Abstract
Antimony telluride (Sb2Te3) is one of the best thermoelectric materials at room temperature. Low dimension has the potential to improve the material thermoelectric properties. Herein, we demonstrate experimental evidence of the positive influence of tellurium (Te) nanoparticles on thermopower of Sb2Te3 thin film. Sb2Te3 films with Te nanoparticles are prepared by alternate growth of Sb2Te3 layers and Te layers. When the single Te layer thickness is 1 nm, Te nanoparticle diameter is about 5 nm and areal density is approximately 160 µm−2, the Seebeck coefficient increases by ~25 %, thermoelectric power factor by ~50 %, and thermal conductivity decreases by ~26 % compared with Te layer free Sb2Te3 film without Te nanoparticles. The enhancement of thermoelectric thermopower could be attributed to carrier energy filtering effect induced by Te–Sb2Te3 nanocrystal boundary, and the thermal conductivity reduction may be ascribed to enhance phonon scattering by Te nanoparticles. The results show the Te nanoparticles have the ability to improve Sb2Te3 material thermoelectric properties.
Similar content being viewed by others
References
J.C. Caylor, K. Coonley, J. Stuart, T. Colpitts, R. Venkatasubramanian, Enhanced thermoelectric performance in PbTe-based superlattice structures from reduction of lattice thermal conductivity. Appl. Phys. Lett. 87, 023105 (2005)
A.I. Hochbaum, R. Chen, R.D. Delgado, W. Liang, E.C. Garnett, M. Najarian, A. Majumdar, P. Yang, Enhanced thermoelectric performance of rough silicon nanowires. Nature 451, 163–167 (2008)
Y.H. Park, J. Kim, H. Kim, I. Kim, K.Y. Lee, D. Seo, H.J. Choi, W. Kim, Thermal conductivity of VLS-grown rough Si nanowires with various surface roughnesses and diameters. Appl. Phys. A 104, 7–14 (2011)
T.C. Harman, Quantum dot superlattice thermoelectric materials and devices. Science 297, 2229–2232 (2002)
R. Kim, M.S. Lundstrom, Computational study of energy filtering effects in one-dimensional composite nano-structures. J. Appl. Phys. 111, 024508 (2012)
D.K. Ko, Y. Kang, C.B. Murray, Enhanced thermopower via carrier energy filtering in solution-processable Pt–Sb2Te3 nanocomposites. Nano Lett. 11, 2841–2844 (2011)
Y. Zhang, M.L. Snedaker, C.S. Birkel, S. Mubeen, X. Ji, Y. Shi, D. Liu, X. Liu, M. Moskovits, G.D. Stucky, Silver-based intermetallic heterostructures in Sb2Te3 thick films with enhanced thermoelectric power factors. Nano Lett. 12, 1075–1080 (2012)
A. Minnich, M. Dresselhaus, Z. Ren, G. Chen, Bulk nanostructured thermoelectric materials: current research and future prospects. Energy Environ. Sci. 2, 466–479 (2009)
S. Faleev, F. Léonard, Theory of enhancement of thermoelectric properties of materials with nanoinclusions. Phys. Rev. B 77, 214304 (2008)
S.I. Kim, S. Hwang, J.W. Roh, K. Ahn, D.H. Yeon, K.H. Lee, S.W. Kim, Experimental evidence of enhancement of thermoelectric properties in tellurium nanoparticle-embedded bismuth antimony telluride. J. Mater. Res. 27, 2449–2456 (2012)
I.J. Yoo, Y. Song, D.C. Lim, N.V. Myung, K.H. Lee, M. Oh, D. Lee, Y.D. Kim, S. Kim, Y.H. Choa, J.Y. Lee, K.H. Lee, J.H. Lim, Thermoelectric characteristics of Sb2Te3 thin films formed via surfactant-assisted electrodeposition. J. Mater. Chem. A 1, 5430 (2013)
Y. Zhang, M.L. Snedaker, C.S. Birkel, S. Mubeen, X. Ji, Y. Shi, D. Liu, X. Liu, M. Moskovits, G.D. Stucky, Silver-based intermetallic heterostructures in Sb2Te3 thick films with enhanced thermoelectric power factors. Nano Lett. 12, 1075–1080 (2012)
G. Hao, X. Qi, G. Wang, X. Peng, S. Chang, X. Wei, J. Zhong, Synthesis and characterization of few-layer Sb2Te3 nanoplates with electrostatic properties. RSC Adv. 2, 10694 (2012)
M.A. Matin, M. Mannir Aliyu, A.H. Quadery, N. Amin, Prospects of novel front and back contacts for high efficiency cadmium telluride thin film solar cells from numerical analysis. Sol. Energy Mater. Sol. Cells 94, 1496–1500 (2010)
D.W. Niles, X. Li, P. Sheldon, H. Höchst, A photoemission determination of the band diagram of the Te/CdTe interface. J. Appl. Phys. 77, 4489 (1995)
D.G. Cahill, Thermal conductivity measurement from 30 to 750 K: the 3ω method. Rev. Sci. Instrum. 61, 802 (1990)
W. Kim, J. Zide, A. Gossard, D. Klenov, S. Stemmer, A. Shakouri, A. Majumdar, Thermal conductivity reduction and thermoelectric figure of merit increase by embedding nanoparticles in crystalline semiconductors. Phys. Rev. Lett. 96, 045901 (2006)
Y. Kim, A. Divenere, G.K. Wong, J. Ketterson, S. Cho, J.R. Meyer, Structural and thermoelectric transport properties of Sb2Te3 thin films grown by molecular beam epitaxy. J. Appl. Phys. 91, 715–718 (2002)
V.D. Das, P.G. Ganesan, Thickness and temperature effects on thermoelectric power and electrical resistivity of (Bi0.25Sb0.75)2Te3 thin films. Mater. Chem. Phys. 57, 57–66 (1998)
J. Yu, X. Zhao, Q. Zhao, Effect of film thickness on the grain size and photocatalytic activity of the sol-gel derived nanometer TiO2 thin films. J. Mater. Sci. Lett. 19, 1015–1017 (2000)
P. Ganesan, V.D. Das, Thickness and temperature effects on electrical resistivity of (Bi0.5Sb0.5)2Te3 thin films. Mater. Lett. 60, 2059–2065 (2006)
O. Madelung, U. Rössler, M. Schulz, Non-Tetrahedrally Bonded Elements and Binary Compounds I (Springer, Berlin, 1998), pp. 1–2
K. Rajasekar, L. Kungumadevi, A. Subbarayan, R. Sathyamoorthy, Thermal sensors based on Sb2Te3 and (Sb2Te3)70 (Bi2Te3)30 thin films. Ionics 14, 69–72 (2008)
Z. Xiong, X. Chen, X. Huang, S. Bai, L. Chen, High thermoelectric performance of Yb0.26Co4Sb12/yGaSb nanocomposites originating from scattering electrons of low energy. Acta Mater. 58, 3995–4002 (2010)
J. Zide, D. Vashaee, Z. Bian, G. Zeng, J. Bowers, A. Shakouri, A. Gossard, Demonstration of electron filtering to increase the Seebeck coefficient in In0.53Ga0.47As/In0.53Ga0.28Al0.19As superlattices. Phys. Rev. B 74, 205335 (2006)
J.H. Bahk, Z. Bian, A. Shakouri, Electron energy filtering by a nonplanar potential to enhance the thermoelectric power factor in bulk materials. Phys. Rev. B 87, 075204 (2013)
B. Paul, A. Kumar, P. Banerji, Embedded Ag-rich nanodots in PbTe: enhancement of thermoelectric properties through energy filtering of the carriers. J. Appl. Phys. 108, 064322 (2010)
M. Scheele, N. Oeschler, I. Veremchuk, S.-O. Peters, A. Littig, A. Kornowski, C. Klinke, H. Weller, Thermoelectric properties of lead chalcogenide core–shell nanostructures. ACS Nano 5, 8541–8551 (2011)
M. Cutler, N. Mott, Observation of anderson localization in an electron gas. Phys. Rev. 181, 1336–1340 (1969)
J.P. Heremans, C.M. Thrush, D.T. Morelli, Thermopower enhancement in PbTe with Pb precipitates. J. Appl. Phys. 98, 063703 (2005)
X. Cai, X.A. Fan, Z. Rong, F. Yang, Z. Gan, G. Li, Improved thermoelectric properties of Bi2Te3−xSex alloys by melt spinning and resistance pressing sintering. J. Phys. D Appl. Phys. 47, 115101 (2014)
W. Wang, X. Yan, B. Poudel, Y. Ma, Q. Hao, J. Yang, G. Chen, Z. Ren, Chemical synthesis of anisotropic nanocrystalline Sb2Te3 and low thermal conductivity of the compacted dense bulk. J. Nanosci. Nanotechnol. 8, 452–456 (2008)
W. Kim, J. Zide, A. Gossard, D. Klenov, S. Stemmer, A. Shakouri, A. Majumdar, Thermal conductivity reduction and thermoelectric figure of merit increase by embedding nanoparticles in crystalline semiconductors. Phys. Rev. Lett. 96, 045901 (2006)
Acknowledgments
This research was supported by Shanghai Science and Technology Funds (10520710400, 10PJ1403800, 11DZ1111200), Yunnan Provincial Science and Technology Department (2010AD003), National Natural Science Foundation of China (21103104), Innovation Foundation of Shanghai University, and the Special Fund for Selection and Cultivation Excellent Youth in the University of Shanghai city. The authors gratefully acknowledge the Instrumental Analysis Research Centre of Shanghai University for helping in XRD and TEM experiment.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Zhang, Z., Zhang, H., Wu, Y. et al. Optimization of the thermopower of antimony telluride thin film by introducing tellurium nanoparticles. Appl. Phys. A 118, 1043–1051 (2015). https://doi.org/10.1007/s00339-014-8871-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00339-014-8871-8