Skip to main content
SpringerLink
Log in

Antiwear Properties of Binary Ashless Blend of Phosphonium Ionic Liquids and Borate Esters in Partially Formulated Oil (No Zn)

  • Original Paper
  • Published:
Tribology Letters Aims and scope Submit manuscript

Abstract

In this study, interaction of ionic liquid (IL) and borate esters (SBs) as antiwear (AW) additives with steel surfaces in tribological contacts was examined using blends which contained no prior AW additives but all the other ingredients present in a fully formulated engine oil. In detail, low phosphorus oil blends were prepared by adding trihexyltetradecylphosphonium bis(2-ethylhexyl)phosphate (P_DEHP) at 700 ppm phosphorus and 2-methoxy-4,4,6-trimethyl-1,3,2-dioxaborinane or trimethoxyboroxine at 200 ppm boron treat rate to a partially formulated oil. The tribological properties of these novel ionic liquid (IL) additive and IL + SB additive mixtures were compared with those of zinc dialkyldithiophosphate (ZDDP) at equal phosphorus levels in the oil blends. Tribological experiments with a reciprocating cylinder on flat contact revealed that both P_DEHP and binary mixtures of P_DEHP + SB offer superior wear protection than ZDDP and the partially formulated oil without AW additives, expressed by a wear reduction of minimum 50%. X-ray absorption near edge structure spectroscopy (XANES) analysis revealed that tribologically formed films are primarily composed of calcium phosphate for oils with AW additives. The interaction of P_DEHP with SB results in additional boron oxide/boric acid and to some extent boron phosphate domains incorporated into the tribofilms.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8

Similar content being viewed by others

References

  1. Sharma, V., Doerr, N., Aswath, P.: Chemical-mechanical properties of tribofilms and its relation to ionic liquid chemistry. RSC Adv. 6, 22341–22356 (2016)

    Article  CAS  Google Scholar 

  2. Somers, A.E., Khemchandani, B., Howlett, P.C., Sun, J., MacFarlane, D.R., Forsyth, M.: Ionic liquids as antiwear additives in base oils: influence of structure on miscibility and antiwear performance for steel on aluminum. ACS Appl. Mater. Interfaces 5, 11544–11553 (2013)

    Article  CAS  Google Scholar 

  3. Anand, M., Hadfield, M., Viesca, J., Thomas, B., Battez, A.H., Austen, S.: Ionic liquids as tribological performance improving additive for in-service and used fully-formulated diesel engine lubricants. Wear 334, 67–74 (2015)

    Article  Google Scholar 

  4. Barnhill, W.C., Qu, J., Luo, H., Meyer, H.M., Ma, C., Chi, M., et al.: Phosphonium-organophosphate ionic liquids as lubricant additives: effects of cation structure on physicochemical and tribological characteristics. ACS Appl. Mater. Interfaces 6, 22585–22593 (2014)

    Article  CAS  Google Scholar 

  5. Pisarova, L., Gabler, C., Dörr, N., Pittenauer, E., Allmaier, G.: Thermo-oxidative stability and corrosion properties of ammonium based ionic liquids. Tribol. Int. 46, 73–83 (2012)

    Article  CAS  Google Scholar 

  6. Cai, M., Liang, Y., Yao, M., Xia, Y., Zhou, F., Liu, W.: Imidazolium ionic liquids as antiwear and antioxidant additive in poly (ethylene glycol) for steel/steel contacts. ACS Appl. Mater. Interfaces 2, 870–876 (2010)

    Article  CAS  Google Scholar 

  7. Minami, I.: Ionic liquids in tribology. Molecules 14, 2286–2305 (2009)

    Article  CAS  Google Scholar 

  8. Yu, B., Bansal, D.G., Qu, J., Sun, X., Luo, H., Dai, S., et al.: Oil-miscible and non-corrosive phosphonium-based ionic liquids as candidate lubricant additives. Wear. 289, 58–64 (2012)

    Article  CAS  Google Scholar 

  9. Gusain, R., Gupta, P., Saran, S., Khatri, O.P.: Halogen-free bis (imidazolium)/bis (ammonium)-di [bis (salicylato) borate] ionic liquids as energy efficient and environment-friendly lubricant additives. ACS Appl. Mater. Interfaces 6(17), 15318–15328 (2014)

    Article  CAS  Google Scholar 

  10. Qu, J., Luo, H., Chi, M., Ma, C., Blau, P.J., Dai, S., et al.: Comparison of an oil-miscible ionic liquid and ZDDP as a lubricant anti-wear additive. Tribol. Int. 71, 88–97 (2014)

    Article  CAS  Google Scholar 

  11. Totolin, V., Minami, I., Gabler, C., Brenner, J., Dörr, N.: Lubrication mechanism of phosphonium phosphate ionic liquid additive in alkylborane–imidazole complexes. Tribol. Lett. 53, 421–432 (2014)

    Article  CAS  Google Scholar 

  12. Qu, J., Blau, P.J., Dai, S., Luo, H., Meyer, H.M.: Ionic liquids as novel lubricants and additives for diesel engine applications. Tribol. Lett. 35, 181–189 (2009)

    Article  CAS  Google Scholar 

  13. Jiménez, A.E., Bermúdez, M.: Ionic liquids as lubricants of titanium–steel contact. Tribol. Lett. 33, 111–126 (2009)

    Article  Google Scholar 

  14. Jimenez, A., Bermudez, M.: Ionic liquids as lubricants of titanium–steel contact. Part 2: friction, wear and surface interactions at high temperature. Tribol. Lett. 37, 431–443 (2010)

    Article  CAS  Google Scholar 

  15. Kronberger, M., Pejaković, V., Gabler, C., Kalin, M.: (2012) How anion and cation species influence the tribology of a green lubricant based on ionic liquids. Proc. Inst. Mech. Eng. Part J. 226, 933–951

    Article  CAS  Google Scholar 

  16. Bermúdez, M., Jiménez, A., Sanes, J., Carrión, F.: Ionic liquids as advanced lubricant fluids. Molecules 14, 2888–2908 (2009)

    Article  Google Scholar 

  17. Sharma, V., Gabler, C., Doerr, N., Aswath, P.B.: Mechanism of tribofilm formation with P and S containing ionic liquids. Tribol. Int. 92, 353–364 (2015)

    Article  CAS  Google Scholar 

  18. González, R., Bartolomé, M., Blanco, D., Viesca, J., Fernández-González, A., Battez, A.H.: Effectiveness of phosphonium cation-based ionic liquids as lubricant additive. Tribol. Int. 98, 82–93 (2016)

    Article  Google Scholar 

  19. Sharma, V., Doerr, N., Erdemir, A., Aswath, P.: Interaction of phosphonium ionic liquids with borate esters at tribological interfaces. RSC Adv. 6, 53148–53161 (2016)

    Article  CAS  Google Scholar 

  20. Qu, J., Bansal, D.G., Yu, B., Howe, J.Y., Luo, H., Dai, S., et al.: Antiwear performance and mechanism of an oil-miscible ionic liquid as a lubricant additive. ACS Appl. Mater. Interfaces 4, 997–1002 (2012)

    Article  CAS  Google Scholar 

  21. Grocholski, B.: Additive explanation for anti-wear. Science. 348, 87–88 (2015)

    Google Scholar 

  22. Qu, J., Barnhill, W.C., Luo, H., Meyer, H.M., Leonard, D.N., Landauer, A.K., et al.: Synergistic effects between phosphonium-alkylphosphate ionic liquids and zinc dialkyldithiophosphate (ZDDP) as lubricant additives. Adv. Mater. 27, 4767–4774 (2015)

    Article  CAS  Google Scholar 

  23. Kasrai, M., Lennard, W.N., Brunner, R.W., Bancroft, G.M., Bardwell, J.A., Tan, K.H.: Sampling depth of total electron and fluorescence measurements in Si L- and K-edge absorption spectroscopy. Appl. Surf. Sci. 99, 303–312 (1996)

    Article  CAS  Google Scholar 

  24. Parekh, K., Chen, X., Aswath, P.B.: Synthesis of fluorinated ZDDP compounds. Tribol. Lett. 34, 141–153 (2009)

    Article  CAS  Google Scholar 

  25. Sharma, V., Erdemir, A., Aswath, P.B.: An analytical study of tribofilms generated by the interaction of ashless antiwear additives with ZDDP using XANES and nano-indentation. Tribol. Int. 82, 43–57 (2015)

    Article  CAS  Google Scholar 

  26. Sharma, V., Uy, D., Gangopadhyay, A., O’Neill, A., Paxton, W.A., Sammut, A., et al.: Structure and chemistry of crankcase and exhaust soot extracted from diesel engines. Carbon. 103, 327–338 (2016)

    Article  CAS  Google Scholar 

  27. Chen, X., Elsenbaumer, R.L., Aswath, P.B.: Synthesis and tribological behavior of ashless alkylphosphorofluoridothioates. Tribol. Int. 69, 114–124 (2013)

    Article  CAS  Google Scholar 

  28. Chen, X., Kim, B., Elsenbaumer, R., Aswath, P.B.: Synthesis and antiwear behavior of alkylthioperoxydiphosphates. Tribology 6(3), 121–133 (2012)

    CAS  Google Scholar 

  29. Nicholls, M., Najman, M.N., Zhang, Z., Kasrai, M., Norton, P.R., Gilbert, P.U.P.A.: The contribution of XANES spectroscopy to tribology. Can. J. Chem. 85, 816–830 (2007)

    Article  CAS  Google Scholar 

  30. Kim, B., Mourhatch, R., Aswath, P.B.: Properties of tribofilms formed with ashless dithiophosphate and zinc dialkyl dithiophosphate under extreme pressure conditions. Wear. 268, 579–591 (2010)

    Article  CAS  Google Scholar 

  31. Li, Y., Pereira, G., Lachenwitzer, A., Kasrai, M., Norton, P.R.: X-ray absorption spectroscopy and morphology study on antiwear films derived from ZDDP under different sliding frequencies. Tribol. Lett. 27, 245–253 (2007)

    Article  CAS  Google Scholar 

  32. Li, Y., Pereira, G., Kasrai, M., Norton, P.R.: Studies on ZDDP anti-wear films formed under different conditions by XANES spectroscopy, atomic force microscopy and 31P NMR. Tribol. Lett. 28, 319–328 (2007)

    Article  Google Scholar 

  33. Nicholls, M.A., Do, T., Bancroft, G.M., Norton, P.R., Kasrai, M., Capehart, T.W., et al.: Chemical and mechanical properties of ZDDP antiwear films on steel and thermal spray coatings studied by XANES spectroscopy and nanoindentation techniques. Tribol. Lett. 15(3), 241–248 (2003)

    Article  CAS  Google Scholar 

  34. Najman, M.N., Kasrai, M., Bancroft, G.M., Frazer, B.H., DeStatio, G.: The correlation of microchemical properties to antiwear (AW) performance in ashless thiophosphate oil additives. Tribol. Lett. 17(4), 811–822 (2004)

    Article  CAS  Google Scholar 

  35. Najman, M.N., Kasrai, M., Bancroft, G.M.: Chemistry of anti-wear films from ashless thiophosphate oil additives. Tribol. Lett. 17(2), 217–229 (2004)

    Article  CAS  Google Scholar 

  36. Najman, M., Kasrai, M., Michael Bancroft, G., Davidson, R.: Combination of ashless antiwear additives with metallic detergents: Interactions with neutral and overbased calcium sulfonates. Tribol. Int. 39, 342–355 (2006)

    Article  CAS  Google Scholar 

  37. Pereira, G., Munoz-Paniagua, D., Lachenwitzer, A., Kasrai, M., Norton, P.R., Capehart, T.W., et al.: A variable temperature mechanical analysis of ZDDP-derived antiwear films formed on 52100 steel. Wear 262, 461–470 (2007)

    Article  CAS  Google Scholar 

  38. Warren, O.L., Graham, J.F., Norton, P.R., Houston, J.E., Michalske, T.A.: Nanomechanical properties of films derived from zinc dialkyldithiophosphate. Tribol. Lett. 4, 189–198 (1998)

    Article  CAS  Google Scholar 

  39. Aswath, P., Chen, X., Sharma, V., Igartua, M.A., Pagano, F., Binder, W., et al.: (2013) Synergistic mixtures of ionic liquids with other ionic liquids and/or with ashless thiophosphates for antiwear and/or friction reduction applications. U.S. Patent Application No. 13/889,037

  40. Willermet, P.A., Dailey, D.P., Carter, R.O., Schmitz, P.J., Zhu, W., Bell, J.C., et al.: The composition of lubricant-derived surface layers formed in a lubricated cam/tappet contact, II. Effects of adding overbased detergent and dispersant to a simple ZDTP solution. Tribol. Int. 28(3), 163–175 (1995)

    Article  CAS  Google Scholar 

  41. Wan, Y., Suominen Fuller, M.L., Kasrai, M., Bancroft, G.M., Fyfe, K., Torkelson, J.R., et al.: Effects of detergent on the chemistry of tribofilms from ZDDP: studied by X-ray absorption spectroscopy and XPS. In: Dowson, D., Priest, M., Dalmaz, G., Lubrecht, A.A. (eds.) Tribology Series, vol. 40, pp. 155–166. Elsevier, Amsterdam (2002)

    Google Scholar 

  42. Kasrai, M., Fuller, M.S., Bancroft, G.M., Ryason, P.R.: X-ray absorption study of the effect of calcium sulfonate on antiwear film formation generated from neutral and basic ZDDPs: part 1—phosphorus species. Tribol. Trans. 46, 534–542 (2003)

    Article  CAS  Google Scholar 

  43. Yin, Z., Kasrai, M., Bancroft, G.M., Tan, K.H., Feng, X.: X-ray-absorption spectroscopic studies of sodium polyphosphate glasses. Phys. Rev. B 51, 742–750 (1995)

    Article  CAS  Google Scholar 

  44. Kasrai, M., Fleet, M.E., Muthupari, S., Li, D., Bancroft, G.: Surface modification study of borate materials from B K-edge X-ray absorption spectroscopy. Phys. Chem. Miner. 25, 268–272 (1998)

    Article  CAS  Google Scholar 

  45. Zhang, Z., Yamaguchi, E.S., Kasrai, M., Bancroft, G.M.: Interaction of ZDDP with borated dispersant using XANES and XPS. Tribol. Trans. 47, 527–536 (2004)

    Article  CAS  Google Scholar 

Download references

Acknowledgements

XANES experiments were conducted at the Canadian Light Source, Saskatoon, Saskatchewan, Canada that is supported by NSERC, NRC, CIHR and the University of Saskatchewan. Tribological tests were performed at Argonne National Laboratory and were supported by the U.S. Department of Energy, Office of Energy Efficiency and Renewable Energy, Office of Vehicle Technology under contract DE-AC02-06CH11357. Scanning probe microscopy experiments were conducted at Center for Characterization for Materials and Biology at The University of Texas at Arlington. This work was also supported by the “Austrian COMET-Program” in the frame of K2 XTribology (Project No. 849109).

Author information

Authors and Affiliations

  1. Materials Science and Engineering Department, University of Texas at Arlington, Arlington, TX, USA

    Vibhu Sharma & Pranesh B. Aswath

  2. AC2T research GmbH, Wiener Neustadt, Austria

    Nicole Dörr

  3. Argonne National Laboratory, Argonne, IL, USA

    Ali Erdemir

Authors
  1. Vibhu Sharma
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Nicole Dörr
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Ali Erdemir
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Pranesh B. Aswath
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Pranesh B. Aswath.

Additional information

Publisher’s Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Sharma, V., Dörr, N., Erdemir, A. et al. Antiwear Properties of Binary Ashless Blend of Phosphonium Ionic Liquids and Borate Esters in Partially Formulated Oil (No Zn). Tribol Lett 67, 42 (2019). https://doi.org/10.1007/s11249-019-1152-0

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1007/s11249-019-1152-0

Keywords

Search

Navigation