Abstract
Flow-induced structures in suspensions containing spheres in viscoelastic suspending media were investigated by microscopy and rheo-optical methods. Suspensions of monodisperse polystyrene spheres with diameters ranging from 1.2 to 2.8 μm and dispersed in aqueous solutions of hydroxypropylcellulose were studied in simple shear flows. Optical microscopy observations as well as small-angle light-scattering (SALS) experiments were performed using a parallel plate geometry. In agreement with previous work, necklaces of particles aligned in the flow direction were observed when shearing faster then a critical shear rate, which was found to be independent of particle size. In contrast to earlier work, however, the role of particle migration was found to be of prime importance. Particles were shown to migrate toward the plates where the particles assembled and aligned in strings running in the flow direction. For the smallest particles (1 μm diameter), the formation of particle doublets or short strings along the vorticity direction was observed at low shear rates, which flipped to an orientation into the flow direction and grew into longer strings at higher shear rates. SALS experiments were used to quantify the degree of alignment and its dependence on particle size, shear rate, and gap. For the system under investigation, the degree of alignment was found to increase with increasing shear rate and particle size and with decreasing gap. The present results suggest that, depending on the details of the suspending medium and the size and nature of the suspended particles, the formation of aligned structures is affected by the relative magnitude of the colloidal and hydrodynamic forces and the kinetics of string formation versus the kinetics of migration.
Similar content being viewed by others
References
Almog Y, Reich S, Levy M (1982) Monodisperse polymeric spheres in the micron size range by a single step process. Br Polym J 14:131–136
Bodvik R, Dedinaite A, Karlson L, Bergstrom M, Baverback P, Pedersen JS, Edwards K, Karlsson G, Varga I, Claesson Per M (2010) Aggregation and network formation of aqueous methylcellulose and hydroxypropylmethylcellulose solutions. Colloids Surf A Physicochem Eng Asp 354:162–171
Brunn P (1976) Slow motion of a sphere in a second-order fluid. Rheol Acta 15:163–171
Giesekus H (1978) Die bewegung von teilchen in stromungen nicht-newtonscher flussigkeiten. Z Angew Math Mech 58:T26–T37
Giesekus H (1981) Some new results in suspension rheology. In: Wendt F (ed) Lect. Ser. 1981–1988, Non-Newt. Flows. Von Karman Inst. for Fl. Dynamics, Rhode Saint Genese
Gunes D, Scirocco R, Mewis J, Vermant J (2008) Effects of aspect ratio and suspending medium rheology on flow-induced orientation of non-spherical particles. J Non-Newton Fluid Mech 155:39–50
Ho BP, Leal LG (1976) Migration of rigid spheres in a two-dimensional unidirectional shear-flow of a second order fluid. J Fluid Mech 76:783–799
Jefri MA, Zahed AH (1989) Elastic and viscous effects on particle migration in plane-Poiseulle flow. J Rheol 33:691–708
Johnson SJ, Fuller GG (1987) The dynamics of colloidal particles suspended in a second-order fluid. Faraday Discuss Chem Soc 83:271–285
Joseph DD, Feng J (1996) A note on forces that move particles in a second order fluid. J Non-Newton Fluid Mech 64:299–302
Karnis A, Mason SG (1966) Particle motions in sheared suspensions. XIX. Viscoelastic media. Trans Soc Rheol 10:571–592
Lormand BM, Philips LG (2004) Sphere migration in oscillatory Couette flow of a viscoelastic fluid. J Rheol 48:551–570
Lyon MK, Mead DW, Elliot RE, Leal LG (2001) Structure formation in moderately concentrated viscoelastic suspensions in simple shear flow. J Rheol 45:881–890
Maranzano BJ, Wagner NJ (2002) Flow-small angle neutron scattering measurements of colloidal dispersion microstructures through the shear thickening transition. J Chem Phys 117:10291–10302
Michele J, Patzold R, Donis R (1977) Alignment and aggregation effects in suspensions of spheres in non-Newtonian media. Rheol Acta 16:317–321
Morris JF, Boulay F (1999) Curvilinear flows of noncolloidal suspensions. The role of normal stresses. J Rheol 43:1213–1237
Ponche A, Dupuis D (2005) On instabilities and migration phenomena in cone and plate geometry. J Non-Newton Fluid Mech 127:123–129
Scirocco R, Vermant J, Mewis J (2004) Effect of the viscoelasticity of the suspending fluid on structure formation in suspensions J Non-Newton Fluid Mech 117:183–192
Tehrani MA (1966) An experimental study of particle migration in pipe flow of viscoelastic fluids. J Rheol 40:1057–1077
Won D, Kim C (2004) Alignment and aggregation of spherical particles in viscoelastic fluid under shear flow. J Non-Newton Fluid Mech 117:141–146
Acknowledgements
The financial support of Regione Campania (Funds L.5-2007) is gratefully acknowledged. FS thanks FWO-Vlaanderen for a graduate fellowship. JV also acknowledges support of the EU through FP7, project Nanodirect NMP4-SL-2008-213948.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Pasquino, R., Snijkers, F., Grizzuti, N. et al. The effect of particle size and migration on the formation of flow-induced structures in viscoelastic suspensions. Rheol Acta 49, 993–1001 (2010). https://doi.org/10.1007/s00397-010-0466-5
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00397-010-0466-5