Abstract
The adoption of the popular laser-flash method at temperatures far below 300 K is restricted by the weak signal-to-noise ratio and the limited spectral bandwidth of the commonly used mercury cadmium tellurite (MCT) infrared (IR) detector used as a non-contacting temperature probe. In this work, a different approach to measure the temperature rise in pulse heating experiments is described and evaluated. This method utilizes the change of the temperature-dependent electrical resistance of a thin strip of sputtered gold for the detection of a temperature rise as it was proposed by Kogure et al. The main advantage of this method at lower temperatures is the significantly higher signal-to-noise ratio compared to the commonly used IR detectors. A newly developed laser-flash apparatus using this detection method for the determination of the thermal diffusivity in the temperature range from 80 K to 300 K is presented. To test the accuracy of the new detection method, the thermal diffusivity of a borosilicate crown glass (BK7) specimen at 300 K was determined and compared to results derived with a MCT detector. Good agreement of the derived thermal diffusivity values within 3 % was found. The thermal diffusivity of BK7 and polycrystalline aluminum nitride (AlN) was measured at temperatures between 80 K and 300 K by a laser-flash method to test the functionality of the apparatus. Finally, the thermal conductivity was calculated using values for the specific heat capacity determined by temperature modulated differential scanning calorimetry (MDSC). Comparisons with literature data confirm the reliability of the experimental setup.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Parker W.J., Jenkins R.J., Butler C.P., Abbott G.L.: J. Appl. Phys. 32, 1679 (1961)
Cowan R.D.: J. Appl. Phys. 34, 926 (1963)
Azumi T., Takahashi Y.: Rev. Sci. Instrum. 52, 1411 (1981)
Cape J.A., Lehman G.W.: J. Appl. Phys. 37, 1909 (1963)
Hofmann R., Hahn O., Raether F., Mehling H., Fricke J.: High Temp. High Press. 29, 703 (1997)
Blumm J.: Int. J. Thermophys. 28, 674 (2007)
B. Schulz, W. Rapp, M. Hofmann, in Proceedings of the 25th International Thermal Conductivity Conference, Ann Arbor, MI (1999), p. 98
R.C. Heckman, in Proceedings of the 7th Symposium on Thermophysical Properties, ed. by A. Cezairliyan (ASME, New York, 1977), p. 11
R. Fischer, Doctoral Thesis, University of Wuerzburg, Germany, 1999
Kogure Y., Mugishima T., Hiki Y.: J. Phys. Soc. Jpn. 55, 3469 (1986)
Kubičár L., Vretenár V., Hammerschmidt U.: Int. J. Thermophys. 26, 507 (2005)
Slack G.A., Tanzilly R.A., Pohl R.A., Vandersande J.W.: J. Phys. Chem. Solids 48, 641 (1987)
Bickermann M., Epelbaum B.M., Winnacker A.: J. Cryst. Growth 269, 432 (2004)
ISO: Guide to the Expression of Uncertainty in Measurement. ISO-International Organization for Standardization, Geneva, Switzerland (1998)
Y.S. Touloukian, E.H. Buyco, (eds.), Thermophysical Properties of Matter, Specific Heat: Nonmetallic Solids, vol. 5 (Plenum, New York, 1973)
H. Hausen, Landolt-Börnstein, Zahlenwerte und Funktionen, part IV.4.b (Springer-Verlag, Berlin, 1972)
Y.S. Touloukian, R.K. Kirby, R.E. Taylor, T.Y.R. Lee, (eds.), Thermophysical Properties of Matter: Thermal Expansion: Nonmetallic Solids, vol. 13 (Plenum, New York, 1977)
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Hemberger, F., Göbel, A. & Ebert, HP. Determination of the Thermal Diffusivity of Electrically Non-Conductive Solids in the Temperature Range from 80 K to 300 K by Laser-Flash Measurement. Int J Thermophys 31, 2187–2200 (2010). https://doi.org/10.1007/s10765-010-0876-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10765-010-0876-8