Abstract
Hydroxyectoine is an important compatible solute that holds potential for development into a high-value chemical with broad applications. However, the traditional high-salt fermentation for hydroxyectoine production presents challenges in treating the high-salt wastewater. Here, we report the rational engineering of Halomonas salifodinae to improve the bioproduction of hydroxyectoine under lower-salt conditions. The comparative transcriptomic analysis suggested that the increased expression of ectD gene encoding ectoine hydroxylase (EctD) and the decreased expressions of genes responsible for tricarboxylic acid (TCA) cycle contributed to the increased hydroxyectoine production in H. salifodinae IM328 grown under high-salt conditions. By blocking the degradation pathway of ectoine and hydroxyectoine, enhancing the expression of ectD, and increasing the supply of 2-oxoglutarate, the engineered H. salifodinae strain HS328-YNP15 (ΔdoeA::PUP119-ectD p-gdh) produced 8.3-fold higher hydroxyectoine production than the wild-type strain and finally achieved a hydroxyectoine titer of 4.9 g/L in fed-batch fermentation without any detailed process optimization. This study shows the potential to integrate hydroxyectoine production into open unsterile fermentation process that operates under low-salinity and high-alkalinity conditions, paving the way for next-generation industrial biotechnology.
Key points
• Hydroxyectoine production in H. salifodinae correlates with the salinity of medium
• Transcriptomic analysis reveals the limiting factors for hydroxyectoine production
• The engineered strain produced 8.3-fold more hydroxyectoine than the wild type
Graphical Abstract
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Introduction
Halophilic bacteria enable themselves to survive in high salt and alkaline environments by importing or biosynthesizing a variety of compatible solutes (Kempf and Bremer 1998). Hydroxyectoine is such a crucial compatible solute that helps halophilic bacteria maintain turgor pressure without interfering with normal cellular processes (Brown 1976; Inbar and Lapidot 1988). Compared with its biosynthetic precursor ectoine that binds seven water molecules, hydroxyectoine that can bind up to nine water molecules possesses a stronger hydration property. Besides, hydroxyectoine possesses excellent protective properties that can effectively enhance the protein stabilization, offering a promising reagent to protect proteins against a variety of harmful environmental stresses such as high salinity, heat, desiccation, freezing, and radiation (Lippert and Galinski 1992; Pastor et al. 2010; Tanne et al. 2014). Beyond its bioprotective role, hydroxyectoine has the potential to be developed into drugs in treating diseases such as Alzheimer’s and rhinoconjunctivitis (Bilstein et al. 2021; Kanapathipillai et al. 2005; Salapatek et al. 2011). Therefore, the biosynthesis of hydroxyectoine has attracted increasing attention due to its promising prospects across various applications (Graf et al. 2008; Liu et al. 2021).
The biosynthesis of hydroxyectoine begins with aspartate serving as the initial precursor (Fig. 1). The L-aspartate kinase (Ask_LysC) and L-aspartate-β-semialdehyde dehydrogenase (Asd) are responsible for the conversion of aspartate to aspartate-β-semialdehyde. Subsequently, a three-step enzymatic reaction involving L-2,4-diaminobutyrate aminotransferase (EctB), L-2,4-diaminobutyrate acetyltransferase (EctA), and ectoine synthase (EctC) catalyzes the synthesis of ectoine from aspartate-β-semialdehyde (Louis and Galinski 1997; Ono et al. 1999). The conversion of ectoine to hydroxyectoine is conducted by ectoine hydroxylase (EctD), a member of the non-heme-containing iron (II) and 2-oxoglutarate-dependent dioxygenase superfamily (Bursy et al. 2007; Garcia-Estepa et al. 2006; Reuter et al. 2010; Widderich et al. 2014b).
In the process of ectoine and hydroxyectoine production known as “bacterial milking,” halophilic bacteria such as Halomonas elongata are first grown under high-salt conditions to accumulate ectoine and hydroxyectoine (Sauer and Galinski 1998). Subsequently, these bacterial cells are transferred to water to release ectoine and hydroxyectoine. However, the accumulation of hydroxyectoine is positively correlated with the salinity of fermentation broth, causing the traditional high-salt fermentation to face huge challenges in the treatment of high-salt wastewater (Liu et al. 2021). Therefore, many attempts have been made to engineer non-halophilic bacteria for the production of hydroxyectoine under lower-salt conditions. By expressing the ectABCD_ask gene cluster from Pseudomonas stutzeri A1501 in E. coli FF4169, which cannot synthesize the compatible solute trehalose, 14.39 mg/g DCW hydroxyectoine was obtained in the presence of 0.3 mol/L NaCl, with an almost equivalent amount of ectoine produced (Stoeveken et al. 2011). When a single ectD gene from P. stutzeri A1501 was expressed in E. coli FF4169, 2.13 g/L ectoine supplemented in the medium was completely converted into hydroxyectoine within 24 h at a salinity of 0.4 mol/L NaCl (Czech et al. 2016). In a similar experiment, the ectABCD-ask gene cluster from P. stutzeri DSM5190T was introduced into E. coli DH5α, resulting in the predominant production of hydroxyectoine (over 95%) at a yield of 79.08 mg/g DCW in low-salt conditions (0.34 mol/L NaCl) (Seip et al. 2011). Additionally, the engineered E. coli expressing the hydroxyectoine biosynthetic pathway from Acidiphilium cryptum produced 1.6 g/L of hydroxyectoine at 0.08 mol/L NaCl, with a yield of 2.2 g/g DCW (Bethlehem and Moritz 2020). By optimizing the heterologous expression of hydroxyectoine biosynthetic genes and controlling the intracellular 2-oxoglutarate levels through quorum sensing-based autoregulation, an engineered E. coli employing an efficient osmolarity-independent production strategy achieved hydroxyectoine production of 14.93 g/L, with a yield as high as 1.678 g/g DCW (Ma et al. 2022).
Besides E. coli, an engineered Hansenula polymorpha expressing the codon-optimized ectABCD genes from Halomonas elongata produced hydroxyectoine with a yield of 57.73 mg/g dry cell weight (DCW) in the absence of NaCl (Eilert et al. 2013). Recently, hydroxyectoine production from carbon dioxide (CO2)-based biorefineries has been demonstrated in halotolerant hydrogen-oxidizing bacteria that naturally have the hydroxyectoine biosynthetic genes, with Rhodococcus opacus and Hydrogenibacillus schlegelii achieving yields of 53 mg/g biomass and 62 mg/g biomass at salinities of 1.20 and 0.85 mol/L NaCl, respectively (Cantera et al. 2023; Liang et al. 2024; Liu et al. 2023). Hybrid biological-inorganic systems were also employed for the production of hydroxyectoine from CO2 in halotolerant hydrogen-oxidizing Achromobacter xylosoxidans and Mycolicibacterium mageritense, which produced 208.77 µg/L and 9.49 µg/L hydroxyectoine at a salinity equivalent to seawater, respectively (Feng et al. 2023). In addition, by heterologously expressing of codon-optimized ectD from P. stutzeri A1501, the recombinant Corynebacterium glutamicum produced 74 g/L hydroxyectoine from ectoine, representing the highest hydroxyectoine titer reported so far (Jungmann et al. 2022). However, these processes still require high temperature sterilization, as these chassis cells are unable to survive in extreme conditions that can effectively prevent the growth of unwanted microorganisms. To decrease the energy consumption and production cost of hydroxyectoine production, it is necessary to develop a new strategy for efficient bioproduction of hydroxyectoine under lower-salt but higher-alkali conditions that allow open unsterile fermentation (Rodriguez-Moya et al. 2013).
Here, we explored the influence of salinity on the biosynthesis of hydroxyectoine by comparative transcriptomic analysis of halo- and alkali-tolerant Halomonas salifodinae IM328 grown under low-salt and high-salt conditions, respectively, and found that the expression levels of ectD and hydroxyectoine degradative pathway and the availability of 2-oxoglutarate affected the hydroxyectoine biosynthesis. Moreover, metabolic engineering of H. salifodinae IM328 was carried out to improve the hydroxyectoine production under lower-salt but alkaline conditions, and the finally obtained H. salifodinae strain HS328-YNP15 (ΔdoeA::PUP119-ectD p-gdh) finally achieved an 8.3-fold higher hydroxyectoine production compared to the wild-type strain, showing its potential for future hydroxyectoine production into open unsterile fermentation processes under conditions of low salinity and high alkalinity.
Materials and methods
Strains, plasmids, and growth conditions
The strains and plasmids used in this study are listed in Table 1. H. salifodinae IM328 (CGMCC 22183) grown in 80-LB medium was used as the start strain for genetic engineering (Zhang et al. 2021), while E. coli S17-1 grown in LB medium (containing 0.2 mol/L NaCl) was used for the plasmid constructions and conjugations (Fu et al. 2014). The 80-LB medium is the same as LB medium but contains 1.4 mol/L NaCl (Ma et al. 2020). For shake-flask culture, all H. salifodinae and E. coli strains were grown at 37 °C in an orbital shaker at 200 rpm.
Total RNA preparation and comparative transcriptomic analysis
H. salifodinae IM328 (GenBank: JADOTW000000000.1) was grown at 37 °C in LB medium containing 0.2 and 3.0 mol/L NaCl, respectively. After the cells reached the log phase of growth, 10 mL cultures were harvested and centrifuged at 4 °C for 10 min. The resultant pellets were then quickly frozen using liquid nitrogen before being stored at −80 °C. Total RNA extraction and transcriptome sequencing were carried out by Shanghai Majorbio Bio-Pharm Technology Co., Ltd. The RSEM (http://deweylab.github.io/RSEM/) and the DESeq2 (http://bioconductor.org/packages/release/bioc/html/DESeq2.html) software packages were employed to quantify the gene expression and identify the differentially expressed genes (DEGs), respectively. To account for multiple testing, the false discovery rate (FDR) was calculated to adjust the threshold of the p value. DEGs were defined as genes with FDR values < 0.01 and |log2 (fold change)| >1 (Liu et al. 2018). The Gene Ontology (GO) enrichment analysis of DEGs was conducted using Goatools (https://github.com/tanghaibao/GOatools). KEGG, as a database resource, was used to interpret the higher-order functional meanings and utilities of the organisms based on molecular-level information (Kanehisa et al. 2004). Consequently, KEGG pathway enrichment analysis was carried out to assess statistical significance.
Genetic manipulation of H. salifodinae
The pBBR1-PTac-RFP plasmid was constructed as follows. The MCS-TrrnB DNA fragment amplified from pBBR-rfp-ptac (Mu et al. 2017) by PCR using the Q5 high-fidelity DNA polymerase (New England Biolabs) was inserted into the HindIII/BamHI-digested pBBR-rfp-ptac using the T5 exonuclease-dependent assembly system (Xia et al. 2019) to obtain pBBR1-PTac, which was then digested by HindIII and NdeI and ligated with the mCherry gene (GenBank: PP001104) to obtain the pBBR1-PTac-RFP plasmid. To examine the strengths of different promoters, the PUP119, PJ23119, PJ23111, PJ23110, PJ23100, and PBAD(araC) promoters were incorporated into the XhoI/HindIII-digested pBBR1-PTac-RFP respectively. The constructed pBBR1-prompter-RFP plasmids were mobilized into H. salifodinae IM328 respectively by conjugation with E. coli S17-1 to obtain different H. salifodinae strains (HS328-YNP01 to HS328-YNP07) (Zhang et al. 2021). The ectD gene (GenBank: JADOTW010000016.1 /IHD13_09630) coding for ectoine hydroxylase in the genome of H. salifodinae IM328 was amplified and inserted into XhoI/NdeI-digested pBBR1-PTac to obtain the pBBR1-ectD plasmid. Then, PUP119, PJ23119, PJ23110, and PBAD (araC) promoters were incorporated into the XhoI-digested pBBR1-ectD for the plasmid-based overexpression of ectD. The constructed pBBR1-prompter-ectD plasmids were mobilized into H. salifodinae IM328 respectively by conjugation with E. coli S17-1 to obtain different H. salifodinae strains (HS328-YNP08 to HS328-YNP11) (Zhang et al. 2021).
In-frame deletion of doeA gene (GenBank: JADOTW010000003.1/IHD13_02420) from the ectoine degradation pathway (Schwibbert et al. 2011) was achieved as follows. Q5 high-fidelity DNA polymerase was used to amplify 1189 bp of DNA upstream of its start codon and 1184 bp of DNA downstream of its stop codon by PCR. Using the T5 exonuclease-dependent assembly system, the two DNA fragments obtained by PCR were incorporated into XhoI/BamHI-digested pJQ suicide plasmid. This plasmid is the same as the pJQ200SK suicide plasmid except that it harbors chloramphenicol resistance gene in place of gentamicin resistance gene. The obtained pJQ-ΔdoeA plasmid was then mobilized into H. salifodinae IM328 by conjugation with E. coli S17-1. Double-crossover event for allelic exchange was achieved using a selection and screening strategy employed in Rhodopseudomonas palustris (Rey et al. 2007). The H. salifodinae ΔdoeA mutant (strain HS328-YNP12), whose doeA gene was deleted in the genome, was finally obtained.
For the overexpression of ectD gene coding for ectoine hydroxylase, substitution of the native promoter in front of ectD with PUP119 promoter in the genome of HS328-YNP12 was achieved by using a pJQ suicide vector. Q5 high-fidelity DNA polymerase was used to amplify 1073 bp of DNA upstream of PectD promoter, 84 bp of PUP119 promoter DNA, and 936 bp of DNA downstream of PectD promoter by PCR. These three DNA fragments were incorporated into pJQ suicide vector using the T5 exonuclease-dependent assembly system to obtain the plasmid pJQ-PUP119-ectD. The HS328-YNP12 strain was used as the parent strain and pJQ-PUP119-ectD was mobilized into HS328-YNP12 by conjugation, using the same protocol as mentioned above. Double-crossover event for allelic exchange was achieved using a selection and screening strategy employed in Rhodopseudomonas palustris (Rey et al. 2007) to obtain H. salifodinae ΔdoeA::PUP119-ectD (strain HS328-YNP13).
For the overexpression of glutamate dehydrogenase, the genomic DNA of H. elongata DSM2581 (CGMCC 1.6329) was first used as template to amplify gdh gene (GenBank: FN869568.2/ HELO_3049) by PCR. The PCR fragment of gdh gene was then incorporated into the HindIII/NdeI-digested pBBR1-PJ23119-RFP to obtain pBBR1-PJ23119-gdh plasmid, which was then mobilized into HS328-YNP12 and HS328-YNP13 by conjugation with E. coli S17-1 to obtain the H. salifodinae ΔdoeA p-gdh (strain HS328-YNP14) and H. salifodinae ΔdoeA::PUP119-ectD p-gdh (strain HS328-YNP15), respectively (Zhang et al. 2021). The mutations of all engineered strains were verified through PCR and sequencing. Primers used in this study are listed in Supplementary Table S1.
Measurement of the fluorescence intensity
The cell pellets of the recombinant H. salifodinae strains (HS328-YNP01 to HS328-YNP07) overexpressing mCherry gene were washed three times and then resuspended with 10 mM phosphate-buffered saline (PBS). Then, 200 µL of cell suspension solution was transferred to a 96-well black microplate for the measurement of relative fluorescence intensity by a microplate reader (Synergy TMH4, BioTek Instruments), with the excitation and emission wavelengths configured to 587 nm and 610 nm, respectively (Jiang et al. 2022).
Shake-flask and fed-batch fermentation
For shake-flask culture, H. salifodinae strains (HS328-YNP08 to HS328-YNP15) were grown in MME or MMD medium under different salt conditions (37 °C, 200 rpm). The MME medium consisted of 30 g/L glucose, 1 g/L yeast extract, 0.25 g/L (NH4)2SO4, 0.2 g/L MgSO4, 9.65 g/L Na2HPO4·12H2O, 1.5 g/L KH2PO4, 1.7 g/L citric acid, 17.71 g/L sodium aspartate, 7.46 g/L KCl, 9 g/L beef extract, 10 mL/L trace element solution I, 1 mL/L trace element solution II, and varied amounts of NaCl. The trace element solution I contained 5 g/L Fe(III)-NH4-citrate, 2 g/L CaCl2, and 1 M HCl, while the trace element solution II comprised 100 mg/L ZnSO4·7H2O, 30 mg/L MnCl2·4H2O, 300 mg/L H3BO3, 200 mg/L CoCl2·6H2O, 10 mg/L CuSO4·5H2O, 20 mg/L NiCl2·6H2O, and 30 mg/L NaMoO4·2H2O. The pH of the medium was adjusted to 8.0 using 5 M NaOH (Ma et al. 2020). The MMD medium is identical to the MME medium, with the sole distinction being the substitution of sodium aspartate with sodium glutamate.
A 5-L bioreactor (Baoxing Co., China) containing 2 L of MMD medium supplemented with 1.4 mol/L NaCl was used for fed-batch culture of the finally obtained H. salifodinae ΔdoeA::PUP119-ectD p-gdh (strain HS328-YNP15). The dissolved oxygen (DO%) was maintained at ~ 30% of air saturation by flushing air with a maximum flow rate of 1 VVM (air volume per culture volume per min). The OD600, the concentration of glucose, sodium glutamate, ectoine, and hydroxyectoine were determined every 4 h.
Ectoine and hydroxyectoine measurements
To quantify the extracellular ectoine and hydroxyectoine, cultures were centrifuged at 12,000 rpm at room temperature for 2 min to collect their supernatants, which were then subjected to a 20-fold dilution for HPLC analysis. To measure the amounts of intracellular ectoine and hydroxyectoine, the cell pellets were first resuspended with 1 mL of ultrapure water and then treated with three freeze-thaw cycles (− 80 °C for 15 min and 65 °C for 2 min). The cell lysates were centrifuged at 12,000 rpm at room temperature for 20 min to collect the supernatants for HPLC analysis. Agilent 1260 Infinity II system equipped with an Inertsil NH2 column (4.6 × 250 mm, 5 μm, GL Sciences, Tokyo, Japan) was used to measure the ectoine and hydroxyectoine. Acetonitrile/ultrapure water (70:30, v/v) was used as the mobile phase at a flow rate of 1 mL/min. The detection wavelength of 210 nm was used to measure the ectoine and hydroxyectoine. The standard curves of ectoine and hydroxyectoine were created by determining the HPLC response to the commercially available ectoine (Mreda Technology Co., Beijing, China) and hydroxyectoine (Macklin Biochemical Technology Co., Shanghai, China) at a range of concentrations (0.0, 0.2, 0.4, 0.6, 0.8, and 1.0 g/L), respectively, with absorbance on the y-axis and concentration on the x-axis.
Results
The effect of salinity on hydroxyectoine production
Salinity has been shown to affect the production of ectoine and hydroxyectoine in halophiles (Bursy et al. 2007; Joghee and Jayaraman 2016; Seip et al. 2011; Tao et al. 2016). To examine the influence of salinity on the biosynthesis of hydroxyectoine in H. salifodinae IM328, we measured the hydroxyectoine production of H. salifodinae IM328 grown in media supplemented with 0.2, 0.8, 1.4, 2.0, and 3.0 mol/L NaCl, respectively. The hydroxyectoine production was positively correlated with the salinity. At salinity levels below 1.4 mol/L, almost no hydroxyectoine was detected in H. salifodinae IM328, which achieved a titer of 0.96 g/L hydroxyectoine at a NaCl concentration of 3.0 mol/L. H. salifodinae IM328 also produced ectoine, the titer of which was correlated with the salinity up to 2.0 mol/L NaCl. Ectoine production reached 1.87 g/L in conditions of 2.0 mol/L NaCl (Fig. 2).
Comparative transcriptomic analysis of H. salifodinae IM328 grown under low-salt and high-salt conditions
To uncover how hydroxyectoine biosynthesis responded to the increased salinity and find out the limitations on hydroxyectoine production under low-salt conditions, we performed a comparative transcriptomic analysis of H. salifodinae IM328 grown under low-salt and high-salt conditions. The gene expression profile was significantly altered when H. salifodinae IM328 growing in LB medium containing 0.2 mol/L NaCl was switched to LB medium containing 3.0 mol/L NaCl (Fig. 3a). H. salifodinae IM328 significantly upregulated the expression of hydroxyectoine biosynthesis genes (ectA, ectB, ectC, and ectD), especially the ectD gene encoding ectoine hydroxylase (Fig. 3b). Furthermore, the increased salinity resulted in the decreased expression of genes responsible for the tricarboxylic acid (TCA) cycle, a pivotal process for breaking down organic molecules to generate reducing power (FADH2 and NADH) and energy that organisms need to grow (Fig. 3c). Besides, the KEGG analysis revealed a decrease in the expression of genes directly associated with 2-oxoglutarate-related pathways (Fig. 3d). In addition, GO enrichment analysis of DEGs showed that the expression of genes involved in chemotaxis and locomotion increased significantly under high-salt conditions (Fig. 3e).
Overexpression of ectD for lower-salt hydroxyectoine production
To test whether the increased expression of ectD could improve the production of hydroxyectoine in H. salifodinae IM328 grown under lower-salt conditions, we need to express different amounts of ectD. Therefore, the mCherry gene driven by PUP119, PJ23119, PTac, PJ23111, PJ23110, PJ23100, or PBAD(araC) promoter was incorporated into the derivative plasmid of broad-host-range plasmid pBBR1MCS1 to examine the promoter strength, which was indicated by the relative fluorescence intensity. Among the promoters tested, the PUP119 promoter exhibited the strongest activity (Fig. 4a).
Subsequently, recombinant plasmids expressing ectD gene under the control of the PUP119, PJ23119, PJ23110, and PBAD (araC) promoters were constructed and introduced into H. salifodinae IM328. Given that H. salifodinae IM328 grown with 1.4 mol/L NaCl produced much more ectoine than grown with 0.2 or 0.8 mol/L NaCl, the engineered H. salifodinae strains (HS328-YNP08 to HS328-YNP11) were cultured in MME medium supplemented with 1.4 mol/L NaCl. Though a three-fold higher production of hydroxyectoine was obtained by expressing ectD gene transcribed from the strongest PUP119 promoter, the titer of hydroxyectoine production (0.33 g/L) was still rather low (Fig. 4b).
Prevention of the hydroxyectoine degradation by blocking the hydroxyectoine degradation pathway
To examine if a low-salt environment triggers degradation of ectoine and hydroxyectoine, we added 2 g/L ectoine or hydroxyectoine to H. salifodinae IM328 cultures grown in low-salt conditions (0.2 mol/L NaCl). Initially, the intracellular ectoine or hydroxyectoine gradually increased with time, suggesting that the extracellular ectoine and hydroxyectoine were transported into H. salifodinae IM328 cells. After 48-h incubation with wild-type H. salifodinae IM328 cells, nearly no detectable amounts of ectoine or hydroxyectoine remained (Fig. 5a and b).
Our genome analysis of H. salifodinae IM328 revealed a doeABXCD-eutBC gene cluster that is potentially responsible for the degradation of ectoine/hydroxyectoine (Schulz et al. 2017; Schwibbert et al. 2011). Therefore, improved hydroxyectoine production could benefit from the deletion of ectoine/hydroxyectoine degradative genes. To delete the doeABXCD-eutBC gene cluster, we developed a genetic operating system based on the counterselectable marker sacB gene. Unfortunately, we failed to delete the whole doeABXCD-eutBC gene cluster from the H. salifodinae IM328 genome. As an alternative, we deleted the doeA gene, which is responsible for the first step of ectoine degradation in Halomonas elongata (Schwibbert et al. 2011). After incubating the H. salifodinae ΔdoeA mutant (strain HS328-YNP12) with 2 g/L ectoine or hydroxyectoine for 48 h, 1 g/L of ectoine or hydroxyectoine remained within the cells (Fig. 5c and d). Although the deletion of doeA gene was unable to completely prevent the degradation of ectoine and hydroxyectoine, a substantially reduced degradation rate was achieved compared to the wild-type strain.
Engineering of H. salifodinae IM328 for improved hydroxyectoine production under lower-salt conditions
To improve the production of hydroxyectoine, H. salifodinae IM328 was engineered by deleting the ectoine/hydroxyectoine degradation pathway, enhancing the expression level of ectD and increasing the supply of 2-oxoglutarate (Fig. 6a). Given that glutamate can be easily used to make 2-oxoglutarate and is also a cheaper substrate than aspartate, we used MMD medium that contains glutamate in place of aspartate in MME. H. salifodinae ΔdoeA mutant (strain HS328-YNP12) grown in lower-salt conditions accumulated more ectoine compared to the wild-type H. salifodinae IM328, suggesting the deletion of doeA gene partially prevented ectoine from entering its degradation pathway (Fig. 5a and c). However, the hydroxyectoine production showed no improvement (Fig. 6b).
To examine whether the increased expression of ectD can improve the production of hydroxyectoine, we overexpressed the ectD gene by replacing its native promoter with a strong constitutive PUP119 promoter in strain HS328-YNP12, generating the engineered H. salifodinae ΔdoeA::PUP119-ectD (strain HS328-YNP13). After a 48-h shake flask fermentation under lower-salt conditions, we observed a significant improvement in hydroxyectoine production. The engineered H. salifodinae HS328-YNP13 produced 6.9-fold as much hydroxyectoine (0.84 g/L) as the wild-type strain.
Based on the comparative transcriptomic analysis, the availability of 2-oxoglutarate was another critical factor influencing hydroxyectoine production in H. salifodinae IM328 because it is a co-substrate for the ectoine hydroxylase EctD (Garcia-Estepa et al. 2006). However, the expression level of the gdh gene, which encodes glutamate dehydrogenase GDH that catalyzes the conversion of glutamate to 2-oxoglutarate (Johnson and Westlake 1972), was relatively low in H. salifodinae IM328 grown under low-salt conditions. It was less than half that of the expression level of the rpoD gene encoding the RNA polymerase sigma factor. To provide H. salifodinae strains HS328-YNP12 and HS328-YNP13 with sufficient 2-oxoglutarate, we overexpressed the gdh gene. The H. salifodinae ΔdoeA p-gdh (strain HS328-YNP14) generated by mobilizing the pBBR1-PJ23119-gdh plasmid into strain HS328-YNP12 produced 0.27 g/L hydroxyectoine, 1.45-fold higher than the wild-type strain (Fig. 6b). This result demonstrates that the increased supply of 2-oxoglutarate is able to enhance the biosynthesis of hydroxyectoine. Remarkably, by mobilizing the pBBR1-PJ23119-gdh plasmid into strain HS328-YNP13, the engineered H. salifodinae ΔdoeA::PUP119-ectD p-gdh (strain HS328-YNP15) finally produced 1.02 g/L hydroxyectoine in shake-flask culture, showing a 8.3-fold higher hydroxyectoine production than the wild-type strain (Fig. 6b).
To further test the performance of the engineered strain in continuous fermentation, we carried out the fed-batch fermentation of H. salifodinae HS328-YNP15 strain using a 5-L bioreactor filled with 2-L MMD medium. The ectoine/hydroxyectoine accumulation was positively correlated with the cell growth, with more hydroxyectoine synthesized at the later stage of fermentation. Without any detailed optimization of the fermentation process, the engineered strain HS328-YNP15 achieved a hydroxyectoine titer of 4.9 g/L after incubation for 60 h, representing a good performance for hydroxyectoine production under lower-salt conditions.
Discussion
Increased salinity has been shown to stimulate the production of ectoine and hydroxyectoine in many microorganisms (Bursy et al. 2007; Joghee and Jayaraman 2016; Seip et al. 2011; Tao et al. 2016), indicating the fact of ectoine and hydroxyectoine as compatible solutes for organisms to resist hyperosmotic stress. We found that H. salifodinae IM328 isolated from a soda lake also accumulated ectoine and hydroxyectoine to cope with challenges caused by high salinity (Fig. 2). Although the production of ectoine first increased and then decreased with increasing salt concentration, hydroxyectoine was produced only under higher salinities and had a linear relationship with the salinity (Fig. 2). A similar phenomenon was also observed in moderate halophile Virgibacillus halodenitrificans PDB-F2 (Tao et al. 2016). These observations indicate that hydroxyectoine biosynthesis responds to a much higher salinity compared to ectoine biosynthesis, consistent with the fact that hydroxyectoine has a better protection performance than ectoine (Pastor et al. 2010).
Genes responsible for hydroxyectoine biosynthesis were significantly upregulated, especially the ectD gene encoding ectoine hydroxylase, to enhance the production of hydroxyectoine, supporting the halophilic cells to better withstand the hyperosmotic stress (Fig. 3b). It was found that the enzymatic activity of EctD was not significantly stimulated by increased salinity (Widderich et al. 2014a). Therefore, the increased synthesis level but not the specific activity of EctD were responsible for the improved hydroxyectoine production under high-salt conditions. Besides its role in the TCA cycle and intracellular nitrogen metabolism, 2-oxoglutarate plays a pivotal role in hydroxyectoine production as a substrate for ectoine hydroxylation (Chen et al. 2019; Ma et al. 2022; Reuter et al. 2010). Therefore, there is a competition for 2-oxoglutarate between the TCA cycle and the hydroxylation process. In response to these challenging circumstances, H. salifodinae IM328 primarily utilized 2-oxoglutarate for the synthesis of hydroxyectoine by reducing the metabolic flux into the TCA cycle under high-salt conditions (Fig. 3c). Therefore, the increased expression of ectD and the oversupply of 2-oxoglutarate contributed to the enhanced hydroxyectoine biosynthesis under high salt conditions to a large extent.
The PUP119, PJ23119, PTac, PJ23111, PJ23110, PJ23100, and PBAD (araC) promoters exhibited different activities (Fig. 4a), facilitating the precise regulation of gene expression in H. salifodinae IM328. The increased expression of ectD improved the hydroxyectoine production in conditions of 1.4 mol/L NaCl (Fig. 4b), indicating the importance of high EctD synthesis for enhanced hydroxyectoine biosynthesis under lower-salt conditions. However, the highest titer of hydroxyectoine production in the engineered strains grown with 1.4 mol/L NaCl (0.33 g/L hydroxyectoine) was still lower than that in wild with 3.0 mol/L NaCl (0.96 g/L hydroxyectoine), implying that the produced hydroxyectoine may be directed into the hydroxyectoine degradative pathway for biodegradation under lower-salt conditions.
Our ectoine and hydroxyectoine degradation assays suggest that an ectoine/hydroxyectoine degradation pathway exists in H. salifodinae IM328 to balance the ectoine and hydroxyectoine levels in response to changes in environmental salinities. Besides their excellent performance in hyperosmotic stress protection, the carbon- and nitrogen-rich ectoine and hydroxyectoine have been found as nutrients for halophiles (Vargas et al. 2006). Hence, H. salifodinae IM328 produces more ectoine and hydroxyectoine to combat the hyperosmotic pressure when environmental salinity rises, and utilizes them as nutrients for cell growth when environmental salinity falls. Like Halomonas elongata DSM 2581T, H. salifodinae IM328 has a doeABXCD-eutBC gene cluster that is potentially responsible for the degradation of ectoine/hydroxyectoine (Schwibbert et al. 2011), which is reasonable given that the two strains belong to the same genus Halomonas. In H. elongata DSM 2581T, DoeA has been proved as ectoine hydrolase catalyzing the first step of ectoine degradation (Schwibbert et al. 2011). Here, the deletion of doeA gene reduced the degradation rate of both ectoine and hydroxyectoine (Fig. 5c and d), indicating that DoeA is responsible for the degradation of both compounds in H. salifodinae IM328. Similar conclusion was obtained in another salt-tolerant bacteria Ruegeria pomeroyi, where EutD/EutE (homologue to DoeA and DoeB, respectively) complex has been proved to be able to degrade both ectoine and hydroxyectoine with EutD responsible for the hydrolyzation of the two compounds (Mais et al. 2020). However, the deletion of doeA gene was unable to completely prevent the degradation of ectoine and hydroxyectoine (Fig. 5c and d), implying that other pathways responsible for the degradation of ectoine and hydroxyectoine exist in H. salifodinae IM328.
Overexpression of glutamate dehydrogenase (GDH) that catalyzes the conversion of glutamate to 2-oxoglutarate enhanced the production of hydroxyectoine under lower-salt condition (Fig. 6b), proving that the availability of 2-oxoglutarate was exactly a critical factor influencing hydroxyectoine production in H. salifodinae IM328. Chen et al. reported that the supply of 2-oxoglutarate increased the production of hydroxyectoine in Halomonas salina BCRC 17875 until the 2-oxoglutarate concentration reached to 50 mM, while bacterial growth and hydroxyectoine production were both decreased when over 50 mM 2-oxoglutarate was added (Chen et al. 2019). Ma et al. also observed a similar phenomenon in the engineered E. coli strains that produce hydroxyectoine (Ma et al. 2022). By substituting the 2-oxoglutarate addition with auto-regulating intracellular 2-oxoglutarate pool based on quorum sensing, Ma et al. further improved the production of hydroxyectoine and no ectoine accumulation in the absence of osmotic stress (Ma et al. 2022). These results implied that more flexible 2-oxoglutarate supply might be necessary for efficient lower-salt production of hydroxyectoine in H. salifodinae IM328.
With a series of metabolic optimization, the final obtained H. salifodinae strain HS328-YNP15 (ΔdoeA::PUP119-ectD p-gdh) produced 1.02 g/L hydroxyectoine in shake-flask culture, showing a 8.3-fold higher hydroxyectoine production than the wild-type strain (Fig. 6b). In the fed-batch fermentation, the engineered HS328-YNP15 strain further achieved a hydroxyectoine titer of 4.9 g/L. These results confirm that increased synthesis of EctD is pivotal to enhance the hydroxyectoine biosynthesis under lower-salt conditions. Furthermore, the knockout of doeA gene also contributes to an increased supply of ectoine towards hydroxylation, thereby further improving the production of hydroxyectoine. Moreover, the increased supply of co-substrate 2-oxoglutarate improved the production of hydroxyectoine as well.
Comparative transcriptomic analysis showed that ectA, ectB, and ectC were all upregulated in H. salifodinae IM328 in response to the high-salt stress. Therefore, it is feasible to improve the production of direct substrate ectoine by optimizing the expression of ectA, ectB, and ectC genes in H. salifodinae HS328-YNP15 strain. Besides, even if we overexpressed ectD and gdh, the ectoine precursor still existed at the end of fermentation. Prabhu et al. improved the conversion of ectoine to hydroxyectoine by expressing an ectoine hydroxylase from Streptomyces chrysomallus (ThpD) in H. elongata, though the thpD expression plasmid was unstable without selective pressure (Prabhu et al. 2004). Czech et al. tested the ability of different EctD to convert ectoine into 5-hydroxyectoine in E. coli and found that only EctD from P. stutzeri and Nitrosopumilus maritimus could convert almost all the provided ectoine into hydroxyectoine (Czech et al. 2016). Therefore, an alternative EctD may be required for H. salifodinae HS328-YNP15 strain to further enhance the conversion of ectoine to hydroxyectoine.
Altogether, this study showed that the ectoine/hydroxyectoine degradation, the expression level of ectD, and the supply of 2-oxoglutarate were three major influencing factors for the biosynthesis of hydroxyectoine. The engineered H. salifodinae HS328-YNP15 strain (ΔdoeA::PUP119-ectD p-gdh) with these limiting factors eliminated produced 8.3-fold more hydroxyectoine than the wild-type strain when they were grown under lower-salt but alkaline conditions, and it finally achieved a hydroxyectoine titer of 4.9 g/L in a fed-batch fermentation. In comparison to the commonly used process employed by non-halophilic chassis cells such as E. coli and C. glutamicum, this work demonstrates advantages for the next-generation of open unsterile fermentation, which can effectively save energy and fresh water. When compared with the traditional “bacterial milking” process for hydroxyectoine production by halophiles like H. elongata, this work significantly mitigates the challenges associated with high-salt wastewater treatment. Therefore, the strategy employed in this study can be used for further developments on the economic viability of hydroxyectoine and other value-added chemical production from the engineered halophiles.
Data availability
The data that support the findings of this study are available on request from the corresponding author. The transcriptome sequencing data have been deposited in the NCBI Short Read Archive (SRA) under accession number PRJNA1018600.
References
Bethlehem L, Moritz KD (2020) Boosting Escherichia coli’s heterologous production rate of ectoines by exploiting the non-halophilic gene cluster from Acidiphilium cryptum. Extremophiles 24(5):733–747. https://doi.org/10.1007/s00792-020-01188-8
Bilstein A, Heinrich A, Rybachuk A, Moesges R (2021) Ectoine in the treatment of irritations and inflammations of the eye surface. Biomed Res Int 2021:8885032. https://doi.org/10.1155/2021/8885032
Brown AD (1976) Microbial water stress. Bacteriol Rev 40(4):803–846. https://doi.org/10.1128/mmbr.40.4.803-846.1976
Bursy J, Pierik AJ, Pica N, Bremer E (2007) Osmotically induced synthesis of the compatible solute hydroxyectoine is mediated by an evolutionarily conserved ectoine hydroxylase. J Biol Chem 282(43):31147–31155. https://doi.org/10.1074/jbc.M704023200
Cantera S, Di Benedetto F, Tumulero BF, Sousa DZ (2023) Microbial conversion of carbon dioxide and hydrogen into the fine chemicals hydroxyectoine and ectoine. Bioresour Technol 374:128753. https://doi.org/10.1016/j.biortech.2023.128753
Chen W-C, Hsu C-C, Wang L-F, Lan JC-W, Chang Y-K, Wei Y-H (2019) Exploring useful fermentation strategies for the production of hydroxyectoine with a halophilic strain, Halomonas salina BCRC 17875. J Biosci Bioeng 128(3):332–336. https://doi.org/10.1016/j.jbiosc.2019.02.015
Czech L, Stoeveken N, Bremer E (2016) EctD-mediated biotransformation of the chemical chaperone ectoine into hydroxyectoine and its mechanosensitive channel-independent excretion. Microb Cell Fact 15:126. https://doi.org/10.1186/s12934-016-0525-4
Eilert E, Kranz A, Hollenberg CP, Piontek M, Suckow M (2013) Synthesis and release of the bacterial compatible solute 5-hydroxyectoine in Hansenula Polymorpha. J Biotechnol 167(2):85–93. https://doi.org/10.1016/j.jbiotec.2013.02.005
Feng X, Kazama D, He S, Nakayama H, Hayashi T, Tokunaga T, Sato K, Kobayashi H (2023) Enrichment of halotolerant hydrogen-oxidizing bacteria and production of high-value-added chemical hydroxyectoine using a hybrid biological-inorganic system. Front Microbiol 14:1254451. https://doi.org/10.3389/fmicb.2023.1254451
Fu XZ, Tan D, Aibaidula G, Wu Q, Chen JC, Chen GQ (2014) Development of Halomonas TD01 as a host for open production of chemicals. Metab Eng 23:78–91. https://doi.org/10.1016/j.ymben.2014.02.006
Garcia-Estepa R, Argandona M, Reina-Bueno M, Capote N, Iglesias-Guerra F, Nieto JJ, Vargas C (2006) The ectD gene, which is involved in the synthesis of the compatible solute hydroxyectoine, is essential for thermoprotection of the halophilic bacterium Chromohalobacter salexigens. J Bacteriol 188(11):3774–3784. https://doi.org/10.1128/jb.00136-06
Graf R, Anzali S, Buenger J, Pfluecker F, Driller H (2008) The multifunctional role of ectoine as a natural cell protectant. Clin Dermatol 26(4):326–333. https://doi.org/10.1016/j.clindermatol.2008.01.002
Inbar L, Lapidot A (1988) The structure and biosynthesis of new tetrahydropyrimidine derivatives in actinomycin D producer Streptomyces parvulus. Use of 13C- and 15N-labeled L-glutamate and 13C and 15N NMR spectroscopy. J Biol Chem 263(31):16014–16022
Jiang M, Zeng Y, Cui L, Wang M, Zheng Y (2022) A red fluorescent protein reporter system developed for measuring gene expression in photosynthetic bacteria under anaerobic conditions. Microorganisms 10(2):201. https://doi.org/10.3390/microorganisms10020201
Joghee NN, Jayaraman G (2016) Biochemical changes induced by salt stress in halotolerant bacterial isolates are media dependent as well as species specific. Prep Biochem Biotechnol 46(1):8–14. https://doi.org/10.1080/10826068.2014.970689
Johnson WM, Westlake DW (1972) Purification and characterization of glutamicacid dehydrogenase and alpha-ketoglutaric acid reductase from Peptococcus aerogenes. Can J Microbiol 18(6):881–892. https://doi.org/10.1139/m72-136
Jungmann L, Hoffmann SL, Lang C, De Agazio R, Becker J, Kohlstedt M, Wittmann C (2022) High-efficiency production of 5-hydroxyectoine using metabolically engineered Corynebacterium glutamicum. Microb Cell Fact 21(1):274. https://doi.org/10.1186/s12934-022-02003-z
Kanapathipillai M, Lentzen G, Sierks M, Park CB (2005) Ectoine and hydroxyectoine inhibit aggregation and neurotoxicity of Alzheimer’s beta-amyloid. FEBS Lett 579(21):4775–4780. https://doi.org/10.1016/j.febslet.2005.07.057
Kanehisa M, Goto S, Kawashima S, Okuno Y, Hattori M (2004) The KEGG resource for deciphering the genome. Nucleic Acids Res 32:D277–D280. https://doi.org/10.1093/nar/gkh063
Kempf B, Bremer E (1998) Uptake and synthesis of compatible solutes as microbial stress responses to high-osmolality environments. Arch Microbiol 170(5):319–330. https://doi.org/10.1007/s002030050649
Kunte HJ, Lentzen G, Galinski EA (2014) Industrial production of the cell protectant ectoine: protection mechanisms, processes, and products. Curr Biotechnol 3(1):10–25. https://doi.org/10.2174/22115501113026660037
Liang F, Wei S, Xue L, Yan S (2024) Adopting green absorbent for CO2 capture and agricultural utilization: Biogas slurry and biomass ash case. Green Carbon doi. https://doi.org/10.1016/j.greenca.2024.03.001
Lippert K, Galinski EA (1992) Enzyme stabilization by ectoine-type compatible solutes - protection against heating, freezing and drying. Appl Microbiol Biotechnol 37(1):61–65. https://doi.org/10.1007/BF00174204
Liu Y, Xin ZZ, Song J, Zhu XY, Liu QN, Zhang DZ, Tang BP, Zhou CL, Dai LS (2018) Transcriptome analysis reveals potential antioxidant defense mechanisms in Antheraea Pernyi in response to zinc stress. J Agric Food Chem 66(30):8132–8141. https://doi.org/10.1021/acs.jafc.8b01645
Liu M, Liu H, Shi M, Jiang M, Li L, Zheng Y (2021) Microbial production of ectoine and hydroxyectoine as high-value chemicals. Microb Cell Fact 20(1):76. https://doi.org/10.1186/s12934-021-01567-6
Liu Z, Shi S, Ji Y, Wang K, Tan T, Nielsen J (2023) Opportunities of CO2-based biorefineries for production of fuels and chemicals. Green Carbon 1(1):75–84. https://doi.org/10.1016/j.greenca.2023.09.002
Louis P, Galinski EA (1997) Characterization of genes for the biosynthesis of the compatible solute ectoine from Marinococcus halophilus and osmoregulated expression in Escherichia coli. Microbiology 143(4):1141–1149. https://doi.org/10.1099/00221287-143-4-1141
Ma H, Zhao Y, Huang W, Zhang L, Wu F, Ye J, Chen GQ (2020) Rational flux-tuning of Halomonas bluephagenesis for co-production of bioplastic PHB and ectoine. Nat Commun 11(1):3313. https://doi.org/10.1038/s41467-020-17223-3
Ma Q, Xia L, Wu H, Zhuo M, Yang M, Zhang Y, Tan M, Zhao K, Sun Q, Xu Q, Chen N, Xie X (2022) Metabolic engineering of Escherichia coli for efficient osmotic stress-free production of compatible solute hydroxyectoine. Biotechnol Bioeng 119(1):89–101. https://doi.org/10.1002/bit.27952
Mais C-N, Hermann L, Altegoer F, Seubert A, Richter AA, Wernersbach I, Czech L, Bremer E, Bange G (2020) Degradation of the microbial stress protectants and chemical chaperones ectoine and hydroxyectoine by a bacterial hydrolase-deacetylase complex. J Biol Chem 295(27):9087–9104. https://doi.org/10.1074/jbc.RA120.012722
Mu T, Yang M, Zhao J, Sharshar MM, Tian J, Xing J (2017) Improvement of desulfurizing activity of haloalkaliphilic Thialkalivibrio versutus SOB306 with the expression of Vitreoscilla hemoglobin gene. Biotechnol Lett 39(3):447–452. https://doi.org/10.1007/s10529-016-2266-1
Ono H, Sawada K, Khunajakr N, Tao T, Yamamoto M, Hiramoto M, Shinmyo A, Takano M, Murooka Y (1999) Characterization of biosynthetic enzymes for ectoine as a compatible solute in a moderately halophilic eubacterium, Halomonas elongata. J Bacteriol 181(1):91–99. https://doi.org/10.1128/jb.181.1.91-99.1999
Pastor JM, Salvador M, Argandona M, Bernal V, Reina-Bueno M, Csonka LN, Iborra JL, Vargas C, Nieto JJ, Canovas M (2010) Ectoines in cell stress protection: uses and biotechnological production. Biotechnol Adv 28(6):782–801. https://doi.org/10.1016/j.biotechadv.2010.06.005
Prabhu J, Schauwecker F, Grammel N, Keller U, Bernhard M (2004) Functional expression of the ectoine hydroxylase gene (thpD) from Streptomyces chrysomallus in Halomonas elongata. Appl Environ Microbiol 70(5):3130–3132. https://doi.org/10.1128/aem.70.5.3130-3132.2004
Quandt J, Hynes MF (1993) Versatile suicide vectors which allow direct selection for gene replacement in Gram-negative bacteria. Gene 127(1):15–21. https://doi.org/10.1016/0378-1119(93)90611-6
Reuter K, Pittelkow M, Bursy J, Heine A, Craan T, Bremer E (2010) Synthesis of 5-hydroxyectoine from ectoine: crystal structure of the non-heme iron(II) and 2-oxoglutarate-dependent dioxygenase EctD. PLoS ONE 5(5):e10647. https://doi.org/10.1371/journal.pone.0010647
Rey FE, Heiniger EK, Harwood CS (2007) Redirection of metabolism for biological hydrogen production. Appl Environ Microbiol 73(5):1665–1671. https://doi.org/10.1128/aem.02565-06
Rodriguez-Moya J, Argandona M, Iglesias-Guerra F, Nieto JJ, Vargas C (2013) Temperature- and salinity-decoupled overproduction of hydroxyectoine by Chromohalobacter salexigens. Appl Environ Microbiol 79(3):1018–1023. https://doi.org/10.1128/aem.02774-12
Salapatek A, Bates M, Bilstein A, Patel D (2011) Ectoin®, a novel, non-drug, extremophile-based device, relieves allergic rhinoconjunctivitis symptoms in patients in an environmental exposure chamber model. J Allergy Clin Immunol 127(2):AB202. https://doi.org/10.1016/j.jaci.2010.12.803
Sauer T, Galinski EA (1998) Bacterial milking: a novel bioprocess for production of compatible solutes. Biotechnol Bioeng 57(3):306–313. https://doi.org/10.1002/(SICI)1097-0290(19980205)57:3<306::AID-BIT7>3.3.CO;2-T
Schulz A, Stoeveken N, Binzen IM, Hoffmann T, Heider J, Bremer E (2017) Feeding on compatible solutes: a substrate-induced pathway for uptake and catabolism of ectoines and its genetic control by EnuR. Environ Microbiol 19(3):926–946. https://doi.org/10.1111/1462-2920.13414
Schwibbert K, Marin-Sanguino A, Bagyan I, Heidrich G, Lentzen G, Seitz H, Rampp M, Schuster SC, Klenk HP, Pfeiffer F, Oesterhelt D, Kunte HJ (2011) A blueprint of ectoine metabolism from the genome of the industrial producer Halomonas elongata DSM 2581T. Environ Microbiol 13(8):1973–1994. https://doi.org/10.1111/j.1462-2920.2010.02336.x
Seip B, Galinski EA, Kurz M (2011) Natural and engineered hydroxyectoine production based on the Pseudomonas stutzeri ectABCD-ask gene cluster. Appl Environ Microbiol 77(4):1368–1374. https://doi.org/10.1128/aem.02124-10
Simon R, Priefer U, Pühler A (1983) A broad host range mobilization system for in vivo genetic engineering: transposon mutagenesis in Gram negative bacteria. Bio-Technology 1(9):784–791. https://doi.org/10.1038/nbt1183-784
Stoeveken N, Pittelkow M, Sinner T, Jensen RA, Heider J, Bremer E (2011) A specialized aspartokinase enhances the biosynthesis of the osmoprotectants ectoine and hydroxyectoine in Pseudomonas stutzeri A1501. J Bacteriol 193(17):4456–4468. https://doi.org/10.1128/jb.00345-11
Tanne C, Golovina EA, Hoekstra FA, Meffert A, Galinski EA (2014) Glass-forming property of hydroxyectoine is the cause of its superior function as a desiccation protectant. Front Microbiol 5:150. https://doi.org/10.3389/fmicb.2014.00150
Tao P, Li H, Yu Y, Gu J, Liu Y (2016) Ectoine and 5-hydroxyectoine accumulation in the halophile Virgibacillus halodenitrificans PDB-F2 in response to salt stress. Appl Microbiol Biotechnol 100(15):6779–6789. https://doi.org/10.1007/s00253-016-7549-x
Vargas C, Jebbar M, Carrasco R, Blanco C, Calderon MI, Iglesias-Guerra F, Nieto JJ (2006) Ectoines as compatible solutes and carbon and energy sources for the halophilic bacterium Chromohalobacter salexigens. J Appl Microbiol 100(1):98–107. https://doi.org/10.1111/j.1365-2672.2005.02757.x
Widderich N, Höppner A, Pittelkow M, Heider J, Smits SHJ, Bremer E (2014a) Biochemical properties of ectoine hydroxylases from extremophiles and their wider taxonomic distribution among microorganisms. PLoS ONE 9(4):e93809. https://doi.org/10.1371/journal.pone.0093809
Widderich N, Pittelkow M, Höppner A, Mulnaes D, Buckel W, Gohlke H, Smits SH, Bremer E (2014b) Molecular dynamics simulations and structure-guided mutagenesis provide insight into the architecture of the catalytic core of the ectoine hydroxylase. J Mol Biol 426(3):586–600. https://doi.org/10.1016/j.jmb.2013.10.028
Xia Y, Li K, Li J, Wang T, Gu L, Xun L (2019) T5 exonuclease-dependent assembly offers a low-cost method for efficient cloning and site-directed mutagenesis. Nucleic Acids Res 47(3):e15. https://doi.org/10.1093/nar/gky1169
Zhang M, Xue Q, Zhang S, Zhou H, Xu T, Zhou J, Zheng Y, Li M, Kumar S, Zhao D, Xiang H (2021) Development of whole-cell catalyst system for sulfide biotreatment based on the engineered haloalkaliphilic bacterium. AMB Express 11(1):142. https://doi.org/10.1186/s13568-021-01302-9
Funding
This study was funded by the National Key R&D Program of China (2020YFA0906800, 2022YFC2105300), the Strategic Priority Research Program of the Chinese Academy of Sciences (XDA28030201), and the National Natural Science Foundation of China (92351302, 91851102, 32070034, and 32270056).
Author information
Authors and Affiliations
Contributions
N.Y. and Y.Z. (Yanning Zheng) conceived and designed the research. N.Y., M.L., and M.J. constructed the plasmids. N.Y., J.H., Y.Z. (Yan Zeng), and Y.L. performed the other experiments. N.Y., J.H., H.X., and Y.Z. (Yanning Zheng) analyzed the data. All authors discussed the results. N.Y. and M.L. wrote the manuscript. H.X. and Y.Z. (Yanning Zheng) revised and edited the manuscript. All authors read and approved the final manuscript.
Corresponding author
Ethics declarations
Ethical approval
This article does not contain any studies with human participants or animals performed by any of the authors.
Conflict of interest
The authors declare no competing interests.
Additional information
Publisher’s Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary information
Below is the link to the electronic supplementary material.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Yang, N., Liu, M., Han, J. et al. Rational engineering of Halomonas salifodinae to enhance hydroxyectoine production under lower-salt conditions. Appl Microbiol Biotechnol 108, 353 (2024). https://doi.org/10.1007/s00253-024-13197-0
Received:
Revised:
Accepted:
Published:
DOI: https://doi.org/10.1007/s00253-024-13197-0