropical soil: Effect of reaction time, pH, and competitive anions on arsenic and selenium adsorption. Chemosphere, 55(6), 849–859. https://doi.org/10.1016/j.chemosphere.2003.11.041
Goh, K. H., & Lim, T. T. (2010). Influences of co-existing species on the sorption of toxic oxyanions from aqueous solution by nanocrystalline Mg/Al layered double hydroxide. Journal of Hazardous Materials, 180(1–3), 401–408. https://doi.org/10.1016/j.jhazmat.2010.04.045
He, Y., Zhang, L., An, X., Wan, G., Zhu, W., & Luo, Y. (2019). Enhanced fluoride removal from water by rare earth (La and Ce) modified alumina: Adsorption isotherms, kinetics, thermodynamics and mechanism. Science of the Total Environment, 688, 184–198. https://doi.org/10.1016/j.scitotenv.2019.06.175
Ho, Y. S., & McKay, G. (1998). Kinetic model for lead (II) sorption on to peat. Adsorption Science & Technology, 16(4), 243–255. https://doi.org/10.1177/026361749801600401
Hsieh, L. S., Kumar, U., & Wu, J. C. (2010). Continuous production of biodiesel in a packed-bed reactor using shell–core structural Ca(C3H7O3)2/CaCO3 catalyst. Chemical Engineering Journal, 158(2), 250–256. https://doi.org/10.1016/j.cej.2010.01.025
Huang, Y. H., Shih, Y. J., & Chang, C. C. (2011). Adsorption of fluoride by waste iron oxide: The effects of solution pH, major coexisting anions, and adsorbent calcination temperature. Journal of Hazardous Materials, 186(2–3), 1355–1359. https://doi.org/10.1016/j.jhazmat.2010.12.025
Iriel, A., Bruneel, S. P., Schenone, N., & Cirelli, A. F. (2018). The removal of fluoride from aqueous solution by a lateritic soil adsorption: Kinetic and equilibrium studies. Ecotoxicology and Environmental Safety, 149, 166–172. https://doi.org/10.1016/j.ecoenv.2017.11.016
Islam, M., & Patel, R. K. (2007). Evaluation of removal efficiency of fluoride from aqueous solution using quick lime. Journal of Hazardous Materials, 143(1–2), 303–310. https://doi.org/10.1016/j.jhazmat.2006.09.030
Joo, S., Jo, K., Bae, H., Seo, H., & Kim, T. (2021). Optimal sediment grain size and sorting for survival and growth of juvenile Manila clams. Venerupis Philippinarum. Aquaculture, 543, 737010. https://doi.org/10.1016/j.aquaculture.2021.737010
Kagne, S., Jagtap, S., Dhawade, P., Kamble, S. P., Devotta, S., & Rayalu, S. S. (2008). Hydrated cement: A promising adsorbent for the removal of fluoride from aqueous solution. Journal of Hazardous Materials, 154(1–3), 88–95. https://doi.org/10.1016/j.jhazmat.2007.09.111
Kim, M. J., Hong, S. H., Lee, J. I., Lee, C. G., & Park, S. J. (2019). Removal of fluoride from water using thermally treated dolomite and optimization of experimental conditions using response surface methodology. Desalination and Water Treatment, 155, 311–320. https://doi.org/10.5004/dwt.2019.24059
Korean statistical information service (KOSIS), Fishery production trend survey. 2021, from https://kosis.kr/index/index.do
Lagergren, S. (1898). About the theory of so-called adsorption of soluble substances. Handlingar, 24, 1–39.
Langmuir, I. (1916). The constitution and fundamental properties of solids and liquids. Journal of the American Chemical Society, 38(11), 2221–2295. https://doi.org/10.1021/ja02268a002
Lee, J. I., Hong, S. H., Lee, C. G., & Park, S. J. (2020). Experimental and model study for fluoride removal by thermally activated sepiolite. Chemosphere, 241, 125094. https://doi.org/10.1016/j.chemosphere.2019.125094
Lee, J. I., Kang, J. K., Hong, S. H., Lee, C. G., Jeong, S., & Park, S. J. (2021). Thermally treated Mytilus coruscus shells for fluoride removal and their adsorption mechanism. Chemosphere, 263, 128328. https://doi.org/10.1016/j.chemosphere.2020.128328
Li, Y., Zhang, P., Du, Q., Peng, X., Liu, T., Wang, Z., Xia, Y., Zhang, W., Wang, K., & Wu, D. (2011). Adsorption of fluoride from aqueous solution by graphene. Journal of Colloid and Interface Science, 363(1), 348–354. https://doi.org/10.1016/j.jcis.2011.07.032
Liu, Y., Li, Y., Hu, Y., Mostofa, K. M., Li, S., & Liu, Z. (2019). Adsorption Characteristics and Transport Behavior of Cr (VI) in Shallow Aquifers Surrounding a Chromium Ore Processing Residue (COPR) Dumpsite. Journal of Chemistry, 2019.https://doi.org/10.1155/2019/4932837
Maiti, A., DasGupta, S., Basu, J. K., & De, S. (2007). Adsorption of arsenite using natural laterite as adsorbent. Separation and Purification Technology, 55(3), 350–359. https://doi.org/10.1016/j.seppur.2007.01.003
Marie, B., Trinkler, N., Zanella-Cleon, I., Guichard, N., Becchi, M., Paillard, C., & Marin, F. (2011). Proteomic identification of novel proteins from the calcifying shell matrix of the Manila clam Venerupis philippinarum. Marine Biotechnology, 13(5), 955–962. https://doi.org/10.1007/s10126-010-9357-0
Meenakshi, S., & Viswanathan, N. (2007). Identification of selective ion-exchange resin for fluoride sorption. Journal of Colloid and Interface Science, 308(2), 438–450. https://doi.org/10.1016/j.jcis.2006.12.032
Mourabet, M., El Rhilassi, A., El Boujaady, H., Bennani-Ziatni, M., El Hamri, R., & Taitai, A. (2015). Removal of fluoride from aqueous solution by adsorption on hydroxyapatite (HAp) using response surface methodology. Journal of Saudi Chemical Society, 19(6), 603–615. https://doi.org/10.1016/j.arabjc.2013.12.028
Mourabet, M., El Rhilassi, A., El Boujaady, H., Bennani-Ziatni, M., & Taitai, A. (2017). Use of response surface methodology for optimization of fluoride adsorption in an aqueous solution by Brushite. Arabian Journal of Chemistry, 10, S3292–S3302. https://doi.org/10.1016/j.arabjc.2013.12.028
Murakami, F. S., Rodrigues, P. O., Campos, C. M. T. D., & Silva, M. A. S. (2007). Physicochemical study of CaCO3 from egg shells. Food Science and Technology, 27, 658–662. https://doi.org/10.1590/S0101-20612007000300035
Nkutha, C. S., Naidoo, E. B., & Shooto, N. D. (2021). Adsorptive studies of toxic metal ions of Cr (VI) and Pb (II) from synthetic wastewater by pristine and calcined coral limestones. South African Journal of Chemical Engineering, 36, 43–57. https://doi.org/10.1016/j.sajce.2021.01.001
Onyango, M. S., Kojima, Y., Aoyi, O., Bernardo, E. C., & Matsuda, H. (2004). Adsorption equilibrium modeling and solution chemistry dependence of fluoride removal from water by trivalent-cation-exchanged zeolite F-9. Journal of Colloid and Interface Science, 279(2), 341–350. https://doi.org/10.1016/j.jcis.2004.06.038
Panagiotou, E., Kafa, N., Koutsokeras, L., Kouis, P., Nikolaou, P., Constantinides, G., & Vyrides, I. (2018). Turning calcined waste egg shells and wastewater to Brushite: Phosphorus adsorption from aqua media and anaerobic sludge leach water. Journal of Cleaner Production, 178, 419–428. https://doi.org/10.1016/j.jclepro.2018.01.014
Sakhare, N., Lunge, S., Rayalu, S., Bakardjiva, S., Subrt, J., Devotta, S., & Labhsetwar, N. (2012). Defluoridation of water using calcium aluminate material. Chemical Engineering Journal, 203, 406–414. https://doi.org/10.1016/j.cej.2012.07.065
Salifu, A., Petrusevski, B., Ghebremichael, K., Modestus, L., Buamah, R., Aubry, C., & Amy, G. L. (2013). Aluminum (hydr) oxide coated pumice for fluoride removal from drinking water: Synthesis, equilibrium, kinetics and mechanism. Chemical Engineering Journal, 228, 63–74. https://doi.org/10.1016/j.cej.2013.04.075
Sepehr, M. N., Sivasankar, V., Zarrabi, M., & Kumar, M. S. (2013). Surface modification of pumice enhancing its fluoride adsorption capacity: An insight into kinetic and thermodynamic studies. Chemical Engineering Journal, 228, 192–204. https://doi.org/10.1016/j.cej.2013.04.089
Sheikhmohammadi, A., Mohseni, S. M., Khodadadi, R., Sardar, M., Abtahi, M., Mahdavi, S., Keramati, H., Dahaghin, Z., Rezaei, S., Almasian, M., Sarkhosh, M., Faraji, M., & Nazari, S. (2017). Application of graphene oxide modified with 8-hydroxyquinoline for the adsorption of Cr (VI) from wastewater: Optimization, kinetic, thermodynamic and equilibrium studies. Journal of Molecular Liquids, 233, 75–88. https://doi.org/10.1016/j.molliq.2017.02.101
Shen, J., & Schäfer, A. (2014). Removal of fluoride and uranium by nanofiltration and reverse osmosis: A review. Chemosphere, 117, 679–691. https://doi.org/10.1016/j.chemosphere.2014.09.090
Shen, C., Wu, L., Chen, Y., Li, S., Rashid, S., Gao, Y., & Liu, J. (2016). Efficient removal of fluoride from drinking water using well-dispersed monetite bundles inlaid in chitosan beads. Chemical Engineering Journal, 303, 391–400. https://doi.org/10.1016/j.cej.2016.05.103
Sivasankar, V., Rajkumar, S., Murugesh, S., & Darchen, A. (2012). Tamarind (Tamarindus indica) fruit shell carbon: A calcium-rich promising adsorbent for fluoride removal from groundwater. Journal of Hazardous Materials, 225, 164–172. https://doi.org/10.1016/j.jhazmat.2012.05.015
Song, B., Gong, J., Tang, W., Zeng, G., Chen, M., Xu, P., Shen, M., Ye, S., Feng, H., Zhou, C., & Yang, Y. (2020). Influence of multi-walled carbon nanotubes on the microbial biomass, enzyme activity, and bacterial community structure in 2, 4-dichlorophenol-contaminated sediment. Science of the Total Environment, 713, 136645. https://doi.org/10.1016/j.scitotenv.2020.136645
Tang, Y., Guan, X., Wang, J., Gao, N., McPhail, M. R., & Chusuei, C. C. (2009). Fluoride adsorption onto granular ferric hydroxide: Effects of ionic strength, pH, surface loading, and major co-existing anions. Journal of Hazardous Materials, 171(1–3), 774–779. https://doi.org/10.1016/j.jhazmat.2009.06.079
Tchomgui-Kamga, E., Ngameni, E., & Darchen, A. (2010). Evaluation of removal efficiency of fluoride from aqueous solution using new charcoals that contain calcium compounds. Journal of Colloid and Interface Science, 346(2), 494–499. https://doi.org/10.1016/j.jcis.2010.01.088
Wang, S. G., Ma, Y., Shi, Y. J., & Gong, W. X. (2009). Defluoridation performance and mechanism of nano-scale aluminum oxide hydroxide in aqueous solution. Journal of Chemical Technology & Biotechnology: International Research in Process, Environmental & Clean Technology, 84(7), 1043–1050. https://doi.org/10.1002/jctb.2131
Wang, F. Y., Wang, H., & Ma, J. W. (2010). Adsorption of cadmium (II) ions from aqueous solution by a new low-cost adsorbent—Bamboo charcoal. Journal of Hazardous Materials, 177(1–3), 300–306. https://doi.org/10.1016/j.jhazmat.2009.12.032
Wang, X., Pfeiffer, H., Wei, J., Dan, J., Wang, J., & Zhang, J. (2022). 3D porous Ca-modified Mg-Zr mixed metal oxide for fluoride adsorption. Chemical Engineering Journal, 428, 131371. https://doi.org/10.1016/j.cej.2021.131371
World Health Organization (WHO) (2004). Guidelines for drinking-water quality (third ed.). Recommendations. WHO, Geneva, 1, 334–335.
Xiang, W., Zhang, G., Zhang, Y., Tang, D., & Wang, J. (2014). Synthesis and characterization of cotton-like Ca–Al–La composite as an adsorbent for fluoride removal. Chemical Engineering Journal, 250, 423–430. https://doi.org/10.1016/j.cej.2014.03.118
Yagub, M. T., Sen, T. K., Afroze, S., & Ang, H. M. (2014). Dye and its removal from aqueous solution by adsorption: A review. Advances in Colloid and Interface Science, 209, 172–184. https://doi.org/10.1016/j.cis.2014.04.002
Zhang, Z., Tan, Y., & Zhong, M. (2011). Defluorination of wastewater by calcium chloride modified natural zeolite. Desalination, 276(1–3), 246–252. https://doi.org/10.1016/j.desal.2011.03.057
Funding
This work was supported by a National Research Foundation of Korea (NRF) grant funded by the Korean government (MSIT) (No. 2020R1C1C1008982).
Author information
Authors and Affiliations
Contributions
Moon-Yeong Choi was involved in writing—original draft, experiment, and data analysis; Chang-Gu Lee contributed to writing—review and editing; Seong-Jik Park was involved in the conceptualization, writing—review and editing, supervision and funding acquisition.
Corresponding author
Ethics declarations
Ethics approval and consent to participate
Not applicable.
Consent for publication
Not applicable.
Consent for participation
Not applicable.
Conflicts of interest
The authors declare that they have no competing interests.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary Information
Below is the link to the electronic supplementary material.
Rights and permissions
About this article
Cite this article
Choi, MY., Lee, CG. & Park, SJ. Conversion of Organic Waste to Novel Adsorbent for Fluoride Removal: Efficacy and Mechanism of Fluoride Adsorption by Calcined Venerupis philippinarum Shells. Water Air Soil Pollut 233, 281 (2022). https://doi.org/10.1007/s11270-022-05757-9
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s11270-022-05757-9