Abstract
Evaluation of water inrush risk is becoming increasingly important as coal mining activities reach greater depths. Hazard identification, as well as hazard analysis, is the first step in accident prevention. However, there have not been any studies that focus on the hazard analysis system for mine water inrush. In this paper, hazard identification and its definitions are briefly summarized and a comprehensive review of methods for hazard identification and classification are conducted. To illustrate the hazard of coal mine water inrush, data on coal mine accidents (since 2001) are collected and hundreds water inrush accidents were analyzed in depth. Empirical, statistical analysis and case study method were used to conduct the research. By collecting a large number of mine water inrush cases, hazard identification and risk control measures for coal mine water inrush accidents were conducted. Hazard identification method based on fault tree analysis, as well as a method based on management oversight and risk tree (MORT) and energy release theory were put forward. The analysis results show that the historical information and experiences are critically important in hazard identification of mine water inrush. Hazard of mine water inrush is divided into dynamic root hazard and static root hazard which can be further categorized into static innate hazard and dynamic-triggered hazard. Strategies for risk control of mine water inrush are combined into three aspects: engineering controls, operation system controls, and human behavior controls. Finally, a case study of the Taoyuan coal mine was conducted to illustrate the proposed system, with limitations and future studies are discussed. The hazard identification and classification system can be broadly applied to coal mines and will improve risk control and prevention of mine water inrush accidents.
Similar content being viewed by others
References
Abdollahi S, Madadi M, Ostad-Ali-Askari K (2021) Monitoring and investigating dust phenomenon on using remote sensing science, geographical information system and statistical methods. Appl Water Sci 11(7):1–14. https://doi.org/10.1007/s13201-021-01419-z
Alexander D (2006) The expected value of catastrophes in underground coal mines, 1987–2001 (Order No. 3225348). Available from ProQuest Dissertations & Theses Global. SciTech Premium Collection (304971673). Retrieved from http://mines.idm.oclc.org/login?url=https://search.proquest.com/docview/304971673?accountid=25386
Bahr NJ (2014) System safety engineering and risk assessment: a practical approach. CRC Press
Bird F (1974) Management guide to loss control. Institute Press, Loganville, GA
Cao Z, Gu Q, Huang Z, Fu J (2022) Risk assessment of fault water inrush during deep mining. Int J Min Sci Technol 32(2):423–434. https://doi.org/10.1016/j.ijmst.2022.01.005
Carter T, Dershowitz W, Shuttle D, Jefferies M (2012) Improved methods of design for grouting fractured rock. Grouting and Deep Mixing 1472–1483. https://doi.org/10.1061/9780784412350.0123
Chai J, Lei W, Du W et al (2019) Experimental study on distributed optical fiber sensing monitoring for ground surface deformation in extra-thick coal seam mining under ultra-thick conglomerate. Opt Fiber Technol 53:102006. https://doi.org/10.1016/j.yofte.2019.102006
Chen D, Tian H (2012) Behavior based safety for accidents prevention and positive study in China construction project. Procedia Eng 43:528–534. https://doi.org/10.1016/j.proeng.2012.08.092
Chen H, Qi H, Long R, Zhang M (2012) Research on 10-year tendency of China coal mine accidents and the characteristics of human factors. Saf Sci 50(4):745–750. https://doi.org/10.1016/j.ssci.2011.08.040
Cheng G, Ma T, Tang C et al (2017) A zoning model for coal mining-induced strata movement based on microseismic monitoring. Int J Rock Mech Min Sci 94:123–138. https://doi.org/10.1016/j.ijrmms.2017.03.001
Dai G, Xue X, Xu K et al (2018) A GIS-based method of risk assessment on no. 11 coal-floor water inrush from Ordovician limestone in Hancheng mining area, China. Arab J Geosci 11(22):1–10. https://doi.org/10.1007/s12517-018-4071-8
Deng Q, Wang Y, Liu M, Wei J (2014) Statistical analysis and enlightenment on coal mine accident of China from 2001–2013 periods. Coal Technol 33(9):73–75
Ericson C, Li C (1999) Fault tree analysis. In System Safety Conference, Orlando, Florida 1:1–9
Fattahi NR, Raeisi VH, Noori PK et al (2022) Investigation on the effect of inclined crest step pool on scouring protection in erodible river beds. Nat Hazards 110(3):1495–1505. https://doi.org/10.1007/s11069-021-04999-w
Feng X, Yu Y, Feng G et al (2016) Fractal behavior of the microseismic energy associated with immediate rock bursts in deep, hard rock tunnels. Tunnel Undergr Space Technol 51:98–107. https://doi.org/10.1016/j.tust.2015.10.002
Fleming M, Fischer B (2017) Hazard recognition: Bridging knowledge & competency for process & occupational safety. Prof Saf 62(6):52
Fu G (2013) Behavior-based accident causation: the “2-4” model and its safety implications in coal mines. J China Coal Soc 38(7):1123–1129
Guo G (2013) Simulation analysis on feasibility of water pumping and water table dropping for pressurized water mining in underground mine. Int J Coal Sci Technol 41(05):125–128
Hallowell M, Alexander D, Gambatese A (2017) Energy-based safety risk assessment: does magnitude and intensity of energy predict injury severity? Constr Manag Econ 35(1–2):64–77. https://doi.org/10.1080/01446193.2016.1274418
Han C, Wei J, Xie D et al (2020) Water-richness evaluation of sandstone aquifer based on set pair analysis-variable fuzzy set coupling method: A case from Jurassic Zhiluo formation of Jinjiaqu coal mine in Ningdong mining area. J China Coal Soc 45(7):2432–2443
Heinrich HW (1941) Industrial accident prevention: a scientific approach. McGraw-Hill, New York
Hu Y, Li W, Wang Q et al (2019) Evaluation of water inrush risk from coal seam floors with an AHP–EWM algorithm and GIS. Environ Earth Sci 78(10):1–15
Javadinejad S, Eslamian S, Ostad-Ali-Askari K (2019a) Investigation of monthly and seasonal changes of methane gas with respect to climate change using satellite data. Appl Water Sci 9(8):1–8
Javadinejad S, Ostad-Ali-Askari K, Jafary F (2019b) Using simulation model to determine the regulation and to optimize the quantity of chlorine injection in water distribution networks. Model Earth Syst Environ 5:1015–1023. https://doi.org/10.1007/s40808-019-00587-x
Jiang B, Ren B, Su M et al (2021) A new quantitative method for risk assessment of coal floor water inrush based on PSR theory and extension cloud model. Geofluids. https://doi.org/10.1155/2021/5520351
Jiang X, Li C (2019) Statistical analysis on coal mine accidents in China from 2013 to 2017. Coal Engineering 51(1):101–105
Jiang J, Zhang Y, Luo G et al (2001) The application of preferred plane theory to geological engineering practice. J Hydraul Eng 8:90–96
Kabir S (2017) An overview of fault tree analysis and its application in model based dependability analysis. Expert Syst Appl 77(1):114–135. https://doi.org/10.1016/j.eswa.2017.01.058
Kang J, Wang Z, Pang N (2015) Analysis of water disaster type and prevention countermeasures in Shendong Mine Area. Int. J Coal Sci Technol 43(S2):155–157, 178
Khanzode V, Maiti J, Ray P (2012) Occupational injury and accident research: A comprehensive review. Saf Sci 50(5):1355–1367. https://doi.org/10.1016/j.ssci.2011.12.015
Kumamoto H, Henley E (1996) Probabilistic risk assessment and management for engineers and scientists, 2nd edn. IEEE Press
Kumar R, Ghosh A (2017) Mines systems safety improvement using an integrated event tree and fault tree analysis. J Inst Eng (India): Series D 98(1):101–108. https://doi.org/10.1007/s40033-016-0121-0
Li J, Wang S, Wang Y et al (2021) Water inrush risk assessment of coal floor after cbm development based on the fractal-ahp-vulnerability index method. Geotech Geol Eng 39(5):3487–3497
Li L, Qian M, Wen Q, Meng Y (1995) Relationship between the stability of floor structure and water inrush from floor. J China Univ Min Technol 24(4):18–23
Li Q, Sui W (2021) Risk evaluation of mine-water inrush based on principal component logistic regression analysis and an improved analytic hierarchy process. Hydrogeol J 1–13
Li S, Liu R, Zhang Q, Zhang X (2016) Protection against water or mud inrush in tunnels by grouting: A review. J Rock Mech Geotech Eng 8(5):753–766. https://doi.org/10.1016/j.jrmge.2016.05.002
Li Y, Yang T, Liu H et al (2016b) Real-time microseismic monitoring and its characteristic analysis in working face with high-intensity mining. J Appl Geophys 132:152–163. https://doi.org/10.1016/j.jappgeo.2016.07.010
Liu C, Li S, Cheng C, Xue J (2017) Activation characteristics analysis on concealed fault in the excavating coal roadway based on microseismic monitoring technique. Int J Min Sci Technol 27(5):883–887. https://doi.org/10.1016/j.ijmst.2017.06.023
Liu W, Han M, Meng X, Qin Y (2021) Mine water inrush risk assessment evaluation based on the gis and combination weight-cloud model: a case study. ACS Omega 6(48):32671–32681
Liu Y, Li W, He J et al (2018) Application of Brillouin optical time domain reflectometry to dynamic monitoring of overburden deformation and failure caused by underground mining. Int J Rock Mech Min Sci 106:133–143. https://doi.org/10.1016/j.ijrmms.2018.04.030
Maiti J, Khanzode V, Ray P (2009) Severity analysis of Indian coal mine accidents - A retrospective study for 100 years. Saf Sci 47(7):1033–1042. https://doi.org/10.1016/j.ssci.2008.11.007
Mares R, Nagy M, Radu I (2020) Using the event tree analysis in the investigation of a work accident. In MATEC Web of Conferences (Vol. 305, p. 00088). EDP Sciences
McKinnon RC (2019) Cause, effect, and control of accidental loss with accident investigation kit. CRC Press, Boca Raton, Fla
Meng X, Liu Q, Luo X, Zhou X (2019) Risk assessment of the unsafe behaviours of humans in fatal gas explosion accidents in China’s underground coal mines. J Clean Prod 210:970–976. https://doi.org/10.1016/j.jclepro.2018.11.067
Meng Z, Gao Y, Lu A et al (2013) Water inrush risk evaluation of coal mining under quaternary alluvial water and reasonable design method of waterproof coal pillar. J Min Saf Eng 30(1):23–29
Meng Z, Li G, Xie X (2012) A geological assessment method of floor water inrush risk and its application. Eng Geol 143:51–60
Mottahedi A, Ataei M (2019) Fuzzy fault tree analysis for coal burst occurrence probability in underground coal mining. Tunn Underg Space Technol 83:165–174. https://doi.org/10.1016/j.tust.2018.09.029
Ostad-Ali-Askari et al (2017a) Chapter No. 18: Deficit Irrigation: Optimization Models. Management of Drought and Water Scarcity. Handbook of Drought and Water Scarcity, Vol. 3, pp: 373–389. Taylor & Francis Publisher. Imprint: CRC Press. eBook ISBN: 9781315226774. 1st Edition. https://doi.org/10.1201/9781315226774
Ostad-Ali-Askari K (2022) Management of risks substances and sustainable development. Appl Water Sci 12(4):1–23. https://doi.org/10.1007/s13201-021-01562-7
Ostad-Ali-Askari K, Shayannejad M, Ghorbanizadeh-Kharazi H (2017) Artificial neural network for modeling nitrate pollution of groundwater in marginal area of Zayandeh-rood River, Isfahan Iran KSCE. J Civ Eng 21(1):134–140
Ostad-Ali-Askari K, Shayannejad M (2021) Computation of subsurface drain spacing in the unsteady conditions using Artificial Neural Networks (ANN). Appl Water Sci 11:21. https://doi.org/10.1007/s13201-020-01356-3
Peng W, Wang W, Li Q (2009) Reasonable width of waterproof coal pillar under the condition of different fault dip angles. J Min Saf Eng 26(02):179–182+186
Qian X, Chen B (1994) On identification and control of major hazard. China Safety Science Journal 4(3):16–21
Qian D, Zhang N, Zhang M et al (2017) Application and evaluation of ground surface pre-grouting reinforcement for 800-m-deep underground opening through large fault zones. Arab J Geosci 10(13):285. https://doi.org/10.1007/s12517-017-3052-7
Robinson G (1982) Accidents and sociotechnical systems: principles for design. Accid Anal Prev 14(2):121–130. https://doi.org/10.1016/0001-4575(82)90078-1
Sui W, Wang D, Sun Y et al (2019) Mine hydrogeological structure and its responses to mining. J Eng Geol 27(1): 21–28. https://doi.org/10.13544/j.cnki.jeg.2019-072
Sun J, Wang L, Hou H (2012) Application of micro-seismic monitoring technology in mining engineering. Int J Min Sci Technol 22(1):79–83. https://doi.org/10.1016/j.ijmst.2011.06.007
Sun W, Xue Y (2019) An improved fuzzy comprehensive evaluation system and application for risk assessment of floor water inrush in deep mining. Geotech Geol Eng 37(3):1135–1145. https://doi.org/10.1007/s10706-018-0673-x
Talebmorad H, Ahmadnejad A, Eslamian S et al (2020) Evaluation of uncertainty in evapotranspiration values by FAO56-Penman-Monteith and Hargreaves-Samani methods. Int J Hydrol Sci Technol 10(2):135–147. https://doi.org/10.1504/IJHST.2020.106481
Tian S (2001) Identification and control research on three types of hazard. Beijing Institute of Technology, Beijing.
Tu W, Li L, Shang C et al (2019) Comprehensive risk assessment and engineering application of mine water inrush based on normal cloud model and local variable weight. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 1–16
Verma S, Chaudhari S (2017) Safety of workers in indian mines: study, analysis, and prediction. Saf Health Work 8(3):267–275. https://doi.org/10.1016/j.shaw.2017.01.001
Wang J (2008) Hazard structure of coal mine production system and prevention of coal mine accident. Mining Safety & Environmental Protection 35(1):85–88
Wang L, Yang S (2000) A catastrophic model of water-inrush from coal floor. J Eng Geol 8(2):160–163
Wang Q, Lin Y, Li W et al (2022) GIS-based evaluation of water-inrush risk from coal floor using logistic regression and certainty factor models. Arab J Geosci 15(3):1–11
Wang X, Li S, Xu Z et al (2019) Analysis of factors influencing floor water inrush in coal mines: a nonlinear fuzzy interval assessment method. Mine Water Environ 38(1):81–92. https://doi.org/10.1007/s10230-018-00578-x
Wang X, Pan G, Zhai J (2012a) Analysis on suitability of water prevention and control measures with water pumping and pressure releasing in underground mine. Coal Science and Technology 40(11):108–111
Wang Y, Yang WF, Li M, Liu X (2012b) Risk assessment of floor water inrush in coal mines based on secondary fuzzy comprehensive evaluation. Int J Rock Mech Min Sci 52(6):50–55. https://doi.org/10.1016/j.ijrmms.2012.03.006
Wells G (1996) Hazard identification and risk assessment. Rugby: Institute of Chemical Engineers
WHO (2020) World Health Organization. Risk assessment
Willquist P, Törner M (2003) Identifying and analyzing hazard in manufacturing industry—a review of selected methods and development of a framework for method applicability. Int J Ind Ergon 32(3):165–180. https://doi.org/10.1016/S0169-8141(03)00061-1
Wu Q, Xu H, Pang W (2008) GIS and ANN coupling model: an innovative approach to evaluate vulnerability of karst water inrush in coalmines of North China. Environ Geol 54(5):937–943. https://doi.org/10.1007/s00254-007-0887-3
Wu Q, Zhou W (2008) Prediction of groundwater inrush into coalmines from aquifers underlying the coal seams in China: vulnerability index method and its construction. Environ Geol 56(2):245–254. https://doi.org/10.1007/s00254-007-1160-5
Wu Q, Zhou W, Li D et al (2006) Management of karst water resources in mining area: dewatering in mines and demand for water supply in the Dongshan Mine of Taiyuan, Shanxi Province. North China Environ Geol 50(8):1107–1117. https://doi.org/10.1007/s00254-006-0284-3
Wu Q, Liu Y, Yang L (2011) Using the vulnerable index method to assess the likelihood of a water inrush through the floor of a multi-seam coal mine in China. Mine Water Environ 30(1):54–60. https://doi.org/10.1007/s10230-010-0125-1
Wu Q, Zhou W, Wang J, Xie S (2009) Prediction of groundwater inrush into coal mines from aquifers underlying the coal seams in China: application of vulnerability index method to Zhangcun Coal Mine. China Environ Geol 57(5):1187–1195. https://doi.org/10.1007/s00254-008-1415-9
Wu Q (2014) Progress, problems and prospects of prevention and control technology of mine water and reutilization in Chinaf. J China Coal Soc 39(5):795–805
Xu S (2013) Mine water disaster type analysis and controlling advices in Fudong coalmine. Shanxi Coal Geol of China 25(10):36–39
Yang B, Sui W, Duan L (2017) Risk assessment of water inrush in an underground coal mine based on GIS and fuzzy set theory. Mine Water Environ 36(4):617–627
Yesilnacar MI, Kadiragagil Z (2013a) Effects of acid mine drainage on groundwater quality: a case study from an open-pit copper mine in eastern Turkey. Bull Eng Geol Environ 72:485–493. https://doi.org/10.1007/s10064-013-0512-5
Yesilnacar MI, Kadiragagil Z (2013b) Effects of acid mine drainage on groundwater quality: a case study from an open-pit copper mine in eastern Turkey. Bull Eng Geol Env 72(3):485–493
Yin H, Bu C, Wei J et al (2009) Types of mine water disasters and control measures in Shandong. China Mining Safety and Environ Protect 36(6):79–81
Zhang H (2010) Research on comprehensive assessment system and application of coal mine safety risks. Dissertation, China University of Mining and Technology
Zhang J (2005) Investigations of water inrushes from aquifers under coal seams. Int J Rock Mech Min Sci 42(3):350–360. https://doi.org/10.1016/j.ijrmms.2004.11.010
Zhang J, Liu T (1990) On depth of fissured zone in seam floor resulted from coal extraction and its distribution characteristics. J China Coal Soc 15(2):46–55
Zhou W, Zhang P, Wu R, Hu X (2019) Dynamic monitoring the deformation and failure of extra-thick coal seam floor in deep mining. J Appl Geophys 163:132–138. https://doi.org/10.1016/j.jappgeo.2019.02.007
Acknowledgements
The authors thank the National Natural Science Foundation of China (Grant No. 42130706) for its financial support. Thanks were given to the anonymous reviewers for the detailed comments and suggestions for improving the quality of this paper.
Author information
Authors and Affiliations
Contributions
Dandan Wang was involved in conceptualization, methodology, formal analysis, literature search, data curation, investigation, resources, visualization, writing—original draft, writing—review & editing. Wanghua Sui helped in project administration, funding acquisition, supervision. James F. Ranville contributed to supervision.
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper.
Rights and permissions
Springer Nature or its licensor holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Wang, D., Sui, W. & Ranville, J.F. Hazard identification and risk assessment of groundwater inrush from a coal mine: a review. Bull Eng Geol Environ 81, 421 (2022). https://doi.org/10.1007/s10064-022-02925-3
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s10064-022-02925-3