Abstract—The estimation of the magnetic properties of the amorphous alloys Fe–P–Si and Fe–P–Si–Mn–V–C fabricated from naturally alloyed ferrophosphorus and a 2NSR-type alloy (Fe–Ni–Si–B–Nb–Cu) shows that they are comparable in saturation induction and coercive force. However, the materials made of ferrophosphorus have a lower cost and can be used as ferrocomposite materials.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
REFERENCES
O. M. Guseva, S. A. Kirillov, and V. A. Semichev, “Soft magnetic ferrocomposites based on crystalline and amorphous powders,” (TsNII Elektronika, Moscow, 1990), Vol. 44, pp. 1–44.
B. A. Kornienkov and E. V. Artamonov, “Improvement of the magnetic properties of a 2NSR amorphous alloy,” Stal’, No. 6, 69–71 (2009).
B. A. Kornienkov and M. A. Libman, “Control of the magnetic properties of Fe–Ni–Si–B amorphous alloys by special-purpose treatment,” Stal’, No. 4, 73–75 (2011).
B. L. Levintov, L. A. Bashaeva, Yu. K. Kovneristyii, V. V. Vavilova, et al., “A charge for preparation of amorphous soft magnetic alloys,” RF Patent 2075871, Byull. Izobret., No. 8 (1997).
V. V. Vavilova, V. T. Zabolotnyi, V. P. Korneev, and M. O. Anosova, “Analysis of the character of phase equilibrium in the Fe–P–Si system, nanocrystallization of amorphous alloys, and the choice of optimum composition,” Russ. Metall. (Metally), No. 3, 228–236 (2015).
M. O. Anosova, Yu. V. Baldokhin, V. V. Vavilova, V. P. Korneev, and N. A. Palii, “Nanostructure forming in soft magnetic Fe–P–Si–Mn–V and Fe–P–Si–Mn–V–C alloys upon annealing,” Russ. Metall. (Metally), No. 3, 239–247 (2011).
V. V. Vavilova, Yu. V. Baldokhin, V. T. Zabolotnyi, M. O. Anosova, V. P. Korneev, and D. A. Gavrilov, “Changes in the structure and properties of an Fe–P–Si–Mn–V soft magnetic alloy in amorphous and relaxed states during corrosion in 0.1 M Na2SO4,” Neorg. Mater. 49 (1), 1201–1210 (2013).
J. Lacaze and B. Sundman, “An assessment of the Fe–C–Si system,” Met. Trans. A 22, 2211–2223 (1991).
Shan-Chang Chueh, “Computer calculations of metastable and stable Fe–C–Si phase diagrams from binary thermodynamic properties,” in Retrospective Theses and Dissertations (1986), p. 8065.
C. A. C. Souza, F. S. Politi, and C. S. Kiminami, “Influence of structural relaxation and partial devitrification on the corrosion resistance of Fe78B13Si9 amorphous alloy,” Scr. Mater. 39 (3), 329–334 (1998).
E. P. Yelsukov, A. N. Maratkanova, S. F. Lomayeva, G. N. Konygin, O. M. Nemtsova, A. I. Ul’yanov, and A. A. Chulkina, “Structure, phase composition and magnetic properties of mechanically alloyed and annealed quasibinary Fe(70)Si(x)C(30 – x) alloys,” J. Alloys Compd. 407 (1–2), 98–105 (2006).
M. Ellner and M. el Boragy, “Über die eisenhaltigen vertrefer das strukturtyps Pd5Sb2,” J. Alloys Compd. 184 (1), 131–138 (1992).
FUNDING
This work was performed in terms of state assignment 007-00129-18-00 and was supported by the Russian Foundation for Basic Research (project no. 17-03-01140).
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated by K. Shakhlevich
Rights and permissions
About this article
Cite this article
Kornienkov, B.A., Vavilova, V.V., Simakov, S.V. et al. Magnetic Properties of the Amorphous Fe–P–Si and Fe–P–Si–Mn–V–C Alloys Fabricated from Naturally Alloyed Ferrophosphorus and a 2NSR Alloy. Russ. Metall. 2019, 721–726 (2019). https://doi.org/10.1134/S0036029519070061
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S0036029519070061