Abstract
The study aimed to analyze the chemical composition of pellet bedding made of straw or coffee husks (10, 25, 50%) and the performance characteristics of broiler ducks and footpad dermatitis. During rearing, the properties of the bedding and utility features of ducks were analyzed, and the frequency of footpad dermatitis (FPD) in ducks was verified. There was a decrease in dry matter from the 28th day of rearing. The crude fiber, NDF, ADF, and nitrogen content decreased compared to fresh bedding, while phosphorus and potassium increased. The highest pH was found in the CH25 and CH50 groups in fresh bedding on day 42 and in CH50 on day 14. High adj. R2 was found due to rearing time and bedding material (0.817–0.985). The ducks’ growth rate in the CH25 group was higher at week 6 than in the other groups. In CH10 and CH25 groups, higher carcass weight was found than in group C. In group CH10, a higher weight of pectoral muscles and lower wing proportion was found than in C. In CH25, a higher remains weight was shown than in C and CH50. In CH50, lower water-holding capacity in the pectoral muscles was found than in the other groups. Considering the bedding (the content of nitrogen, phosphorus, and potassium), carcass features, and meat quality (water-holding capacity, intramuscular fat, and water content), it is possible to use 10, 25 or 50% of coffee husks in straw pellets in the rearing of broiler ducks. Due to the FPD, the moisture should be lowered.
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Introduction
Poultry production requires constant monitoring of environmental conditions in livestock buildings (Loshkarev et al. 2019). It is also necessary to use high-quality bedding, which affects the production results, meat quality, and birds’ health (Bodo and Galik 2018; Diarra et al. 2021). The dynamic development of poultry production, mainly the increased number of birds kept on bedding, requires more good raw materials free from contamination. After the production cycle, such bedding could be used as a fertilizer in plant production. However, due to many factors (composition of the feed, type of bedding, density of birds per 1 m2 of the area), the bedding components content highly varies (Rogeri et al. 2016).
The properties of bedding are influenced mainly by its chemical composition and the content of individual components (Diarra et al. 2021). A good bedding material should be characterized by, among others: high water absorption, anti-caking properties, low price, easy availability (Garcia et al. 2012), softness, and thermal insulation (Souza et al. 2012). Keeping ducks in bedding is primarily one of the elements of their welfare. Birds can exhibit natural behavior, and high bedding quality (mainly absorption capacity) contributes to the formation of ammonia (Mohammed et al. 2019) and inflammation of the foot pads (FPD) (De Jong et al. 2014; Sonnabend et al. 2022). In addition, the high water absorption capacity of the bedding limits its excessive moisture, which is a favorable environment for the development of many microorganisms (Diarra et al. 2021). Keeping birds in the bedding also promotes better hygiene and reduces stress reactions, which has been confirmed in the example of broiler ducks (Mohammed et al. 2019).
Straw is the most popular bedding material in European poultry production, unlike in the United States, where sawdust is most used (Shepherd et al. 2017). However, new, alternative materials are increasingly being sought for such applications (Diarra et al. 2021). Oketch et al. (2023) researched using coconut peat, sawdust, and rice husks as bedding in the Pekin ducks production. As the authors indicated, rice husks can be a good bedding material with beneficial properties. Scientists have indicated that the region where raw material is produced is essential. For rice-producing countries such as South Korea, where the use of rice husks as bedding material for broiler chickens and ducks is approx. 85%. It also is crucial for materials competitiveness. However, bedding for ducks should be free of contaminants (toxins, molds, pathogens). A threat is the consumption of litter by birds (Farghly et al. 2021; Oketch et al. 2023).
Coffee husks are post-production waste during dry roasting (Cangussu et al. 2021), which can be used in various industrial sectors (Oliveira and Franca 2015). The possibility of their use in producing biofuels, mushrooms, and adsorbents and in feeding farm animals (chicken, cattle, sheep, pigs, and horses) has been verified (Oliveira and Franca 2015). Coffee husks were also tested at the request of the European Commission by EFSA for use to produce new food safe for humans (Turck et al. 2022). Available scientific studies also show the use of coffee husks as bedding for horses (Benezoli et al. 2019), pigs (Caldara et al. 2012), and poultry (Marín et al. 2015; Souza et al. 2018). Since coffee processing is increasing in Poland, managing coffee production waste is part of maintaining a sustainable agri-food market (Głowacka et al. 2018).
Coffee husks contain the most carbohydrates (58–85 g/100 g dry matter). In addition, the presence of proteins, fats, and minerals is also found (Oliveira and Franca 2015). The total fiber content of coffee husks was 65.83 g/100 g (Cangussu et al. 2021). The chemical composition of wheat straw includes, among others: dry matter (89–94%), protein (3.6%), acidic detergent fiber (54%), cellulose (40%), hemicellulose (26%), lignin ( 22.9%), ash (up to 9.9%), calcium (0.18%) and phosphorus (0.05%) (Khan and Mubeen 2012).
The available literature considering the effects of various bedding materials, particularly coffee husks, on the chemical composition of bedding, welfare, and performance of ducks under production conditions in Europe is limited. However, as one of the alternatives (e.g., the commonly used straw) coming from so far little-discussed industry sectors, they could support duck meat producers, mainly through an impact on the welfare and quality characteristics of the product.
The study aimed to analyze the chemical composition of bedding in the form of pellets with a different share of coffee husks and to evaluate broiler ducks’ growth performance, carcass characteristics, meat quality, and foot pad condition.
Materials and methods
The experiment was carried out following the applicable regulations on the use of animals in science. The study and methods were carried out after obtaining the opinion of the Departmental Animal Welfare Team and the permission of the Experimental Unit of the Bydgoszcz University of Science and Technology (No. 2/2022).
Animals and experimental design
In the 42 days of experimental rearing, 200 1-day-old male Cherry Valley ducks were used. The average initial body weight was 56.07 ± 1.47. All birds were divided into 4 equal groups (5 replications within 10 birds each). The stocking density did not exceed 17 kg per 1 m2. On the first day, an air temperature of 26 °C was used, and then it was gradually reduced to 20 °C. An additional heat source was installed in each of the pens and used until the 4th week of rearing (from 30 °C decreasing). Humidity was 60–65%. Feed and water were used ad libitum. Environmental conditions were done according to Biesek et al. (2022a). In all groups, ducks were fed with a commercial compound feed, the composition of which corresponded to the nutritional requirements for this poultry species. The two feeding phases were applied; the first feeding period lasted from day 1 to day 28 when the starter feed was used. From day 29 to day 42, the ducks were fed grower feed.
In the control group (C), wheat straw pellets were used as bedding material. Then, in the experimental groups, pellets with a different share of coffee husks were used, which were 10% (CH10), 25% (CH25), and 50% (CH50), respectively. In all groups, 7 kg of bedding per 1 m2 floor area was applied the day before the experiment. The pellet was prepared using the RTH-150 granulator (Peletto, Poznań, Poland) using wheat straw (previously crushed) or wheat straw in combination with the appropriate amount of coffee husks, depending on their percentage in the bedding. Coffee husks were obtained after dry roasting coffee in a roasting plant in the Kuyavian-Pomeranian Voivodeship in Poland. The pellet preparation was carried out under patent application pending procedure number P.44,383. On average, the pellet was characterized by 6 mm in diameter and 2 cm in length.
On the 42nd day of rearing, 10 birds from each group were selected for slaughter, with a body weight similar to the average body weight of birds in a given group (2 replicates each), and slaughtered. The body weight of chosen birds was compared to the average body weight of each replication (pen). In total, the body weight was 3104.05 g ± 254.07. The carcasses were then plucked and gutted. After all, the birds were slaughtered, the carcasses were transferred to a cold store (Hendi, Poznań, Poland) to be cooled at 4 °C for 24 h until meat quality analyzes were performed.
Chemical composition of bedding material
Bedding for chemical analysis was collected in string bags on 7 dates − 1st, 7th, 14th, 21st, 28th, 35th, and 42nd rearing days. The material from the pen’s center, near its wall, and from the feeder and drinker was collected into one bag (2 bags per pen). Samples were collected from the surface to the floor (in cross-section). At one time, 200 g of material per bag was collected. Dry matter content was determined using the PN-ISO 6865:2002 (2002) method, and crude fiber content using the PN-ISO 6496:2002 (2002) method. The content of components such as nitrogen, phosphorus, and potassium was also verified using the Kjeldahl method (PN-EN ISO 6492:2005, 2005), photometric and atomic absorption spectrometry (ASA, PN-EN ISO 6869:2002, 2002), respectively. In addition, the amount of acid detergent fiber (ADF) and neutral detergent fiber (NDF) was determined following the methodological assumptions contained in PN-EN ISO 13906:2009 (2009) and PN-EN ISO 16472:2007 (2007). Bedding pH measurements were made potentiometrically.
Growth performance and production efficiency
Birds’ body weight (BW) was measured on the first rearing day and every 7 days. Feed intake (FI) was recorded daily. Based on these results, growth rate (%) was calculated for each week of rearing, body weight gain ( \(\mathrm{BWG} =final\;body\;weight \left(g\right)-initial\;body\;weight \left(g\right)\)), average daily body weight gain (ADBWG = \(\frac{BW \left(g\right)}{age \left(days\right)}\)), average daily feed intake (ADFI = \(\frac{FI \left(g\right)}{age \left(days\right)}\)), feed conversion ratio (FCR = \(\frac{FI \left(kg\right)}{BWG\left(kg\right) }\)) for each feeding period and throughout the rearing period. In addition, the European Production Efficiency Index (EPEF = \(\frac{\left(viability\;\left(\%\right)\;\times\;BW\;\left(g\right)\right)}{age\;\left(days\right)\;\times\;FCR\;\left(\frac{kg\;feed}{kg\; gain}\right)}\)) and the European Performance Index (EBI = \(\frac{viability\;\left(\%\right)\;\times\;ADG\;\frac{\frac{g}{chick}}{day}}{FCR \frac{kg \ feed}{kg \ gain} \times 10 }\)). Calculations were made using formulas following the methods described by Biesek et al. (2022b).
Incidence of footpad dermatitis
On the day of slaughter, footpad dermatitis in all ducks was verified based on a 5-point scale proposed by Klambeck et al. (2019). In the cited research, the photography was shown. Based on this, the examination was done. Level 0 defines the absence of lesions on the foot pad. For score 1 - slight hyperkeratosis involving < 50% of the foot pad and toes, 2 - severe hyperkeratosis/parakeratosis involving > 50% of the foot pad and toes, 3 - pododermatitis affecting > 50% of the foot pad and all toes, and 4 - severe ulcerative inflammation entire foot and toes. Scores are given as a percentage of the group with a given score.
Carcass features and meat quality
The pH of the pectoral muscle was measured using a pH meter (Elmetron, Zabrze, Poland) with a dagger electrode 24 h after slaughter. The device was previously calibrated with standard pH 4.00, 7.00, and 9.00. The carcass and offal (heart, liver, gizzard) were weighed (Radwag, Radom, Poland), and then dissection was performed according to the method of Ziołecki and Doruchowski (1989). All selected elements were weighed, including neck, neck skin, pectoral muscles (major and minor), leg muscles (drumsticks and thighs, deboned), skin with subcutaneous fat, wings (with skin), abdominal fat, and carcass remains.
Meat color was measured using a Konica Minolta colorimeter (model CR-400) (after prior calibration), using the scale: L*- lightness, a*- redness, and b*- yellowness using the CIELab method. Drip loss was performed by placing the pectoral muscle in a string bag and suspended in a larger string bag to ensure easy water flow. Muscle weight was measured before bagging and after 24 h of storage at 4 °C. Drip loss was then calculated (Grau and Hamm 1952). Water holding capacity (WHC) was analyzed for pectoral and leg muscles minced with a meat grinder (Hendi, Poznań, Poland). A sample of 0.300 g (± 0.005 g) was weighed from each group and placed on pieces of Whatman paper (4 × 5 cm). Then the sample was covered with another piece of tissue paper and loaded with a 2 kg weight for 5 min. After this time, the sample was weighed again, and each group’s WHC of the pectoral and leg muscles was calculated (Honikel, 1987). To analyze the chemical composition (protein, intramuscular fat, salt, water), an 80 g sample of minced meat (legs and pectoral muscles) was prepared for each group. Analyzes were performed using FoodScan (FOSS) by spectrophotometry using near-infrared transmission (NIT). The protein, collagen, salt, intramuscular fat, and water content were analyzed (PN-A-82109:2010, 2010).
Texture analyses of the pectoral muscles were performed using a TA.XT plus C texture meter (Stable Micro System, Godalming, United Kingdom). Two samples measuring 1.5 × 1 × 1 cm were cut from each pectoral muscle. The meat texture was measured using firmness (N) and toughness (N×sec). For this purpose, the prepared samples were placed on a heavy-duty platform and then cut perpendicularly to the course of muscle fibers with a Warner-Bratzler flat knife. The knife speed was set to 1.5 mm/s. The second sample was previously subjected to thermal treatment at 80 °C for 40 min, cooled down, and subjected to analogous measurements as raw samples, following Gornowicz et al. (2018).
Breaking bone strength was performed using an Instron 3345 (Instron, Buckinghamshire, UK) with Bluehill 3.0 software (3345, 2013). Muscle-free tibia and femur were assessed using an appropriate attachment (Bend Future 10 mm Anvil). After the test, the result determined the maximum force necessary to break a bone (N) (Kuźniacka et al. 2017).
Statistical calculation
The numerical data were analyzed in the statistical program Statistica 13.3. (Tibco, Statsoft, Cracow, Poland). Production results were analyzed in 5 replicates per group. The results of carcass and meat quality features were verified on 10 repetitions for each group. For footpad dermatitis, each duck was considered separately. The mean values of quantitative features for each group (C, CH10, CH25, CH50) and the standard error of the mean (SEM) were calculated. The normal distribution and homogeneity of the sample were verified. Dependent variables were subjected to Tukey’s post-hoc test (multiple comparisons of statistically significant differences), assuming P < 0.05. Tukey’s various N test was used for footpad dermatitis. It was related to duck viability. The bedding characteristics were analyzed depending on the rearing days and the type of bedding material. Results are presented as the interaction of bedding material (C, CH10, CH25, CH50) and rearing days (0, 7, 14, 21, 28, 35, 42), assuming P < 0.05. Data are also separately presented as average values for rearing days or bedding material. The adjusted coefficient of determination (adj. R2) for each bedding feature was also analyzed.
Results
Table 1 presents the chemical composition of the pellet bedding with a different share of coffee husks at weekly intervals for 42 days. When comparing the data taking into account the interaction between the factors (breeding days × bedding material), statistically significant differences were found in all physicochemical characteristics of the bedding (P < 0.001).
Dry matter in all groups (C - CH50) was significantly highest in fresh bedding (day 0) compared to the other rearing days (in each group). Significantly the lowest dry matter was found in all types of bedding from day 28 to the end of rearing, compared to pellets on days 0 to 21 (P < 0.001). The highest crude fiber content was recorded in fresh straw pellets (group C) than in other groups. The lowest content was in the CH50 group on the 28th day of rearing (P < 0.001). When analyzing the content of NDF, the significantly highest value in groups C and CH10 in fresh material and the lowest in group CH25 on day 42 was noticed (P < 0.001). The highest ADF content was found in fresh bedding from groups C and CH10 compared to other values, except for the CH25 group from day 0. The lowest ADF content was found in the CH50 group from the 21st day of rearing, compared to other groups, except groups CH10, CH25, and CH50 on day 42 (P < 0.001).
In the CH25 and CH50 groups (day 0), nitrogen content was significantly higher than the CH10 group (day 0). The indicated groups had a significantly higher nitrogen content than the others. The lowest value was shown in group C on the 14th rearing day (P < 0.001). In all groups (C - CH50), fresh bedding (day 0) showed significantly the lowest phosphorus content compared to other groups at all dates (P < 0.001). Then, phosphorus content was increased on the 28th day, with its significantly highest content in group C and CH50 (P < 0.001). In the following days, the value decreased again. On the other hand, fresh bedding from groups C and CH10 was characterized by significantly the lowest potassium content (P < 0.001) compared to all groups at all dates. The highest potassium content was found in the CH50 group on the 42nd day of chicken rearing (P < 0.001). There was an increasing trend in potassium content during rearing, significantly from day 7 to the end of rearing, and a significant difference can be seen between all groups (C - CH50) up to day 21 and from day 28 (P < 0.001). The highest pH value was found in fresh bedding from the CH25 and CH50 groups, compared to the other groups (P < 0.001), except for CH50 on day 14 and CH25 and CH50 on day 42 (P > 0.05). The lowest pH values were found on day 7 in the CH25 and CH50 groups (P < 0.001). When comparing all groups on all dates, a trend of differences in the pH of the bedding was noted, with an increase in pH value on the 28th day after its previous decrease on the 21st day (P < 0.001). High adj. R2 has been demonstrated for all features ranging from 0.817 to 0.985.
When analyzing the chemical composition, according to rearing days, significant differences for each feature were found (P < 0.001). Higher dry matter content was shown in fresh bedding. A decreasing trend was demonstrated in the following days; from day 28, it remained at a similar level (< 25%). The highest crude fiber content was found in fresh bedding, as was the NDF and ADF content (P < 0.001). Significantly the lowest content of crude fiber and NDF was found on day 28, ADF on days 21 and 42 (P < 0.001). Nitrogen content was higher in fresh material, significantly decreased until day 14, and increased on days 21 and 28 (P < 0.001). On the 35th and 42nd days, it significantly decreased compared to the 28th day of rearing (P < 0.001). The lowest content of phosphorus was found in the fresh material. An upward trend to 28–35 days was noticed and decreased again on day 42 (P < 0.001). Similarly, changes in the content of potassium were found. The highest content characterized the material on the 42nd day of rearing (P < 0.001). The pH value, relative to days, was highest in fresh material (day 0) and lowest on day 7 (P < 0.001). High and very high adj. R2 has been demonstrated for features tested according to rearing days (from 0.502 to 0.944).
When comparing the average values with the bedding material, statistically significant differences were found in the content of crude fiber, NDF, ADF, nitrogen, and potassium (P < 0.05). The crude fiber and ADF content were significantly higher in group C and CH10 than in CH50 (P < 0.001, P = 0.002, respectively). The CH50 group showed significantly lower NDF content than the other groups (P < 0.001). Nitrogen content was higher in the CH50 group than in C and CH10 and in CH25 compared to C (P < 0.001). The potassium content in the CH50 group was significantly higher than in the other groups (P = 0.002). When analyzing the characteristics concerning the bedding material, a low adj. R2 was shown (0.002 to 0.122).
The production results of ducks are presented in Table 2. The highest growth rate (%) was found for ducks from the CH25 group (P = 0.009) compared to the other groups in the last week of rearing. For other features, no statistically significant differences between the groups were found (P > 0.05). Footpad dermatitis (FPD) in ducks was also verified on the day of slaughter (Table 3). There were no statistically significant differences between the groups (P > 0.05).
The carcass characteristics of ducks are presented in Table 4. Birds in the CH25 group had the highest pre-slaughter weight compared to groups C and CH50 (P = 0.002). Significantly higher carcass weight and carcass weight with offal were found in the CH10 and CH25 groups compared to group C. In the CH25 group, significantly higher liver weight was also found (P = 0.043), and a lower percentage of the neck in the carcass (P = 0.020). Significantly lower pectoral muscle weight was found in group C compared to CH10 (P = 0.036), in contrast to the percentage of wings in the carcass (P = 0.012). Lower carcass’ remains weight was found in groups C and CH50 (P = 0.006).
The physicochemical properties of the pectoral and leg muscles and leg bone strength are presented in Table 5. The CH25 group pectoral muscles were significantly characterized by the highest water retention capacity (P < 0.001) and the percentage of water content (P < 0.001). The highest protein content was found in group C compared to the other groups (P < 0.001). Significantly the lowest content of collagen, salt, and intramuscular fat was found in the pectoral muscles of ducks from the CH25 group (P < 0.001). The highest water-holding capacity was demonstrated in the leg muscles of ducks from the CH25 and CH50 groups (P = 0.004), which at the same time did not differ significantly from the muscles from the CH10 group. The highest protein and water content characterized leg muscles from group C compared to the experimental groups (P < 0.001). The percentage of salt was significantly highest in leg muscles in the CH10 group and intramuscular fat in the CH50 group (P < 0.001).
Discussion
Conducting a physicochemical analysis of the bedding after the production cycle is essential in assessing its future suitability for use as a natural fertilizer in plant production (Rogeri et al. 2016). Our research found higher nitrogen and potassium content in the CH50 group and phosphorus in all experimental groups compared to group C on the 42nd day. Poultry manure may vary due to the type of feed used, feed additives, bedding, and storage (Bolan et al. 2010). Bedding after rearing chickens, a mixture of wood dust or rice hulls, feed, and feces, was characterized by a lower dry matter (66%) and higher nitrogen, potassium, and phosphorus content (Rogeri et al. 2016). It depends on the type of bedding used and the ability of the birds to use the feed. It is assumed that the nitrogen and phosphorus content is higher in chicken manure than in fresh bedding (Bolan et al. 2010), whereas, in our research, such an effect was in phosphorus and potassium content. According to Kılıc and Guleciuz (2017), wheat straw contains 76.68% NDF and 46.89% ADF.
On the other hand, according to Badarina et al. (2013), coffee husks contained 95.17% and 87.18% of ADF and NDF in dry matter, respectively. In the CH50 group, the value of NDF and ADF was significantly the lowest compared to the other groups. In the litter after 6 weeks of chicken rearing, the NDF was 54.2%, and the ADF was 27.3% (Bakshi and Fontenot 1998). This trend is consistent with our results and may be due to the high proportion of duck feces in the samples for testing on day 42. In our research, on day 21, pH decreased. However, since day 28, was increasing. A lower pH of the litter may improve its quality due to the reduction of enzyme activity and an unfavorable environment for the development of bacteria that convert nitrogen compounds into ammonia (NH3), which is one of the factors affecting the welfare of birds (Toppel et al. 2019).
As pointed out by Brink et al. (2022), high clumping of bedding may explain the significantly lower percentage of nitrogen and uric acid due to reduced water evaporation and oxygen availability, which affected the limited conversion of nitrogen compounds to ammonia. In our research, the pellets (in each group) at the end of rearing contained high moisture, which may have contributed to the high level of caking. Nitrogen content was also lower in bedding than at the beginning of rearing. The increased moisture also affected the increasing pH since the 4th week of rearing.
The highest growth rate of ducks was shown in the CH25 group in the last week of rearing. The influence of the type of litter on the relative growth rate was also found in the studies of Mohammed et al. (2019). As the authors indicate, this may be related to the more intense manifestation of specific bird behaviors, particularly those related to feed intake. Eser et al. (2022) compared wood shavings and paper waste sludge (PWS). As indicated by the authors, the bedding was a mixture of PWS and sepiolite (50:50) to reduce the risk of too high humidity when using only PWS. The birds’ highest body weight and weight gain (P < 0.001) was observed on the 42nd rearing day in the group where this type of bedding and wood shavings were used. There was also no negative effect of PWS and sepiolite on selected carcass features and physicochemical parameters of pectoral and leg muscles. Similar conclusions were reported by Onbaşılar (2022). The study also used PWS and sepiolite as bedding materials in broiler chickens. The author stated that bedding affects birds’ well-being and natural behavior. Using alternative waste materials has been shown to increase the percentage of walking and resting behaviors.
The severity of FPD changes indicates flock health and birds’ well-being. So far, the type of bedding material used has been of great importance in the occurrence of this lesion. Findings of intense changes in FPD in broiler chickens kept on coconut husk or grass at 10.2% and 11.4%, respectively. In contrast, no such changes were noted in wood chips or rice husks (Garcês et al. 2017). Compared to plastic flooring, a lower percentage of FPD in ducks was found with wood chip bedding. Changes at levels 2, 3, and 4 were shown (De Almeida et al. 2017). According to Oke et al. (2019), the type of bedding did not affect the occurrence of FPD in broiler chickens using wood chips, cut corn cobs, and Panicum maximum. According to Qin et al. (2019), FPD in ducks may also increase the inflammatory response of birds (higher concentrations of endotoxins in plasma and interleukins) and affect changes in the cecal microbiome, which is of great importance in terms of herd health.
Barbosa et al. (2022) studied the influence of different litter compositions on broiler chicken locomotion. The authors used wood shavings, rice husks, and grass with different lawn grass (Zoysia japonica) ratios. The pododermatitis on various days was evaluated. The lower presence of FPD was in the group with rice husks and different levels of grass. However, in our research, even severe ulcerative pododermatitis on the whole footpads and toepads in each group. Our observations indicated that this situation might result from a high moisture content (since the 28th day) of the bedding due to splashing a large amount of water from the drinkers during its intake by the birds. Barbosa et al. (2022) discussed that pododermatitis’s severity increases with bedding moisture increasing. The moisture softens and opens the footpad skin. It results in immune system reaction and dermatitis causing. The negative impact on pododermatitis was from the 28th day. It corresponds with our results. In contrast, Boussaada et al. (2022) concluded that inflammation of the foot pads and ankle joints was not correlated with the physicochemical parameters of the bedding (pH, NH3, moisture).
When analyzing the characteristics of duck carcasses, the highest pre-slaughter weight, carcass weight with offal, and liver weight were found in the CH25 group. Nevertheless, the slaughter yield was similar in all groups, which indicates that the bedding had no adverse effect on the carcass. The other types of bedding impact were analyzed (wood chips, sand, coconut husk, rice husks, grass, corncobs, and newspapers), and the authors found a minor effect on the final body weight of birds (Garcês et al. 2017). As cited authors noted, possible changes in carcass characteristics of chickens were attributed to the association with the incidence of footpad dermatitis, which limited the ability to move freely and eat feed.
According to Oke et al. (2019), the bedding did not affect meat’s protein and fat content, unlike our research, where significant differences between the groups were found in all analyzed chemical components (except for collagen in the leg muscles). The most favorable results for water-holding capacity (WHC) were found in groups CH50 (pectoral muscles) and C (leg muscles). WHC is one of the main features influencing consumer preferences when choosing a product and testing its freshness. Significant importance for changes in WHC is also attributed to glycolysis, denaturation of muscle proteins, and shortening of sarcomeres during rigor mortis (Bowker 2017). However, as cited author indicated, WHC is related to many factors. In particular, attention is paid to the environment in the livestock building (e.g., humidity, temperature). It contributes to the potential occurrence of stress (thermal or oxidative). Oxidative stress reduces the activity of calcium ion transfer proteins, disturbs muscle homeostasis, and thus reduces WHC. FPD, which occurred in all groups at different levels, can also be a stress factor (Bowker 2017). It could affect the different WHC values in the pectoral and leg muscles. Significantly higher intramuscular fat content (IMF) was found in the CH50 group for pectoral muscles and leg muscles, which may be a good feature since IMF largely determines the palatability of poultry meat (Zhao et al. 2007). So far, changes in IMF content in ducks depending on the housing system have been confirmed (Guo et al. 2020). With age, increased content of IMF was found in the pectoral muscles of birds kept on the net and in the leg muscles of ducks from the bedding system (sawdust bedding). In addition, the authors also pointed to a higher content of monounsaturated and polyunsaturated fatty acids in the muscles of ducks kept on the grate.
Environmental factors can also influence the deposition of fat in poultry meat. Too high a temperature can lead to heat stress. The studies conducted in this area are inconsistent, as they indicate both an increase and a decrease in the fat content in the meat of broiler chickens (Tůmová and Teimouri 2010). The stress factor in our research may be the bedding moisture and the occurrence of FPD in all groups at different levels, resulting in variability of the IMF content in the pectoral and leg muscles. It can also be assumed that carbohydrate metabolism has been disturbed, which is the most responsible for IMF formation in the muscles (Luo et al. 2022).
Broilers spend their entire lives on bedding. The bedding management strategy is crucial (Onbaşılar 2022). According to the cited author, the behavior of birds is part of the interaction with the environment. Therefore, the behavior of birds and their well-being will affect the efficiency of production and the quality of the raw material. Toghyani et al. (2010) found that different bedding materials affected feed and water intake in birds. Feed, water intake, and bedding quality can influence stress levels in birds (Yerpes et al. 2020). Our study’s results regarding meat quality and carcass traits could have resulted from individual ducks’ perceptions of stress stimuli, e.g., bedding moisture. Stress, related to the environmental conditions of birds (e.g., stocking density), affects carcass characteristics and meat quality (Nasr et al. 2021). A study on duck housing systems showed that it is essential for productivity, carcass characteristics, and meat quality, which is related to the immune and antioxidant status (Ghanima et al. 2020).
No economic analysis was performed in the presented study. The bedding material (straw and coffee husks) was obtained free of charge. The only costs that could affect the profitability of production concerned electricity and work done in producing pellets.
In conclusion, after 42 days of broiler duck rearing, a significantly higher nitrogen and potassium content was found in the manure after the duck production cycle in the CH50 group compared to the other groups. The phosphorus content was also significantly higher in the experimental groups than in the control group, which may be necessary for further management. A significant decrease in bedding dry matter after 28 days was unbeneficial, possibly related to the ducks’ behavior (water intake). Further actions should be taken to improve this indicator. Considering the characteristics of the carcass, it is worth paying attention to the higher carcass weight (CH10 and CH25) and pectoral muscle weight (CH10) in selected groups where coffee husks in the bedding were used. However, considering the slaughter yield, it should be concluded that the different bedding materials had no adverse effect. The pectoral muscles from the CH50 group showed a significantly better ability to hold water and the highest content of IMF (similar to the leg muscles), which may determine the technological suitability of the meat and its sensory properties. No negative impact on production efficiency results allows for the reuse of waste - coffee husks, as support for pro-environmental activities. Using the regression tool (adj. R2) made it possible to conclude that the primary determinant was the time (rearing period) for the characteristics of the bedding material. These changes are also related to feed residues and, above all, duck manure. Thus, the coffee husks could be used in any variant (10, 25, 50%), depending on availability. Nevertheless, due to the foot pads’ condition in all groups, further research should be continued, which could be related to the dry matter of bedding on days 28–42.
Data availability
The datasets generated and analyzed during the current study are not publicly available due to all the results in the form of means and statistics presented in this paper. Still, it is available from the corresponding author at a reasonable request.
Code availability
Not applicable.
References
Badarina I, Evvyernie D, Toharmat T, Herliyana EN, Darusman LK (2013) Nutritive value of Coffee Husk fermented with Pleurotus ostreatus as ruminant feed. Media peternakan 36:58–58
Bahshi MPS, Fontenot JP (1998) Processing and nutritive evaluation of broiler litter as livestock feed. Anim Feed Sci Technol 74:337–345
Barbosa DK, Garcia RG, Burbarelli MFC, Komiyama CM, Gandra ERS, Przybulinski BB, Castilho VAR, Bueno JPT, Santos W (2022) Different litter compositions influence broiler chicken locomotion. Iran J Vet Res 23:137–146
Benezoli AZ, Gonçalves SP, Rondon DA, Moscon LA, Schild AL, Monteiro BS, Riet-Corea F, Marcolongo-Pereira C (2019) Equine poisoning by coffee husk (Coffea canephora) in northern Espírito Santo, Brazil. Acta Sci Vet 47. https://doi.org/10.22456/1679-9216.98955
Biesek J, Banaszak M, Grabowicz M, Wlaźlak S, Adamski M (2022a) Production efficiency and utility features of broiler ducks fed with feed thinned with wheat grain. Animals 12:3427
Biesek J, Banaszak M, Wlaźlak S, Adamski M (2022b) The effect of partial replacement of milled finisher feed with wheat grains on the production efficiency and meat quality in broiler chickens. Poult Sci 101:101817
Bodo S, Galik R (2018) Monitoring of litter quality and temperature in breeding of fattening chickens. Acta Technol Agric 1:33–37
Bolan NS, Szogi AA, Chuasavathi T, Seshadri B, Rothrock MJ, Panneerselvam P (2010) Uses and management of poultry litter. World’s Poult Sci J 66:673–698
Boussaada T, Lakhdari K, Benatallah SA, Meradi S (2022) Effects of common litter types and their physicochemical properties on the welfare of broilers. Vet World 15:1523–1529
Bowker B (2017) Developments in our understanding of water-holding capacity. In Poultry quality evaluation. Woodhead Publishing pp. 77–113.
Brink M, Janssens GPJ, Demeyer P, Bağci Ö, Delezie E (2022) Ammonia concentrations, litter quality, performance and some welfare parameters of broilers kept on different bedding materials. Br Poult Sci 63:768–778
Caldara FR, Rosa PSG, Ferreira RA, Reis NMO, Naas IA, Paz ICLA, Garcia RG, Ferreira VMOS (2012) Behavior, performance and physiological parameters of pigs reared in deep bedding. Eng Agric 32:38–46
Cangussu LB, Melo JC, Franca AS, Oliveira LS (2021) Chemical characterization of Coffee Husks, a By-Product of Coffea arabica production. Foods 10:3125
De Almeida EA, De Souza LFA, Sant’Anna AC, Bahiense RN, Macari M, Furlan RL (2017) Poultry rearing on perforated plastic floors and the effect on air quality, growth performance, and carcass injuries—experiment 1: thermal comfort. Poult Sci 96:3155–3162
De Jong IC, Gunnik H, van Harn J (2014) Wet litter not only induces footpad dermatitis but also reduces overall welfare, technical performance, and carcass yield in broiler chickens. J Appl Poult Res 23:51–58
Diarra S, Lameta S, Amosa F, Anand S (2021) Alternative bedding materials for Poultry: availability, efficacy, and Major Constraints. Front Vet Sci 8:669504
Eser H, Onbaşılar EE, Yalçın S, Ramay MS, Karakan T, Güngör ÖF, Yalçın S (2022) Comparison of litter quality, performance, and some welfare parameters of broilers reared on the sepiolite-supplemented paper waste sludge. Environ Sci Pollut Res 29:10380–10387
Farghly MFA, Mahrose KM, Cooper RG, Metwally KA, Abougabal MS, El-Ratel IT (2021) Use of available crop by-products as alternative bedding materials to wheat straw for rearing broilers. Animal 15:100260
Garcês APJT, Afonso SMS, Chilundo A, Jairoce CTS (2017) Evaluation of different litter materials for broiler production in a hot and humid environment: 2. Productive performance and carcass characteristics. Trop Anim Health Prod 49:369–374
Garcia RG, Almeida Paz ICL, Caldara FL, Nääs IA, Pereira DF, Ferreira VMOS (2012) Selecting the most adequate bedding material for broiler production in Brazil. Braz J Poult Sci 14:121–127
Ghanima MMA, El-Edel MA, Ashour EA, Abd El-Hack ME, Othman SI, Alwaili MA, Allam AA, Khafaga AF, Abd El-Aziz AH (2020) The influences of various Housing Systems on Growth, carcass traits, meat quality, immunity and oxidative stress of meat-type ducks. Animals 10:410
Głowacka R, Górska A, Wirkowska-Wojdyła M (2018) Kawowa łuska srebrzysta – nowa, naturalna alternatywa pozyskiwania wybranych związków bioaktywnych. Zesz Probl Postęp Nauk Rol 592:15–25
Gornowicz E, Lewko L, Zwierzyński R (2018) Analiza tekstury mięsa gęsi. Wiadom Zootech R LVI:42–52 (in Polish)
Grau R, Hamm R (1952) Eine einfache methode zur bestimmung der wasserbindung in fleisch-wirt. Fleischwirtschaft 4:295–297
Guo Y, Guo X, Deng Y, Cheng L, Hu S, Liu H, Hu J, Hu B, Li L, He H, Wang J (2020) Effects of different rearing systems on intramuscular fat content, fatty acid composition, and lipid metabolism–related genes expression in breast and thigh muscles of Nonghua ducks. Poult Sci 99:4832–4844
Honikel KO (1987) The water binding of meat. Fleischwirtschaft 67:1098–1102
Khan TS, Mubeen U (2012) Wheat straw: a pragmatic overview. Cur Res J Biol Sci 4:673–675
Kılıc U, Gulecyuz E (2017) Effects of some additives on in Vitro true digestibility of wheat and soybean straw pellets. Open Life Sci 12:206–213
Klambeck L, Stracke J, Spindler B, Klotz D, Wohlsein P, Schön HG, Kaufmann F, Kemper N, Andersson R (2019) First approach to validate a scoring system to assess footpad dermatitis in Pekin ducks. Europ Poult Sci 83. https://doi.org/10.1399/eps.2019.262
Kuźniacka J, Banaszak M, Adamski M (2017) The analysis of meat and bone traits of Plymouth Rock cockerels and capons (P55) at different age. Poult Sci 96:3169–3175
Loshkarev IY, Shirobokova TA, Baranova IA, Batanov SD (2019) Implementation of the energy-saving lighting mode in the poultry-farming house due to the automated control system. J Phys Conf Ser 1333:042019
Luo N, Shu J, Yuan X, Jin Y, Cui H, Zhao G, Wen J (2022) Differential regulation of intramuscular fat and abdominal fat deposition in chickens. BMC Genom 23:308
Marín OLZ, Tinôco IFF, Saraz JAO, Souza CF, Vieira MFA (2015) Evaluation of the fertilizer and contamination potential of different broiler litter types subjected to various use cycles. Rev Fac Nac Agron Medellin 68:7637–7646
Mohammed HH, Abdelaty AI, Saleem ASY, Youssef MI, Abdel-Hamid SE (2019) Effect of bedding materials on duck’s welfare and growth performance. Slov Vet Res 56:149–156
Nasr MAF, Alkhedaide AQ, Ramadan AAI, Hafez ASE, Hussein MA (2021) Potential impact of stocking density on growth, carcass traits, indicators of biochemical and oxidative stress and meat quality of different broiler breeds. Poult Sci 100:101442
Oke OE, Daramola JO, Uyanga V, Iyasere OS, Njoku CP, Babatunde MB (2019) Influence of bedding materials on organ weights, meat quality, breast and footpad dermatitis of broiler chickens under hot humid climate. ATS 52:3–8
Oketch E, Kim YB, Yu M, Hong JS, Nawarathne SR, Heo JM (2023) Differences in bedding material type could alter the growth performance of White Pekin ducks raised over 42 days. J Anim Sci Technol 65:377–386
Oliveira LS, Franca AS (2015) Chap. 31 - An overview of the potential uses for coffee husks. In: Preedy VR (ed) Coffee in Health and Disease Prevention. Academic Press, Elsevier Inc., pp. 283–291
Onbaşılar EE (2022) Effect of alternative litter materials on the behaviour of male broilers. Behav Processes 195:104566
PN-A-82109:2010 (2010) Meat and meat preparations—determination of fat, protein, and water content. Near Infrared Transmission Spectrometry (NIT) using Artificial Neural Network (ANN) calibration, Lublin, Poland (in Polish)
PN-EN ISO 6869:2002 (2002) Pasze – oznaczanie zawartości wapnia, miedzi, żelaza, magnezu, manganu, potasu, sodu i cynku – metoda absorpcyjnej spektrometrii atomowej (in Polish)
PN-EN ISO 6492:2005 (2005) Pasze – oznaczanie zawartości tłuszczu (in Polish)
PN-EN ISO 16472:2007 (2007) Pasze – oznaczanie zawartości włókna obojętnodetergentowego po traktowaniu amylazą (aNDF) (in Polish)
PN-EN ISO 13906:2009 (2009) Pasze – oznaczanie zawartości włókna kwaśnodetergentowego (ADF) i ligniny kwaśnodetergentowej (ADL) (in Polish)
PN-ISO 6496:2002 (2002) Pasze – oznaczanie wilgotności i zawartości innych substancji lotnych (in Polish)
PN-ISO 6865:2002 (2002) Pasze – oznaczanie zawartości włókna surowego – metoda z pośrednią filtracją (in Polish)
Qin SM, Bai WQ, Zhang KY, Ding XM, Bai SP, Wang JP, Peng HW, Yang YF, Chen C, Zeng QF (2019) Different microbiomes are found in healthy breeder ducks and those with foot pad dermatitis. Poult Sci 98:6340–6348
Rogeri DA, Ernani PR, Mantovani A, Lourenço KS (2016) Composition of Poultry Litter in Southern Brazil. Rev Bras Cienc Solo 40:e0140697
Shepherd EM, Fairchild BD, Ritz CW (2017) Alternative bedding materials and litter depth impact litter moisture and footpad dermatitis. J Appl Poult Res 26:5018–5528
Sonnabend SJ, Spieß F, Reckels B, Ahmed MFE, El-Wahab AA, Sürie C, Lingens JB, Visscher C (2022) Influence of using Perforated Plastic Flooring beneath the Waterline on Growth Performance, Litter Quality, and Footpad Health of broiler chickens: a Field Study. Animals 12:1749
Souza CF, Santos CR, Inoue KRA, Tinôco IFF, Ferreira WPM (2018) Additives to control the quality of coffee husk poultry litter. Eng Agric 26:197–206
Souza C de F, Santos CR dos, Inoue KRA, Tinôco I de FF, Sousa MS, Savastano Júnior H (2012) Effect of chemical conditioners on the quality of the poultry litter. ASABE Dallas, Texas. https://doi.org/10.13031/2013.41975
Toghyani M, Gheisari A, Modaresi M, Tabeidian SA, Toghyani M (2010) Effect of different litter material on performance and behaviour of broiler chickens. Appl Anim Behav Sci 122:48–52
Toppel K, Kaufmann F, Schon H, Gauly M, Andersson R (2019) Effect of pH-lowering litter amendment on animal-based welfare indicators and litter quality in a european commercial broiler husbandry. Poult Sci 98:1181–1189
Tůmová E, Teimouri A (2010) Fat deposition in the broiler chicken: a review. Sci Agric Bohem 41:121–128
Turck D, Bohn T, Castenmiller J, De Henauw S, Hirsch-Ernst KI, Maciuk A, Mangelsdorf I, McArdle HJ, Naska A, Pelaez C, Pentieva K, Siani A, Thies F, Tsabouri S, Vinceti M, Cubadda F, Frenzel T, Heinonen M, Marchelli R, Neuh€auser-Berthold M, Poulsen M, Maradona MP, Schlatter J, van Loveren H, Ververis E, Knutsen HK (2022) Safety of dried coffee husk (cascara) from Coffea arabica L. as a novel food pursuant to regulation (EU) 2015/2283, 2015. EFSA J 20:7085
Yerpes M, Llonch P, Manteca X (2020) Factors associated with cumulative first-week mortality in broiler chicks. Animals 10:310
Zhao GP, Chen JL, Zheng MQ, Wen J, Zhang Y (2007) Correlated responses to selection for increased intramuscular Fat in a chinese Quality Chicken line. Poult Sci 86:2309–2314
Ziołecki J, Doruchowski W (1989) Methods for the analysis of meat traits. COBRD Publishing, Poznan, PL (in Polish)
Acknowledgements
The authors would like to thank the Laboratory of Chemical Research and Instrumental Analyzes for technical assistance in the chemical analyses.
Funding
The research was carried out as part of project No. 2021/05/X/NZ9/00820, financed by the National Science Center (NSC, Poland).
Author information
Authors and Affiliations
Contributions
All authors participated in the described experiment. J.B. - research concept, J.B., S.W., M.B. - control of work during the rearing of ducks and meat quality analyses; J.B., M.G. – bedding chemical composition analyses; J.B. – statistical analyses; J.B., S.W. - drafting the manuscript; M.B., M.G., - revision of the manuscript. All authors participated in and approved the final version of the manuscript.
Corresponding author
Ethics declarations
Ethics statement
The experiment was carried out following the applicable regulations on the use of animals in science. The study and methods were carried out after obtaining the opinion of the Departmental Animal Welfare Team and the permission of the Experimental Unit of the Bydgoszcz University of Science and Technology (No. 2/2022).
Consent to participate
Authors have permission to participate.
Consent for publication
Authors have permission for publication.
Competing interests
The authors declare no competing interests.
Additional information
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Biesek, J., Wlaźlak, S., Banaszak, M. et al. Evaluation of coffee husks in pellet bedding, performance characteristics, footpad dermatitis scoring, and meat quality of broiler ducks. Vet Res Commun 48, 165–177 (2024). https://doi.org/10.1007/s11259-023-10196-w
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11259-023-10196-w