Abstract
The voltage ripple and power loss in the DC-capacitor of a voltage source inverter depend on the harmonic currents flowing through the capacitor. This paper presents a double Fourier series based analysis of the harmonic contents of the DC capacitor current in a three-level neutral-point clamped (NPC) inverter, modulated with sine-triangle pulse-width modulation (SPWM) or conventional space vector pulse-width modulation (CSVPWM) schemes. The analytical results are validated experimentally on a 3-kVA three-level inverter prototype. The capacitor current in an NPC inverter has a periodicity of 120∘ at the fundamental or modulation frequency. Hence, this current contains third-harmonic and triplen-frequency components, apart from switching frequency components. The harmonic components vary with modulation index and power factor for both PWM schemes. The third harmonic current decreases with increase in modulation index and also decreases with increase in power factor in case of both PWM methods. In general, the third harmonic content is higher with SPWM than with CSVPWM at a given operating condition. Also, power loss and voltage ripple in the DC capacitor are estimated for both the schemes using the current harmonic spectrum and equivalent series resistance (ESR) of the capacitor.
Similar content being viewed by others
References
ALCON electronics Pvt Ltd 2011 Aluminum electrolytic capacitors – catalogue no. PG-6DI-00-00, URL: www.icd-sales.com
Aluminum Electrolytic Capacitors – catalogue no. PG-6DI-00-00 ALCON electronics Pvt Ltd, Jan-2011. URL: www.icd-sales.com
Bierhoff M H and Fuchs F W 2008 DC-link harmonics of three-phase voltage-source converters influenced by the pulsewidth-modulation strategy: An analysis. IEEE Trans. Ind. Electron. 55(5): 2085–2092
Choi U M, Lee J S and Lee K B 2014 New modulation strategy to balance the neutral-point voltage for three-level neutral-clamped inverter systems. IEEE Trans. Energy Conv. 29(1): 91–100
Das S 2013 Study on pulsewidth modulation techniques for a neutral-point-clamped voltage source inverter. PhD Thesis, Indian Institute of Science, Bangalore, May 2013
Gasperi M L 1997 A method for predicting the expected life of bus capacitors. Proc. Conf. Industry Appl. 2: 1042–1047
Gopalakrishnan K S, Soumitra Das and Narayanan G 2011 Analytical expression for RMS DC link capacitor current in a three-level inverter. Proc. Conf. Centenary. IISc Bangalore, India
Gopalakrishnan K S and Narayanan G 2013 Harmonic analysis of DC-link capacitor current in sinusoidally modulated neutral-point-clamped inverter. National Power Electronics Conference
Holmes D G and Lipo T A 2003 Pulse width modulation for power converters. Piscataway, NJ: IEEE Press
Kieferndorf F D, Forster M and Lipo T A 2004 Reduction of DC-bus capacitor ripple current with PAM/PWM converter. IEEE Trans. Ind. Appl. 40(2): 607–614
Kolar J W and Round S D 2006 Analytical calculation of the RMS current stress on the DC-link capacitor of voltage-PWM converter systems. IEE Proc. Electric Power., Appl. 153(4): 535–543
Kouro S., Malinowski M, Gopakumar K, Pou J, Franquelo L G, Wu B, Rodriguez J, Prez M A and Leon J I 2010 Recent advances and industrial applications of multilevel converters. IEEE Trans. Ind. Electron. 57(8): 2553–2580
Lee Y H, Kim D H and Hyun D S 2000 Carrier based SVPWM method for multi-level system with reduced HDF [harmonic distortion factor]. Industry Applications Conference 3: 1996–2003
Lee J S and Lee K B 2014 New modulation techniques for a leakage current reduction and a neutral-point voltage balance in transformerless photovoltaic systems using a three-level inverter. IEEE Trans. Power Electron. 29(4): 1720–1732
Lekha S 2013 Comparison of two-level and three-level neutral-point clamped inverters in automotive application MASc Thesis, University of Concordia, Quebec Canada
McGrath B P and Holmes D G 2002 An analytical technique for the determination of spectral components of multilevel carrier-based PWM methods. IEEE Trans. Ind. Electron. 49(4): 847–857
Moynihan J F, Egan M G and Murphy J M D 1998 Theoretical spectra of space-vector-modulated waveforms. IEE Trans. Elec. Power Appl. 145(1): 17–24
Orfanoudakis G I, Sharkh S M, Yuratich M A and Abusara M A 2010 Loss comparison of two and three-level inverter topologies. In: Proc. IET Int. Conf. Power Electron., Machines and Drives 1–6
Orfanoudakis G I, Yuratich M A and Sharkh S M 2013a Analysis of dc-link capacitor current in three-level neutral point clamped and cascaded H-bridge inverters. IET Trans. Power. Electron. 6(7): 1376–1389
Orfanoudakis G I, Yuratich M A and Sharkh S M 2013b Nearest-vector modulation strategies with minimum amplitude of low-frequency neutral-point voltage oscillations for the neutral-point-clamped converter. IEEE Trans. Power Electron. 28(10): 4485–4499
Rodriguez J, Bernet S, Steimer P K and Lizama I E 2010 A survey on neutral-point-clamped inverters. IEEE Trans. Ind. Electron. 57(7): 2219–2230
Teichmann R and Bernet S 2005 A comparison of three-level converters versus two-level converters for low-voltage drives, traction, and utility applications. IEEE Trans. Ind. Appl. 41: 855–865
Wang Fei 2002 Sine-triangle versus space-vector modulation for three-level PWM voltage-source inverters. IEEE Trans. Ind. Appl. 38(2): 500–506
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
K S, G., NARAYANAN, G. Harmonic analysis of DC capacitor current in sinusoidal and space-vector modulated neutral-point-clamped inverters. Sadhana 40, 1501–1529 (2015). https://doi.org/10.1007/s12046-015-0401-7
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12046-015-0401-7