Skip to main content

Advertisement

SpringerLink
Log in

Preparation and Characterization of Biomass Carbon–Based Solid Acid Catalysts for the Esterification of Marine Algae for Biodiesel Production

  • Published:
BioEnergy Research Aims and scope Submit manuscript

Abstract

Biomass carbon derived from rice husk (RH), Moringa oleifera seeds (MOR), and biomass of lipid extracted marine algae (BM) bearing sulfuric acid groups, were investigated for the potential application to environmental benign biodiesel production. The physiochemical characteristics of the biomass-derived catalysts were determined with Fourier transform infrared spectroscopy, Raman spectroscopy, scanning electron microscopy, and X-ray diffraction techniques. These studies confirmed the presence of sulfur-incorporated functional groups on the carbonaceous materials. The SO3H-RH demonstrates the amorphous structure and higher surface area that enhances the possibility to attach –SO3H group. The acid site density of the catalysts was measured by utilizing ion exchange titration. It was found that SO3H-RH-based catalyst carries the most prominent acid site density (4.24 mmol/g by NaOH titration) when compared to other prepared solid acid catalysts. However, by employing SO3H-RH and SO3H-BM, almost full quantitative yield of ester was achieved with a 5 wt% mixture of catalyst/lipid for a reaction time of 20 min at a 5:1 M ratio of methyl alcohol/lipid extract. Whereas, they outperform the conventionally used sulfuric acid catalyst that gave 70% yield after 2 h under the same reaction condition. The results proved that the SO3H-RH has highly porous carbon structure and greater surface area that prominently enhances the acid site density. Therefore, SO3H-RH displays relatively better catalytic activity and stability when used compared to other solid acid and a sulfuric acid catalyst. The solid acid catalysts prepared from low-cost raw materials show enhance catalytic performance at room temperature and suitable for biodiesel production applications.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8

Similar content being viewed by others

References

  1. Koh MY, Mohd Ghazi TI (2011) A review of biodiesel production from Jatropha curcas L. oil. Renew Sust Energ Rev 15:2240–2251. https://doi.org/10.1016/j.rser.2011.02.013

    Article  CAS  Google Scholar 

  2. Kandaramath Hari T, Yaakob Z, Binitha NN (2015) Aviation biofuel from renewable resources: routes, opportunities and challenges. Renew Sust Energ Rev 42:1234–1244. https://doi.org/10.1016/j.rser.2014.10.095

    Article  Google Scholar 

  3. Bilgen S (2014) Structure and environmental impact of global energy consumption. Renew Sust Energ Rev 38:890–902

    Article  CAS  Google Scholar 

  4. Martínez N, Callejas N, Morais EG, Vieira Costa JA, Jachmanián I, Vieitez I (2017) Obtaining biodiesel from microalgae oil using ultrasound-assisted in-situ alkaline transesterification. Fuel 202:512–519. https://doi.org/10.1016/j.fuel.2017.04.040

    Article  CAS  Google Scholar 

  5. Malins K, Kampars V, Kampare R, Prilucka J, Brinks J, Murnieks R, Apseniece L (2014) Properties of rapeseed oil fatty acid alkyl esters derived from different alcohols. Fuel 137:28–35. https://doi.org/10.1016/J.FUEL.2014.07.091

    Article  CAS  Google Scholar 

  6. Serqueira DS, Fernandes DM, Cunha RR, Squissato AL, Santos DQ, Richter EM, Munoz RAA (2014) Influence of blending soybean, sunflower, colza, corn, cottonseed, and residual cooking oil methyl biodiesels on the oxidation stability. Fuel 118:16–20. https://doi.org/10.1016/j.fuel.2013.10.028

    Article  CAS  Google Scholar 

  7. Mahmudul HM, Hagos FY, Mamat R, Adam AA, Ishak WFW, Alenezi R (2017) Production, characterization and performance of biodiesel as an alternative fuel in diesel engines – a review. Renew Sust Energ Rev 72:497–509. https://doi.org/10.1016/j.rser.2017.01.001

    Article  CAS  Google Scholar 

  8. Aguieiras ECG, de Barros DSN, Sousa H, Fernandez-Lafuente R, Freire DMG (2017) Influence of the raw material on the final properties of biodiesel produced using lipase from Rhizomucor miehei grown on babassu cake as biocatalyst of esterification reactions. Renew Energy 113:112–118. https://doi.org/10.1016/j.renene.2017.05.090

    Article  CAS  Google Scholar 

  9. Scott SA, Davey MP, Dennis JS, Horst I, Howe CJ, Lea-Smith DJ, Smith AG (2010) Biodiesel from algae: challenges and prospects. Curr Opin Biotechnol 21:277–286. https://doi.org/10.1016/j.copbio.2010.03.005

    Article  CAS  PubMed  Google Scholar 

  10. Nautiyal P, Subramanian KA, Dastidar MG (2014) Production and characterization of biodiesel from algae. Fuel Process Technol 120:79–88. https://doi.org/10.1016/j.fuproc.2013.12.003

    Article  CAS  Google Scholar 

  11. Vassilev SV, Vassileva CG (2016) Composition, properties and challenges of algae biomass for biofuel application: an overview. Fuel 181:1–33. https://doi.org/10.1016/j.fuel.2016.04.106

    Article  CAS  Google Scholar 

  12. Reyero I, Arzamendi G, Zabala S, Gandía LM (2015) Kinetics of the NaOH-catalyzed transesterification of sunflower oil with ethanol to produce biodiesel. Fuel Process Technol 129:147–155. https://doi.org/10.1016/j.fuproc.2014.09.008

    Article  CAS  Google Scholar 

  13. Correia LM, Saboya RMA, de Sousa Campelo N, Cecilia JA, Rodríguez-Castellón E, Cavalcante CL Jr, Vieira RS (2014) Characterization of calcium oxide catalysts from natural sources and their application in the transesterification of sunflower oil. Bioresour Technol 151:207–213. https://doi.org/10.1016/j.biortech.2013.10.046

    Article  CAS  PubMed  Google Scholar 

  14. Wang B, Li S, Tian S, Feng R, Meng Y (2013) A new solid base catalyst for the transesterification of rapeseed oil to biodiesel with methanol. Fuel 104:698–703. https://doi.org/10.1016/j.fuel.2012.08.034

    Article  CAS  Google Scholar 

  15. Casas A, Fernández CM, Ramos MJ, Pérez Á, Rodríguez JF (2010) Optimization of the reaction parameters for fast pseudo single-phase transesterification of sunflower oil. Fuel 89:650–658. https://doi.org/10.1016/J.FUEL.2009.08.004

    Article  CAS  Google Scholar 

  16. Zhang P, Liu Y, Fan M, Jiang P (2016) Catalytic performance of a novel amphiphilic alkaline ionic liquid for biodiesel production: influence of basicity and conductivity. Renew Energy 86:99–105. https://doi.org/10.1016/j.renene.2015.08.008

    Article  CAS  Google Scholar 

  17. Marinković DM, Stanković MV, Veličković AV, Avramović JM, Miladinović MR, Stamenković OO, Veljković VB, Jovanović DM (2016) Calcium oxide as a promising heterogeneous catalyst for biodiesel production: current state and perspectives. Renew Sust Energ Rev 56:1387–1408. https://doi.org/10.1016/j.rser.2015.12.007

    Article  CAS  Google Scholar 

  18. Guldhe A, Singh P, Ansari FA, Singh B, Bux F (2017) Biodiesel synthesis from microalgal lipids using tungstated zirconia as a heterogeneous acid catalyst and its comparison with homogeneous acid and enzyme catalysts. Fuel 187:180–188. https://doi.org/10.1016/j.fuel.2016.09.053

    Article  CAS  Google Scholar 

  19. Sun Z, Duan X, Zhao J, Wang X, Jiang Z (2015) Homogeneous borotungstic acid and heterogeneous micellar borotungstic acid catalysts for biodiesel production by esterification of free fatty acid. Biomass Bioenergy 76:31–42. https://doi.org/10.1016/j.biombioe.2015.03.002

    Article  CAS  Google Scholar 

  20. Sani YM, Daud WMAW, Abdul Aziz AR (2014) Activity of solid acid catalysts for biodiesel production: a critical review. Appl Catal A Gen 470:140–161. https://doi.org/10.1016/j.apcata.2013.10.052

    Article  CAS  Google Scholar 

  21. Mansir N, Taufiq-Yap YH, Rashid U, Lokman IM (2017) Investigation of heterogeneous solid acid catalyst performance on low grade feedstocks for biodiesel production: a review. Energy Convers Manag 141:171–182. https://doi.org/10.1016/j.enconman.2016.07.037

    Article  CAS  Google Scholar 

  22. Fu J, Chen L, Lv P, Yang L, Yuan Z (2015) Free fatty acids esterification for biodiesel production using self-synthesized macroporous cation exchange resin as solid acid catalyst. Fuel 154:1–8. https://doi.org/10.1016/j.fuel.2015.03.048

    Article  CAS  Google Scholar 

  23. Lokman IM, Rashid U, Taufiq-Yap YH, Yunus R (2015) Methyl ester production from palm fatty acid distillate using sulfonated glucose-derived acid catalyst. Renew Energy 81:347–354. https://doi.org/10.1016/j.renene.2015.03.045

    Article  CAS  Google Scholar 

  24. Lokman IM, Rashid U, Taufiq-Yap YH (2015) Production of biodiesel from palm fatty acid distillate using sulfonated-glucose solid acid catalyst: characterization and optimization. Chin J Chem Eng 23:1857–1864. https://doi.org/10.1016/j.cjche.2015.07.028

    Article  CAS  Google Scholar 

  25. Konwar LJ, Das R, Thakur AJ, Salminen E, Mäki-Arvela P, Kumar N, Mikkola JP, Deka D (2014) Biodiesel production from acid oils using sulfonated carbon catalyst derived from oil-cake waste. J Mol Catal A Chem 388–389:167–176. https://doi.org/10.1016/j.molcata.2013.09.031

    Article  CAS  Google Scholar 

  26. Konwar LJ, Wärnå J, Mäki-Arvela P, Kumar N, Mikkola JP (2016) Reaction kinetics with catalyst deactivation in simultaneous esterification and transesterification of acid oils to biodiesel (FAME) over a mesoporous sulphonated carbon catalyst. Fuel 166:1–11. https://doi.org/10.1016/j.fuel.2015.10.102

    Article  CAS  Google Scholar 

  27. Konwar LJ, Mäki-Arvela P, Salminen E, Kumar N, Thakur AJ, Mikkola JP, Deka D (2015) Towards carbon efficient biorefining: multifunctional mesoporous solid acids obtained from biodiesel production wastes for biomass conversion. Appl Catal B Environ 176–177:20–35. https://doi.org/10.1016/j.apcatb.2015.03.005

    Article  CAS  Google Scholar 

  28. Yu H, Niu S, Lu C, Li J, Yang Y (2017) Sulfonated coal-based solid acid catalyst synthesis and esterification intensification under ultrasound irradiation. Fuel 208:101–110. https://doi.org/10.1016/j.fuel.2017.06.122

    Article  CAS  Google Scholar 

  29. Mardhiah HH, Ong HC, Masjuki HH, Lim S, Pang YL (2017) Investigation of carbon-based solid acid catalyst from Jatropha curcas biomass in biodiesel production. Energy Convers Manag 144:10–17. https://doi.org/10.1016/j.enconman.2017.04.038

    Article  CAS  Google Scholar 

  30. González ME, Cea M, Reyes D, Romero-Hermoso L, Hidalgo P, Meier S, Benito N, Navia R (2017) Functionalization of biochar derived from lignocellulosic biomass using microwave technology for catalytic application in biodiesel production. Energy Convers Manag 137:165–173. https://doi.org/10.1016/j.enconman.2017.01.063

    Article  CAS  Google Scholar 

  31. Touhami D, Zhu Z, Balan WS, Janaun J, Haywood S, Zein S (2017) Characterization of rice husk-based catalyst prepared via conventional and microwave carbonisation. J Environ Chem Eng 5:2388–2394. https://doi.org/10.1016/J.JECE.2017.04.020

    Article  CAS  Google Scholar 

  32. Ravikovitch PI, Haller GL, Neimark AV (1998) Density functional theory model for calculating pore size distributions: pore structure of nanoporous catalysts. Adv Colloid Interf Sci 76–77:203–226. https://doi.org/10.1016/S0001-8686(98)00047-5

    Article  Google Scholar 

  33. Lastoskie C, Gubbins KE, Quirkeft$ N (1993) Pore size distribution analysis of microporous carbons: a density functional theory approach. J Phys Chem 97:4786–4796

    Article  CAS  Google Scholar 

  34. Vadery V, Narayanan BN, Ramakrishnan RM, Cherikkallinmel SK, Sugunan S, Narayanan DP, Sasidharan S (2014) Room temperature production of jatropha biodiesel over coconut husk ash. Energy 70:588–594. https://doi.org/10.1016/j.energy.2014.04.045

    Article  CAS  Google Scholar 

  35. Bhunia S, Banerjee B, Bhaumik A (2015) A new hypercrosslinked supermicroporous polymer, with scope for sulfonation, and its catalytic potential for the efficient synthesis of biodiesel at room temperature. Chem Commun 51:5020–5023. https://doi.org/10.1039/C4CC09872B

    Article  CAS  Google Scholar 

  36. Piker A, Tabah B, Perkas N, Gedanken A (2016) A green and low-cost room temperature biodiesel production method from waste oil using egg shells as catalyst. Fuel 182:34–41. https://doi.org/10.1016/j.fuel.2016.05.078

    Article  CAS  Google Scholar 

  37. Bai Y-Y, Xiao L-P, Sun R-C (2015) Microwave-assisted conversion of biomass derived hemicelluloses into xylo-oligosaccharides by novel sulfonated bamboo-based catalysts. Biomass Bioenergy 75:245–253. https://doi.org/10.1016/J.BIOMBIOE.2015.02.023

    Article  CAS  Google Scholar 

  38. Chen G, Fang B (2011) Preparation of solid acid catalyst from glucose-starch mixture for biodiesel production. Bioresour Technol 102:2635–2640. https://doi.org/10.1016/j.biortech.2010.10.099

    Article  CAS  PubMed  Google Scholar 

  39. Shu Q, Gao J, Nawaz Z, Liao Y, Wang D, Wang J (2010) Synthesis of biodiesel from waste vegetable oil with large amounts of free fatty acids using a carbon-based solid acid catalyst. Appl Energy 87:2589–2596. https://doi.org/10.1016/j.apenergy.2010.03.024

    Article  CAS  Google Scholar 

  40. Hara M (2010) Biodiesel production by amorphous carbon bearing SO3H, COOH and phenolic OH groups, a solid Brønsted acid catalyst. Top Catal 53:805–810. https://doi.org/10.1007/s11244-010-9458-z

    Article  CAS  Google Scholar 

  41. Zhou L, Lin X, Huang T, Yu A (2014) Binder-free phenyl sulfonated graphene/sulfur electrodes with excellent cyclability for lithium sulfur batteries. J Mater Chem A 2:5117. https://doi.org/10.1039/c3ta15175a

    Article  CAS  Google Scholar 

  42. Brahmayya M, Dai SA, Suen S-Y (2017) Sulfonated reduced graphene oxide catalyzed cyclization of hydrazides and carbon dioxide to 1,3,4-oxadiazoles under sonication. Sci Rep 7(4675):4675. https://doi.org/10.1038/s41598-017-04143-4

    Article  CAS  PubMed  PubMed Central  Google Scholar 

  43. Dawodu FA, Ayodele O, Xin J, Zhang S, Yan D (2014) Effective conversion of non-edible oil with high free fatty acid into biodiesel by sulphonated carbon catalyst. Appl Energy 114:819–826. https://doi.org/10.1016/j.apenergy.2013.10.004

    Article  CAS  Google Scholar 

  44. Liu T, Li Z, Li W, Shi C, Wang Y (2013) Preparation and characterization of biomass carbon-based solid acid catalyst for the esterification of oleic acid with methanol. Bioresour Technol 133:618–621. https://doi.org/10.1016/j.biortech.2013.01.163

    Article  CAS  PubMed  Google Scholar 

  45. Yang J, Li G, Zhang L, Zhang S (2018) Efficient production of N-butyl levulinate fuel additive from levulinic acid using amorphous carbon enriched with oxygenated groups. Catalysts 8:14. https://doi.org/10.3390/catal8010014

    Article  CAS  Google Scholar 

  46. Okamura M, Takagaki A, Toda M, Kondo JN, Domen K, Tatsumi T, Hara M, Hayashi S (2006) Acid-catalyzed reactions on flexible polycyclic aromatic carbon in amorphous carbon. Chem Mater 18:3039–3045. https://doi.org/10.1021/cm0605623

    Article  CAS  Google Scholar 

  47. Lou W-Y, Zong M-H, Duan Z-Q (2008) Efficient production of biodiesel from high free fatty acid-containing waste oils using various carbohydrate-derived solid acid catalysts. Bioresour Technol 99:8752–8758. https://doi.org/10.1016/j.biortech.2008.04.038

    Article  CAS  PubMed  Google Scholar 

  48. Poonjarernsilp C, Sano N, Tamon H (2014) Hydrothermally sulfonated single-walled carbon nanohorns for use as solid catalysts in biodiesel production by esterification of palmitic acid. Appl Catal B Environ 147:726–732. https://doi.org/10.1016/J.APCATB.2013.10.006

    Article  CAS  Google Scholar 

Download references

Funding

The authors received financial support from the Deanship of Scientific Research at King Fahd University of Petroleum and Minerals through an undergraduate student research project grant no. USRG -1701.

Author information

Authors and Affiliations

  1. Department of Chemistry, King Fahd University of Petroleum and Minerals, Dhahran, 31261, Saudi Arabia

    Azeem Rana, Mohammed S. M. Alghazal, Mohammed M. Alsaeedi, Rashed S. Bakdash, Chanbasha Basheer & Abdulaziz A. Al-Saadi

Authors
  1. Azeem Rana
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Mohammed S. M. Alghazal
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Mohammed M. Alsaeedi
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Rashed S. Bakdash
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Chanbasha Basheer
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Abdulaziz A. Al-Saadi
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Chanbasha Basheer.

Additional information

Publisher’s Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Electronic Supplementary Material

ESM 1

(DOCX 155 kb)

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Rana, A., Alghazal, M.S.M., Alsaeedi, M.M. et al. Preparation and Characterization of Biomass Carbon–Based Solid Acid Catalysts for the Esterification of Marine Algae for Biodiesel Production. Bioenerg. Res. 12, 433–442 (2019). https://doi.org/10.1007/s12155-019-9965-0

Download citation

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s12155-019-9965-0

Keywords

Search

Navigation