Abstract
Micron thin films and microsupercapacitors based on polyvinyl alcohol, starch, methyl cellulose, and nickel acetate have been fabricated using the one-step formation of laser-induced graphene. Surface finishing of films and decomposition of nickel acetate to nickel oxide have been achieved with the help of CO2 laser. The optical studies of thin films and microsupercapacitors have been conducted, which are highly transparent in the UV–visible regime. There is no need of binders, current collectors, or separators in interdigitated microsupercapacitors. Starch-based microsupercapacitors (PSM) have superior electrochemical performance and stability than methyl cellulose (PMM) in the presence of 6-M KOH electrolyte. The maximum capacitance of PSM is 28.89 µF cm−2 in 6-M KOH at the scan rate of 1 mV s−1 from cyclic voltammetry. The specific energy density is 93.75 × 10−6 µWh cm−2 and the power density is 0.12 µW cm−2. The PMM has a specific capacitance of 2.5 nF cm−2 when compared to PSM of 0.52 µF cm−2 without electrolyte. The cycle life of PSM is 2500 cycles which shows its robustness. The performance of the microsupercapacitors is better than the other gate dielectric materials used in transistors and in the range for integration of energy storage devices in on-chip electronic and photonic devices.
Similar content being viewed by others
Data availability
The datasets generated during and/or analyzed during the current study are available from the corresponding author on reasonable request.
References
F. Bu, W. Zhou, Y. Xu, Y. Du, C. Guan, W. Huang, Npj Flex. Electron. 4, 31 (2020)
X. Jiang, X. Zhao, Y. Sun, Y. He, L. Jiang, Chem. Eng. J. 462, 142209 (2023)
P. Huang, C. Lethien, S. Pinaud, K. Brousse, R. Laloo, V. Turq, M. Respaud, A. Demortière, B. Daffos, P.L. Taberna, B. Chaudret, Y. Gogotsi, P. Simon, Science. 351, 691 (2016)
R. Nigam, R. Kumar, K.K. Kar, in Handbook of Nanocomposite Supercapacitor Materials IV, ed. By K.K. Kar (Springer, Cham, 2023), pp. 89–122
K.H. Dinh, P. Roussel, C. Lethien, ACS Omega. 8, 8977 (2023)
N.A. Kyeremateng, T. Brousse, D. Pech, Nat. Nanotechnol. 12, 7 (2017)
H. Liu, Z. Sun, Y. Chen, W. Zhang, X. Chen, C.-P. Wong, ACS Nano. 16, 10088 (2022)
Y. Wang, Y. Zhao, L. Qu, J. Energy Chem. 59, 642–665 (2021)
G.F. Hawes, P. Verma, M. Uceda, G. Karimi, B.S. Noremberg, M.A. Pope, ACS Appl. Mater. Interfac. 15, 10570 (2023)
Z. Peng, R. Ye, J.A. Mann, D. Zakhidov, Y. Li, P.R. Smalley, J. Lin, J.M. Tour, ACS Nano 9, 5868–5875 (2015)
Y. Chyan, R. Ye, Y. Li, S.P. Singh, C.J. Arnusch, J.M. Tour, ACS Nano. 12, 2176 (2018)
W. Zhang, Y. Lei, F. Ming, Q. Jiang, P.M.F.J. Costa, H.N. Alshareef, Adv. Energy Mater. 8, 1801840 (2018)
H. Liu, Y. Xie, J. Li, Z. Sun, J. Liu, K. Moon, L. Lu, Y. Chen, Y. Tang, X. Chen, C.-P. Wong, Chem. Eng. J. 404, 126375 (2021)
W.B. Han, J.H. Lee, J. Shin, S. Hwang, Adv. Mater. 32, 2002211 (2020)
E.A. Van Etten, E.S. Ximenes, L.T. Tarasconi, I.T.S. Garcia, M.M.C. Forte, H. Boudinov, Thin Solid Films. 568, 111 (2014)
Y. Zhai, J.-Q. Yang, Y. Zhou, J.-Y. Mao, Y. Ren, V.A.L. Roy, S.-T. Han, Mater. Horiz. 5, 641 (2018)
B. Jacob, S.W. Ng, D.T. Wang, in Memory Systems-Cache, DRAM, Disk (Elsevier, 2008), pp. 1–54
H.N. Fard, G.B. Pour, M.N. Sarvi, P. Esmaili, Ionics (Kiel). 25, 2951 (2019)
R. Nigam, K.K. Kar, Langmuir. 38, 12235 (2022)
N.H. Zakaria, N. Muhammad, M.M.A.B. Abdullah, IOP Conf. Ser. Mater. Sci. Eng. 209, 012087 (2017)
P. Nasatto, F. Pignon, J. Silveira, M. Duarte, M. Noseda, M. Rinaudo, Polym. (Basel). 7, 777 (2015)
S. Alipoori, M.M. Torkzadeh, M.H.M. Moghadam, S. Mazinani, S.H. Aboutalebi, F. Sharif, Polym. (Guildf). 184, 121908 (2019)
M.E. Rodriguez-Garcia, M.A. Hernandez-Landaverde, J.M. Delgado, C.F. Ramirez-Gutierrez, M. Ramirez-Cardona, B.M. Millan-Malo, S.M. Londoño-Restrepo, Curr. Opin. Food Sci. 37, 107–111 (2021)
K. Das, D. Ray, N.R. Bandyopadhyay, A. Gupta, S. Sengupta, S. Sahoo, A. Mohanty, M. Misra, Ind. Eng. Chem. Res. 49, 2176 (2010)
N.A. Shamsuri, S.N.A. Zaine, Y. Mohamed, Yusof, M.F. Shukur, J. Appl. Polym. Sci. 139, 52076 (2022)
J.L. Garcia-Miquel, Q. Zhang, S.J. Allen, A. Rougier, A. Blyr, H.O. Davies, A.C. Jones, T.J. Leedham, P.A. Williams, S.A. Impey, Thin Solid Films. 424, 165 (2003)
T. Sheela, R.F. Bhajantri, V. Ravindrachary, S.G. Rathod, P.K. Pujari, B. Poojary, R. Somashekar, Radiat. Phys. Chem. 103, 45 (2014)
Y. Shi, D. Xiong, J. Li, K. Wang, N. Wang, RSC Adv. 7, 1045 (2017)
V. Vuiblet, T.T. Nguyen, A. Wynckel, M. Fere, L. Van-Gulick, V. Untereiner, P. Birembaut, P. Rieu, O. Piot, Analyst. 140, 7382 (2015)
L. Bonetti, L. De Nardo, F. Variola, S. Farè, Mater. Lett. 274, 128011 (2020)
S.-H. Lee, K.-Y. Kim, J.-R. Yoon, NPG Asia Mater. 12, 28 (2020)
G. Anandha Babu, G. Ravi, T. Mahalingam, M. Kumaresavanji, Y. Hayakawa, Dalton Trans. 44, 4485 (2015)
H.S. Ragab, Abd El-Kader. Phys. Scr. 87, 025602 (2013)
Y. Thaver, S.O. Oseni, and G. Tessema Mola, Solar Energy 214, 11–18 (2021)
J. Adhikary, P. Chakraborty, B. Das, A. Datta, S.K. Dash, S. Roy, J.-W. Chen, T. Chattopadhyay, RSC Adv. 5, 35917 (2015)
S. Kadian, G. Manik, A. Kalkal, M. Singh, R.P. Chauhan, Nanotechnology. 30, 435704 (2019)
Y. Wang, L. Sun, D. Xiao, H. Du, Z. Yang, X. Wang, L. Tu, C. Zhao, F. Hu, B. Lu, ACS Appl. Mater. Interfac. 12, 43864 (2020)
Y. He, X. Zhang, Y. Zhong, X. Li, L. Wu, H. Liu, H. Gou, G. Wang, J. Coll. Interfac. Sci. 554, 650 (2019)
A. Ramadoss, K.-Y. Yoon, M.-J. Kwak, S.-I. Kim, S.-T. Ryu, J.-H. Jang, J. Power Sources. 337, 159 (2017)
P. Xu, J. Kang, J.-B. Choi, J. Suhr, J. Yu, F. Li, J.-H. Byun, B.-S. Kim, T.-W. Chou, ACS Nano. 8, 9437 (2014)
I. Popoola, M. Gondal, L. Oloore, A. Popoola, J. AlGhamdi, Electrochim. Acta. 332, 135536 (2020)
T. Ghomian, S. Mehraeen, Energy. 178, 33 (2019)
D. Pankratov, E. González-Arribas, Z. Blum, S. Shleev, Electroanalysis. 28, 1250 (2016)
M. Mastragostino, C. Arbizzani, F. Soavi, J. Power Sources. 97–98, 812 (2001)
Y. Song, T.-Y. Liu, X.-X. Xu, D.-Y. Feng, Y. Li, X.-X. Liu, Adv. Funct. Mater. 25, 4626 (2015)
N. Liu, Y. Gao, Small. 13, 1701989 (2017)
N. Kurra, M.K. Hota, H.N. Alshareef, Nano Energy. 13, 500 (2015)
N. Hu, X. Dong, X. He, J.F. Browning, D.W. Schaefer, Corros. Sci. 97, 17 (2015)
C.D. Dieleman, P.J. Denissen, S.J. Garcia, Adv. Mater. Interfac. 5, 1800176 (2018)
M. Yadav, M. Kumar, T. Tiwari, N. Srivastava, Ionics (Kiel). 23, 2871 (2017)
N.O. Laschuk, E.B. Easton, O.V. Zenkina, RSC Adv. 11, 27925 (2021)
B. Wang, W. Huang, L. Chi, M. Al-Hashimi, T.J. Marks, A. Facchetti, Chem. Rev. 118, 5690 (2018)
G.D. Alley, in G-MTT 1970 International Microwave Symposium (IEEE, 1970), pp. 7–13
M.P. Aleksandrova, S.K. Andreev, IEEE Sens. J. 22, 10126 (2022)
J. Devi, P. Datta, J. Electron. Mater. 47, 3529 (2018)
W. Hilber, H. Enser, M. Knoll, C. Offenzeller, B. Jakoby, IEEE Sens. J. 21, 12444 (2021)
L. Feng, W. Tang, X. Xu, Q. Cui, X. Guo, IEEE Electron Device Lett. 34, 129 (2013)
U. Zschieschang, H. Klauk, Org. Electron. 25, 340 (2015)
G. Park, H. Yang, J.H. Lee, G. Lee, J. Kwak, U. Jeong, Adv. Mater. Interfac. 6, 1900588 (2019)
Y. Xia, G. He, W. Wang, Q. Gao, Y. Liu, IEEE Trans. Electron. Devices. 68, 2522 (2021)
H. Liu, J. Sun, Q. Tang, Q. Wan, J. Phys. Chem. C 114, 12316 (2010)
Acknowledgements
The authors acknowledge the suggestions of Dr. Rajesh Kumar (Ramanujan fellow, DST/SERB, India) and support of Prof. Janakarajan Ramkumar, Department of Mechanical Engineering, IIT Kanpur regarding laser facilities and discussion. Prof. Dattatraya H. Dethe, Department of Chemistry, IIT Kanpur support regarding NMR spectroscopy is cited.
Funding
The authors declare that no funds, grants, or other support were received during the preparation of this manuscript.
Author information
Authors and Affiliations
Contributions
RN contributed to Conceptualization, Methodology, Validation, Investigation, Writing of the original draft and editing, and Visualization. KKK contributed to Resources, Review, Visualization, and Supervision. All authors read and approved the final manuscript.
Corresponding author
Ethics declarations
Competing interests
The authors have no relevant financial or non-financial interests to disclose.
Additional information
Publisher’s Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Nigam, R., Kar, K.K. Starch/methyl cellulose-based microsupercapacitors for on-chip applications. J Mater Sci: Mater Electron 34, 1927 (2023). https://doi.org/10.1007/s10854-023-11296-8
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s10854-023-11296-8