Abstract
Cerium oxide nanoparticles were continuously precipitated from a solution of cerium(III) nitrate and ammonium hydroxide using a static microchannel T-mixer. T-mixer synthesis results were compared with synthesis results from batch precipitation. Findings show that the method of mixing is important in the ceria precipitation process. Uniform porous film structures and nanorods were produced when the particle chemistry was synthesized using T-mixing followed by spin coating. Batch mixing, when using higher NH4OH feed concentrations followed by spin coating, was characterized by the heavy agglomeration of nanoparticles. Similar, high aspect ratio nanorods were produced when feed conditions in both batch mixing and T-mixing were identical demonstrating that the momentum effects of continuous microchannel T-mixing did not impact the synthesis process. In addition, it was found that the micromixing approach reduced the exposure of the Ce(OH)3 precipitates to oxygen, yielding hydroxide precipitates in place of CeO2 precipitates. The key advantage of the micro-scale T-mixing approach is higher throughput which is important for the scaling of ceria nanoparticle production.
Similar content being viewed by others
References
Tsunekawa S, Kasuya A (2000) Blue shift in ultraviolet absorption spectra of monodisperse CeO nanoparticles. J Appl Phys 87:1318
Trovarelli A, de Leitenburg C, Boaro M, Dolcetti G (1999) The utilization of ceria in industrial catalysis. Catal Today 50:353–367
Spanier JE, Robinson RD, Zhang F, Chan SW, Herman IP (2001) Size-dependent properties of CeO2−y nanoparticles as studied by Raman scattering. Phys Rev B 64:245407
Tsunekawa S, Sahara R, Kawazoe Y, Kasuya A (2000) Origin of the blue shift in ultraviolet absorption spectra of nanocrystalline CeO2−x particles. Mater Trans JIM 41:1104–1107
Bekyarova E, Fornasiero P, Kašpar J, Graziani M (1998) CO oxidation on Pd/CeO2–ZrO2 catalysts. Catal Today 45:179–183
Yahiro H, Baba Y, Eguchi K, Arai H (1988) High temperature fuel cell with Ceria-Yttria solid electrolyte. J Electrochem Soc 135:2077–2080
Li M, Zhang R, Zhang H, Feng W, Liu X (2010) Synthesis, structural and magnetic properties of CeO2 nanoparticles. Micro & Nano Letters 5:95
Izu N, Shin W, Murayama N, Kanzaki S (2002) Resistive oxygen gas sensors based on CeO2 fine powder prepared using mist pyrolysis. Sensor Actuator B Chem 87:95–98
Hirta Y, Harada A, Wang X (2005) Wet forming and sintering behavior of nanometer-sized ceria powder. Ceram Int 31:1007–1013
Chu X, Chung W-I, Schmidt LD (1993) Sintering of sol–gel prepared submicrometer particles studied by transmission electron microscopy. J Am Ceram Soc 76:2115–2118
Makishima A, Kubo H, Wada K, Kitami Y, Shimohira T (1986) Yellow coatings produced on glasses and aluminum by the sol–gel process. J Am Ceram Soc 69:C–127–C–129
Hakuta Y, Onai S, Terayama H, Adschiri T, Arai K (1998) Production of ultra-fine ceria particles by hydrothermal synthesis under supercritical conditions. J Mater Sci Lett 17:1211–1213
Uekawa N, Ueta M, Wu YJ, Kakegawa K (2004) Characterization of CeO2 fine particles prepared by the homogeneous precipitation method with a mixed solution of ethylene glycol and polyethylene glycol. J Mater Res 19:1087–1092
Dong X, Hong G, Yu D, Yu D (1997) Synthesis and properties of cerium oxide nanometer powders by pyrolysis of amorphous citrate. J Mater Sci Technol 13:113–116
Masui T, Fujiwara K, Machida K-I, Adachi G-Y, Sakata T, Mori H (1997) Characterization of cerium(IV) oxide ultrafine particles prepared using reversed micelles. Chem Mater 9:2197–2204
Hsu WP, Ronnquist L, Matijevic E (1988) Preparation and properties of monodispersed colloidal particles of lanthanide compounds. 2. Cerium (IV). Langmuir 4:31–37
Chen P-L, Chen IW (1993) Reactive cerium(IV) oxide powders by the homogeneous precipitation method. J Am Ceram Soc 76:1577–1583
Liu K, Zhong M (2010) Synthesis of monodispersed nanosized CeO2 by hydrolysis of the cerium complex precursor. J Rare Earths 28:680–683
Zhou XD, Huebner W, Anderson HU (2002) Room-temperature homogeneous nucleation synthesis and thermal stability of nanometer single crystal CeO2. Appl Phys Lett 80:3814
Hessel V, Löwe H, Schönfeld F (2005) Micromixers—a review on passive and active mixing principles. Chem Eng Sci 60:2479–2501
Nguyen NT, Wu Z (2005) Micromixers—a review. J Micromech Microeng 15:R1
Schwarzer HC, Peukert W (2004) Tailoring particle size through nanoparticle precipitation. Chem Eng Commun 191:580–606
Chang CH, Liu SH, Tennico Y, Rundel JT, Remcho VT, Blackwell E, Tseng CH and Paul BK (2005) Progress towards chip-based high-throughput dendrimer synthesis. In: International Conference on Microreaction Technology. Atlanta, Georgia, pp. 3011–3018
Joanicot M, Ajdari A (2005) Droplet control for microfluidics. Science 309:887
Nakamura H, Yamaguchi Y, Miyazaki M, Maeda H, Uehara M, Mulvaney P (2002) Preparation of CdSe nanocrystals in a micro-flow-reactor. Chem Commun 23:2844–2845
Chan EM, Mathies RA, Alivisatos AP (2003) Size-controlled growth of CdSe nanocrystals in microfluidic reactors. Nano Lett 3:199–201
Yen BKH, Stott NE, Jensen KF, Bawendi MG (2003) A continuous-flow microcapillary reactor for the preparation of a size series of CdSe nanocrystals. Adv Mater 15:1858–1862
Krishnadasan S, Tovilla J, Vilar R (2004) On-line analysis of CdSe nanoparticle formation in a continuous flow chip-based microreactor. J Mater Chem 14:2655–2660
Ehrfeld W, Hessel V, Löwe H (2000) Microreactors: new technology for modern chemistry. Wiley, Weinhem
Tseng C, Paul B (2007) Comparison of batch mixing and micromixing approaches in the synthesis and deposition of ceria nanoparticles. Trans NAMRI 35
Chang H, Chen H (2005) Morphological evolution for CeO2 nanoparticles synthesized by precipitation technique. J Cryst Growth 283:457–468
Yamashita M, Kameyama K, Yabe S, Yoshida S, Fujishiro Y, Kawai T, Sato T (2002) Synthesis and microstructure of calcia doped ceria as UV filters. J Mater Sci 37:683–687
Wang ZL, Feng X (2003) Polyhedral shapes of CeO2 nanoparticles. J Phys Chem B 107:13563–13566
Tang C, Bando Y, Liu B, Golberg D (2005) Cerium oxide nanotubes prepared from cerium hydroxide nanotubes. Adv Mater 17:3005–3009
Mai H-X, Sun L-D, Zhang Y-W, Si R, Feng W, Zhang H-P, Liu H-C, Yan C-H (2005) Shape-selective synthesis and oxygen storage behavior of ceria nanopolyhedra, nanorods, and nanocubes. J Phys Chem B 109:24380–24385
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Tseng, C.H.T., Paul, B.K., Chang, CH. et al. Continuous precipitation of ceria nanoparticles from a continuous flow micromixer. Int J Adv Manuf Technol 64, 579–586 (2013). https://doi.org/10.1007/s00170-012-4428-1
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00170-012-4428-1