Abstract
Thermal diodes are a novel method to rectify the heat transfer mechanism and help reduce heat losses in solar thermal collectors during non-collection periods. The current study introduces and analyzes a new planar thermal diode integrated collector storage (ICS) solar water heating system using an experimental approach. This thermal diode ICS system has a simple, affordable structure composed of two parallel plates. Water serves as a phase change material to transfer heat through evaporation and condensation inside the diode. Three scenarios were considered to assess the dynamics of the thermal diode ICS: atmospheric pressure, depressurized thermal diodes, and Ppartial = 0, − 0.2, and − 0.4 bar. The water temperature reached 40 °C, 46 °C, and 42 °C in Ppartial = 0, − 0.2, and − 0.4 bar, respectively. The heat gain coefficients are 38.61, 40.65, and 39.26 W/K, while the heat loss coefficients are 9.56, 5.16, and 7.03 W/K in Ppartial = 0, − 0.2, and − 0.4 bar, respectively. The optimum heat collection and retention efficiencies are 45.3% and 33.5% in Ppartial = − 0.2 bar. Hence, there is an optimum partial pressure to achieve the best performance, equal to − 0.2 bar. The acquired results illustrate the robustness of the planar thermal diode in reducing heat losses and rectifying the heat transfer mechanism. Furthermore, despite the simple structure of the planar thermal diode, its efficiency is as high as that of other types of thermal diodes analyzed in recent studies.
Similar content being viewed by others
Data availability
The data is available with authors and available on reasonable request.
Abbreviations
- A c :
-
Collector area, m2
- c p :
-
Specific heat, J/kg. K
- G :
-
Solar irradiation heat flux, W/m2
- m :
-
Mass, kg
- Q :
-
Heat gain, J
- R :
-
Independent parameter
- R t :
-
Thermal resistance, K/W
- T :
-
Temperature, °C
- ∆t :
-
Time period, s
- U :
-
Thermal heat transfer coefficient, W/K
- U C :
-
Heat gain coefficient, W/K
- U L :
-
Heat loss coefficient, W/K
- w R :
-
Uncertainty associated with dependent parameter
- w x :
-
Uncertainty associated with independent parameter
- η :
-
Efficiency
- amb :
-
Ambient
- coll :
-
Collection
- f :
-
Final
- i :
-
Initial
- in :
-
Incoming
- ret :
-
Retention
- w :
-
Water
References
Ahmed SF, Khalid M, Vaka M, Walvekar R, Numan A, Rasheed AK, Mubarak NM (2021) Recent progress in solar water heaters and solar collectors: a comprehensive review. Therm Sci Eng Prog 25:100981
Baig W, Ali HM (2019) An experimental investigation of performance of a double pass solar air heater with foam aluminum thermal storage medium. Case Stud Therm Eng 14:100440
Bamisile O, Olagoke O, Dagbasi M, Dika F, Okwesi B (2019) Review of solar assisted HVAC systems; its performance analysis using CO2 as a refrigerant. Energy Sources, Part a: Recov, Util Environ Eff 41(24):2957–2974
Bergman TL, Bergman TL, Incropera FP, Dewitt DP, Lavine AS (2011) Fundamentals of heat and mass transfer. John Wiley & Sons, New York
Esen M (2000) Thermal performance of a solar-aided latent heat store used for space heating by heat pump. Sol Energy 69(1):15–25
Esen M (2004) Thermal performance of a solar cooker integrated vacuum-tube collector with heat pipes containing different refrigerants. Sol Energy 76(6):751–757
Esen M, Ayhan T (1996) Development of a model compatible with solar assisted cylindrical energy storage tank and variation of stored energy with time for different phase change materials. Energy Convers Manag 37(12):1775–1785
Esen M, Esen H (2005) Experimental investigation of a two-phase closed thermosyphon solar water heater. Sol Energy 79(5):459–468
Esen M, Yuksel T (2013) Experimental evaluation of using various renewable energy sources for heating a greenhouse. Energy Build 65:340–351
Esen M, Durmuş A, Durmuş A (1998) Geometric design of solar-aided latent heat store depending on various parameters and phase change materials. Sol Energy 62(1):19–28
Esen M, Hazar H, Esen H (2005) Experimental investigation of a solar cooker using collector with heat pipes. Sigma J Eng Nat Sci 23(1):114–122
Esen H, Esen M, Ozsolak O (2017) Modelling and experimental performance analysis of solar-assisted ground source heat pump system. J Exp Theor Artif Intell 29(1):1–17
Farzan H (2019) The study of thermostat impact on energy consumption in a residential building by using TRNSYS. J Renew Energy Environ 6(1):15–20
Farzan H, Zaim EH, Amiri T (2022) Performance investigation on a new solar air heater using phase change material/expanded metal mesh composite as heat storage unit: an experimental study. J Energy Storage 47:103602
Garnier C, Muneer T, Currie J (2018) Numerical and empirical evaluation of a novel building integrated collector storage solar water heater. Renew Energy 126:281–295
Harrabi I, Hamdi M, Hazami M (2022) Potential of simple and hybrid nanofluid enhancement in performances of a flat plate solar water heater under a typical North-African climate (Tunisia). Environ Sci Pollut Res 30(12):35366–35383
He Y, Kou F, Wang X, Zhu N, Song Y, Chu Y, Shi S, Liu M, Chen X (2022) Hybrid model combining multivariate regression and machine learning for the rapid prediction of interior temperatures affected by thermal diodes and solar cavities. Build Environ 211:108723
Khalifa A-JN (1999) Thermal performance of locally made flat plate solar collectors used as part of a domestic hot water system. Energy Convers Manag 40(17):1825–1833
Kline SJ (1953) Describing uncertainty in single sample experiments. Mech Eng 75:3–8
Kumar R, Kharub M, Sharma R, Hrisheekesha PN, Goel V, Bhattacharyya S, Tyagi VV (2022) A novel design for solar collector used for water heating application having nanofluid as working medium: CFD modeling and simulation. Environ Sci Pollut Res 30(2): 3942–3952
Messaouda A, Hamdi M, Hazami M, Guizani AA (2020) Analysis of an integrated collector storage system with vacuum glazing and compound parabolic concentrator. Appl Therm Eng 169:114958
Muhumuza R, Zacharopoulos A, Mondol JD, Smyth M, Pugsley A (2019a) Experimental study of heat retention performance of thermal diode integrated collector storage solar water heater (ICSSWH) configurations. Sustain Energy Technol Assess 34:214–219
Muhumuza R, Zacharopoulos A, Mondol JD, Smyth M, Pugsley A, Giuzio GF, Kurmis D (2019b) Experimental investigation of horizontally operating thermal diode solar water heaters with differing absorber materials under simulated conditions. Renew Energy 138:1051–1064
Nahar N (2002) Capital cost and economic viability of thermosyphonic solar water heaters manufactured from alternate materials in India. Renew Energy 26(4):623–635
Panahi R, Khanjanpour MH, Javadi AA, Akrami M, Rahnama M, Ameri M (2019) Analysis of the thermal efficiency of a compound parabolic integrated collector storage solar water heater in Kerman. Iran Sustain Energy Technol Assess 36:100564
Pandey KM, Chaurasiya R (2017) A review on analysis and development of solar flat plate collector. Renew Sustain Energy Rev 67:641–650
Pugsley A, Zacharopoulos A, Mondol JD, Smyth M (2019) Theoretical and experimental analysis of a horizontal planar liquid-vapour thermal diode (PLVTD). Int J Heat Mass Transf 144:118660
Pugsley A, Zacharopoulos A, Mondol JD, Smyth M (2020a) BIPV/T facades–a new opportunity for integrated collector-storage solar water heaters? Part 1: State-of-the-art, theory and potential. Sol Energy 207:317–335
Pugsley A, Zacharopoulos A, Mondol JD, Smyth M (2020b) Vertical planar liquid-vapour thermal diodes (PLVTD) and their application in building façade energy systems. Appl Therm Eng 179:115641
Rao YA, Somwanshi A (2022) A comprehensive review on integrated collector-storage solar water heaters. Mater Today: Proceedings
Said Z, Ghodbane M, Tiwari AK, Ali HM, Boumeddane B, Ali ZM (2021) 4E (energy, exergy, economic, and environment) examination of a small LFR solar water heater: an experimental and numerical study. Case Stud Therm Eng 27:101277
Sajawal M, Rehman T-U, Ali HM, Sajjad U, Raza A, Bhatti MS (2019) Experimental thermal performance analysis of finned tube-phase change material based double pass solar air heater. Case Stud Therm Eng 15:100543
Shah SMK, Rasheed TU, Ali HM (2022) Smart integrated decentralization strategies of solar power system in buildings. Int J Photoenergy 2022:1–14
Sharma DK, Sharma D, Ali AHH (2022) Energy, exergy, environmental impact, and economic analyses of evacuated tube compound parabolic concentrator–powered solar thermal domestic water heating system. Environ Sci Pollut Res 29(54):82390–82410
Singh R, Lazarus IJ, Souliotis M (2016) Recent developments in integrated collector storage (ICS) solar water heaters: a review. Renew Sustain Energy Rev 54:270–298
Smyth M, Eames P, Norton B (2004) Techno-economic appraisal of an integrated collector/storage solar water heater. Renew Energy 29(9):1503–1514
Smyth M, Quinlan P, Mondol J, Zacharopoulos A, McLarnon D, Pugsley A (2017) The evolutionary thermal performance and development of a novel thermal diode pre-heat solar water heater under simulated heat flux conditions. Renew Energy 113:1160–1167
Smyth M, Quinlan P, Mondol JD, Zacharopoulos A, McLarnon D, Pugsley A (2018) The experimental evaluation and improvements of a novel thermal diode pre-heat solar water heater under simulated solar conditions. Renew Energy 121:116–122
Smyth M, Pugsley A, Hanna G, Zacharopoulos A, Mondol J, Besheer A, Savvides A (2019) Experimental performance characterisation of a hybrid photovoltaic/solar thermal façade module compared to a flat integrated collector storage solar water heater module. Renew Energy 137:137–143
Smyth M, Barone G, Buonomano A, Forzano C, Giuzio GF, Palombo A, Mondol J, Muhumuza R, Pugsley A, Zacharopoulos A (2020a) Modelling and experimental evaluation of an innovative integrated collector storage solar water heating (ICSSWH) prototype. Renew Energy 157:974–986
Smyth M, Mondol JD, Muhumuza R, Pugsley A, Zacharopoulos A, McLarnon D, Forzano C, Buonomano A, Palombo A (2020b) Experimental characterisation of different hermetically sealed horizontal, cylindrical double vessel integrated collector storage solar water heating (ICSSWH) prototypes. Sol Energy 206:695–707
Souliotis M, Chemisana D, Caouris Y, Tripanagnostopoulos Y (2013) Experimental study of integrated collector storage solar water heaters. Renew Energy 50:1083–1094
Souliotis M, Papaefthimiou S, Caouris YG, Zacharopoulos A, Quinlan P, Smyth M (2017) Integrated collector storage solar water heater under partial vacuum. Energy 139:991–1002
Tripanagnostopoulos Y, Souliotis M (2004) ICS solar systems with horizontal cylindrical storage tank and reflector of CPC or involute geometry. Renew Energy 29(1):13–38
Wong MY, Traipattanakul B, Tso C, Chao CY, Qiu H (2019) Experimental and theoretical study of a water-vapor chamber thermal diode. Int J Heat Mass Transf 138:173–183
Author information
Authors and Affiliations
Contributions
Hadi Farzan: conceptualization, data curation, resources, methodology, investigation, writing—review and editing, visualization, and formal analysis. Mohammad Javad Yousefelahi: data curation and investigation.
Corresponding author
Ethics declarations
Ethics approval
Authors consciously assure that the manuscript is an original work and follows the ethical standards of research.
Consent to participate
Not applicable.
Consent for publication
All authors give consent to publish.
Competing interests
The authors declare no competing interests.
Additional information
Responsible Editor: Philippe Garrigues
Publisher's note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Farzan, H., Yousefelahi, M.J. Study on collection and retention efficiencies of a new integrated collector storage solar water heating system using a planar thermal diode: an experimental study. Environ Sci Pollut Res 30, 75141–75155 (2023). https://doi.org/10.1007/s11356-023-27700-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-023-27700-z