Abstract
A microfabricated high-throughput cell electrofusion chip with 1,368 pairs of high aspect ratio silicon microelectrodes is presented. These microelectrodes, which were distributed in six individual microscale cell-fusion chambers, were covered with titanium and gold thin film to improve their electric conductivity as well as surface hydrophobility. Six chambers having different electrode distances make the chip highly suitable for fusing cells with different sizes. A microfluidic platform was set up for flowing control, cell manipulation and also experimental observation. Cells for electrofusion were first aligned at the prearranged locations by the dielectrophoretic force between two counter-electrodes, which benefits the traverse of electric pulse through the cell–cell contacting point for electroporation. Several on-chip cell electrofusion experiments have been carried out on different kinds of animal cells and plant protoplasts. Compared with conventional electrofusion methods, higher fusion efficiency was achieved on this device for precisely forming micropores on the proximate membranes of two contacting cells, and high throughput was also obtained due to the use of a large number of microelectrodes for cell manipulation and fusion. Moreover, a much lower power supply was required for the shorter distance between two counter-electrodes.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Bengochea T (1986) Plant protoplasts : a biotechnological tool for plant improvement. Chapman and Hall, London
Benguigui L, Lin IJ (1986) The dielectrophoresis force. Am J Phys 54(5):447–450
Cao Y, Yang J, Hou WS et al (2008) Electric field simulation of the high-throughput cell electrofusion chip. Chin J Anal Chem (in press)
Chen EH, Grote E, Mohler W et al (2007) Cell–cell fusion. FEBS Lett 581:2181–2193
Chiu DT (2001) A microfluidics platform for cell fusion—commentary. Curr Opin Chem Biol 5(5):609–612
Christensen TB, Pedersen CM, Bang DD et al (2007) Sample preparation by cell guiding using negative dielectrophoresis. Microelectron Eng 84(5–8):1690–1693
Hughes MP (2002) Strategies for dielectrophoretic separation in laboratory-on-a-chip systems. Electrophoresis 23(16):2569–2582
Hui SW, Stenger DA (1993) Electrofusion of cells—hybridoma production by electrofusion and polyethylene-glycol. Methods Enzymol 220:212–227
Neil GA, Zimmermann U (1993) Electrofusion. Methods Enzymol 220:174–196
Pavlin M, Leben V, Miklavcic D (2007) Electroporation in dense cell suspension—theoretical and experimental analysis of ion diffusion and cell permeabilization. Biochimica et Biophysica Acta 1770:12–23
Perch-Nielsen IR, Bang DD, Poulsen CR et al (2003) Removal of PCR inhibitors using dielectrophoresis as a selective filter in a microsystem. Lab Chip 3(3):212–216
Robinson JM, Roos DS, Davidson RL et al (1979) Membrane-alterations and other morphological features associated with polyethylene glycol-induced cell fusion. J Cell Sci 40:63–75
Steubing RW, Cheng S, Wright WH et al (1991) Laser-induced cell fusion in combination with optical tweezers—the laser cell-fusion trap. Cytometry 12(6):505–510
Stromberg A, Karlsson A, Ryttsen F et al (2001) Microfluidic device for combinatorial fusion of liposomes and cells. Anal Chem 73(1):126–130
Tan WH, Takeuchi S (2006) Timing controllable electrofusion device for aqueous droplet-based microreactors. Lab Chip 6(6):757–763
Tresset G, Takeuchi S (2004) A microfluidic device for electrofusion of biological vesicles. Biomed Microdevices 6(3):213–218
Vaughan VL, Hansen D, Stadler J (1976) Parameters of polyethylene glycol-induced cell fusion and hybridization in lymphoid cell lines. Somatic Cell Genet 2:537–544
Wang J, Lu C (2006) Microfluidic cell fusion under continuous direct current voltage. Appl Phys Lett 89(23): Article no. 234102
Washizu M, Techaumnat B (2007) Cell membrane voltage during electrical cell fusion calculated by re-expansion method. J Electrostat 65:555–561
Wiegand R, Weber G, Zimmermann K et al (1987) Laser-induced fusion of mammalian cells and plant protoplasts. J Cell Sci 88:145–149 Part 2 SEP
Zimmermann U (1982) Electric field-mediated fusion and related electrical phenomena. Biochim Biophys Acta 694(3):227–277
Zimmermann U, Scheurich P, Pilwat G et al (1981) Cells with manipulated functions—new perspectives for cell biology, medicine, and technology. Angew Chem Int Ed Engl 20(4):325–344
Zimmermann U, Arnold WM, Mehrle W (1988) Biophysics of electroinjection and electrofusion. J Electrostat 21(2–3):309–345
Acknowledgments
The authors would like to acknowledge financial support by the National Natural Science Foundation of China (30500120, 30770568, 30770569), the National Hi-Tech Research and Development Program of China (2006AA04Z343, 2006AA04Z349) and the Natural Science Foundation of Chongqing (CSTC2007BB5166). We are very grateful to Dr. Zhengyuan Zhang in the 24th Research Institute of CETC, China, for his technical support.
Author information
Authors and Affiliations
Corresponding authors
Rights and permissions
About this article
Cite this article
Cao, Y., Yang, J., Yin, Z.Q. et al. Study of high-throughput cell electrofusion in a microelectrode-array chip. Microfluid Nanofluid 5, 669–675 (2008). https://doi.org/10.1007/s10404-008-0289-1
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10404-008-0289-1