Abstract
The effects of static magnetic field (5000 Oe) were investigated on undercooling of a copper melt in glass slag. The procedure of melting and solidifying was repeated 13 times in each sample. The thermal analysis curves for ten samples (five samples in the presence of magnetic field and five samples in the absence of magnetic field) were measured during every melting-solidifying cycle and the degree of undercooling was obtained in every cycle. The undercoolings of all samples increased in a few numbers of early cycles and after about six cycles they were almost saturated and independent of cycle number. Irregular and unexpectedly large decreases of undercooling sometimes appeared. Two remarkable effects of magnetic field on undercooling were found. One is that the maximum undercooling in the presence of a magnetic field is apparently higher than that in the absence of a magnetic field for every sample. The second is that the application of magnetic field tends to suppress the irregular and unexpectedly large decreases of undercooling. These results are discussed in respect of the thermodynamic effect (the magnetic free energy change on solidification) and the magnetohydrodynamic effect (the suppression of thermal convection).
Similar content being viewed by others
References
H. Jones,J. Mater. Sci. 19 (1984) 1043.
A. J. McLeod andL. M. Hogan,Met. Trans. 9A (1978) 987.
T. Z. Kattamis andM. C. Flemings,Trans. Met. Soc. AIME 236 (1966) 1523.
K. F. Kobayashi andP. H. Shingu,J. Mater. Sci. 23 (1988) 2157.
M. C. Flemings andY. Shiohara,Mater. Sci. Engng 65 (1984) 157.
H. P. Utech andM. C. Flemings,J. Appl. Phys. 37 (1966) 2021.
H. A. Chedzey andD. T. J. Hurle,Nature 210 (1966) 933.
A. F. Witt, C. J. Herman andH. C. Gatos,J. Mater. Sci. 5 (1970) 822.
K. M. Kim,J. Electrochem. Soc. 129 (1982) 427.
Y. Kishida, K. Takeda, I. Miyoshino andE. Takeuchi,ISIJ Int. 30 (1990) 34.
R. W. Series,J. Cryst. Growth 97 (1989) 92.
M. Schieber,ibid. 1 (1967) 131.
W. V. Youdelis, D. R. Colton andJ. Cahoon,Can. J. Phys. 42 (1964) 2238.
Y. Aoki, S. Hayashi andH. Komatsu,J. Crystal Growth 108 (1991) 121.
T. Takahashi, M. Kudoh, K. Ohsasa andJ. Tanaka,Trans. ISIJ 27 (1987) 936.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Hasegawa, M., Asai, S. Effects of static magnetic field on undercooling of a copper melt. J Mater Sci 27, 6123–6126 (1992). https://doi.org/10.1007/BF01133759
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF01133759