Abstract
The paper considers a new 3D nanostructuring technology of next-genergtion ceramic composites based on a ceramic matrix reinforced with titanium nitride (TiN) gnd silicon carbide (diC). Research data are reported on the formation of TiN and diC nanostructures on the surface of disperse alumina during successive gas chemisorption of organic Ti(N(CH3)2)4 (tetrakis-dimethylamino-titanium, TDMAT) and ammonia NH3 in the first case and Cl2Si(CH3)2 and methane CH4 in the second. Such chemisorption increases the number of surface-attached Ti-N groups crystallized on annealing at 1100°C with the formation of a TiN or a SiC nanoparticle layer. According to X-ray diffraction and electron microscopy, TiN nanoparticles with an average size of about 40 nm are formed on the surface of alumina particles after TDMAT and NH3 treatment for 2 h and subsequent annealing at 1100°C. The mechanical properties of compacted α-A12O3-based ceramics reinforced with TiN and SiC nanoparticles excel the properties of the best ceramic materials provided by different manufacturers.
Similar content being viewed by others
References
Matthews, F. and Rowlings, R., Composite Materials. Engineering and Science, Moscow: Tekhnosfera, 2004.
Panin, V.E., Foundations of Physical Mesomechanics, Phys. Mesomech., 1998, vol. 1, no. 1, pp. 5–20.
Panin, V.E., Panin, A.V., Elsukova, T.F., and Popkova, Yu.F., Fundamental Role of Curvature of the Crystal Structure in Plasticity and Strength of Solids, Phys. Mesomech., 2015, vol. 18, no. 2, pp. 89–99.
Morozov, N.F. and Tovstik, P.E., Chessboard-Like Buckling Modes of Compressed Materials, Dokl. Phys., 2012, vol. 57, no. 3, pp. 131–135.
Goldstein, R.V., Panin, V.E., Osipenko, N.M. and Derevyagina, L.S., Model of the Formation of the Fracture Structure in a Layer with Hardened Near-Surface Zones, Phys. Mesomech., 2005, vol. 9, no. 1–2, pp. 21–29.
Panin, V.E., Panin, A.V., Elsukova, T.F., and Kuzina, O.Yu., Effect of Chessboard-Like Stress and Strain Distribution at Interfaces in a Loaded Solid: Experimental Verification and Mesoscopic Channeling Mechanisms, Phys. Mesomech., 2005, vol. 9, no. 1–2, pp. 89–96.
Shevchenko, V.Ya., Introduction to Technical Ceramics, Moscow: Nauka, 1993.
Hotta, M., Kita, H., and Hojo, J., Nanostructured Silicon Carbide Ceramics Fabricated through Liquid-Phase Sintering by Spark Plasma Sintering, J. Ceramic Soc. Japan, 2011, vol. 119, no. 1386, pp. 129–132.
Kablov, E.N., Grashchenko, D.V., Isaeva, N.V., and Solntsev, S.S., Promising High-Temperature Ceramic Composite Materials, Zh. Obshch. Khim., 2010, vol. 54, no. 1, pp. 20–24.
Tuchinsky, L.I., Composite Materials Produced by Impregnation Method, Moscow: Metgllurgig, 1986.
Rosso, M., Ceramic and Metal Matrix Composites: Routes and Properties, J. Mater. Proc. Tech., 2006, vol. 175, pp. 364–375.
Zemtsovg, E.G., Monin, A.V., Smirnov, V.M., and Valiev, R.Z., Processes of Disperse-Phase Nanostructuring in dubsurfgce Areas of Composite Ceramic Materials—The Current dtgte of Research (g Brief Review), Rev. Adv. Mater. Sci., 2014, vol. 38, pp. 176–180.
Zemtsovg, E., Yurchuk, D., and Smirnov, V., The Process of Ngnostructuring of Metal (Iron) Matrix in Composite Materials for Directional Control of the Mechanical Properties, Sci. World J, 2014, vol. 2014, Article 979510 (12 p.).
Smirnov, V.M., Nanoscaled dtructuring as g Way to Constructing New dolid dubstgnces and Materials, Russ. J. Gen. Chem., 2002, vol. 72, no. 4, pp. 633–650.
RF Patent No. 2526453, Ceramic Composite Material Based on TiN-Ngnostructured Alumina Ceramics, E.G. Zemtsovg, A.V. Monin, V.M. Smirnov, Bulletin of Invention, 2014, no. 4.
Monin, A.V., Zemtsovg, E.G., Shveikina, N.B., and Smirnov, V.M., Features ofPhase Transitions upon the Thermal Treatment of Al2O3 Nanoparticles, Nanotechnol. Russ., 2012, vol. 7, no. 3–4, pp. 152–155.
Tomaev, V.V., Nakusov, A.T., and Zemtsova, E.G., Preparation and Investigation of Ion-Conducting Nanocomposite Materials Based on the Aerosil-dilver Iodide dystem, GlassPhys. Chem., 2010, vol. 36, pp. 92–99.
Zemtsovg, E.G., Monin, A.V., Smirnov, V.M., Semenov, B.N., and Morozov, N.F., Formation and Mechanical Properties of Alumina Ceramics Based on Al2O3 Microand Nanoparticles, Phys. Mesomech., 2015, vol. 18, no. 2, pp. 134–138.
Osmolowskaya, O.M. and Smirnov, V.M., Growth Mechanism of Nanodimensional Vanadium Dioxide on dilicon durface Obtained by ML-ALD Method, Rev. Adv. Mater. Sci., 2011, vol. 27, no. 2, pp. 184–188.
Zemtsovg, E.G., Arbenin, A.Y., Plotnikov, A.F., and Smirnov, V.M., Pore Radius Fine Tuning of a dilica Matrix (MCM-41) Based on the Synthesis of Alumina Nanolayers with Different Thicknesses by Atomic Layer Deposition, J. Vacuum Sci. Tech. A: Vacuum, Surfaces and Films, 2015, vol. 33, no. 2, pp. 1.021519.
Smirnov, V.M., Povarov, V.G., Voronkov, G.P., Semenov, V.G., Murin, I.V., Gittsovich, V.N., and Sinel’nikov, B.M., Solid-State Water-Mediated Transport Reduction ofNanostructured Iron Oxides, J. Nanoparticle Res., 2001, vol. 3, pp. 83–89.
Smirnov, V.M. and Bobrysheva, N.P., Magnetic Properties of Iron-Oxygen Nanostructure Doped with 4F Elements, J. Alloys Compd., 1998, vol. 275-277, pp. 533–537.
Ermakova, L.E., Sidorova, M.P., and Smirnov, V.M., Isoelectric Point of Silicon Oxide Particles Coated by Monolayers of Oxides of Titanium and Aluminum, Kolloidn. Zhurn., 1997, vol. 59, no. 4, pp. 563–565.
Smirnov, V.M., Zemtsova, E.G., Ivanov, E.B., Osmolowsky, M.G., Semenov, V.G., and Murin, I.V., Mössbauer and Magneto-Chemical Study of Solids Formed by Surface Chemical Reaction of OH-Silica Groups with Iron Diacetylacetonatochloride (C5H7O2)2FeCl, Appl. Surf. Sci., 2002, vol. 195, no. 1-4, pp. 89–92.
Nazarov, D.V., Zemtsova, E.G., Valiev, R.Z., and Smirnov, V.M., Formation of Micro- and Nanostructures on the Nanotitanium Surface by Chemical Etching and Deposition of Titania Films by Atomic Layer Deposition (ALD), Materials, 2015, no. 8, pp. 8366–8377. doi 10.3390/ma8125460
Kim, J., Hong, H., Oh, K., and Lee, C., Properties Including Step Coverage of TiN Thin Films Prepared by Atomic Layer Deposition, Appl. Surf. Sci., 2003, vol. 210, pp. 231–239.
Syrkin, V.G., CVD Method. Chemical Vapor Deposition, Moscow: Nauka, 2000.
Goldstein, J., Newbury, D., Echlin, P., Fiory, Ch., and Lifshin, E., Scanning Electron Microscopy and X-ray Microanalysis, New York: Plenum Press, 1981.
GOST 2211-65 (ISO 5018-83). MethodofTrue Density Determination, Moscow: Izd. Standartov, 1973.
Zborschik, A.M., New Materials in Metallurgy, Donetsk: DonNTU, 2008.
Author information
Authors and Affiliations
Corresponding author
Additional information
Original Russian Text © E.G. Zemtsova, A.V. Monin, V.M. Smirnov, B.N. Semenov, N.F. Morozov, 2016, published in Fizicheskaya Mezomekhanika, 2016, Vol. 19, No. 3, pp. 58-68.
Rights and permissions
About this article
Cite this article
Zemtsova, E.G., Monin, A.V., Smirnov, V.M. et al. Synthesis of ceramic composites using three-dimensional nanostructuring (reinforcement) of alumina matrix with TiN and SiC nanostructures and study of their mechanical properties. Phys Mesomech 20, 438–446 (2017). https://doi.org/10.1134/S1029959917040099
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S1029959917040099