Abstract
Pesticide residues in water can cause varying degrees of damage to the ecological system and human health, attracting widespread attention. During this research, a cost-effective, easily synthesized, and high surface area mesoporous poly (melamine–formaldehyde) (mPMF) was employed as an adsorbent to effectively absorb forchlorfenuron (CPPU) pesticide from water. The maximum adsorption capacity and maximum adsorption effectiveness were found to be 231.43 mg/g and 81%, respectively. The study of adsorption kinetics revealed that the adsorption mechanism conforms to a quasi-second-order kinetic model, indicating that chemical adsorption predominates, and the overall adsorption process is influenced by two or more factors. The adsorption isotherm experiment demonstrated that the adsorption mechanism is better described by the Freundlich model, suggesting that mPMF exhibits multi-layer heterogeneous adsorption of CPPU, involving both physical and chemical adsorption mechanisms. Additionally, mPMF showed the potential for cyclic regeneration through desorption after adsorbing CPPU from water, as its adsorption capacity remained largely unaffected even after four consecutive cycles.
Similar content being viewed by others
Data Availability
The data supporting the findings of this study are available within the paper. Should any raw data files be needed in another format, they are available from the corresponding author upon reasonable request.
References
Abilarasu, A., Kumar, P. S., Vo, D.-V.N., Krithika, D., Ngueagni, P. T., Joshiba, G. J., et al. (2021). Enhanced photocatalytic degradation of diclofenac by Sn0.15Mn0.85Fe2O4 catalyst under solar light. Journal of Environmental Chemical Engineering, 9(1), 104875. https://doi.org/10.1016/j.jece.2020.104875
Boruah, P. K., Sharma, B., Hussain, N., & Das, M. R. (2017). Magnetically recoverable Fe3O4/graphene nanocomposite towards efficient removal of triazine pesticides from aqueous solution: Investigation of the adsorption phenomenon and specific ion effect. Chemosphere, 168, 1058–1067. https://doi.org/10.1016/j.chemosphere.2016.10.103
Bu, Q., Wang, X., Xie, H., Zhong, K., Wu, Y., Zhang, J., et al. (2019). 180 day repeated-dose toxicity study on forchlorfenuron in Sprague-Dawley rats and its effects on the production of steroid hormones. Journal of Agricultural and Food Chemistry, 67(36), 10207–10213. https://doi.org/10.1021/acs.jafc.9b03855
Cheng, Y., Nie, J., Li, Z., Yan, Z., Xu, G., Li, H., & Guan, D. (2017). A molecularly imprinted polymer synthesized using β-cyclodextrin as the monomer for the efficient recognition of forchlorfenuron in fruits. Analytical and Bioanalytical Chemistry, 409(21), 5065–5072. https://doi.org/10.1007/s00216-017-0452-1
Chowdhury, S., Mishra, R., Saha, P., & Kushwaha, P. (2011). Adsorption thermodynamics, kinetics and isosteric heat of adsorption of malachite green onto chemically modified rice husk. Desalination, 265(1–3), 159–168. https://doi.org/10.1016/j.desal.2010.07.047
Cosgrove, S., Jefferson, B., & Jarvis, P. (2019). Pesticide removal from drinking water sources by adsorption: A review. Environmental Technology Reviews, 8(1), 1–24. https://doi.org/10.1080/21622515.2019.1593514
Costa, J. A. S., De Jesus, R. A., Santos, D. O., Mano, J. F., Romão, L. P. C., & Paranhos, C. M. (2020). Recent progresses in the adsorption of organic, inorganic, and gas compounds by MCM-41-based mesoporous materials. Microporous and Mesoporous Materials, 291, 109698. https://doi.org/10.1016/j.micromeso.2019.109698
Day, G. S., Drake, H. F., Joseph, E. A., Bosch, M., Tan, K., Willman, J. A., et al. (2019). Improving alkylamine incorporation in porous polymer networks through dopant incorporation. Advanced Sustainable Systems, 3(12), 1900051. https://doi.org/10.1002/adsu.201900051
Deng, S., Chen, Y., Wang, D., Shi, T., Wu, X., Ma, X., et al. (2015). Rapid biodegradation of organophosphorus pesticides by Stenotrophomonas sp. G1. Journal of Hazardous Materials, 297, 17–24. https://doi.org/10.1016/j.jhazmat.2015.04.052
Diaw, P. A., Oturan, N., Seye, M. D. G., Coly, A., Tine, A., Aaron, J.-J., & Oturan, M. A. (2017). Oxidative degradation and mineralization of the phenylurea herbicide fluometuron in aqueous media by the electro-Fenton process. Separation and Purification Technology, 186, 197–206. https://doi.org/10.1016/j.seppur.2017.06.005
Drout, R. J., Robison, L., Chen, Z., Islamoglu, T., & Farha, O. K. (2019). Zirconium metal–organic frameworks for organic pollutant adsorption. Trends in Chemistry, 1(3), 304–317. https://doi.org/10.1016/j.trechm.2019.03.010
Duan, H., Hu, X., & Sun, Z. (2020). Magnetic zeolite imidazole framework material-8 as an effective and recyclable adsorbent for removal of ceftazidime from aqueous solution. Journal of Hazardous Materials, 384, 121406. https://doi.org/10.1016/j.jhazmat.2019.121406
Farag, Z. R., Friedrich, J. F., & Krüger, S. (2014). Adhesion promotion of thick fire-retardant melamine polymer dip-coatings at polyolefin surfaces by using plasma polymers. Journal of Adhesion Science and Technology, 28(21), 2113–2132. https://doi.org/10.1080/01694243.2014.943339
García-García, C. R., Parrón, T., Requena, M., Alarcón, R., Tsatsakis, A. M., & Hernández, A. F. (2016). Occupational pesticide exposure and adverse health effects at the clinical, hematological and biochemical level. Life Sciences, 145, 274–283. https://doi.org/10.1016/j.lfs.2015.10.013
Ghanbarlou, H., Nasernejad, B., Nikbakht Fini, M., Simonsen, M. E., & Muff, J. (2020). Synthesis of an iron-graphene based particle electrode for pesticide removal in three-dimensional heterogeneous electro-Fenton water treatment system. Chemical Engineering Journal, 395, 125025. https://doi.org/10.1016/j.cej.2020.125025
Gong, G., Kam, H., Tse, Y., & Lee, S. M. (2019). Cardiotoxicity of forchlorfenuron (CPPU) in zebrafish (Danio rerio) and H9c2 cardiomyocytes. Chemosphere, 235, 153–162. https://doi.org/10.1016/j.chemosphere.2019.06.027
Gong, G., Kam, H., Tse, Y., Giesy, J. P., Seto, S., & Lee, S. M. (2021). Forchlorfenuron (CPPU) causes disorganization of the cytoskeleton and dysfunction of human umbilical vein endothelial cells, and abnormal vascular development in zebrafish embryos. Environmental Pollution, 271, 115791. https://doi.org/10.1016/j.envpol.2020.115791
Hu, Q., Nelson, W. J., & Spiliotis, E. T. (2008). Forchlorfenuron alters mammalian septin assembly, organization, and dynamics. Journal of Biological Chemistry, 283(43), 29563–29571. https://doi.org/10.1074/jbc.M804962200
Ighalo, J. O., Adeniyi, A. G., & Adelodun, A. A. (2021). Recent advances on the adsorption of herbicides and pesticides from polluted waters: Performance evaluation via physical attributes. Journal of Industrial and Engineering Chemistry, 93, 117–137. https://doi.org/10.1016/j.jiec.2020.10.011
Isinkaralar, K. (2023a). Multi-component volatile organic compounds (VOCs) treatment nexus: High-performance of activated carbon derived from residual agroforestry biomass. International Journal of Environmental Science and Technology. https://doi.org/10.1007/s13762-023-05202-2
Isinkaralar, Kaan. (2023). Comparison of the gaseous benzene adsorption capacity by activated carbons from Fraxinus excelsior L. as a lignocellulosic residual. Chemical Papers, 77(10), 6111–6124. https://doi.org/10.1007/s11696-023-02925-x
Isinkaralar, K. (2023c). Improving the adsorption performance of non-polar benzene vapor by using lignin-based activated carbon. Environmental Science and Pollution Research, 30(50), 108706–108719. https://doi.org/10.1007/s11356-023-30046-1
Isinkaralar, K. (2023d). Adsorption of gaseous naphthalene on carbonaceous sorbent: Perspective of affecting factors. Biomass Conversion and Biorefinery. https://doi.org/10.1007/s13399-023-04755-z
Isinkaralar, K., Turkyilmaz, A., & Lakestani, S. (2023). Equilibrium study of benzene, toluene, ethylbenzene, and xylene (BTEX) from gas streams by black pine cones-derived activated carbon. Environmental Technology and Innovation, 31, 103209. https://doi.org/10.1016/j.eti.2023.103209
Ji, Y., Yang, X., Ji, Z., Zhu, L., Ma, N., Chen, D., et al. (2020). DFT-calculated IR spectrum amide I, II, and III band contributions of N -methylacetamide fine components. ACS Omega, 5(15), 8572–8578. https://doi.org/10.1021/acsomega.9b04421
Kim, K.-H., Kabir, E., & Jahan, S. A. (2017). Exposure to pesticides and the associated human health effects. Science of the Total Environment, 575, 525–535. https://doi.org/10.1016/j.scitotenv.2016.09.009
Li, J., Wang, H., Yuan, X., Zhang, J., & Chew, J. W. (2020a). Metal-organic framework membranes for wastewater treatment and water regeneration. Coordination Chemistry Reviews, 404, 213116. https://doi.org/10.1016/j.ccr.2019.213116
Li, P., Lu, Y., Cao, J., Li, M., Yang, C., & Yan, H. (2020b). Imidazolium ionic-liquid-modified phenolic resin for solid-phase extraction of thidiazuron and forchlorfenuron from cucumbers. Journal of Chromatography A, 1623, 461192. https://doi.org/10.1016/j.chroma.2020.461192
Lichtfouse, E., Morin-Crini, N., Fourmentin, M., Zemmouri, H., Do Carmo Nascimento, I. O., Queiroz, L. M., et al. (2019). Chitosan for direct bioflocculation of wastewater. Environmental Chemistry Letters, 17(4), 1603–1621. https://doi.org/10.1007/s10311-019-00900-1
Lv, Z., Zhao, D., Liang, C., Cui, J., Cai, Y., & Xu, S. (2015). Magnetically recoverable mesoporous melamine–formaldehyde nanoparticles as an efficient adsorbent for hexavalent chromium removal. RSC Advances, 5(102), 83788–83794. https://doi.org/10.1039/C5RA14439F
Ma, H., Xu, Z., Wang, W., Gao, X., & Ma, H. (2019). Adsorption and regeneration of leaf-based biochar for p -nitrophenol adsorption from aqueous solution. RSC Advances, 9(67), 39282–39293. https://doi.org/10.1039/C9RA07943B
Mansouriieh, N., Sohrabi, M. R., & Khosravi, M. (2016). Adsorption kinetics and thermodynamics of organophosphorus profenofos pesticide onto Fe/Ni bimetallic nanoparticles. International Journal of Environmental Science and Technology, 13(5), 1393–1404. https://doi.org/10.1007/s13762-016-0960-0
Mao, H., Tang, J., Day, G. S., Peng, Y., Wang, H., Xiao, X., et al. (2022). A scalable solid-state nanoporous network with atomic-level interaction design for carbon dioxide capture. Science Advances, 8(31), eabo6849. https://doi.org/10.1126/sciadv.abo6849
Mojiri, A., Andasht Kazeroon, R., & Gholami, A. (2019). Cross-linked magnetic chitosan/activated biochar for removal of emerging micropollutants from water: Optimization by the artificial neural network. Water, 11(3), 551. https://doi.org/10.3390/w11030551
Mondol, Md. M. H., & Jhung, S. H. (2021). Adsorptive removal of pesticides from water with metal–organic framework-based materials. Chemical Engineering Journal, 421, 129688. https://doi.org/10.1016/j.cej.2021.129688
Morales-Pérez, A. A., Arias, C., & Ramírez-Zamora, R.-M. (2016). Removal of atrazine from water using an iron photo catalyst supported on activated carbon. Adsorption, 22(1), 49–58. https://doi.org/10.1007/s10450-015-9739-8
Morin-Crini, N., Lichtfouse, E., Torri, G., & Crini, G. (2019). Applications of chitosan in food, pharmaceuticals, medicine, cosmetics, agriculture, textiles, pulp and paper, biotechnology, and environmental chemistry. Environmental Chemistry Letters, 17(4), 1667–1692. https://doi.org/10.1007/s10311-019-00904-x
Nethaji, S., Sivasamy, A., Thennarasu, G., & Saravanan, S. (2010). Adsorption of Malachite Green dye onto activated carbon derived from Borassus aethiopum flower biomass. Journal of Hazardous Materials, 181(1–3), 271–280. https://doi.org/10.1016/j.jhazmat.2010.05.008
Ponnuchamy, M., Kapoor, A., Senthil Kumar, P., Vo, D.-V.N., Balakrishnan, A., Mariam Jacob, M., & Sivaraman, P. (2021). Sustainable adsorbents for the removal of pesticides from water: A review. Environmental Chemistry Letters, 19(3), 2425–2463. https://doi.org/10.1007/s10311-021-01183-1
Rojas, S., & Horcajada, P. (2020). Metal–organic frameworks for the removal of emerging organic contaminants in water. Chemical Reviews, 120(16), 8378–8415. https://doi.org/10.1021/acs.chemrev.9b00797
Rubí-Juárez, H., Cotillas, S., Sáez, C., Cañizares, P., Barrera-Díaz, C., & Rodrigo, M. A. (2016). Removal of herbicide glyphosate by conductive-diamond electrochemical oxidation. Applied Catalysis b: Environmental, 188, 305–312. https://doi.org/10.1016/j.apcatb.2016.02.006
Salomón, Y. L., Georgin, J., Franco, D. S. P., Netto, M. S., Piccilli, D. G. A., Foletto, E. L., et al. (2022). Adsorption of atrazine herbicide from water by diospyros kaki fruit waste activated carbon. Journal of Molecular Liquids, 347, 117990. https://doi.org/10.1016/j.molliq.2021.117990
Shankar, A., Kongot, M., Saini, V. K., & Kumar, A. (2020). Removal of pentachlorophenol pesticide from aqueous solutions using modified chitosan. Arabian Journal of Chemistry, 13(1), 1821–1830. https://doi.org/10.1016/j.arabjc.2018.01.016
Sharma, D., & Awasthi, M. D. (2003). Behaviour of forchlorfenuron residues in grape, soil and water. Chemosphere, 50(5), 589–594. https://doi.org/10.1016/S0045-6535(02)00619-7
Tan, M. X., Sum, Y. N., Ying, J. Y., & Zhang, Y. (2013a). Mesoporous poly-melamine-formaldehyde polymer as a solid sorbent for toxic metal removal. Energy and Environmental Science, 6(11), 3254. https://doi.org/10.1039/c3ee42216j
Tan, M. X., Zhang, Y., & Ying, J. Y. (2013b). Mesoporous poly(melamine–formaldehyde) solid sorbent for carbon dioxide capture. Chemsuschem, 6(7), 1186–1190. https://doi.org/10.1002/cssc.201300107
Vacca, A., Mais, L., Mascia, M., Usai, E. M., & Palmas, S. (2020). Design of experiment for the optimization of pesticide removal from wastewater by photo-electrochemical oxidation with TiO2 nanotubes. Catalysts, 10(5), 512. https://doi.org/10.3390/catal10050512
Vieira, W. T., De Farias, M. B., Spaolonzi, M. P., Da Silva, M. G. C., & Vieira, M. G. A. (2020). Removal of endocrine disruptors in waters by adsorption, membrane filtration and biodegradation. A Review. Environmental Chemistry Letters, 18(4), 1113–1143. https://doi.org/10.1007/s10311-020-01000-1
Wagner, M., Andrew Lin, K.-Y., Oh, W.-D., & Lisak, G. (2021). Metal-organic frameworks for pesticidal persistent organic pollutants detection and adsorption – A mini review. Journal of Hazardous Materials, 413, 125325. https://doi.org/10.1016/j.jhazmat.2021.125325
Wang, K.-S., Lu, C.-Y., & Chang, S.-H. (2011). Evaluation of acute toxicity and teratogenic effects of plant growth regulators by Daphnia magna embryo assay. Journal of Hazardous Materials, 190(1–3), 520–528. https://doi.org/10.1016/j.jhazmat.2011.03.068
Wang, T., Ai, S., Zhou, Y., Luo, Z., Dai, C., Yang, Y., et al. (2018). Adsorption of agricultural wastewater contaminated with antibiotics, pesticides and toxic metals by functionalized magnetic nanoparticles. Journal of Environmental Chemical Engineering, 6(5), 6468–6478. https://doi.org/10.1016/j.jece.2018.10.014
Wang, M., Qiao, F., & Yan, H. (2021). A simple and benign protocol for the synthesis of a deep eutectic solvent-based hydrophilic molecularly imprinted resin in water for excellent selective molecular recognition in aqueous phase. Green Chemistry, 23(14), 5179–5188. https://doi.org/10.1039/D1GC00789K
Yin, J., Zhang, T., Schulman, E., Liu, D., & Meng, J. (2018). Hierarchical porous metallized poly-melamine-formaldehyde (PMF) as a low-cost and high-efficiency catalyst for cyclic carbonate synthesis from CO2 and epoxides. Journal of Materials Chemistry A, 6(18), 8441–8448. https://doi.org/10.1039/C8TA00625C
Yoon, J.-Y., Kim, J. E., Song, H. J., Oh, K. B., Jo, J. W., Yang, Y.-H., et al. (2021). Assessment of adsorptive behaviors and properties of grape pomace-derived biochar as adsorbent for removal of cymoxanil pesticide. Environmental Technology and Innovation, 21, 101242. https://doi.org/10.1016/j.eti.2020.101242
Zhou, F., Gao, L., Cui, S., Tian, J., Wang, T., Li, G., et al. (2023). Exploring the potential of magnetic persimmon tannins-based bio-adsorbent for Cd (II) ions removal from water: Experiment and DFT study. Journal of Water Process Engineering, 56, 104283. https://doi.org/10.1016/j.jwpe.2023.104283
Zhu, D., Ping, L., Shen, X., Hong, Y., Weng, Q., He, Q., et al. (2020). Effects of prepubertal exposure to forchlorfenuron through prenatal and postnatal gavage administration in developing Sprague-Dawley rats. Reproductive Toxicology, 98, 157–164. https://doi.org/10.1016/j.reprotox.2020.09.009
Zhu, M., Zhang, L., Chen, Y., You, N., & Shen, H. (2022). Nanocomposites of zirconia@activated carbon derived from a hazelnut shell for the adsorption of tetracyclines from water. Environmental Science: Water Research & Technology, 8(7), 1434–1443. https://doi.org/10.1039/D2EW00115B
Funding
This work was supported by the National Natural Science Foundation of China (No. 51961010) and the Guangxi Key Research and Development Program (Nos. Guike AB18281013 and Guike AB16380278).
Author information
Authors and Affiliations
Corresponding authors
Ethics declarations
Conflict of Interest
The authors declare no competing interests.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Wang, T., Yang, A., Zhang, J. et al. Mesoporous Poly (Melamine–Formaldehyde) Resin as an Efficient Adsorbent for the Removal of Forchlorfenuron Pesticide from Water. Water Air Soil Pollut 234, 775 (2023). https://doi.org/10.1007/s11270-023-06804-9
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s11270-023-06804-9