Abstract
Heterogeneous plastic deformation behavior of two bimodal ultrafine-grained nickel materials with different ultrafine-grained (UFG) and coarse-grained (CG) components fractions was investigated experimentally at the grain level. The prismatic specimens were deformed quasistatically up to 10% axial plastic strain using compression test at room temperature. The local microstructure of the initial and deformed samples was measured by electron backscattered diffraction pattern analysis in a scanning electron microscope. It was found that the plastic deformation of bimodal materials is highly heterogeneous and the degree of heterogeneity depends strongly on the grain size distribution and the volume fraction of the CG component. The large localized plastic strain within the coarse grains was observed during compression. The strain localization resulted in occurrence of debonding and cracks in the UFG region or in the interface between CG and UFG components.
Similar content being viewed by others
References
Dalla Torre F, Van Swygenhoven H, Victoria M (2002) Acta Mater 50:3957
Cao W, Dirras G, Benyoucef M, Bacroix B (2007) Mater Sci Eng A 462:100
Bui QH, Dirras G, Ramtani S, Gubicza J (2010) Mater Sci Eng A 32:1612
Wang YM, Ma E (2004) Acta Mater 52:1699
Wang Y, Chen M, Zhou F, Ma E (2002) Nature 419:912
Witkin D, Lee Z, Rodriguez R, Nutt S, Lavernia E (2003) Scripta Mater 49:297
Han BQ, Lee Z, Witkin D, Nutt S, Lavernia EJ (2005) Metall Mater Trans A 36:957
Shen X, Lian J, Jiang Z, Jiang Q (2008) Mater Sci Eng A 487:410
Zhao Y, Topping T, Bingert JF, Thornton JJ, Dangelewicz AM, Li Y, Liu W, Zhu Y, Zhou Y, Lavernia EJ (2008) Adv Mater 20:3028
Xia S, Vychigzhanina L, Wang J, Alexandrov I, Sharafutdinov A (2008) Mater Sci Eng A 490:471
Srinivasarao B, Oh-ishi K, Ohkubo T, Mukai T, Hono K (2008) Scripta Mater 58:759
Prasad M, Suwas S, Chokshi A (2009) Mater Sci Eng A 503:86
Dirras G, Gubicza J, Ramtani S, Bui QH, Szilagyi T (2010) Mater Sci Eng A 527:1206
Lee Z, Witkin D, Radmilovic V, Lavernia E, Nutt S (2005) Mater Sci Eng A 410–411:462
Fan G, Choo H, Liaw P, Lavernia E (2006) Acta Mater 54:1759
Srinivasarao B, Oh-ishi K, Ohkubo T, Hono K (2009) Acta Mater 57:3277
Tepper F (1998) Met Powder Rep 53:31
Kwon Y, Jung Y, Yavorovsky NA, Illyn AP, Kim J (2001) Scripta Mater 44:2247
Bui QH (2010) Polycristaux a grains fins elabores par metallurgie des poudres : microstructures, proprietes mecaniques (in french). Editions universitaires europeenne, ISBN :978-613-1-51805-8
Billard S, Fondere J, Bacroix B, Dirras G (2006) Acta Mater 54:411
Gubicza J, Bui QH, Fellah F, Dirras G (2009) J Mater Res 24:217
Bui QH, Pham XT (2011) Int J Mech Sci 53:812
Gubicza J, Bui QH, Fellah F, Szasz N, Dirras G (2008) Mater Sci Forum 589:93
Ahn B, Lavernia EJ, Nutt SR (2008) J Mater Sci 43:7403. doi:10.1007/s10853-008-2950-1
Acknowledgements
The author is very grateful to J.-P. Michel for HIPing operations.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Bui, Q.H. Heterogeneous plastic deformation in bimodal bulk ultrafine-grained nickel. J Mater Sci 47, 1902–1909 (2012). https://doi.org/10.1007/s10853-011-5979-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10853-011-5979-5