Experience with the burning of coals from the Kansk-Achinsk Basin in a P-49 boiler with different burner and furnace configurations is examined. Problems in running the boiler with liquid slag removal are noted. Some studies of boiler operation with low-temperature vortex coal firing following technical renovation are discussed.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
I. N. Shnitser, Fuel Combustion Technology in Coal-dust Boilers [in Russian], Énergoatomizdat, St. Petersburg (1994).
E. A. Bolychev, V. V. Lisitsin, L. I. Pugach, E. P. Demb, E. G. Alfimov, V. A. Muzlov, and V. A. Sem’yaninov, “Operating experience with and results of tests on a reconstructed P-49 boiler,” Teploénergetika, No. 5, 16 – 19 (1986).
A. A. Popov, A. I. Tarasov, and V. A. Muzlov, “Operating experience and studies of a system with concentrated dust feed under pressure on a 500 MW P-49 boiler unit at the Nazarovo GRÉS power plant,” Tr. TsKTI. Sist. Oborud. Pylepit. Par. Kotlov, No. 203, 54 – 60 (1983).
E. A. Bolychev, V. N. Tochilkin, V. V. Lisitsin, L. I. Pugach, V. A. Muslov, V. K. Stolyarevksii, and V. A. Sem’yaninov, “Summary of tests on a P-49 boiler in a 500 MWunit after reconstruction,” Élektr. Stantsii, No. 5, 4 – 45 (1986).
Thermal Calculation of Boilers (standard method) [in Russian], Izd. NPO TsKTI, St. Petersburg (1998).
V. R. Kotler, Special Furnaces for Power Plant Boilers [in Russian], Énergoatomizdat, Moscow (1990).
E. E. Gil’de, A. A. Popov, V. G. Gulyev, V. G. Gendelev, L. M. Gul’tsev, and A. N. Zhemchugov, “Studies of a reconstructed ‘B’ housing of a P-49 boiler with firing of Kansk-Achinsk coals,” Énergomashinostroenie, No. 7, 5 – 8 (1986).
V. V. Lisitsin, L. I. Pugach, N. N. Skerko, L. S. Lisitsina, E. A. Bolychev, V. N. Tochilkin, and K. V. Agapov, “Industrial studies of some ways of suppressing nitrogen oxide during coal-dust firing of Siberian and Kazakh coals,” Teploénergetika, No. 8, 17 – 20 (1988).
Rus. Pat. No. 2253799, K. A. Grigor’ev, V. E. Skuditskii, Yu. A. Rundygin, A. L. Popov, A. P. Tokunov, and R. G. Anoshin, “Vortex furnace,” Byull. Izobret., No. 16 (2005).
Rus. Pat. No. 2253801, K. A. Grigor’ev, V. E. Skuditskii, Yu. A. Rundygin, A. L. Popov, A. P. Tokunov, A. A. Trinchenko, and F. R. Valiev, “Vortex furnace,” Byull. Izobret., No. 16 (2005).
K. A. Grigor’ev, V. E. Skuditskii, R. G. Anoshin, F. R. Valiev, and V. V. Litvinenko, “Experience with using vortex low-temperature firing technology on a BKZ-220-100 boiler,” Énergetik, No. 1, 24 – 26 (2009).
K. A. Grigor’ev, V. E. Skuditskii, Yu. V. Zykin, Yu. A. Chirkov, R. G. Anoshin, and V. V. Osmanov, “Experience with low-temperature vortex firing of different kinds of fuel in the BKZ-210-13.8 at the Kirov TÉTs-4 power plant,” Élektr. Stantsii, No. 4, 9 – 13 (2010).
V. E. Skuditskii, R. G. Anoshin, K. A. Grigor’ev, and V. V. Mikhailov, “Introduction of low-temperature vortex firing technology in a 500 MW unit at the Nazarovo GRÉS,” in: Proc. II Int. Sci.-Tech. Conf. “Use of Solid Fuels for Efficient and Ecologically Clean Production of Electricity and Heat,” October 28 – 29, 2014, Moscow, OJSC “VTI,” Moscow (2014), pp. 128 – 135.
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated from Élektricheskie Stantsii, No. 2, February 2017, pp. 23 – 28.
Rights and permissions
About this article
Cite this article
Skuditskiy, V.E., Anoshin, R.G., Roundyguine, Y.A. et al. Solution of Problems with the Burning of Coals from the Kansk-Achinsk Basin in the P-49 Boiler of a 500 MW Unit at the Nazarovo State Regional Electric Power Plant. Power Technol Eng 51, 220–225 (2017). https://doi.org/10.1007/s10749-017-0813-0
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10749-017-0813-0