Abstract
The potential damage effect from fatigue on Zr bulk metallic glass alloys of Zr50Cu40Al10 at the eutectic point and Zr60Cu30Al10 away from the eutectic point (in atomic percent) is examined via the local atomic structure, which was obtained from the pair density function analysis of the synchrotron X-ray radiation and neutron data. Samples cut from the same rods were subjected to 104, 105, and 106 compression cycles ex situ, and the evidence for fatigue damage was investigated by comparing alloys before and after cyclic loading. Bond orientation was observed particularly in Zr50Cu40Al10, suggesting that fatigue damage occurs even in the elastic range, below the yield point, and during cyclic loading. The initiation of fatigue changes is observed first within small localized atomic regions.
Similar content being viewed by others
References
A. Inoue: Acta Mater., 2000, vol. 48, pp. 279-306.
A. Inoue and W. Zhang: Mater. Trans. JIM, 2004, vol. 45, pp. 1210-13.
J.J. Wall, C. Fan, P.K. Liaw, C.T. Liu, and H. Choo: Rev. Scient. Instr., 2006, vol. 77, p. 033902.
C. Fan, H.Q. Li, L.J. Kecskes, K.X. Tao, H. Choo, P.K. Liaw, and C.T. Liu: Phys. Rev. Lett., 2006, vol. 96, p. 145506.
H.Q. Li, C. Fan, K.X. Tao, H. Choo, and P.K. Liaw: Adv. Mater., 2006, vol. 18, pp. 752-54.
M.L. Morrison, R.A. Buchanan, A. Peker, W.H. Peter, I.A. Horton, and P.K. Liaw: Intermetallics, 2004, vol. 12, pp. 1177-81.
W.H. Peter, R.A. Buchanan, C.T. Liu, P.K. Liaw, M.L. Morrison, I.A. Horton, C.A. Carmichael, and J.L. Wright: Intermetallics, 2002, vol. 10, pp. 1157-62.
S.J. Poon: Phys. Rev. B, 1985, vol. 31, pp. 7442-45.
Y. Yokoyama, K. Fukaura, and A. Inoue: Mater. Trans., 2004, vol. 45, pp. 1672-78.
A.L. Greer: Science, 1995, vol. 267, pp. 1947-53.
K.M. Flores and R.H. Dauskardt: Acta Mater., 2001, vol. 49, pp. 2527-37.
B. Yang, M.L. Morrison, P.K. Liaw, R.A. Buchanan, G.Y. Wang, C.T. Liu., and M. Denda: Appl. Phys. Lett., 2005, vol. 86, p. 141904.
F. Spaepen: Acta Mater., 1977, vol. 25, pp. 407-15.
L.A. Davis: J. Mater. Sci., 1976, vol. 11, pp. 711-17.
M.E. Launey, D.C. Hofmann, W.L. Johnson, and R.O. Ritchie: Proc. Nat. Acad. Sci. USA, 2009, vol. 106, pp. 4986–91.
C.A. Schuh, T.C. Hufnagel, and U. Ramamurty: Acta Mater., 2007, vol. 55, pp. 4067-4109.
G.Y. Wang, P.K. Liaw, W.H. Peter, B. Yang, Y. Yokoyama, M.L. Benson, B. A. Green, M.J. Kirkham, S.A. White, T.A. Saleh, R.L. McDaniels, R.V. Steward, R.A. Buchanan, C.T. Liu, and C.R. Brooks: Intermetallics, 2004, vol. 12, pp. 885-92.
C.E. Packard, L.M. Witmer, and C.A. Schuh: Appl. Phys. Lett., 2008, vol. 92, p. 171911.
B.C. Menzel and R.H. Dauskardt: Scripta Mater., 2006, vol. 55, pp. 601-04.
G.Y. Wang, P.K. Liaw, and M.L. Morrison: Intermetallics, 2009, vol. 17, pp. 579-90.
Y. Yokoyama, T. Yamasaki, P.K. Liaw, and A. Inoue: Acta Mater., 2008, vol. 56, pp. 6097-6108.
B.E. Warren: X-ray Diffraction, Dover Publications, New York, NY, 1969, 1990.
V.Y. Kazimirov, D. Louca, M. Widom, X.-J. Gu, S.J. Poon, and G.J. Shifiet: Phys. Rev. B, 2008, vol. 78, p. 054112.
V.Y. Kazimirov, D. Louca, V. Ponnambalam, S.J. Poon, and T. Proffen: Phys. Rev. B, 2005, vol. 72, p. 054207.
K. Ahn, D. Louca, S.J. Poon, and G.J. Shifiet: Phys. Rev. B, 2004, vol. 70, p. 224103.
K. Ahn, D. Louca, S.J. Poon, and G.J. Shifiet: J. Phys. Condens. Matter, 2003, vol. 15, pp. S2357-64.
Acknowledgments
The authors would like to acknowledge valuable discussions with S.J. Poon and M. Widom. Support for this work was provided by the National Science Foundation, Nos: 130398GA10715 and DMR 0231320. The use of the Advanced Photon Source was supported by the U. S. Department of Energy, Office of Science, Office of Basic Energy Sciences, under Contract No. DE-AC02-06CH11357.
Author information
Authors and Affiliations
Corresponding author
Additional information
Manuscript submitted March 28, 2011
Rights and permissions
About this article
Cite this article
Tong, P., Louca, D., Wang, G. et al. The Effects of Fatigue on the Atomic Structure with Cyclic Loading in Zr50Cu40Al10 and Zr60Cu30Al10 Glasses. Metall Mater Trans A 43, 2676–2679 (2012). https://doi.org/10.1007/s11661-011-0887-5
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11661-011-0887-5