Abstract
The influence of several polymeric additives on specific glucose uptake rate of flocs of a S. cerevisiae strain — S. cerevisiae NRRLY 265 was studied. A special continuous membrane microreactor was used to measure glucose uptake on the presence of calcium and of the tested additives — two cationic polymers — bis(polyoxyethylene-bis(amine)) 20,000 and BPA 1,000 and one anionic polymer — Magna Floc LT25.
An increase on glucose uptake rate was always observed when comparing with calcium bound flocs. For bis(polyoxyethylene-bis(amine)) 20,000 the increase was only 19% but for BPA 1,000 a value of more than 50% was observed. For Magna Floc LT25 a two fold increase was measured.
The determination of floc size and porosity in the presence of the additives indicated that, on the basis of these parameters, it was not possible to explain the observed glucose uptake rates. The floc porosites in additive bound flocs were similar and 10% larger than for calcium bound flocs and glucose uptake rate was larger for the largest flocs — Magna Floc LT25 bound flocs were the largest followed by BPA 1,000, bis(polyoxyethylene-bis(amine)) 20,000 and calcium bound flocs. These values disagree with what should be expected in diffusion controlled processes.
The calculation of intercellular floc distance indicated that polymeric additives act on the reduction of diffusional limitations by increasing the available flux area for glucose inside the flocs. By analysing different kinds of packings, it was also observed that the packing arrangement for yeast cells in flocs is close to the cubic packing. The simulation of this arrangement for the obtained floc sizes confirmed that the 10% increase in floc porosity is sufficient to explain the increase in the available flux area.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Greenshields, R. N.; Smith, E. L.: Tower fermentation systems and their applications. The Chemical Engineer. May (1971) 182–190
Prince, I. G.; Barford, J. P.: Induced flocculation of yeast for use in the tower fermentor. Biotechnology Letters 4 (1982) 621–626
Comberbach, D. M.; Bu'Lock, J. D.: Continuous ethanol production on the gas lift tower fermentor. Biotechnology Letters 6 (1984) 129–134
Netto, C. B.; Destruhaut, A.; Goma, G.: Ethanol fermentation by flocculating yeast: Performance and stability dependence on a critical fermentation rate. Biotechnology Letters 7 (1985) 335–360
Limtomg, S. A.; Nakata, M.; Funahashi, H.; Yoshida, T.; Siki, T.; Kumnuanta, J.; Taguchi, H.: Contiuous ethanol production by a concentrated culture of flocculating yeast. J. Ferm. Technol. 62 (1984) 55–62
Admassu, W.; Korus, R. A.; Heimsch, R. C.: Ethanol fermentation with a flocculating yeast. The Chem. Eng. J. 31 (1985) B1-B8
Baratti, J.; Varma, R.; Bu'Lock, J. D.: High productivity ethanol fermentation on mineral medium using a flocculating strain of Zymomonas mobilis. Biotechnology Letters 8 (1986) 175–180
Teixeira, J. A.; Mota, M.; Goma, G.: Continuous ethanol production by a flocculating strain of Kluyveromyces marxianus: Bioreactor performance. Bioprocess Eng. 5 (1990) 123–127
Atkinson, P.: Biochemical reactors, pp. 115–151. London: Pion Limited 1974.
Bailey, J. E.; Ollis, D. F.: Biochemical engineering fundamentals, pp. 242–354. New York: McGraw-Hill 1977
Logan, B. E.; Hunt, J. R.: Bioflocculation as a microbial response to substrate limitations. Biotechnol. and Bioeng. 31 (1988) 91–101
Libicki, S. B.; Salmon, P. R.; Robertson, C. R.: The effective diffusive permeability of a non reacting solute in microbial cell aggregates. Biotechnol. and Bioeng. 32 (1988) 68–85
Teixeira, J. A.; Mota, M.: Experimental assessment of internal diffusion limitations in yeast flocs. The Chem. Eng. J. 43 (1990) B13-B17
Eddy, A. A.; Phill, D.: Composite nature of the flocculation process of top and bottom strains of Saccharomyces. J. Inst. Brewing 64 (1958) 143–147
Stewart, G. G.: Yeast flocculation-practical implications and experimental findings. The Brewers Digest March (1975) 42–56
Amri, M. A.; Bonaly, R.; Duteurtre, B.; Moll, M.: Interrelation between Ca2+ and K+ ions in the flocculation of two brewers yeast strains. European J. Appl. Microbiol. Biotechnol. 7 (1979) 235–240
Miki, B. L. A.; Poon, N. H.; James, A. P.; Seligy, V. L.: Flocculation in Saccharomyces cerevisiae: mechanism of cell-cell interactions. Current Develop. in yeast research (1981) 193–198
Stewart, G. G.; Russel, I.: One hundred years of yeast research and development in the brewing industry. J. Inst. Brew. 92 (1986) 537–558
Kim, C. W.; Kim, S. K.; Rha, C.; Robinson, E.: Removal of cell and cell debris by electrostatic adsorption of positively charged polymeric particles. In: Attia, Y. A. (Ed.): Flocculation in biotechnology and separation systems, pp. 429–439. Amsterdam: Elsevier Science Publishers B. V. 1987
Chaplin, M. F.: In: Chaplin, M. F.; Kennedy, J. F. (Ed.): Carbohydrate analysis: a practical approach, pp. 5. Oxford: IRL Press 1975
Mota, M.: Inhibition et fermentation alcoolique: quelques concepts non conventionels. These de doctorat. Toulouse 1985
Uribelarrea, J. L.; Pacaud, S.; Goma, G.: New method for measuring the cell wall content by thermogravimetry. Biotechnology Letters 7 (2) (1985) 75–80
Netto, C.: Fermentation alcoolique par des levures flocculées: Etude des facteurs limitants et potentialités technologiques. These de doctorat. Toulouse 1984
Cumberland, D. J.; Crawford, R. J.: The packing of particles, pp. 14–39. Amsterdam: Elsevier 1987
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Lima, N., Teixeira, J.A. & Mota, M. Enhancement of metabolic rates of yeast flocculent cells through the use of polymeric additives. Bioprocess Engineering 7, 343–348 (1992). https://doi.org/10.1007/BF00369489
Received:
Issue Date:
DOI: https://doi.org/10.1007/BF00369489