Abstract
Background
The modification of glucose import capacity is an engineering strategy that has been shown to improve the characteristics of Escherichia coli as a microbial factory. A reduction in glucose import capacity can have a positive effect on production strain performance, however, this is not always the case. In this study, E. coli W3110 and a group of four isogenic derivative strains, harboring single or multiple deletions of genes encoding phosphoenolpyruvate:sugar phosphotransferase system (PTS)-dependent transporters as well as non-PTS transporters were characterized by determining their transcriptomic response to reduced glucose import capacity.
Results
These strains were grown in bioreactors with M9 mineral salts medium containing 20 g/L of glucose, where they displayed specific growth rates ranging from 0.67 to 0.27 h−1, and specific glucose consumption rates (qs) ranging from 1.78 to 0.37 g/g h. RNA-seq analysis revealed a transcriptional response consistent with carbon source limitation among all the mutant strains, involving functions related to transport and metabolism of alternate carbon sources and characterized by a decrease in genes encoding glycolytic enzymes and an increase in gluconeogenic functions. A total of 107 and 185 genes displayed positive and negative correlations with qs, respectively. Functions displaying positive correlation included energy generation, amino acid biosynthesis, and sugar import.
Conclusion
Changes in gene expression of E. coli strains with impaired glucose import capacity could be correlated with qs values and this allowed an inference of the physiological state of each mutant. In strains with lower qs values, a gene expression pattern is consistent with energy limitation and entry into the stationary phase. This physiological state could explain why these strains display a lower capacity to produce recombinant protein, even when they show very low rates of acetate production. The comparison of the transcriptomes of the engineered strains employed as microbial factories is an effective approach for identifying favorable phenotypes with the potential to improve the synthesis of biotechnological products.
Similar content being viewed by others
Introduction
The bacterium Escherichia coli is widely used both in academia and industry. The culture media for growing this organism usually contains glucose, since this carbohydrate is relatively inexpensive, and is the preferred carbon and energy source of E. coli [1]. When E. coli grows under conditions where both glucose and oxygen are non-limiting, it displays high specific glucose consumption (qs) and growth rates (µ) with concomitant acetic acid synthesis. Acetic acid production has been a widely discussed topic by many authors. The production of acetic acid can be explained as an unbalance between the glucose uptake flux and the rate of conversion of the molecules derived from this sugar to energy and the metabolic products diverting acetyl coenzyme A (acetyl-CoA) from the tricarboxylic acid cycle (TCA) towards acetate. Acetate production is not dependent on oxygen availability, so it can occur under aerobic conditions. At low growth rates, glucose can be completely oxidized to carbon dioxide. However, when the growth rate increases, at certain threshold overflow metabolism is observed. This phenomenon coincides with the highest rate of oxygen consumption, above this value, overflow metabolism is evident. In summary, acetic acid production has been related to the saturation of TCA and respiratory chain capacity, as well as insufficient coenzymes replenishment [2,3,4,5,6]. Since acetate is a toxic compound, its accumulation has a negative effect on E. coli growth and productivity [7, 8]. Various approaches have been explored to try to reduce or eliminate acetate accumulation in cultures with E. coli. These include adjustments to the fermentation process, as well as strain genetic modifications. The use of various glucose feeding strategies for limiting the accumulation of acetate in the culture medium is an effective strategy to reduce overflow metabolism. Another successful approach is based on genetic modifications that eliminate acetate synthesis pathways or reduce glucose import capacity by deleting genes that encode transporter proteins. These strategies have been proven to be successful in increasing the production of chemicals, plasmid DNA vaccines, and recombinant proteins [9,10,11,12].
Glucose transport and phosphorylation in E. coli are dependent on the phosphoenolpyruvate:sugar phosphotransferase system (PTS) [13]. Protein IICBGlc, encoded by gene ptsG, is the glucose-specific PTS component. Under glucose limitation conditions, a high-affinity glucose uptake pathway composed of the outer membrane protein LamB and the MglABC transport system is induced [14]. It is also known that the galactose:H + symporter GalP can import glucose which is afterward phosphorylated by the glucokinase enzyme in an ATP-dependent reaction [15]. It has also been reported that PTS components, such as IICDMan which is normally involved in mannose import, can replace the function of IICBGlc for glucose import [11, 16, 17].
In E. coli, internal metabolic fluxes, as well as the phosphorylation state of PTS proteins, allows this organism to sense if glucose is abundant or limited in the culture medium and if other carbon sources are present. Carbon catabolite repression (CRR) can be defined as the hierarchical consumption of carbon sources that allow the highest growth rate [18,19,20]. As we have mentioned before, glucose is the preferred carbon and energy source of E. coli. This carbohydrate is simultaneously transported and phosphorylated by the glucose-specific PTS components. One of these components is the protein PTS EIIAGlc which transfers a high-energy phosphate group from protein HPr to the glucose-specific component IICBGlc. Protein EIIAGlc is non-phosphorylated when glucose is actively transported and metabolized by the cell and in this state, it is available to bind to other non-PTS permeases inhibiting the uptake of alternate carbon sources such as lactose. On the contrary, when glucose is absent in the medium, EIIAGlc is mainly phosphorylated, and in this state, it is available to bind to the adenylate cyclase enzyme (CyaA), stimulating its activity, thus increasing the intracellular concentration of cyclic AMP (cAMP)[1, 18, 19]. An increased amount of cAMP and its binding to the cAMP receptor protein (CRP) leads to the expression of catabolite-repressed genes, enabling the utilization of alternative carbon sources [1, 18, 19]. In another example of cellular response to glucose availability, it has recently been reported that hydrogenase 4 subunits HyfBDF can sense two different glucose concentrations (2 or 8 g/L). Depending on the amount of glucose in the medium, hydrogenase 4 can regulate the H + /K + fluxes to maintain proton motive force generation [21].
The physiological response of E. coli to nutrient limitation has been studied extensively [14, 22,23,24,25]. When glucose concentration is limiting, a hunger state is defined if it causes a reduction in the µ to a value below the maximal rate observed when this nutrient is abundant [14]. In contrast, a starvation state is defined by growth cessation because of glucose depletion. The hunger response is characterized by the expression of nutrient scavenging systems, including genes encoding proteins involved in high-affinity glucose uptake such as LamB and MglABC, that replace PTS-dependent glucose import by OmpC and IICBGlc [14]. Knowledge about the global transcriptional response of E. coli to glucose limitation has been extended by using technologies such as qPCR, microarrays, and RNA-seq. These studies have enabled a better understanding of the physiological state under specific conditions, providing insight into the roles of cellular components on cell adaptability and survival [23, 26,27,28]. Among key findings is the elucidation of regulatory components coordinating the response to glucose limitation. The global regulator CRP, bound to its effector cAMP, has been determined to control about one-third of the genes responding to this condition [29]. In addition, growth rate-dependent control, including the alternative sigma factor RpoS and small untranslated RNAs is involved in the carbon source limitation response [27, 30].
Even though much is known about how E. coli responds to nutrient limitation conditions, there is growing interest in understanding how glucose-limitation responses would relate to the performance of this organism as a biotechnological production host. It would be useful to characterize E. coli strains that are improved cell factories for biotechnological products. In this regard, a set of mutant strains have been generated to display distinct glucose consumption rates, based on the deletion of PTS and non-PTS glucose importers [11, 31, 32]. These strains import glucose at fixed values that cause a growth rate below the maximum. Thus, these mutants can emulate the dilution rates of continuous culture, but without any external process control [11, 12]. When compared to wild-type E. coli W3110, some of these mutant strains have displayed increased production of a DNA vaccine and membrane proteins [11, 32]. A recent study compared the capacity for GFP production among a group of six isogenic strains that exhibit distinct qs values as a result of the deletion of glucose transporters. E. coli W3110 and mutant derivatives displayed qs ranging from 1.75 to 0.45 g/g h. It was determined that all mutant strains produced a 4 to 25 higher GFP titer when compared to W3110 [12]. These results can be explained in part by the observed reduction in acetate accumulation in the culture medium. However, the acetate titer and specific rate of production did not correlate with GFP yield or titer [12]. These data strongly suggest that a reduction in qs results in modifications of cell physiology that go beyond a reduction in overflow metabolism and these perturbations have an impact on recombinant protein production capacity. Thus, it is of interest to determine the physiological state of these strains to help in understanding the basis for their improved performance. To address these questions, we performed comparative transcriptome analyses.
Material and methods
Strains and cultivation conditions
The strains used in this work are described in Table 1 and Fig. 1. The strain E. coli W3110 is a derivative of K-12 [33]. Strains WG, WGM, WGMC, and WHIC are derivatives of W3110 [11]. All the strains were cultured in 5 mL Luria–Bertani medium, stored in 40% glycerol, and kept frozen at − 70 °C. These strains were grown in stirred tank bioreactors, using M9 minimum salts medium supplemented with 20 g/L of glucose, and 0.15 mL/L of trace elements solution. The M9 medium contained 6 g/L Na2HPO4, 3 g/L KH2PO4,0.5 g/L NaCl, 1 g/L NH4Cl, 0.5 g/L MgSO4, 0.01 g/L CaCl2, 0.01 g/L thiamine hydrochloride. The trace elements solution contained the following: 1.5 g/L Na2EDTA · 2H2O, 0.45 g/L ZnSO4 · 7H2O, 0.03 g/L MnCl2 · 4H2O, 0.1 g/L H3BO3, 0.04 g/L Na2MoO4 · 2H2O, 0.3 g/L FeSO4 · 7H2O, and 0.03 g/L CuSO4 · 5H2O. Glucose and salts solutions were sterilized separately at 121 °C for 20 min. The inoculum for bioreactor cultures started with a single colony placed in a tube with 5 mL of LB medium and incubated at 37 °C, 300 rpm in an orbital shaker. After 8 h, a sample of this culture was used to inoculate a 250 mL shake flask containing 50 mL of M9 medium with 20 g/L glucose starting at an OD 600 nm of 0.1 and incubated at 37 °C, 300 rpm until an OD 600 nm of 2.0 was reached. Then a sample from this culture was used to inoculate sterile bioreactors containing 750 mL of the same medium, starting at an OD 600 nm of 0.1. Batch cultures in stirred tank bioreactor were performed using 1 L autoclavable glass bioreactors (Applikon, The Netherlands). The reactors were equipped with controls for pH, temperature, agitation, and dissolved oxygen. 3% NH4OH and H3PO4 solutions were automatically added to control pH at 7.0. The temperature was maintained at 37 °C, dissolved oxygen was manually maintained above 20% by changing stirring speed, and airflow was set to 1 vvm. Samples were taken periodically for offline analyses. All cultures were performed in triplicate.
RNA extraction, purification, mRNA library construction and RNA-seq
We carried out cultures for each strain under the same conditions as described above. Cultures were started at an OD 600 nm of 0.1 and growth was monitored until each strain reached an OD 600 nm of 1.0. At this point (mid-exponential growth phase), a 50 mL sample of culture medium was taken, placed in an ice bath, immediately added 1 ml of RNA later buffer (Ambion Inc., USA) mixed it, and centrifuged 10 min at 4 °C at 5000 rpm. The pellet was immediately kept frozen at − 70 °C. To perform RNA-seq sequencing, RNA extraction was made using the RNeasy Midi Kit (Qiagen) following the manufacturer’s instructions. RNA extractions and purifications were carried out from three independent cultures for each strain.
The ribosomal ribonucleic acid (rRNA) integrity was determined by the Bioanalyzer 2100 system (Agilent Technologies, Inc., Santa Clara, CA) using an Agilent RNA 6000 Nano chip, RNA Integrity Number (RIN) values were obtained for each RNA sample, and we only considered those with a value higher than 8 to elaborate RNAseq libraries. Subsequently, bacterial rRNA was depleted using Ribo-Zero rRNA Removal Kit for Bacteria (Epicentre™) following the manufacturer’s instructions. RNA was analyzed using the Bioanalyzer 2100 once again. Afterward, RNAseq libraries were constructed using Illumina TruSeq Stranded mRNA sample prep kit (Illumina, Inc., San Diego, CA) from RNA obtained previously, and following instructions of the manufacturer. Briefly, RNA was chemically fragmented by divalent cations to generate 200–600 bp fragments. After that, the cDNA of each fragmented RNA sample was synthesized with retrotranscriptase enzyme using degenerated primers of 6 nucleotides. dsDNA was obtained from cDNA using a Klenow DNA polymerase. Once dsDNA was obtained, both ends of each molecule were repaired to join with Illumina adapters by employing T4 DNA polymerase and T4 DNA ligase. Later, each library was amplified by PCR with specific primers for P5 and P7 adapter of Illumina, to increase the molecule number for high-throughput sequencing. Each library was analyzed by Bioanalyzer 2100 system using a DNA High Sensitivity chip. Finally, libraries were quantified fluorometrically using a Qubit®fluorometer with Qubit dsDNA HS Assay kit (Invitrogen). Libraries were amplified clonally into a Flowcell and sequenced on Illumina NextSeq 500 employing a NextSeq 500/550 High Output v2 kit for 150 cycles. Sequencing configuration was indexed Paired-End 2 × 76, following the protocol described by the manufacturer.
Differential expression analysis by pairwise comparison of strains WG-W3110, WGM-WG, WGMC-WGM, and WHIC-WGMC
RNA-seq reads were quantified by Salmon using default parameters [34], with the E. coli K-12 substr. W3110 genome cds file as a reference (ftp://ftp.ncbi.nlm.nih.gov/genomes/all/GCF/000/010/245/GCF_000010245.2_ASM1024v1/GCF_000010245.2_ASM1024v1_cds_from_genomic.fna.gz).
Differential expression analysis was carried out employing edgeR v 3.26.8 [35]. We used the transcript levels from the strain with the higher qs value as a reference among pairs. Thus, we performed the following comparisons WG-W3110, WGM-WG, WGMC-WGM, and WHIC-WGMC. In addition, we used the Benjamini-Hochberg (BH) as a p-value adjustment method [36]. Differentially expressed genes were those with a p-value < 0.01 and False Discovery Rate (FDR) < 0.01 and a fold-change ≥ 2 as the cutoff. We obtained a list of differentially expressed genes for each mutant strain against its respective partner. Afterward, we converted the RefSeq identifiers in Uniprot database (http://www.uniprot.org) using the Retrieve/ID mapping tool to obtain genes names, descriptions, and accession numbers of bnumbers and additional protein information. In addition, we calculated the Pearson correlation coefficient of the differentially expressed genes using their logarithm of fold change (logFC) and their qs values. Also, we calculated the slope with the parameter logFC/qs, similar to the method reported by Veit et al. 2007 [37].
COG, annotation of differentially expressed genes
We performed annotation of our list of genes through Cluster of Orthologous Groups (COG’s) using eggNOG-mapper (http://eggnogdb.embl.de/) with DIAMOND mapping mode, the taxonomic scope of Gamma-proteobacteria, prioritizing precision on orthologues, and prioritizing quality on gene ontology evidence. To visualize the results, we used the ggplot2 library based on R.
RNA extraction, cDNA synthesis and RT-qPCR conditions
To confirm RNA-seq and differential expression analysis results, we performed three RNA extractions and purifications from three independent fermentations for each strain. For this purpose, 50 mL samples were taken of each different strain growing logarithmically. Those samples were collected when the biomass reached 1.0 (OD600nm). Then, 1 mL of RNA later buffer (Ambion Inc., USA) was added to each sample, mixed, and centrifuged for 10 min at 4 °C and 5000 rpm. Conditions for total RNA extraction, cDNA synthesis, and RT-qPCR conditions were those previously reported [38], primers used are listed in Additional file 3: Table S1.
Results
Growth kinetics characterization
The isogenic mutant strains employed in this study are derived from W3110 and harbor deletions in genes that encode proteins related to carbohydrate import of PTS and non-PTS systems. They belong to a group of strains that displayed a wide range of qs values when grown in a minimal medium with glucose [11]. From this group of mutants, we selected five strains that span the full range of observed qs values. Strain WG lacks the gene encoding the IICBGlc PTS component. Strain WGM lacks both the IICBGlc and IICDMan components. Whereas strain WGMC lacks the IICBGlc, IICDMan components, and the MglABC system. In strain WHIC, genes ptsHIcrr were deleted, causing the complete disruption of the PTS system (Fig. 1). Since the PTS phosphorelay chain is disrupted, none of the PTS components is expected to be functional. This strain also lacks the MglABC system.
The mutant strains and E. coli W3110 were grown in a stirred bioreactor employing minimal salts medium containing 20 g/L glucose. The kinetic and stoichiometric parameters are summarized in Table 2. These strains displayed qs and µ values that span from 1.52 to 0.35 g/g h and 0.67 to 0.27 h−1, respectively (Additional file 1: Fig S1). We observed that qs and µ values displayed a linear correlation (R2 = 0.99; Fig. 2). The final biomass concentration was similar for all strains. The cultures were stopped when the stationary phase was reached at the times listed in Table 2. At these times, we did not detect residual glucose in the medium. Strains W3110, WG, WGMC, and WHIC secreted acetate, reaching the maximum concentration when glucose was depleted, afterwards, the organic acid was consumed. No acetate was detected in the culture medium of strain WGM. Strain W3110 displayed the highest specific rate of acetate production (qac) and acetate titer of 0.43 g/g h and 1.94 g/L, respectively. The qac in W3110 was almost 28-fold higher when compared with the other strains. In these experiments, the biomass yield (YX/S) values differed by less than 20% among all the strains employed in this study.
Differential expression analysis, reads abundance and mapping
RNA-seq libraries were generated from triplicate samples of WG, WGM, WGMC, WHIC, and W3110 strains. Libraries were sequenced, and 37–48 million reads were obtained from the W3110 library, 31–59, 32–53, 35–56, and 52–54, million reads for WG, WGM, WGMC, and WHIC, respectively. These results indicated that we have generated a similar amount of data among libraries of the strains. Afterward, we used the Salmon program to quantify reads against the annotated E. coli K-12 substr. W3110 genome. We obtained on average 3.3 ± 1.2, 2.4 ± 1.2, 3.0 ± 1.1, 4.2 ± 2.1, and 2.6 ± 0.3 million of mapped reads from W3110, WG, WGM, WGMC, and WHIC, respectively, those data are shown in Table 3. The RNA-seq data for this study have been deposited in the European Nucleotide Archive (ENA) at EMBL-EBI under accession number PRJEB32273 (https://www.ebi.ac.uk/ena/browser/view/PRJEB32273).
The global transcriptomic response among strains with a reduced glucose uptake rate
Strains W3110, WG, WGM, WGMC, and WHIC were grown in a minimal medium containing 20 g/L glucose, and samples from these cultures were subjected to RNA-seq analysis. The transcriptomes of the mutant strains were compared to that of W3110. Figure 3 shows a comparison of the number of genes that were differentially expressed when compared to W3110, corresponding to 281, 201, 222, and 779 for strains WG, WGM, WGMC, and WHIC, respectively (Additional file 4: Table S2). It can be observed that in all mutant strains, the number of upregulated genes is higher than those downregulated. The differentially expressed genes belonged to several COGs, as will be discussed below.
Distribution of differentially expressed genes among mutant strains in Clusters of Orthologous genes when comparing transcriptomes of W3110 with mutant strains WG, WGM, WGMC, and WHIC. The qs value for each strain is shown between parenthesis and it is presented as g glucose/g DCW h Values for GFP yield from biomass (YGFP/X) were obtained from a previous publication [11] and are expressed as mg GFP/g DCW
To determine the effects of the change in qs (Δqs) among strains, differential expression analysis was performed by comparing pairs of strains with progressively lower qs values: W3110-WG (Δqs = 0.41 g/g h), WG-WGM (Δqs = 0.49 g/g h), WGM-WGMC (Δqs = 0 g/g h), and WGMC-WHIC (Δqs = 0.27 g/g h) (Table 4). When performing this comparison, it can be observed that genes clustered in COG S (Function unknown) were the most numerous (Table 5 and Fig. 4). It cannot be discarded that the genes included in this COG have a function related to the production performance of these strains. However, since the functions of these genes are not known, they were not further considered in this study. Most of the genes with known functions belonged to COGs C, E, G, and K, related to energy production and conversion, amino acid transport and metabolism, carbohydrate transport and metabolism, and transcription. Table 4 shows the number of differentially expressed genes for each pairwise comparison. It can be observed that the magnitude of this number shows a partial correlation with the Δqs. An exception to this behavior stands for strains WHIC-WGMC, with a higher-than-expected number of differentially expressed genes to the observed Δqs. This can be explained considering that operon ptsHIcrr was deleted in strain WHIC, resulting in the complete disruption of PTS activity. Inactivation of PTS not only eliminates several carbohydrate import functions but also impairs global regulatory functions [39, 40].
Distribution of differentially expressed genes among pairs of strains in Clusters of Orthologous genes. The number of genes upregulated (positive value) or downregulated (negative value) from each COG is indicated. Transcriptome comparisons: WG-W3110 (yellow), WGM-WG (blue), WGMC-WGM (orange) and WHIC-WGMC (red)
When comparing the transcriptomes of strains WG and W3110 (Additional file 5: Table S3, Fig. 5), we detected upregulated genes coding for PTS transport and catabolic proteins for N-acetylgalactosamine (agaV, 4.3-fold), fructose (fruABK, 9.1, 13.8, 12.4-fold), galactitol (gatBC, 4.2 and 4.5-fold), mannose (manXYZ, 4.3, 3.7, and 4.2-fold), mannitol (mtlA, 2.4-fold), glucitol/sorbitol (srlABED, 6.3, 7.8, 7.3, 5.7-fold), N-acetylglucosamine (nagBE, 2 and 4.2-fold), and trehalose (treBC, 19.9 and 18.6-fold) (Fig. 4). Upregulated genes related to non-PTS carbohydrate transport and catabolic proteins were detected for maltose (malEFG, malK, and malM; 8.8–18.1-fold), ribose (rbsABCK, and rpiB, 13.6, 4.2, 12.7, 3.9, and 4.3-fold), galactose/glucose (mglABC, 7.2, 22, and 5.8-fold), arabinose (araF, 2.6-fold), inositol (agp, 3.5-fold), 2-dehydro-3-deoxygalactose (dgoK, 2.1-fold), fuculose (fucA and fucI, 3.3 and 3.1-fold), 5- keto-4-deoxy-D-glucarate and 2-keto-3-deoxy-D-glucarate (garL, 2.7-fold), tagatose (gatYZ, 5.4 and fourfold), maltose and maltodextrin (malPQ, malS, and malZ; 4.7, 3.9, 5.7, and twofold), N-acetilmannosamine (nanEK, 3.6 and 2.2-fold), 2-methylisocitrate (prpB, 5.1-fold), glucuronate (uidA and uxaC, 2.3 and 2.4-fold), altronate (uxaA, 3.1-fold), mannonate (uxuAB¸ 3.4 and 2.5-fold) and 5-dehydro-4-deoxy-D-glucuronate (kduI, 2.6-fold). It is noteworthy that none of these PTS and non-PTS carbon sources are present in the culture medium. It is also worth noting that transcriptome data detected, in most cases, the expected coordinated expression of genes when they are part of operons. Genes acs (17.4-fold) and actP (18-fold) form an operon, and they were found upregulated. The acs-actP operon encodes proteins of an acetate scavenging pathway, possibly contributing to lowering the accumulation of this organic acid in the culture medium. Also detected, were upregulated genes encoding transport proteins for glycerol (glpF, 5.6-fold), the outer porin encoded by lamB (14.9-fold) and the hexose-6-phosphate:phosphate antiporter (uhpT, 3.5-fold). Another upregulated gene was glk (twofold). The transport proteins encoded by the mglABC operon and lamB constitute a high-affinity pathway for glucose import that is independent of PTS activity. The induction of these genes indicates a carbon source limitation state [13]. The upregulation of glk encoding the enzyme glucokinase suggests its participation in the phosphorylation of glucose molecules that are not internalized and phosphorylated by PTS. In strain WG, a lower transcript level of gene pykF (-2.1-fold) was detected, it encodes pyruvate kinase 1 from the Embden Meyerhof-Parnas (EMP) pathway. This enzyme is involved in pyruvate formation, so the downregulation of pykF suggests diminished glycolytic flux in WG when compared to W3110, resulting in the observed reduced overflow metabolism. Upregulated genes also included part of the glyoxylate and TCA cycles (aceA, 3.1-fold; acnB, 2.1-fold; fumC, 2.3-fold; glcB, 4.2-fold; gltA, 2.6-fold; and sdhAB, 2.4 and 2.2-fold), as well as genes maeB¸(twofold) and pckA (2.9-fold), that are involved in gluconeogenesis. The induction of gene pka (threefold) that is related to the acetylation of proteins was detected in WG. It has been determined that deletion of pka leads to lower resistance to heat and oxidative stresses [41].
Comparison of the transcriptomes from strains WGM and WG, showed a further increase in transcript levels in the former strain for genes encoding transport and catabolic proteins for the following carbon sources: chitobiose, trehalose, maltose, and N-acetylglucosamine. The opposite response was observed for transport and catabolic genes for fructose, galactitol, glucitol, arabinose, glycerol, ribose, galactose, trehalose, altronate, and mannonate (Additional file 5: Table S3, Fig. 6). A higher transcript level in WGM was detected for genes pykF (2.5-fold), talA (2.3-fold), and tktB (2.2-fold), indicating a potential for higher flux in the EMP and PP pathways (Additional file 5: Table S3, Fig. 6). Compared to WG, in strain WGM downregulation was observed for genes from the TCA and glyoxylate shunt gltA (− 2.7-fold), aceA (− 2.5-fold), acnB (− 3.1-fold), fumAC (− 2.7 and − 2.5-fold), sdhAB (− 2.5 and − 2.2-fold), and glcB (− 3.1-fold). These data suggest that energy and reducing power production capacity through TCA could be lower in WGM when compared to WG. It is noteworthy that genes involved in gluconeogenesis as well as the PEP/PYS metabolism ppsA (− 2.6-fold), pckA (-threefold), and the glpK (− 3.4-fold) gene which encodes for glycerol kinase were downregulated in this comparison but displayed the opposite response in the WG and W3110 comparison. Upregulation was detected for gene iraP, (2.7-fold). The gene iraP is required for the stabilization of σS during phosphate or nitrogen starvation and it plays a role in the stationary phase. A higher transcript level for genes gadX (4.8-fold) and gadW (5.9-fold) was detected in WG. These two genes form a complex operon and encode transcriptional regulators that control the glutamic acid decarboxylase acid resistance system. Genes belonging to this system were found induced: gadA (17.3), gadB (22.9) gadC (26.5), and gadE (22.9). It should be noted that pH was controlled and maintained at a neutral value in cultures with these strains. Therefore, the physiological role of this acid resistance system under these conditions is not clear.
Strains WGM and WGMC displayed an identical qs value (0.62 g/g h) under the growth conditions employed in this study. This result suggests that the MglABC high-affinity transporter is not contributing to glucose import in strain WGM or that its function was replaced by other proteins in WGMC. Strain WGMC accumulated 0.32 g/L of acetate, while this organic acid was not detected in cultures with WGM. This result indicates that deletion of mglABC influences metabolism by an unknown mechanism that causes an increase in acetic acid production [42,43,44]. The transcriptome analysis yielded 12 differentially expressed genes when comparing WGMC to WGM, most of them without a defined function (Additional file 5: Table S3). Among these genes, galS was found upregulated (20-fold), it encodes a transcription factor that regulates the expression of genes involved in the transport and catabolism of D-galactose. However, no increase in transcript level was detected for members of the GalS regulon. Further characterization of WGMC should be useful to determine how the deletion of mglABC causes the observed metabolic and transcriptional responses.
The transcriptome comparison of WHIC to WGMC yielded upregulated genes encoding transport and/or catabolic proteins for the consumption of fructose, arabinose, O-acetylserine/cysteine, α-ketoglutarate, 3-hydroxyphenylpropionate/3-hydroxycinnamate, glycerol, maltose/maltodextrin, mannose, ribose, and trehalose (Additional file 5: Table S3, Fig. 7). In contrast to the response observed in mutant strains WG and WGM, gene lamB (-3.1-fold) was downregulated. This result is consistent with the reported poor expression for this gene under glucose excess and glucose-starved conditions [13]. A higher transcript level was detected for gluconeogenic genes fbp (2.1-fold) and ppsA (3.9-fold) (Additional file 5: Table S3, Fig. 7). In contrast, several genes from the EMP pathway were downregulated (gapA, − 2.5-fold; gpmI, − 3.7-fold; pfkA, and − 2.3-fold). Gene cydA (− 2.8-fold), which is related to the respiratory chain, was downregulated. Also detected were lower transcript levels of genes encoding part of the pyruvate dehydrogenase (aceEF, 3.2 and − 2.6-fold), and ackA (− 2.9-fold) related to acetic acid assimilation/production. Genes related to the synthesis of glutamine, asparagine cysteine, and lysine (glnA − 7.7-fold, asnAB − 5.6 and − 5.9-fold, cysK − 3.2-fold, lysA -twofold) were downregulated. A lower transcript level was observed for gene iraP (− 2.8-fold). In this case, the response of this gene was opposite to that observed for the WG-W3110 and WGM-WG transcriptome comparisons. Genes encoding functions related to the synthesis of the extracellular polysaccharide colonic acid displayed higher transcript level in strain WHIC: wcaA (3.9-fold), wcaC (3.2-fold), wcaD (4.5-fold), wcaE (6.6-fold), wcaF (8.7-fold), wcaI (fourfold), wcaJ (fourfold), wza (7.7-fold), wzb (7.4-fold), and wzc (3.2-fold). Strain WHIC displayed the lowest qs among studied mutants and the observed transcriptome response is characteristic of severe carbon and energy limitation. As will be discussed below, part of the observed response can be explained considering the dual transport-regulatory role of PTS in E. coli.
The set of differentially expressed genes and their intersections in the WG-W3110, WGM-WG, and WHIC-WGMC pairwise comparisons are shown in Additional file 1: Fig S2 and Additional file 6: Table S4. These comparisons were tagged as A, B, and C, in the Venn diagram respectively. It is important to mention that we did not include the WGMC-WGM comparison because they displayed very similar µ and qs values (see Additional file 6: Table 4) and a nearly identical transcriptomic response. Comparisons A, B, and C had unique genes that appeared to be more numerous in WGMC-WHIC (C; 287), followed by WG-W3110 (A; 96) and WGM-WG (B;65).
Validation of gene expression by qPCR
RT-qPCR experiments were performed for the following genes displaying differential expression in the RNA-seq results: galP, manX, nagE, lamB, ompC, ompF, mglB, gltA, acs, poxB and ppsA. (Table 6). The magnitude of the expression levels detected by qPCR was different to those observed in the RNA-seq experiments, but the general response regarding upregulation or downregulation was conserved for most of the genes: manX, nagE, lamB, ompC, mglB, gltA, acs, poxB and ppsA.
Correlations between qs and expression levels
In this study, we detected genes displaying expression levels that correlated with the qs. This response was characterized by calculating the Pearson correlation coefficient between qs and the logarithm of fold change (logFC). Also, we defined that (ΔlogFC/Δqs) ratios larger than 1.5 or lower than − 1.5 were considered as differentially expressed among the full set of strains. Briefly, a negative correlation indicates that genes increase their expression values while the qs value is decreasing. In contrast, a positive correlation means that genes decrease their expression level while qs is decreasing. Lists of genes displaying positive and negative correlations with qs are included in Additional file 6, 7: Tables S5 and S6, respectively. The results were then organized in COG classes to facilitate their analysis. Of 292 genes having a positive or negative correlation, 47% are not classified in a COG class. The remaining 138 genes were distributed in the O, P, M, K, C, E, S, and G classes.
Inspection of COG C shows 20 genes displaying a positive correlation with qs, among them we found the nuoFGHIJKLM operon and the phosphoenolpyruvate carboxylase (pckA). Also, dehydrogenases for glycerol (glpA), sorbitol (srlD), galactitol (gatD), hydroxycarboxylate (hcxA), and acetoin (ucpA). Conversely, we detected 13 genes with negative correlation to qs, the pyruvate dehydrogenase (poxB), ubiquinol reductase (appBC), 2-methylcitrate synthase (prpC), and an alcohol/ethanol dehydrogenase (adhP). From this set, the response of the nuo genes can be explained considering that energy production requirements are lower under the reduced growth rates of the mutant strains. This assumption should be tested experimentally since E. coli has a second NADH dehydrogenese encoded by ndh. The nuo operon forms part of the DNA-binding transcriptional dual regulator Fis regulon, it has been demonstrated that repression by Fis, a growth-dependent regulator, occurs when this transcription factor is in high concentrations [45].
We detected 16 genes from COG E with positive and 9 with negative correlations. Among the former, there were genes related to the synthesis of arginine (argB and argF), aspartic acid (aspA), cysteine (cysK), histidine (hysG), serine/threonine (sstT), proline (proW), and cysteine (fliY). Decreased expression of genes encoding functions related to amino acid biosynthesis can be expected because of the lower growth rates of the mutant strains with the lower qs values. However, it is not clear why this response is selective for some amino acids. Genes displaying a negative correlation with qs included gadA and gadBC that encode proteins of the glutamate-dependent acid resistance system 2. Expression of these genes is increased in the mutant strains displaying the lower qs values. Since pH is maintained at a neutral value in these cultures, the upregulation of these genes should be dependent on another type of stress or metabolic signal. It should be noted that these genes are subject to complex regulation by transcriptional factors GadX, GadW, Fis, and CRP [46].
From COG G we found 22 and 19 genes with positive and negative correlations, respectively. Genes showing a positive correlation with qs encode functions related to galactitol, glucitol/sorbitol, trehalose PTS transport systems (gatC, srlABC, and treB), the ribose (rbsBC) and maltose (malG) ABC transporters, as well as a set of genes encoding proteins for the utilization of ribose (rbsDK), trehalose (treC), fucose (fucA and fucI), tagatose (gatZ), galactonate (dgoA), methylglyoxal (mgsA), and altronate (uxaAC and uxaB). These genes are likely induced as a response to carbon limitation in strain WG. Paradoxically, their expression is progressively reduced in strains with lower qs, possibly as a result of energy limitation or another type of metabolic perturbation. In contrast, genes encoding PTS transport proteins for chitobiose (chbB) and N-acetylglucosamine (nagE), and the non-PTS galactose symporter (galP) displayed a negative correlation. From these proteins, GalP has been shown to replace the PTS-dependent glucose transport function in a mutant lacking a functional PTS system [47]. Therefore, GalP may be contributing to glucose import in some of these mutants. Interestingly, some mutant strains showed increased expression of glk, encoding the enzyme glucokinase that can phosphorylate the glucose internalized by GalP.
Three genes from this COG J class displayed a negative correlation (argS, rmf, and sra). The argS gene encodes for the arginyl-tRNa synthetase. The rmf encodes for a ribosome modification factor which reversibly converts active 70S ribosomes into their 100S dimeric form during the transition from exponential growth to stationary phase [48]. Gene sra encodes for a protein associated to the ribosomal 30S subunit during the stationary phase [49]. The observed expression pattern for genes sra and rmf indicate that mutant strains with the lower qs values have a physiological state like that observed in the stationary phase. These results could indicate that strains with lower qs values have a physiological state that is not optimal for recombinant protein production.
Discussion
This study aimed to characterize E. coli strains with impaired capacity for glucose import. We expect these data and their analysis will provide an insight into the basis for their distinct microbial factory characteristics [12]. Transcriptome analysis was performed on E. coli strain W3110 and isogenic derivatives reduced glucose consumption capacity: WG, WGM, WGMC, and WHIC.
The number of differentially expressed genes when comparing WG-W3110 and WGM-WG was similar, indicating a correlation with the qs ratio among each pair of strains (Table 4). In contrast, strains WGMC and WGM displayed nearly identical qs values. The only difference between these strains is the deletion of the mglABC operon. In this case, 12 genes were found to be differentially expressed. Strain WGMC produced 0.32 g/L of acetic acid, while in the culture medium of WGM we did not detect this organic acid (Table 2). This phenotypic difference could explain the set of differentially expressed genes. However, further strain characterization will have to be performed to verify this assumption. When comparing strains WHIC and WGMC the Δqs was about half of that detected for WG-W3110 and WGM-WG. However, the number of differentially expressed genes was about twice as expected. These results show that transcriptomic response does not have a linear relationship with changes in qs. It should be noted that the qs value for WHIC is only 23% of that determined for W3110. These data suggest that very low qs values cause stress that elicits a large transcriptomic response. It should also be considered that deleted glucose import proteins could have a regulatory role. This is the case for strain WHIC, the deletion of operon ptsHIcrr eliminates the synthesis of protein EIIAGlc, thus disrupting the stimulation of cAMP synthesis by enzyme adenylate cyclase. Therefore, the expression of genes from the CRP regulon should be disrupted in strain WHIC. In this regard, it was found that in the WHIC-WGMC comparison there were 48 genes regulated by CRP, (33 belonging to COGs C, E, G, and K). This number is lower than that detected when comparing WG-W3110, 76 genes (53 from COGs C, E, G, and K) and WGM-WG 56 genes (39 from COGs C, E, G, and K). The transcription factor CRP-cAMP regulates several hundred genes in E. coli, and some of them are also transcriptional regulators [29]. The obtained data suggest that the observed transcriptomic response in WHIC is the combined effect of very low qs, which would induce many genes related to carbon source limitation, and the indirect disruption of the CRP regulon.
Strain WG is isogenic with W3110 except for the deletion of the gene encoding IICBGlc in the former. This genetic modification caused a transcriptional response consistent with a carbon limitation and hunger response characterized by a decrease in transcript level for genes encoding functions related to glycolytic activity and an increase in expression of genes from gluconeogenic metabolism. The expected reduction in overflow metabolism was observed in cultures with this strain with 6.7% of the acetate titer detected in cultures with W3110 (Table 2). As part of the hunger response, genes involved in the transport and utilization of several different carbohydrates and amino acids were upregulated. It should be noted that these compounds were not present in the culture medium, so the observed response should be a carbon source scavenging strategy. Additionally, several genes related to amino acid synthesis were downregulated, possibly caused by the 22% lower growth rate of WG when compared to W3110, resulting in lower demand for amino acids.
The deletion of manX in the ptsG background results in strain WGM that lacks two PTS components related to glucose import [11]. Strain WGM lacks gene manX, so PTS components IIAman and IIBman are not synthesized. This strain displays µ and qs values corresponding to 65 and 56% of those observed for WG (Table 2). Acetate was not detected in cultures with WGM. The transcriptome data showed that the further decrease in glucose import capacity in strain WGM, when compared to WG, caused the induction of additional genes encoding PTS and non-PTS proteins involved in the uptake and catabolism of secondary carbon sources that were not present in the culture medium. Interestingly, the observed transcriptional response included several genes from the EMP and PPP that were found upregulated. A lower level of transcripts was detected for genes from the TCA cycle. This response suggests a decrease in energy production capacity for WGM when compared to WG, likely because of the lower growth rate. Strain WGM displayed a higher transcript level for gene iraP (2.7-fold), encoding a small anti-adaptor protein that is required for stabilization of the alternative sigma factor σS. The expression of iraP is dependent on phosphate starvation and to a lesser extent on carbon limitation, and this response is dependent on ppGpp [50]. These data suggest an involvement of σS in the observed transcriptional response in WGM. The transcriptome data is indicative of a more severe carbon limitation when comparing WGM to WG. It should be noted that no acetate accumulation was detected in cultures with strain WGM, thus, overflow metabolism was eliminated in this strain (Table 2). A derivative of strain WGM that expresses gfp displayed a 1.4-fold increase in the specific rate of GFP synthesis and its yield from biomass when compared to isogenic WG. Strain WGM displayed the highest GFP production capacity when compared to production strains derived from all mutants in this study [12]. This improvement in recombinant protein production capacity for WGM when compared to other strains in this study, can be attributed in part to the specific state of carbon source limitation, and the complete elimination of overflow metabolism.
The effect of eliminating the high-affinity glucose uptake system MglABC on the WGM background was studied by comparing it with strain WGMC. This modification did not alter the qs. However, acetate was produced to a maximum level of 0.32 g/L, whereas this organic acid was not detected in cultures with strain WGM. Among the 12 genes that showed differential expression in WGMC when compared to WGM, nagD was found to be downregulated (− 2.2-fold) and galS upregulated (20.1-fold). Gene nagD, also known as umpH is part of the N-acetylglucosamine utilization operon and encodes a ribonucleotide phosphatase [51]. It has been determined that overexpression of nagD results in the induction of genes related to cell envelope and heat shock stress. The co-expression of nagD and mammalian G protein-coupled receptors (GPCR) in E. coli resulted in a 3- to tenfold increase in the yield of the latter [52]. This result can be explained considering that induction of stress-related proteins provides a favourable environment to produce recombinant proteins. It remains to be determined if the lower transcript level of nagD in WGMC could explain in part why this strain displayed lower GFP production capacity when compared to WGM [12]. Gene galS, also known as mglD encodes the galactose isorepressor, a transcription factor that represses the transcription of genes involved in galactose catabolism [53]. It has been reported that growth under a low glucose concentration causes the synthesis of galactose as an autoinducer of the gal regulon [14, 54]. The gal regulon contains genes encoding proteins involved in the transport and metabolism of galactose. It should be noted that the transport proteins that are members of this regulon, GalP, and MglABC, can also employ glucose as substrate [11]. When comparing GFP production strains derivatives of WGM and WGMC it was determined that the latter produced about 40% less recombinant protein [12]. This result can be explained considering the increased production of acetate and possibly also the downregulation of nagD. However, with the available data, it is not possible to determine how the deletion of mglABC caused such effects. It is interesting to note the lack of correlation between the qs and qac values when comparing strains WGM and WGMC. Elimination of MglABC may abolish the ATP-dependent high-affinity import of glucose that is dependent on ATP for phosphorylation. If MglABC has an important role in glucose import in strain WGM, the deletion of this transporter could shift glucose import to systems dependent on energy from PEP (PTS) or proton motive force (GalP). This modification could alter the energetic state of the cell and central metabolic fluxes, indirectly affecting acetate production in WGMC. These results suggest that deletion of operon mglABC should be carefully considered as a strategy to modify qs in a production strain since, as shown here, this modification causes unexpected results. Further strain characterization, including measurement of the energy state, as well as carbon flux determination in central pathways should help in understanding the consequences of this modification.
Strain WHIC displayed the lowest values for µ and qs among studied strains and an extremely low level of acetate production (Table 2). Strain WHIC showed the largest number of differentially transcribed genes when compared to the other strains in this study. Even when comparing transcriptome data of WHIC with the strain showing the closest qs value, WGMC, 421 genes were found to be expressed differentially. In this comparison, several genes encoding PTS components as well as genes encoding proteins for the transport and metabolism of alternate carbon sources were upregulated in WHIC. Downregulation of genes from the respiratory chain was detected. In the context of GFP production, this strain displayed a threefold higher titer when compared to an isogenic producer strain derived from W3110 [12]. However, WHIC showed the lowest GFP titer when compared to the other mutant strains in this study. The transcriptome profile shown by WHIC suggests the most severe level of carbon and energy limitation when compared to the other mutant strains. Overflow metabolism is reduced and nearly non-existing. However, the extreme hunger state displayed by this strain can be considered the cause for the relatively low GFP production capacity when grown in minimal salts media.
When compared to the transcriptome of wild-type strainW3110, all isogenic derivatives with reduced glucose consumption capacity displayed a relatively large number of differentially expressed genes. The ratios of upregulated to downregulated genes corresponded to 2.2, 5.5, 4.6, and 1.4 for strains WG, WGM, WGMC, and WHIC, respectively. It is noteworthy that even though these strains displayed a transcriptomic response consisting mainly of upregulated genes, all of them have shown an improved capacity for recombinant protein production when compared to W3110 [12]. The observed response suggests that a strategy for further strain optimization for recombinant protein production could be based on avoiding the upregulation of non-essential functions. This approach, also known as resource allocation engineering, has been proven to be effective in improving microbial cell factories [55]. In the case of the glucose transport mutant strains employed in this study, resource allocation engineering could be employed to determine if avoiding the induction of scavenging functions for carbon sources that are not present in the culture medium and other non-essential functions would improve performance for recombinant protein production. It should be noted that several research groups have reported the improvement of E. coli strains to produce recombinant proteins or chemicals by employing mutants with reduced glucose import rates [10, 32, 56]. Those strains may be improved by applying an engineering strategy based on eliminating the non-essential induced functions identified in this study.
Availability of data and materials
The datasets used and/or analyzed during the current study are available from the corresponding authors on reasonable request.
Abbreviations
- AcCoA:
-
Acetyl-coenzyme A
- Ack:
-
Acetate kinase
- Spc:
-
Spectinomycin
- LB:
-
Luria Bertani
- CDW:
-
Cell dry weight
- GFP:
-
Green fluorescent protein
- Pta:
-
Phosphotransacetylase
- PEP:
-
Phosphoenolpyruvate
- LacI:
-
Lactose repressor
- PTS:
-
Phosphoenolpyruvate:sugar phosphotransferase system
- TCA:
-
Tricarboxylic acid cycle
- qac :
-
Specific rate of acetate production
- qs :
-
Substrate uptake rate
- qp :
-
Recombinant product formation rate
- SD:
-
Standard deviation
- gfp :
-
Superglo GFP gene
- YX/S :
-
Biomass yield from glucose
References
Görke B, Stülke J. Carbon catabolite repression in bacteria: many ways to make the most out of nutrients. Nat Rev Microbiol. 2008;6:613–24.
Ma E, Altman E. Overcoming acetate in Escherichia coli recombinant protein fermentations. Trends Biotechnol. 2006;24:530–6.
Valgepea K, Adamberg K, Nahku R, Lahtvee P-J, Arike L, Vilu R. Systems biology approach reveals that overflow metabolism of acetate in Escherichia coli is triggered by carbon catabolite repression of acetyl-CoA synthetase. BMC Syst Biol. 2010;4:166.
De M, Ae M, De Maeseneire S, Wim AE, Ae S, Vandamme E. Minimizing acetate formation in E. coli fermentations. Available from: https://academic.oup.com/jimb/article/34/11/689/5993063
Wolfe AJ. The Acetate Switch. Microbiol Mol Biol Rev 2005;69:12–50. Available from: https://journals.asm.org/journal/mmbr
Taymaz-Nikerel H, Lara AR. Vitreoscilla Haemoglobin: a tool to reduce overflow metabolism. Microorganisms. 2021;10:43.
Han K, Han K, Lim HC, Lim HC, Hong J, Hong J. Acetic acid formation in Escherichia coli fermentation. Biotechnol Bioeng. 1992;39:663–71.
Shiloach J, Kaufman J, Guillard aS, Fass R. Effect of glucose supply strategy on acetate accumulation, growth, and recombinant protein production by Escherichia coli BL21 (hDE3) and Escherichia coli JM 109. Biotechnology. 1996;49:421–8.
Lin C, Cheng L, Wang J, Zhang S, Fu Q, Li S, et al. Optimization of culture conditions to improve the expression level of beta1–epsilon toxin of Clostridium perfringens type B in Escherichia coli. Biotechnol Biotechnol Equip. 2016;30:324–31.
De Anda R, Lara AR, Hernández V, Hernández-Montalvo V, Gosset G, Bolívar F, et al. Replacement of the glucose phosphotransferase transport system by galactose permease reduces acetate accumulation and improves process performance of Escherichia coli for recombinant protein production without impairment of growth rate. Metab Eng. 2006;8:281–90.
Fuentes LG, Lara AR, Martínez LM, Ramírez OT, Martínez A, Bolívar F, et al. Modification of glucose import capacity in Escherichia coli: physiologic consequences and utility for improving DNA vaccine production. Microb Cell Fact. 2013;12:42.
Fragoso-Jiménez JC, Baert J, Nguyen TM, Liu W, Sassi H, Goormaghtigh F, et al. Growth-dependent recombinant product formation kinetics can be reproduced through engineering of glucose transport and is prone to phenotypic heterogeneity. Microb Cell Fact. 2019. https://doi.org/10.1186/s12934-019-1073-5.
Tchieu JH, Norris V, Edwards JS, Saier MH. The complete phosphotransferase system in Escherichia coli. J Mol Biotechnol. 2001;3:329–46.
Ferenci T. Hungry bacteria—definition and properties of a nutritional state. Enviromental Microbiol. 2006;3:605–11.
Death A, Ferenci T. Between feast and famine: endogenous inducer synthesis in the adaptation of Escherichia coli to growth with limiting carbohydrates. J Bacteriol. 1994;176:5101–7.
Picon A, Teixeira de Mattos MJ, Postma PW. Reducing the glucose uptake rate in Escherichia coli affects growth rate but not protein production. Biotechnol Bioeng. 2005;90:191–200. https://doi.org/10.1002/bit.20387.
Steinsiek S, Bettenbrock K. Glucose transport in Escherichia coli mutant strains with defects in sugar transport systems. J Bacteriol. 2012;194:5897–908.
Hogema BM, Arents JC, Bader R, Eijkemans K, Yoshida H, Takahashi H, et al. Inducer exclusion in Escherichia coli by non-PTS substrates: the role of the PEP to pyruvate ratio in determining the phosphorylation state of enzyme IIA(Glc). Mol Microbiol. 1998;30:487–98.
Gutierrez-Ríos R, Freyre-Gonzalez JA, Resendis O, Collado-Vides J, Saier M, Gosset G. Identification of regulatory network topological units coordinating the genome-wide transcriptional response to glucose in Escherichia coli. BMC Microbiol. 2007;7:53. https://doi.org/10.1186/1471-2180-7-53.
JR S, H. M. Regulation of carbon utilization. Escherichia coli Salmonella Cell Mol Biol. ASM Press; 1996 [cited 2021 Sep 21];1325–43. Available from: http://ci.nii.ac.jp/naid/10005857743/en/
Vanyan L, Trchounian K. HyfF subunit of hydrogenase 4 is crucial for regulating FOF1 dependent proton/potassium fluxes during fermentation of various concentrations of glucose. J Bioenerg Biomembr. 2022;54:69–79.
Hempfling WP, Mainzer SE. Effects of varying the carbon source limiting growth on yield and maintenance characteristics of Escherichia coli in continuous culture. J Bacteriol. 1975. https://doi.org/10.1128/jb.123.3.1076-1087.1975.
Vital M, Chai B, Østman B, Cole J, Konstantinidis KT, Tiedje JM. Gene expression analysis of E coli strains provides insights into the role of gene regulation in diversification. ISME J. 2015;9:1130–40. https://doi.org/10.1038/ismej.2014.204
Death A, Ferenci T. Between feast and famine: endogenous inducer synthesis in the adaptation of Escherichia coli to growth with limiting carbohydrates. J Bacteriol. 1994. https://doi.org/10.1128/jb.176.16.5101-5107.1994.
Hewitt CJ, Nebe-Von Caron G, Nienow AW, McFarlane CM. The use of multi-parameter flow cytometry to compare the physiological response of Escherichia coli W3110 to glucose limitation during batch, fed—batch and continuous culture cultivations. J Biotechnol. 1999;75:251–64.
Yao R, Hirose Y, Sarkar D, Nakahigashi K, Ye Q, Shimizu K. Catabolic regulation analysis of Escherichia coli and its crp, mlc, mgsA, pgi and ptsG mutants. Microb Cell Fact. 2011;10:67.
Borirak O, Rolfe MD, De Koning LJ, Hoefsloot HCJ, Bekker M, Dekker HL, et al. Time-series analysis of the transcriptome and proteome of Escherichia coli upon glucose repression. Biochim Biophys Acta Proteins Proteomics. 2015;1854:1269–79.
Castaño-Cerezo S, Bernal V, Post H, Fuhrer T, Cappadona S, Sánchez-Díaz NC, et al. Protein acetylation affects acetate metabolism, motility and acid stress response in Escherichia coli. Mol Syst Biol. 2014. https://doi.org/10.15252/msb.20145227.
Gosset G, Zhang Z, Nayyar S, Cuevas WA, Saier MH. Transcriptome analysis of Crp-dependent catabolite control of gene expression in Escherichia coli. J Bacteriol. 2004;186:3516–24. https://doi.org/10.1128/JB.186.11.3516-3524.2004.
Klumpp S, Hwa T. Bacterial growth: global effects on gene expression, growth feedback and proteome partition. Curr Opin Biotechnol. 2014;28:96–102.
Bäcklund E, Markland K, Larsson G. Cell engineering of Escherichia coli allows high cell density accumulation without fed-batch process control. Bioprocess Biosyst Eng. 2008;31:11–20.
Bäcklund E, Ignatushchenko M, Larsson G. Suppressing glucose uptake and acetic acid production increases membrane protein overexpression in Escherichia coli. Microb Cell Fact. 2011. https://doi.org/10.1186/1475-2859-10-35.
Bachmann BJ. Pedigrees of some mutant strains of Escherichia coli K-12. Bacteriol Rev. 1972;36:525–57.
Patro R, Duggal G, Kingsford C. Salmon: Accurate, versatile and ultrafast quantification from RNA-seq Data using Lightweight-Alignment. bioRxiv. 2015;021592. Available from: http://biorxiv.org/content/early/2015/06/27/021592.abstract
Robinson MD, Mccarthy DJ, Smyth GK. edgeR: a Bioconductor package for differential expression analysis of digital gene expression data. Bioinforma Appl. 2010;26:139–40.
Benjamini Y, Hochberg Y. Controlling the false discovery rate: a practical and powerful approach to multiple testing. Source J R Stat Soc Ser B. 1995;57:289–300.
Veit A, Polen T, Wendisch VF. Global gene expression analysis of glucose overflow metabolism in Escherichia coli and reduction of aerobic acetate formation. Appl Microbiol Biotechnol. 2007;74:406–21.
Aguilar C, Escalante A, Flores N, de Anda R, Riveros-McKay F, Gosset G, et al. Genetic changes during a laboratory adaptive evolution process that allowed fast growth in glucose to an Escherichia coli strain lacking the major glucose transport system. BMC Genomics. 2012;13:385.
Gosset G. Improvement of Escherichia coli production strains by modification of the phosphoenolpyruvate:sugar phosphotransferase system. Microb Cell Fact. 2005;4:14.
Plumbridge J. Regulation of gene expression in the PTS in Escherichia coli: the role and interactions of MIc. Curr Opin Microbiol Elsevier Ltd. 2002;5:187–93.
Christensen DG, Meyer JG, Baumgartner JT, D’souza AK, Payne SH, Kuhn ML, et al. Identification of novel protein lysine acetyltransferases in escherichia coli. MBio. 2018;9:1–24.
Notley L, Ferenci’ T. Differential expression of mai genes under cAMP endogenous inducer controi in nutrient-stressed Escherictiia coli. Mol Microbiol. 1995. https://doi.org/10.1111/j.1365-2958.1995.tb02397.x.
Boos W, Shuman H. Maltose/Maltodextrin system of Escherichia coli: transport, metabolism, and regulation. Microbiol Mol Biol Rev. 1998;62:204–29.
Notley-McRobb L, Ferenci T. Adaptive mgl-regulatory mutations and genetic diversity evolving in glucose-limited Escherichia coli populations. Environ Microbiol. 1999;1:33–43.
Wackwitz B, Bongaerts J, Goodman SD, Unden G. Growth phase-dependent regulation of nuoA-N expression in Escherichia coli K-12 by the Fis protein: upstream binding sites and bioenergetic significance. Mol Gen Genet. 1999;262:876–83.
Tramonti A, De Canio M, Delany I, Scarlato V, De Biase D. Mechanisms of transcription activation exerted by GadX and GadW at the gadA and gadBC gene promoters of the glutamate-based acid resistance system in Escherichia coli. J Bacteriol. 2006;188:8118–27.
Hernández-Montalvo V, Martínez A, Hernández-Chavez G, Bolivar F, Valle F, Gosset G. Expression of galP and glk in a Escherichia coli PTS mutant restores glucose transport and increases glycolytic flux to fermentation products. Biotechnol Bioeng. 2003;83:687–94.
Wada A, Yamazakit Y, Fujitat N, Ishihamatt A. Structure and probable genetic location of a “ribosome modulation factor” associated with 100S ribosomes in stationary-phase Escherichia coli cells (growth-dependent control/translation regulation/two-dimensional gel electrophoresis). Proc Nadl Acad Sci USA. 1990;87:2657–61.
Izutsu K, Wada C, Komine Y, Tomoyuki S, Ueguchi C, Nakura S, et al. Escherichia coli ribosome-associated protein SRA, whose copy number increases during stationary phase. J Bacteriol. 2001;183:2765–73.
Bougdour A, Gottesman S. ppGpp regulation of RpoS degradation via anti-adaptor protein IraP. PNAS. 2007.
Tremblay LW, Dunaway-Mariano D, Allen KN. Structure and activity analyses of Escherichia coli K-12 NagD provide insight into the evolution of biochemical function in the haloalkanoic acid dehalogenase superfamily. Biochemistry. 2006;45:1183–93. https://doi.org/10.1021/bi051842j.
Skretas G, Makino T, Varadarajan N, Pogson M, Georgiou G. Multi-copy genes that enhance the yield of mammalian G protein-coupled receptors in Escherichia coli. Metab Eng. 2012;14:591–602.
Semsey S, Krishna S, Sneppen K, Adhya S. Signal integration in the galactose network of Escherichia coli. Mol Microbiol. 2007;65:465–76.
Geanacopoulos M, Adhya S. Functional characterization of roles of GalR and GalS asRegulators of thegalRegulon. J Bacteriol. 1997. https://doi.org/10.1128/jb.179.1.228-234.1997.
Lastiri-Pancardo G, Mercado-Hernamp JS, Kim J, Jimamp I. A quantitative method for proteome reallocation using minimal regulatory interventions. Nat Chem Biol. 2020. https://doi.org/10.1038/s41589-020-0593-y.
Chou C, Bennett GN, Sari K. Effect of modified glucose uptake using genetic engineering techniques on high-level recombinant protein production in escherichia coli dense cultures. Biotechnol Adv. 1994;44:952–60.
Acknowledgements
The authors would like to thank Georgina Hernández-Chávez, Luz María Martínez, Juan Manuel Hurtado and Ricardo Ciria Merce for their technical support.
Funding
This work was supported by CONACyT grant A1-S-8646. JCFJ was supported by a fellowship from CONACyT.
Author information
Authors and Affiliations
Contributions
GG and JCFJ designed research, JCFJ performed microbial cultures and RNA-seq experiments, NM performed qPCR experiments, JCFJ, RMGR, ARL, FD, GG, and AM analyzed data, JCFJ, RMGR, ARL, FD, GG, and AM wrote the manuscript. All authors read and approved the final manuscript.
Corresponding author
Ethics declarations
Ethics approval and consent to participate
Not applicable.
Consent for publication
Not applicable.
Competing interests
The authors declare no competing financial interest.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary Information
Additional file 1:
Figure S1 Growth kinetics of strains W3110, WG, WGM, WGMC, and WHIC. Glucose concentration (triangles), biomass concentration (squares) and acetate concentration (diamonds).
Additional file 2:
Figure S2 Venn diagram representing the number of unique and overlapping genes among strain transcriptome comparisons. Comparisons WG-W3110, WGM-WG, and WHIC-WGMC were tagged as A, B, and C, respectively. The WGMC-WGM comparison was excluded from this analysis.
Additional file 3:
Supplementary table 1 Primers used in this study.
Additional file 4:
Supplementary table 2 List of differentially expressed genes when comparing the transcriptome of W3110 with those of the mutant strains.
Additional file 5:
Supplementary table 3 List of differentially expressed genes when performing pair-wise comparison of transcriptomes from strain in this study.
Additional file 6:
Supplementary table 5 List of genes displaying a positive correlation of expression with the specific rate of glucose consumption.
Additional file 7
: Supplementary table 5 List of genes displaying a negative correlation of expression with the specific rate of glucose consumption.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated in a credit line to the data.
About this article
Cite this article
Fragoso-Jiménez, J.C., Gutierrez-Rios, R.M., Flores, N. et al. Glucose consumption rate-dependent transcriptome profiling of Escherichia coli provides insight on performance as microbial factories. Microb Cell Fact 21, 189 (2022). https://doi.org/10.1186/s12934-022-01909-y
Received:
Accepted:
Published:
DOI: https://doi.org/10.1186/s12934-022-01909-y