Skip to main content
SpringerLink
Log in

Effect of replacing fish meal with extruded soybean meal on growth, feed utilization and apparent nutrient digestibility of juvenile white shrimp (Litopenaeus vannamei)

  • Published:
Journal of Ocean University of China Aims and scope Submit manuscript

Abstract

Extruded soybean meal (ESBM) was evaluated as a protein source for partial replacement of fish meal (FM) in diets of juvenile Litopenaeus vannamei. In the control diet (Diet 1), FM protein was replaced with increasing dietary levels of ESBM (4.28%, 8.40%, 12.62%, 16.82%, and 25.26%) at 10%, 20%, 30%, 40%, and 60% levels (Diets 2 to 6, respectively). An eight-week feeding trial was conducted on 720 juvenile shrimp (0.67 g ± 0.01 g mean initial weight), and nutrient digestibility of the six diets was determined. ESBM could replace 20% of FM without causing a significant reduction in growth of shrimp, but other dietary treatments strongly affected whole body composition. Crude protein content of the whole body fed Diet 6 was significantly lower than that fed Diet 2 (P < 0.05), while crude lipid content of the whole body fed Diet 5 or 6 was significantly higher than that fed Diet 2 (P < 0.05). Protein digestibilities of Diets 5 and 6 were significantly lower than that of Diet 1 (P < 0.05). Digestibility of lipids ranged from 96.97% in Diet 6 to 98.34% in Diet 3, whereas dry matter digestibility decreased with increasing replacement level. This study indicates that 20% FM replacement with ESBM in the basic diet containing 40% protein and 30% FM is optimal for juvenile L. vannamei.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  • Akiyama, D. M., 1988. Soybean meal utilization by marine shrimp. AOCS World Congress on Vegetable Protein Utilization in Human Food and Animal Feedstuffs, Singapore. American Soybean Association, Singapore.

  • Akiyama, D. M., Dominy, W. G., and Lawrence, A. L., 1991. Penaeid shrimp nutrition for the commercial feed industry revised. In: Proceedings of the Aquaculture Feed Processing and Nutrition Workshop, Thailand and Indonesia September 19–25, 1991. American Soybean Association, Singapore, 80–98.

    Google Scholar 

  • Alvarez, J. S., Alfredo, H. L., Galindo, J., Fraga, I., Garcia, T., and Villarreal, H., 2007. Substitution of fish meal with soybean meal in practical diets for juvenile white shrimp Litopenaeus schmitti (Pérez-Farfante & Kensley 1997). Aquaculture Research, 38: 689–695.

    Article  Google Scholar 

  • Amaya, E. A., Davis, D. A., and Rouse, D. B., 2007. Replacement of fish meal in practical diets for the Pacific white shrimp (LitoPenaeus vannamei) reared under pond conditions. Aquaculture, 262: 393–401.

    Article  Google Scholar 

  • Amin, O., Jafar, S., Abdolmohammad, A. K., and Masoud, R., 2012. Growth and apparent digestibility of nutrients, fatty acids and amino acids in Pacific white shrimp, LitoPenaeus vannamei, fed diets with rice protein concentrate as total and partial replacement of fish meal. Aquaculture, 342-343: 56–61.

    Article  Google Scholar 

  • Association of Official Analytical Chemists (AOAC), 1995. Official Methods of Analysis of AOAC. 16th edition. Helrich, K., ed., Association of Official Analytical Chemists, Inc., Arlington, VA, USA, 1-12.

  • Bharadwaj, A. S., Brignon, W. R., Gould, N. L., Brown, P. B., and Wu, Y. V., 2002. Evaluation of meat and bone meal in practical diets fed to juvenile hybrid striped bass Morone chrysops×M. saxatilis. Journal of the World Aquaculture Society, 33: 448–457.

    Article  Google Scholar 

  • Brown, P. B., Tazik, M. L. H., and Blithe, W. G., 1990. Consumption and apparent dry matter digestibility of aquatic macrophytes by male and female crayfish Orconectes virirlis. Aquaculture, 86: 345–349.

    Google Scholar 

  • Brunson, J. F., Romaire, R. P., and Reigh, R. C., 1997. Apparent digestibility of selected ingredients in diets for white shrimp Penaeus setiferus L. Aquaculture Nutrition, 3: 9–16.

    Article  Google Scholar 

  • Carver, L. A., Akiyama, D. M., and Dominy, W. G., 1989. Processing of wet shrimp heads and squid viscera with soy meal by a dry extrusion process. American Soybean Association Technical Bulletin, 16: 89–94.

    Google Scholar 

  • César, M. P., Mariela, L., and Miguel, J., 2013. Evaluation of the potential of Andean lupin meal (Lupinus mutabilis Sweet) as an alternative to fish meal in juvenile LitoPenaeus vannamei diets. Aquaculture, 410-411: 148–156.

    Article  Google Scholar 

  • Cheng, Z. J., Behnke, K. C., and Dominy, W. G., 2002. Effects of poultry byproduct meal as a substitute for fish meal in diets on growth and body composition of juvenile pacific white shrimp, LitoPenaeus vannamei. Journal of Applied Aquaculture, 12: 71–83.

    Article  Google Scholar 

  • Colvin, L. V., and Brand, C. W., 1977. The protein requirement of penaeid shrimp at various life-cycle stages in controlled environment systems. Proceedings of the World Mariculture Society, 8: 821–840.

    Article  Google Scholar 

  • Cowey, C. B., Mackie, A. M., and Bell, J. G., 1985. Nutrition and Feeding in Fishes. Academic Press, London, 63–89.

    Google Scholar 

  • Crisantema, H., Miguel, A. O. N., Karla, A. V., Blanca, G. R., and Isabel, A. P., 2008. Partial replacement of fish meal by porcine meat meal in practical diets for Pacific white shrimp (LitoPenaeus vannamei). Aquaculture, 277: 244–250.

    Article  Google Scholar 

  • Cruz-Suárez, L. E., Nieto-López, M., Ricque-Marie, D., Guajardo-Barbosa, C., and Scholz, U., 2004. Uso de harina de subproductos avícolas en alimentos para L. vannamei. In: Avances en Nutricion Acuícola VII. Cruz Suárez, L. E., et al., eds., Memorias del VII Simposium Internacional de Nutrición Acuícola, 16–19.

    Google Scholar 

  • D’Abramo, L., and Lovell, T., 1991. Aquaculture research needs for the year 2000: Fish and crustacean nutrition. Journal of the World Aquaculture Society, 22: 57–62.

    Article  Google Scholar 

  • Davis, D. A., and Arnold, C. R., 2000. Replacement of fish meal in practical diets for the Pacific white shrimp, LitoPenaeus vannamei. Aquaculture, 185: 291–298.

    Article  Google Scholar 

  • Divakaran, S., Velasco, M., Beyer, E., Forster, I., and Tacon, A. G. J., 2000. Soybean meal apparent digestibility for LitoPenaeus vannamei, including a critique of methodology. In: Avances en Nutricion Acuicola V. Memorias del V Simposium Internacional de Nutricion Acuicola, 19–22.

    Google Scholar 

  • El-Saidy, D. M. S. D., and Gaber, M. M. A., 2002. Complete replacement of fish meal by soybean meal with dietary L-lysine supplementation for the nile tilapia Oreochromis niloticus (L.) fingerlings. Journal of the World Aquaculture Society, 33: 297–306.

    Article  Google Scholar 

  • Ezquerra, J. M., García-Carreño, F. L., Civera, R., and Haard, N. F., 1997. pH-stat method to predict protein digestibility in white shrimp (Penaeus vannmei). Aquaculture, 157: 249–260.

    Article  Google Scholar 

  • FAO, 2005. FAO Fisheries Department, Fishery Information, Data and Statistics Unit. FISHSTAT Plus: Universal software for statistical time series, Version 2.3.

  • Garza de Yta, A., Rouse, D. B., and Davis, D. A., 2004. Influence of nursery period on the growth and survival of LitoPenaeus vannamei. Journal of the World Aquaculture Society, 35: 357–365.

    Article  Google Scholar 

  • Gatlin III, D. M., Barrows, F. T., Brown, P., Dabrowski, K., Gaylord, T. G., Hardy, R. W., Herman, E., Hu, G. S., Krogdahl, A., Nelson, R., Overturf, K., Rust, M., Sealey, W., Skonberg, D., Souza, E. J., Stone, D., Wilson, R., and Wurtele, E., 2007. Expanding the utilization of sustainable plant products in aquafeeds: A review. Aquaculture Research, 38: 551–579.

    Article  Google Scholar 

  • Goytortúa-Bores, E., Civera-Cerecedo, R., Rocha-Meza, S., and Green-Yee, A., 2006. Partial replacement of red crab (Pleuroncodes planipes) meal for fish meal in practical diets for the white shrimp LitoPenaeus vannamei. Effects on growth and in vivo digestibility. Aquaculture, 256: 414–422.

    Article  Google Scholar 

  • Halver, J. E., and Hardy, R. W., 2002. Fish Nutrition. 3rd edition. Academic Press, New York, 735–824.

    Google Scholar 

  • Hardy, R. W., 1999. Alternate protein sources. Feed Manage, 50: 25–28.

    Google Scholar 

  • Hermosillo, S., Cuzon, G., Guillaume, J., and Cahu, C., 1994. Composition, preparation and utilization of feeds for Crustacea. Aquaculture, 124: 253–267.

    Article  Google Scholar 

  • Julián, G. D., Mónica, G. R. C., Martha, G. N. L., and Lucía, E. C., 2013. Simultaneous estimation of the nutritional contribution of fish meal, soy protein isolate and corn gluten to the growth of Pacific white shrimp (LitoPenaeus vannamei) using dual stable isotope analysis. Aquaculture, 383: 33–40.

    Google Scholar 

  • Law, A. T., Chin, K. S. S., Ang, K. J., and Kamamdin, M. S., 1990. Digestibility of low cost ingredients in pelleted feeds by Macrobrachium rosenbergii (De Man). In: The Second Asian Fisheries Forum. Hirano, R., and Hanyu, I., eds., Manila, 333–336.

    Google Scholar 

  • Lee, P. G., and Lawrence, A. L., 1997. Digestibility. In: Crustacean Nutrition, Vol. 6. D’Abramo, L. R., et al., eds., World Aquaculture Society, 194–260.

    Google Scholar 

  • Lim, C., and Dominy, W., 1990. Evaluation of soybean meal as a replacement for marine animal protein in diets for shrimp (Penaeus vannamei). Aquaculture, 87: 53–63.

    Article  Google Scholar 

  • Lim, C., 1996. Substitution of cottonseed meal for marine animal protein in diets for Penaeus vannamei. Journal of the World Aquaculture Society, 27: 402–409.

    Article  Google Scholar 

  • Lim, C., Beames, R. M., Eales, J. G., Prendergast, A. F., McLeese, J. M., Shearer, K. D., and Higgs, D. A., 1997. Nutritive values of low and high fiber canola meals for shrimp (Penaeus vannamei). Aquaculture Nutrition, 3: 269–279.

    Article  Google Scholar 

  • Lim, C., Klesius, P. H., and Dominy, W., 1998. Soybean products. International Aquaculture Feeds, 3: 17–23.

  • Dabramo, L. R., Conkin, D. E., and Akiyama, D. M., 1997. Crustacean Nutrition. World Aquaculture Society, 243–246.

    Google Scholar 

  • Mahbuba, B., Shunsuke, K., Manabu, I., Saichiro, Y., and Abdul, K. R., 2013. Performance of kuruma shrimp, Marsupenaeus japonicus fed diets replacing fishmeal with a combination of plant protein meals. Aquaculture, 372: 45–51.

    Google Scholar 

  • Mendoza-Alfaro, R., De Dios, A., VaL zquez, C., Cruz-SuaL rez, L. E., Ricque-Marie, D., Aguilera, C., and Montemayor, J., 2001. Fishmeal replacement with feather-enzymatic hydrolyzates co-extruded with soya-bean meal in practical diets for the Pacific white shrimp (LitoPenaeus vannamei). Aquaculture Nutrition, 7: 143–151.

    Article  Google Scholar 

  • Merican, Z. O., and Shim, K. F., 1995. Apparent digestibility of lipid and fatty acids in residual lipids of meals by adult Penaeus monodon. Aquacultur, 133: 275–286.

    Article  Google Scholar 

  • National Research Council (NRC), 1993. Nutrient Requirements of Fish. National Academy Press, Washington, DC, 332-411.

  • Olvera-Novoa, M. A., and Olivera-Castillo, L., 2000. Potencialidad del uso de las leguminosas como fuente proteica en alimentos para peces. In: Avances en Nutrición Acuícola IV. Civera-Cerecedo, R., et al., eds., Memorias del IV Simposium Internacional de Nutrición Acuícola, México, 327–348.

    Google Scholar 

  • Pascual, F., Cruz-SuaL rez, L. E., and Sumalangcay, A., 1990. Supplemental feeding of Penaeus monodon juveniles with diets containing various levels of defatted soybean meal. Aquaculture, 89: 183–191.

    Article  Google Scholar 

  • Pierce, R. W., Van der Veen, J., and Olcott, H. S., 1969. Proximate and lipid analyses of krill (Euphasia species) and red crab (Pleuroncodes planipes). Journal of Agricultural and Food Chemistry, 17: 367–369.

    Article  Google Scholar 

  • Ponce-Palafox, J., Martinez-Palacios, C., and Ross, L., 1997. The effects of salinity and temperature on the growth and survival rates of juvenile white shrimp, Penaeus vannamei, Boone, 1931. Aquaculture, 157: 107–115.

    Article  Google Scholar 

  • Reigh, R. C., Braden, S. L., and Craig, R. J., 1990. Apparent digestibility coefficients for common feedstuffs in formulated diets for red swamp crayfish Procambarus clarkii. Aquaculture, 84: 321–340.

    Article  Google Scholar 

  • Samocha, T., Davis, D. A., Saoud, I. P., and DeBault, K., 2004. Substitution of fish meal by co-extruded soybean poultry by-product meal in practical diets for the Pacific white shrimp, LitoPenaeus vannamei. Aquaculture, 231: 197–203.

    Article  Google Scholar 

  • Sookying, D., and Davis, D. A., 2011. Pond production of Pacific white shrimp (LitoPenaeus vannamei) fed high levels of soybean meal in various combinations. Aquaculture, 319: 141–149.

    Article  Google Scholar 

  • Sudaryono, A., Tsventnenko, E., and Evans, L. H., 1996. Digestibility studies on fisheries by-product based diets for Penaeus monodon. Aquaculture, 143: 331–340.

    Article  Google Scholar 

  • Swick, R. A., Akiyama, D. M., Boonyaratpalin, M., and Creswell, D. C., 1995. Use of Soybean Meal and Synthetic Methionine in Shrimp Feed. Technical Bulletin, American Soybean Association, 43pp.

    Google Scholar 

  • Tacon, A. G. J., and Forster, I. P., 2000. Trends and challenges to aquaculture and aquafeed development in the new millennium. In: Avances en Nutrición Acuícola V. Cruz-Suárez, L. E., et al., eds., World Aquaculture Society, Baton Rouge, 520–549.

    Google Scholar 

  • Tan, B., Mai, K., Zheng, S., Zhou, Q., Liu, L., and Yu, Y., 2005. Replacement of fish meal by meat and bone meal in practical diets for the white shrimp LitoPenaeus vannamei (Boone). Aquaculture Research, 26: 439–444.

    Article  Google Scholar 

  • Velasco, M., 2002. Nutrition de camaron. In: Curso Lance en Acuacultura, 13–17 Mayo 2002. Cruz-Sua L rez, L. E., et al., eds., Monterrey, NuevoLeon, Mexico, 122pp.

    Google Scholar 

  • Venero, J., 2006. Optimization of dietary nutrient inputs for Pacific white shrimp LitoPenaeus vannamei. Doctoral dissertation. Auburn University, Auburn, Alabama, USA.

    Google Scholar 

  • Williams, A. S., Davis, D. A., and Arnold, C. R., 1996. Density-dependent growth and survival of Penaeus setiferus and Penaeus vannamei in a semi-closed recirculating system. Journal of the World Aquaculture Society, 27: 107–112.

    Article  Google Scholar 

  • William, B., Carlos, P. H., Marcelo, B. T., Wilson, W. J., and Luís, H. S. P., 2012. Substitution of fishmeal with microbial floc meal and soy protein concentrate in diets for the pacific white shrimp LitoPenaeus vannamei. Aquaculture, 342-343: 112–116.

    Article  Google Scholar 

  • Yang, Q. H., Zhou, X. Q., Zhou, Q. C., Tan, B. P., Chi, S. Y., and Dong, X. H., 2009. Apparent digestibility of selected feed ingredients for white shrimp LitoPenaeus vannamei, Boone. Aquaculture Research, 41: 78–86.

    Article  Google Scholar 

  • Yu, Y., 2004. Replacement of fishmeal with poultry by-product meal and meat and bone meal in shrimp, tilapia and trout diets. In: Avances en Nutricion Acuícola VII. Cruz Suárez, L. E., et al., eds., Memorias del VII Simposium Internacional de Nutrición Acuícola, 183–201.

    Google Scholar 

  • Zaldivar, F. J., 2002. Las harinas y aceites de pescado en la alimentacion acuicola. In: Avances en Nutricio n Acuicola VI. Memorias delVI Simposio Internacional de Nutricion Acuicola, 516–526.

    Google Scholar 

  • Zelaya, O., 2005. An evaluation of nursery techniques and feed management during culture of marine shrimp LitoPenaeus vannamei. Doctoral dissertation. Auburn University, Auburn, Alabama, USA.

    Google Scholar 

  • Zhou, Q. C., Tan, B. P., Mai, K. S., and Liu, Y. J., 2004. Apparent digestibility of selected feed ingredients for juvenile cobia, Rachycentron canadum. Aquaculture, 241: 441–451.

    Article  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Laboratory of Aquatic Animal Nutrition and Feed, College of Fisheries, Guangdong Ocean University, Zhanjiang, 524025, P. R. China

    Qihui Yang, Beiping Tan, Xiaohui Dong, Shuyan Chi & Hongyu Liu

Authors
  1. Qihui Yang
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Beiping Tan
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Xiaohui Dong
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Shuyan Chi
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Hongyu Liu
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Beiping Tan.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Yang, Q., Tan, B., Dong, X. et al. Effect of replacing fish meal with extruded soybean meal on growth, feed utilization and apparent nutrient digestibility of juvenile white shrimp (Litopenaeus vannamei). J. Ocean Univ. China 14, 865–872 (2015). https://doi.org/10.1007/s11802-015-2572-6

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11802-015-2572-6

Keywords

Search

Navigation