Abstract
A systematic investigation of the structural, morphological, and optical properties of Zn1 − xCuxO thin films (0 ≤ x ≤ 1) is presented. The films were produced by spray pyrolysis on top of glass substrates employing a clean acetate chemical route. X-ray diffraction patterns show the polycrystalline character of the films without secondary phases in wurtzite (up to x = 0.10) and monoclinic (above x = 0.90) symmetries. The intermediate concentrations present both phases. Electron microscopy images exhibit homogeneous surface with increasing roughness as the amount of copper increases. For intermediate Cu concentrations, the films present phase segregation with constant optical absorption coefficient around 2 × 104 cm− 1 in the visible range, while a larger tunable absorbance is available for higher Cu concentrations. The indirect bandgap is reported for Zn1 − xCuxO with x > 0.25, whereas the CuO direct bandgap absorption is very sensitive to the introduction of Zn in the lattice.
Similar content being viewed by others
References
A. Janotti, C.G. Van de Walle, Rep. Prog. Phys. 72, 126501 (2009)
P.S. Shewale, N.K. Lee, S.H. Lee, K.Y. Kang, Y.S. Yu, J. Alloys Compd. 624, 251 (2015)
C.-H. Chen, S.-J. Chang, S.-P. Chang, M.-J. Li, I.-C. Chen, T.-J. Hsueh, A.-D. Hsu, C.-L. Hsu, J. Phys. Chem. C 114, 12422 (2010)
C.-L. Hsu, T.-Y. Tsai, J. Electrochem. Soc. 158, K20 (2011)
N.B. Patil, A.R. Nimbalkar, M.G. Patil, Mater. Sci. Eng. B 227, 53 (2018)
Q. Zhang, K. Zhang, D. Xu, G. Yang, H. Huang, F. Nie, C. Liu, S. Yang, Prog. Mater. Sci. 60, 208 (2014)
D. Jeong, J. Lee, H. Hong, D. Choi, J.-W. Cho, S.-K. Kim, Y. Nam, Sol. Energy Mater. Sol. Cells 169, 270 (2017)
S.B. Wang, C.H. Hsiao, S.J. Chang, K.T. Lam, K.H. Wen, S.C. Hung, S.J. Young, B.R. Huang, Sens. Actuators A 171, 207 (2011)
R. Elilarassi, G. Chandrasekaran, J. Mater. Sci. Mater. Electron. 21, 1168 (2010)
D.H. Kim, T.C. Kim, S.H. Lee, H.K. Jung, J. Jeong, S.H. Han, J. Cryst. Growth 460, 78 (2017)
M.B. Rahmani, S.H. Keshmiri, M. Shafiei, K. Latham, W. Wlodarski, J. du Plessis, K. Kalantar-Zadeh, Sens. Lett. 7, 621 (2009)
T. Dietl, H. Hono, F. Matsukura, J. Cibert, D. Ferrand, Science 287, 1019 (2000)
X.-L. Li, X.-H. Xu, Z.-Y. Quan, J.-F. Guo, H.-S. Wu, G.A. Gehring, J. Appl. Phys. 105, 103914 (2009)
Y. Jin, Q. Cui, G. Wen, Q. Wang, J. Hao, S. Wang, J. Zhang, J. Phys. D Appl. Phys. 42, 215007 (2009)
J.M.D. Coey, M. Venkatesan, C.B. Fitzgerald, Nat. Mater. 4, 173 (2005)
P.S. Shewale, Y.S. Yu, Ceram. Int. 43, 4175 (2017)
J.B. Kim, D. Byun, S.Y. Ie, D.H. Park, W.K. Choi, J.-W. Choi, B. Angadi, Semicond. Sci. Technol. 23, 095004 (2008)
P.S. Patil, Mater. Chem. Phys. 59, 185 (1999)
D. Perednis, L.J. Gauckler, J. Electroceram. 14, 103 (2005)
M. Öztas, M. Bedir, Thin Solid Films 516, 1703 (2008)
N.L. Tarwal, K.V. Gurav, S.H. Mujawar, S.B. Sadale, K.W. .Nam, W.R. .Bae, A.V. Moholkar, J.H. .Kim, P.S. .Patil, J.H. Jang, Ceram. Int. 40, 7669 (2014)
S. de Castro, S.L. dos Reis, A.D. Rodrigues, M.P.F. de Godoy, Mater. Sci. Eng. B 212, 96 (2016)
Y.S. Wang, P.J. Thomas, P. O’Brien, J. Phys. Chem. B 110, 21412 (2006)
Y.J. Onofre, S. de Castro, A.D. Rodrigues, M.P.F. de Godoy, J. Anal. Appl. Pyrolysis 128, 131 (2017)
M. Ashokkumar, S. Muthukumaran, J. Alloys Compd. 587, 606 (2014)
K.L. Choy, B. Su, Thin Solid Films 388, 9 (2001)
A. Van der Drift, Philips Res. Rep. 22, 267 (1967)
H.B. Nguyen, T.Q. Thai, S. Saitoh, B. Wu, Y. Saitoh, S. Shimo, H. Fujitani, H. Otobe, N. Ohno, Sci. Rep. 6, 23721 (2016)
M. Niranjana, L. Yesappa, S.P. Ashokkumar, H. Vijeth, H. Devendrappa, AIP Conference Proc. p. 1953, 030007, 2018
J. Tauc, Mater. Res. Bull. 3, 37 (1968)
M. Heinemann, B. Eifert, C. Heiliger, Phys. Rev. B 87, 115111 (2013)
Y. Wang, S. Lany, J. Ghanbaja, Y. Fagot-Revurat, Y.P. Chen, F. Soldera, D. Horwat, F. Mücklich, J.F. Pierson, Phys. Rev. B 94, 245418 (2016)
B.K. Meyer, A. Polity, D. Reppin, M. Becker, P. Hering, P.J. Klar, Th Sander, C. Reindl, J. Benz, M. Eickhoff, C. Heiliger, M. Heinemann, J. Bläsing, A. Krost, S. Shokovets, C. Müller, C. Ronning, Phys. Status Solidi B 249, 1487 (2012)
M. Ferhat, A. Zaoui, R. Ahuja, Appl. Phys. Lett. 94, 142502 (2009)
Acknowledgements
This work was supported by FAPESP (Grant 2016/10973-4). Fellowships from CAPES and CNPq are acknowledged. The authors thank N. Zanardi from DF-UFSCar for XRD and SEM measurements and N. Coutinho from Laboratório de Pesquisas Fotovoltaicas at UNICAMP for measurements of samples’ thicknesses.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Scolfaro, D., Rodrigues, A.D. & de Godoy, M.P.F. Optical absorption in full composition range of ZnCuO thin films synthesized by spray pyrolysis. Appl. Phys. A 124, 774 (2018). https://doi.org/10.1007/s00339-018-2201-5
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s00339-018-2201-5