Skip to main content
SpringerLink
Log in

The effect of mechanical relaxation on ultra-fast charge pulses in flexible epoxy resin nanocomposites

  • Invited paper
  • Published:
Applied Physics A Aims and scope Submit manuscript

Abstract

Previously we have reported the existence of small-amplitude charge pulses in crosslinked Polyethylene (XLPE) and epoxy resin with a mobility several orders of magnitude higher than that found for the incoherent charge transport relevant to the steady state current. Here the relationship of this phenomenon to mechanical relaxation in the material is investigated by using a series of epoxy resin nanocomposites based on a resin that has its flexibility increased above that of the fully cured glassy epoxy network by the addition of a suitable flexibilizing chemical. Differential Scanning Calorimetry (DSC) measurements show that the stiffness of the nanocomposite is progressively increased as the nanoparticle concentration increases. Pulsed Electro-Acoustic (PEA) measurements reveal that both positive and negative fast charge pulses exist in the unfilled epoxy at 45 and 70°C under a field of 10 kV/mm with mobility 5×10−10 to 9×10−10 m2 V−1 s−1, amplitude between 2×10−5 and 3.6×10−5 C m−2 and repetition rates between 8 and 12 s−1. These values are reduced progressively as the nanoparticle concentration is increased from 0% in the unfilled epoxy. A β-mode mechanical relaxation is identified in the loss modulus by Dynamical Mechanical Analysis (DMA), whose activation energy moves to higher values with increasing nanoparticle concentration. It is shown that the repetition rates of both positive and negative pulses have similar values and are correlated with the β-mode activation energy; a similar correlation is found for the activation energy of the mobility of positive pulses. The correlation of the activation energy of the mobility of negative pulses and that of the β-mode is weaker although both show a progressive increase with nanoparticle concentration. The modification of the fast charge pulse properties by the mechanical stiffness of the epoxy nanocomposite is discussed in terms of the theory presented previously for their formation and transport.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12
Fig. 13
Fig. 14

Similar content being viewed by others

References

  1. D.A. Seanor, Electrical Properties of Polymers (Academic Press, London, 1982)

    Google Scholar 

  2. L.A. Dissado, G.C. Fothergill, Electrical Degradation and Breakdown in Polymers (Peregrinus Press, Stevenage, 1992)

    Book  Google Scholar 

  3. G.C. Montanari, IEEE Trans. Dielectr. Electr. Insul. 11, 56 (2004)

    Article  Google Scholar 

  4. T. Takada, IEEE Trans. Dielectr. Electr. Insul. 6, 519 (1999)

    Article  Google Scholar 

  5. G.C. Montanari, IEEE Trans. Dielectr. Electr. Insul. 7, 309 (2000)

    Article  MathSciNet  Google Scholar 

  6. D. Fabiani, G.C. Montanari, L.A. Dissado, C. Laurent, G. Teyssedre, IEEE Trans. Dielectr. Electr. Insul. 16, 241 (2009)

    Article  Google Scholar 

  7. D. Fabiani, G.C. Montanari, L.A. Dissado, J. Phys. Conf. Ser. 183, 012010 (2009)

    Article  ADS  Google Scholar 

  8. D. Fabiani, G.C. Montanari, L.A. Dissado, in IEEE Conference on Solid Dielectrics (ICSD) (IEEE, Piscataway, 2010), p. 309

    Google Scholar 

  9. D. Fabiani, G.C. Montanari, E. Siracusano, L.A. Dissado, in IEEE Conference on Electric Insulation and Dielectric Phenomena (CEIDP) (IEEE, Piscataway, 2009), p. 31

    Chapter  Google Scholar 

  10. J.-K. Yuan, W.-L. Li, S.-H. Yao, Y.-Q. Lin, A. Sylvestre, J. Bai, Appl. Phys. Lett. 98, 032901 (2011)

    Article  ADS  Google Scholar 

  11. K. Gupta, P.C. Jana, A.K. Meikap, J. Appl. Phys. 109, 123713 (2011)

    Article  ADS  Google Scholar 

  12. V. Tomer, G. Polizos, A. Randall, E. Manias, J. Appl. Phys. 109, 074113 (2011)

    Article  ADS  Google Scholar 

  13. L.A. Dissado, G.C. Montanari, D. Fabiani, J. Appl. Phys. 109, 064104 (2011)

    Article  ADS  Google Scholar 

  14. H. Koerner, D. Misra, A. Tan, L. Drummy, P. Mirau, R. Vaia, Polymer 47, 3426 (2006)

    Article  Google Scholar 

  15. L. Hardy, I. Stevenson, G. Boiteux, G. Seytre, A. Schönhals, Polymer 42, 5679 (2001)

    Article  Google Scholar 

  16. T.J. Lewis, J.P. Llewellyn, M.J. van der Sluijs, IEE Proc. A, Sci. Meas. Technol. 140, 385 (1993)

    Article  Google Scholar 

  17. P. Chen, D. Wang, Epoxy Resin and Application (Chemical Industry Press, Beijing, 2004)

    Google Scholar 

  18. X. Huang, Y. Zheng, X. Jiang, Y. Yin, IEEE Trans. Dielectr. Electr. Insul. 17, 635 (2010)

    Article  Google Scholar 

  19. D. Fabiani, G.C. Montanari, A. Dardano, G. Guastavino, L. Testa, M. Sangermano, in IEEE Conference on Electrical and Insulating Dielectric Phenomena (CEIDP 2003) (IEEE Press, Piscataway, 2008), p. 710

    Google Scholar 

  20. Z. Ranjbara, S. Rastegar, Prog. Org. Coat. 72, 40 (2011)

    Article  Google Scholar 

  21. F.-L. Jin, S.-J. Park, Mater. Sci. Eng. A, Struct. Mater.: Prop. Microstruct. Process. 478, 406 (2008)

    Article  Google Scholar 

  22. M. Sangermano, F. Deorsola, D. Fabiani, G.C. Montanari, G. Rizza, J. Appl. Polym. Sci. 111, 2541 (2009)

    Article  Google Scholar 

  23. L.H. Sperling, Introduction to Physical Polymer Science, 4th edn. (Wiley, New York, 2006)

    Google Scholar 

  24. R.H. Boyd, Polymer 5, 1123 (1985)

    Article  Google Scholar 

  25. J.P. Crine, IEEE Trans. Electr. Insul. 22, 169 (1987)

    Article  Google Scholar 

Download references

Acknowledgements

The authors would like to thank Dr. Krivda for providing the test specimens and Prof. Saccani for helping with DSC and SEM experiments.

Author information

Author notes

  1. M. Xu

    Present address: State Key Laboratory of Electrical Insulation and Power Equipment, Xi’an Jiaotong University, Xi’an, China

Authors and Affiliations

  1. LIMAT-DIE, University of Bologna, Bologna, Italy

    G. C. Montanari, M. Xu & D. Fabiani

  2. Department of Engineering, University of Leicester, Leicester, UK

    L. A. Dissado

Authors
  1. G. C. Montanari
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. M. Xu
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. D. Fabiani
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. L. A. Dissado
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to D. Fabiani.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Montanari, G.C., Xu, M., Fabiani, D. et al. The effect of mechanical relaxation on ultra-fast charge pulses in flexible epoxy resin nanocomposites. Appl. Phys. A 107, 539–551 (2012). https://doi.org/10.1007/s00339-012-6845-2

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00339-012-6845-2

Keywords

Search

Navigation