Abstract
We developed a novel sol–gel method to prepare transparent conductive Al-doped ZnO (AZO) thin film at low temperature. The AZO nanocrystals were prepared by a solvothermal method and then they were dispersed in the monoethanolamine and methanol to form AZO colloids. A (002)-oriented ZnO thin film was used as a nucleation layer to induce the (002)-oriented growth of AZO thin films. The AZO thin films were prepared on Si(100) and fused quartz glass substrates with the (002)-oriented ZnO nucleation layer and annealed at 400 °C for 60 min. All AZO thin films showed (002) orientation. For electrical and optical measurements, the films deposited on glass substrates were post-annealed at 400 °C for 30 min in forming gas (100 % H2) to improve their conductivity. These samples had high transparency in the visible wavelength range, and also showed good conductivity. A 0.2 mol L−1 AZO solution with 3 at.% Al content was heated in a Teflon autoclave at 160 °C for 30 min to form AZO nanocrystals, and then the AZO nanocrystals were suspended in the MEA and methanol to obtain the stable AZO colloid. The Al content in the AZO nanocrystals was 2.7 at.%, and the high Al doping coefficient was mainly attributed to the formation of AZO nanocrystals in the autoclave. The AZO thin film using this colloid had the lowest resistivity of 3.89 × 10−3 Ω cm due to its high carrier concentration of 3.29 × 1020 cm−3.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Ellmer K (2012) Past achievements and future challenges in the development of optically transparent electrodes. Nat photon 6:809–817
Chopra KL, Major S, Pandya DK (1983) Transparent conductors-A status review. Thin Solid Films 102:1–46
Minami T (2005) Transparent conducting oxide semiconductors for transparent electrodes. Semicond Sci Technol 20:s35–s44
Ellmer K, Mientus R (2008) Carrier transport in polycrystalline transparent conductive oxides: a comparative study of zinc oxide and indium oxide. Thin Solid Films 516:4620–4627
Di Trolio A, Bauer EM, Scavia G, Veroli C (2009) Blueshift of optical band gap in c-axis oriented and conducting Al-doped ZnO thin films. J Appl Phys 105:113109
Dasgupta NP, Neubert S, Lee W, Trejo O, Lee JR, Prinz FB (2010) Atomic layer deposition of Al-doped ZnO films: effect of grain orientation on conductivity. Chem Mater 22:4769–4775
Tanaka H, Ihara K, Miyata T, Sato H, Minami T (2004) Low resistivity polycrystalline ZnO:Al thin films prepared by pulsed laser deposition. J Vac Sci Technol A 22:1757–1762
Agashe C, Kluth O, Hupkes J, Zastrow U, Rech B, Wuttig M (2004) Efforts to improve carrier mobility in radio frequency sputtered aluminum doped zinc oxide films. J Appl Phys 95:1911–1917
Hu J, Gordon RG (1992) Textured aluminum-doped zinc oxide thin films from atmospheric pressure chemical-vapor deposition. J Appl Phys 71:880–890
Schuler T, Aegerter MA (1999) Optical, electrical and structural properties of sol gel ZnO:Al coatings. Thin Solid Films 351:125–131
Tang W, Cameron DC (1994) Aluminum-doped zinc oxide transparent conductors deposited by the sol–gel process. Thin Solid Films 238:83–87
Musat V, Teixeira B, Fortunato E, Monteriro RCC, Vilarinho P (2004) Al-doped ZnO thin films by sol–gel method. Surf Coat Technol 180–181:659–662
Hilgendorff M, Spanhel L, Rothenhausler C, Muller G (1998) From ZnO colloids to nanocrystalline highly conductive films. J Electrochem Soc 145:3632–3637
Ohyama M, Kozuka H, Yoko T (1998) Sol–gel preparation of transparent and conductive aluminum-doped zinc oxide films with highly preferential crystal orientation. J Am Ceram Soc 81:1622–1632
Tahar RBH, Tahar NBH (2005) Crystallographic orientation in pure and aluminum-doped zinc oxide thin films prepared by sol–gel technique. J Am Ceram Soc 88:1725–1728
Lin K, Chen H, Chen Y, Chou K (2010) Influences of preferred orientation growth on electrical properties of ZnO:Al films by sol–gel method. J Sol–Gel Sci Technol 55:276–369
Nasr B, Dasgupta S, Wang D, Mechau N, Kruk R, Hahn H (2010) Electrical resistivity of nanocrystalline Al-doped zinc oxide films as a function of Al content and the degree of its segregation at the grain boundaries. J Appl Phys 108:103721
Birkholz M, Selle B, Fenske F, Fuhs W (2003) Structure-function relationship between preferred orientation of crystallites and electrical resistivity in thin polycrystalline ZnO:Al films. Phys Rev B 68:205414
Kaga H, Kinemuchi Y, Yilmaz H, Watari K, Nakano H, Nakano H, Tanaka S, Makiya A, Kato Z, Uematsu K (2007) Orientation dependence of transport property and microstructural characterization of Al-doped ZnO ceramics. Acta Mater 55:4753–4757
Mondal P, Das D (2013) Transparent and conducting intrinsic ZnO thin films prepared at high growth-rate with c-axis orientation and pyramidal surface texture. Appl Surf Sci 286:397–404
Malek MF, Mamat MH, Sahdan MZ, Zahidi MM, Khusaimi Z, Mahmood MR (2013) Influence of various sol concentrations on stress/strain and properties of ZnO thin films synthesized by sol–gel technique. Thin Solid Films 527:102–109
Malek MF, Mamat MH, Khusaimi Z, Sahdan MZ, Musa MZ, Zainun AR, Suriani AB, Md Sin ND, Abd Hamid SB, Rusop M (2014) Sonicated sol–gel preparation of nanoparticulate ZnO thin films with various deposition speeds: the highly preferred c-axis (002) orientation enhances the final properties. J Alloys Comp 582:12–21
Guo D, Sato K, Hibino S, Takeuchi T, Bessho H, Kato K (2014) Low-temperature preparation of (002)-oriented ZnO thin films by sol–gel method. Thin Solid Films 550:250–258
Du H, Yuan F, Huang S, Li J, Zhu Y (2004) A new reaction to ZnO nanoparticles. Chem Lett 33:770–771
Li D, Nielsen MH, Lee JRI, Frandsen C, Banfield JF, De Yoreo JJ (2012) Direction-specific interactions control crystal growth by oriented attachment. Science 336:1014–1018
Liao H, Cui L, Whitelam S, Zheng H (2012) Real-time imaging of Pt3Fe nanorod growth in solution. Science 336:1011–1014
Pacholski C, Kornowski A, Weller H (2012) Self-assembly of ZnO: from nanodots to nanorods. Angew Chem Int Ed 41:1188–1191
Yao P, Hang S, Lin Y, Yen W, Lin Y (2010) Optical and electrical characteristic of Al-doped ZnO thin films prepared by aqueous phase deposition. Appl Surf Sci 257:1441–1448
Lin J, Wu J (2008) The effect of annealing processes on electronic properties of sol–gel derived Al-doped ZnO films. Appl Phys Lett 92:134103
Lu JG, Ye ZZ, Zeng YJ, Zhu LP, Wang L, Yuan J, Zhao BH, Liang QL (2006) Structural, optical, and electrical properties of (Zn, Al)O films over a wide range of compositions. J Appl Phys 100:073714
Serier H, Gaudon M, Menetrier M (2009) Al-doped ZnO powdered materials: Al solubility limit and IR absorption properties. Solid State Sci 11:1192–1197
Minami T, Sato H, Ohashi K, Tomofuji T, Takata S (1992) Conduction mechanism of highly conductive and transparent zinc oxide thin films prepared by magnetron sputtering. J Cryst Growth 117:370–374
Ellmer K (2001) Resistivity of polycrystalline zinc oxide films: current status and physical limit. J Phys D Appl Phys 34:3097–3108
Periasamy C, Chakrabarti P (2011) Tailoring the structural and optoelectronic properties of Al-doped nanocrystalline ZnO thin films. J Electron Mater 40:259–266
Singh AV, Mehra RM, Yoshida A, Wakahara A (2004) Doping mechanism in aluminum doped zinc oxide films. J Appl Phys 95:3640–3643
Acknowledgements
The authors would like to thank Dr. Yoshitake Masuda and Dr. Qiang Ma for their assistance in making some of the characterization measurements.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Guo, D., Sato, K., Hibino, S. et al. Low-temperature preparation of transparent conductive Al-doped ZnO thin films by a novel sol–gel method. J Mater Sci 49, 4722–4734 (2014). https://doi.org/10.1007/s10853-014-8172-9
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10853-014-8172-9