Abstract
Snap-off events are one of the most common and essential phenomena in two-phase flow in porous media. This paper uses the scanning results of a siltstone slice to construct a two-dimensional heterogeneous pore network structure to visualise microscopic snap-off phenomena and displacement processes accurately. The relationship between snap-off events and the non-wetting phase saturation was studied using two-phase flow displacement experiments. Results show that although the non-wetting phase snap-off events benefit freeing the trapped non-wetting phase in the microchannels, high-frequency snap-off events are the main reason for trapping the non-wetting phase during the displacement process, eventually leading to residuals. The frequency of non-wetting phase snap-off events in the pore network structure can be reduced to lower the non-wetting phase saturation and reduce the non-wetting phase residuals by increasing the displacement fluid viscosity, reducing the surface tension coefficient between the phases and increasing the flow rate.
Similar content being viewed by others
Availability of data and materials
The data and materials are available from the corresponding author on reasonable request.
References
Alhosani A, Scanziani A, Lin Q et al (2020) Dynamics of water injection in an oil-wet reservoir rock at subsurface conditions: Invasion patterns and pore-filling events. Phys Rev E 102:23110. https://doi.org/10.1103/PhysRevE.102.023110
Alyafei N, Blunt MJ (2016) The effect of wettability on capillary trapping in carbonates. Adv Water Resour 90:36–50. https://doi.org/10.1016/j.advwatres.2016.02.001
Andrew M, Menke H, Blunt MJ, Bijeljic B (2015) The imaging of dynamic multi-phase fluid flow using synchrotron-based X-ray microtomography at reservoir conditions. Transp Porous Media 110:1–24. https://doi.org/10.1007/s11242-015-0553-2
Ayirala SC, Al-Saleh SH, Al-Yousef AA (2018) Microscopic scale interactions of water ions at crude oil/water interface and their impact on oil mobilisation in advanced water flooding. J Pet Sci Eng 163:640–649. https://doi.org/10.1016/j.petrol.2017.09.054
Bai L, Fu Y, Zhao S, Cheng Y (2016) Droplet formation in a microfluidic T-junction involving highly viscous fluid systems. Chem Eng Sci 145:141–148. https://doi.org/10.1016/j.ces.2016.02.013
Beresnev IA, Li W, Vigil RD (2009) Condition for breakup of non-wetting fluids in sinusoidally constricted capillary channels. Transp Porous Media 80:581–604. https://doi.org/10.1007/s11242-009-9381-6
Berg S, Rücker M, Ott H et al (2016) Connected pathway relative permeability from pore-scale imaging of imbibition. Adv Water Resour 90:24–35. https://doi.org/10.1016/j.advwatres.2016.01.010
Blunt MJ (1998) Physically-based network modeling of multi-phase flow in intermediate-wet porous media. J Pet Sci Eng 20:117–125. https://doi.org/10.1016/S0920-4105(98)00010-2
Buchgraber M, Al-Dossary M, Ross CM, Kovscek AR (2012) Creation of a dual-porosity micromodel for pore-level visualisation of multi-phase flow. J Pet Sci Eng 86–87:27–38. https://doi.org/10.1016/j.petrol.2012.03.012
Chen M, Yortsos YC, Rossen WR (2005) Insights on foam generation in porous media from pore-network studies. Colloids Surfaces A Physicochem Eng Asp 256:181–189. https://doi.org/10.1016/j.colsurfa.2005.01.020
Cubaud T, Mason TG (2008) Capillary threads and viscous droplets in square microchannels. Phys Fluids. https://doi.org/10.1063/1.2911716
Cui J, Zhang Z, Liu G et al (2022) Breakthrough pressure anisotropy and intra-source migration model of crude oil in shale. Mar Pet Geol 135:105433. https://doi.org/10.1016/j.marpetgeo.2021.105433
Datta SS, Ramakrishnan TS, Weitz DA (2014) Mobilisation of a trapped non-wetting fluid from a three-dimensional porous medium. Phys Fluids. https://doi.org/10.1063/1.4866641
Esmaeili S, Modaresghazani J, Sarma H et al (2020) Effect of temperature on relative permeability—role of viscosity ratio. Fuel 278:118318. https://doi.org/10.1016/j.fuel.2020.118318
Garstecki P, Stone HA, Whitesides GM (2005) Mechanism for flow-rate controlled breakup in confined geometries: a route to monodisperse emulsions. Phys Rev Lett 94:1–4. https://doi.org/10.1103/PhysRevLett.94.164501
Ghanbarian B, Hunt AG, Ewing RP, Sahimi M (2013) Tortuosity in porous media: a critical review. Soil Sci Soc Am J 77:1461–1477. https://doi.org/10.2136/sssaj2012.0435
Hammond PS (1983) Nonlinear adjustment of a thin annular film of viscous fluid surrounding a thread of another within a circular cylindrical pipe. J Fluid Mech 137:363–384. https://doi.org/10.1017/S0022112083002451
Heydari-Farsani E, Neilson JE, Alsop GI, Hamidi H (2020) The effect of rock type on natural water flooding and residual oil saturation below free water level and oil water contact: a case study from the Middle East. J Pet Sci Eng 193:107392. https://doi.org/10.1016/j.petrol.2020.107392
Jin BJ, Kim YW, Lee Y, Yoo JY (2010) Droplet merging in a straight microchannel using droplet size or viscosity difference. J Micromech Microeng. https://doi.org/10.1088/0960-1317/20/3/035003
Joekar-Niasar V, Hassanizadeh SM (2012) Analysis of fundamentals of two-phase flow in porous media using dynamic pore-network models: a review. Crit Rev Environ Sci Technol 42:1895–1976. https://doi.org/10.1080/10643389.2011.574101
Lenormand R, Zarcone C, Sarr A (1983) Mechanisms of the displacement of one fluid by another in a network of capillary ducts. J Fluid Mech 135:337–353. https://doi.org/10.1017/S0022112083003110
Li Y, Blois G, Kazemifar F, Christensen KT (2019) High-speed quantification of pore-scale multi-phase flow of water and supercritical CO2 in 2-D heterogeneous porous micromodels: flow regimes and interface dynamics. Water Resour Res 55:3758–3779. https://doi.org/10.1029/2018WR024635
Li Z, Gu Z, Li R et al (2021) Investigation on droplet dynamic snap-off process in a short, abrupt constriction. Chem Eng Sci 235:116496. https://doi.org/10.1016/j.ces.2021.116496
Li Z, Gu Z, Li R et al (2022) A geometrical criterion for the dynamic snap-off event of a non-wetting droplet in a rectangular pore-throat microchannel. Phys Fluids. https://doi.org/10.1063/5.0087523
Liang T, Xu K, Lu J et al (2020) Evaluating the performance of surfactants in enhancing flowback and permeability after hydraulic fracturing through a microfluidic model. SPE J 25:268–287. https://doi.org/10.2118/199346-PA
Liu Z, Li M, Pang Y et al (2019) Flow characteristics inside droplets moving in a curved microchannel with rectangular section. Phys Fluids. https://doi.org/10.1063/1.5080373
Mahdavi S, James LA (2019) Micro and macro analysis of carbonated water injection (CWI) in homogeneous and heterogeneous porous media. Fuel 257:115916. https://doi.org/10.1016/j.fuel.2019.115916
Mehmani A, Kelly S, Torres-Verdín C, Balhoff M (2019) Residual oil saturation following gas injection in sandstones: microfluidic quantification of the impact of pore-scale surface roughness. Fuel 251:147–161. https://doi.org/10.1016/j.fuel.2019.02.118
Nie Z, Seo MS, Xu S et al (2008) Emulsification in a microfluidic flow-focusing device: effect of the viscosities of the liquids. Microfluid Nanofluidics 5:585–594. https://doi.org/10.1007/s10404-008-0271-y
Ning T, Xi M, Hu B et al (2021) Effect of viscosity action and capillarity on pore-scale oil–water flowing behaviors in a low-permeability sandstone waterflood. Energies. https://doi.org/10.3390/en14248200
Osei-Bonsu K, Grassia P, Shokri N (2018) Effects of pore geometry on flowing foam dynamics in 3D-printed porous media. Transp Porous Media 124:903–917. https://doi.org/10.1007/s11242-018-1103-5
Pak T, Butler IB, Geiger S et al (2015) Droplet fragmentation: 3D imaging of a previously unidentified pore-scale process during multi-phase flow in porous media. Proc Natl Acad Sci U S A 112:1947–1952. https://doi.org/10.1073/pnas.1420202112
Peña TJ, Carvalho MS, Alvarado V (2009) Snap-off of a liquid drop immersed in another liquid flowing through a constricted capillary. AIChE J 55:1993–1999. https://doi.org/10.1002/aic
Perazzo A, Tomaiuolo G, Preziosi V, Guido S (2018) Emulsions in porous media: from single droplet behavior to applications for oil recovery. Adv Colloid Interface Sci 256:305–325. https://doi.org/10.1016/j.cis.2018.03.002
Rezaei N, Zendehboudi S, Chatzis I, Lohi A (2018) Combined benefits of capillary barrier and injection pressure control to improve fluid recovery at breakthrough upon gas injection: an experimental study. Fuel 211:638–648. https://doi.org/10.1016/j.fuel.2017.09.048
Riazi M, Sohrabi M, Bernstone C et al (2011) Visualisation of mechanisms involved in CO2 injection and storage in hydrocarbon reservoirsand water-bearing aquifers. Chem Eng Res Des 89:1827–1840. https://doi.org/10.1016/j.cherd.2011.03.009
Rogers JA, Nuzzo RG (2005) Recent progress in soft lithography. Mater Today 8:50–56. https://doi.org/10.1016/S1369-7021(05)00702-9
Roman S, Abu-Al-Saud MO, Tokunaga T et al (2017) Measurements and simulation of liquid films during drainage displacements and snap-off in constricted capillary tubes. J Colloid Interface Sci 507:279–289. https://doi.org/10.1016/j.jcis.2017.07.092
Rossen WR (2000) Snap-off in constricted tubes and porous media. Colloids Surfaces A Physicochem Eng Asp 166:101–107. https://doi.org/10.1016/S0927-7757(99)00408-2
Ruspini LC, Farokhpoor R, Øren PE (2017) Pore-scale modeling of capillary trapping in water-wet porous media: a new cooperative pore-body filling model. Adv Water Resour 108:1–14. https://doi.org/10.1016/j.advwatres.2017.07.008
Singh K, Bijeljic B, Blunt MJ (2016) Imaging of oil layers, curvature and contact angle in a mixed- wet and a water-wet carbonate rock. Water Resour Res 52:1716–1728. https://doi.org/10.1111/j.1752-1688.1969.tb04897.x
Singh K, Menke H, Andrew M et al (2017) Dynamics of snap-off and pore-filling events during two-phase fluid flow in permeable media. Sci. Rep. 7(1):5192
Singh K, Jung M, Brinkmann M, Seemann R (2019) Capillary-dominated fluid displacement in porous media. Annu Rev Fluid Mech 51:429–449. https://doi.org/10.1146/annurev-fluid-010518-040342
Song W, Hatzignatiou DG (2022) On the reduction of the residual oil saturation through the injection of polymer and nanoparticle solutions. J Pet Sci Eng 208:109430. https://doi.org/10.1016/j.petrol.2021.109430
Tian J, Kang Y, Xi Z et al (2020) Real-time visualisation and investigation of dynamic gas snap-off mechanisms in 2-D micro channels. Fuel 279:118232. https://doi.org/10.1016/j.fuel.2020.118232
Wang X, Wang K, Riaud A et al (2014) Experimental study of liquid/liquid second-dispersion process in constrictive microchannels. Chem Eng J 254:443–451. https://doi.org/10.1016/j.cej.2014.05.135
Xu K, Liang T, Zhu P et al (2017) A 2.5-D glass micromodel for investigation of multi-phase flow in porous media. Lab Chip 17:640–646. https://doi.org/10.1039/c6lc01476c
Yun W, Kovscek AR (2015) Microvisual investigation of polymer retention on the homogeneous pore network of a micromodel. J Pet Sci Eng 128:115–127. https://doi.org/10.1016/j.petrol.2015.02.004
Yun W, Ross CM, Roman S, Kovscek AR (2017) Creation of a dual-porosity and dual-depth micromodel for the study of multi-phase flow in complex porous media. Lab Chip 17:1462–1474. https://doi.org/10.1039/c6lc01343k
Zhang C, Wang M (2022) A critical review of breakthrough pressure for tight rocks and relevant factors. J Nat Gas Sci Eng 100:104456. https://doi.org/10.1016/j.jngse.2022.104456
Funding
This work was supported by the Key Research and Development Program of Shaanxi (Program No. 2023-YBSF-218, 2021GXLH-Z-071) and the National Natural Science Foundation of China (No. 12072256).
Author information
Authors and Affiliations
Contributions
RL and ZL: were involved in the experiments and wrote the main manuscript text. ZG and WL: contributed to the writing—reviewing and editing. GZ: helped with the writing—review and editing, and supervision. JS: contributed to the conceptualisation, methodology, writing-reviewing and editing, and supervision. All authors reviewed the manuscript.
Corresponding authors
Ethics declarations
Conflict of interest
The authors declare that they have no competing interests as defined by Springer, or other interests that might be perceived to influence the results and/or discussion reported in this paper.
Ethical approval
Not applicable.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Li, R., Gu, Z., Li, Z. et al. Behaviors of non-wetting phase snap-off events in two-phase flow: microscopic phenomena and macroscopic effects. Microfluid Nanofluid 28, 24 (2024). https://doi.org/10.1007/s10404-024-02718-y
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s10404-024-02718-y