Abstract
Escherichia coli (E. coli) O157:H7 bacterial infection causes severe disease in mammals and results in substantial economic losses worldwide. Due to the development of antibiotic resistance, bacteriophage (phage) therapy has become an alternative to control O157:H7 infection. However, the therapeutic effects of phages are frequently disappointing because of their low resistance to the gastrointestinal environment. In this study, to improve the stability of phages in the gastrointestinal tract, E. coli O157:H7 phages were microencapsulated and their in vitro stability and in vivo therapeutic efficiency were investigated. The results showed that compared to free phages, the resistance of microencapsulated phages to simulated gastric fluid and bile salts significantly increased. The microencapsulated phages were efficiently released into simulated intestinal fluid, leading to a better therapeutic effect in rats infected with E. coli O157:H7 compared to the effects of the free phages. In addition, the microencapsulated phages were more stable during storage than the free phages, showing how phage microencapsulation can play an essential role in phage therapy.
Similar content being viewed by others
Introduction
Enterohemorrhagic E. coli (EHEC) O157:H7, which produces Shiga toxin, can cause haemorrhagic colitis, bloody diarrhoea, thrombocytopenic purpura and haemolytic uraemic syndrome in humans [1,2,3]. As a major foodborne pathogen, E. coli O157:H7 has become a global public health problem. Although the safety of various products is ensured by implementing control strategies, outbreaks still occur. Thus, it has been estimated that 63 153 cases of foodborne disease and 61 deaths are attributed to E. coli O157:H7 annually in the United States, with approximately $255 million in losses each year [4, 5].
E. coli is sensitive to the most commonly used antibiotics, but the overuse and misuse of antibiotics have created a global antibiotic resistance crisis [6]. According to one estimation, there are 2.8 million cases of antibiotic-resistant infections and 35 000 deaths in America each year [7]. China is one of the largest countries that produces and uses antibiotics worldwide, and its per capita use of antibiotics is five times greater than that in Europe and America [8]. Nearly half of all antibiotics are discharged into the soil and water, causing pollution and resulting in more than 80 000 deaths each year due to antibiotic resistance [9]. In addition, broad-spectrum antibiotics might put patients at a risk of other intestinal infections due to resident intestinal microbiota dysbiosis [10, 11]. Phages are viruses that specifically infect bacterial cells. Among them, lytic phages can replicate and proliferate rapidly after infecting the host bacteria, finally rupturing the bacterial cells to achieve their antibacterial effect. Compared with traditional antibiotic therapy, phages have the advantages of strong specificity, self-replication, proliferation, safety, no residual effects and plentiful sources, so phage therapy is considered an ideal alternative to antibiotics [12, 13].
Phages are very effective and have been successfully used to prevent and treat bacterial infections in animals [14,15,16]. Although phages can be administered in a variety of ways, including via parenteral, topical, oral and inhaled routes, by lavage and through eye and nose drops [13, 17], the current problem is that phages lack suitable dosage forms. In particular, during the treatment of animal intestinal diseases, the activity of oral phages is easily destroyed by gastric acid, digestive enzymes and bile salts (BSs) [18, 19], resulting in the loss of antibacterial activity. In addition, their relatively short storage time limits their applications in the fields of food and medicine.
Microencapsulation technology is a new technology that has developed and matured showing wide application potential. This technology that uses natural or synthetic polymers as the encapsulation material to encapsulate the core material (solid, liquid or gas) to form a semipermeable or sealed capsule membrane. The substance that encapsulates the core is the wall material, and the encapsulated product is the core material. In microencapsulation technology, polymers are mainly used to encapsulate functional, active substances and form a dense physical barrier around the core material to reduce the reaction of the core material with the external environment. Microencapsulation of active substances can improve their physical properties and stability, prevent or reduce their deactivation, and prolong their storage time [20]. Ma et al. [21] used the microencapsulated phage Felix O1 for oral administration using a chitosan-alginate-CaCl2 system and then detected the activity of free phage and microencapsulated phage in simulated gastric fluid, bile and intestinal fluid. Colom et al. [22] compared the therapeutic effects of orally administered sodium alginate/CaCO3-coated phages and free phages in commercial chicken broilers infected with Salmonella. Both of these studies demonstrated that microencapsulation significantly improved the survival rate of the phages in the gastrointestinal tract compared with free phages.
Although there have been several studies on the microencapsulation of phages, most of them evaluate the phage microcapsules in vitro, and little is known about the survival of phages in vivo. In this study, phages targeting E. coli O157:H7 were microencapsulated by extrusion using the sodium alginate/CaCl2 system, and the effects of the microencapsulated phages both in vitro and in vivo were evaluated.
Materials and methods
Bacteria and phage
Phage PNJ1901 was isolated from chicken faeces and stored in a lab at Nanjing Agricultural University. E. coli O157:H7 was obtained from the Jiangsu Center for Disease Control and Prevention.
Bacterial culture and phage propagation
E. coli O157:H7 were cultured in LB medium at 37 °C in an incubator shaker at 180 rpm. The double-layer agar method was used for phage propagation as follows. First, 100 µL of E. coli O157:H7 in the logarithmic phase was mixed with 100 µL of phage PNJ1901. Then, the mixture was added to 5 mL of warm LB medium with 0.5% agar and spread onto an LB plate. The prepared plate was cooled at room temperature for 10 min, followed by incubation at 37 °C for approximately 8 h. After that, 5 mL of SM buffer was added to the double agar plate and incubated at 4 °C overnight. The phage solution was obtained by filtering the SM buffer through a 0.22 μm sterile filter.
Preparation of microcapsules
Microcapsules were prepared according to Ma’s descriptions with some modifications [21]. First, the designated amount of sodium alginate (Macklin, China) per the experimental protocol was mixed and stirred with ultrapure water to cause the sodium alginate to fully absorb water and swell for use. Second, the designated amount of phage was mixed with sodium alginate. Then, small droplets of the sodium alginate and phage mixture were pushed through a syringe at a uniform speed into a beaker containing cool CaCl2 solution on a magnetic stirrer (Thermo Scientific, USA). Finally, the droplets were allowed to solidify in the CaCl2 solution to obtain microcapsules, which were washed and filtered repeatedly with distilled water until there was no residual CaCl2 on the surface. The microcapsules obtained were stored at 4 °C in sealed tubes. To determine the titre of the microencapsulated phage, a total of 1 g of microcapsules was added to 9 mL of microcapsule-broken solution (MBS) containing 0.2 M sodium bicarbonate, 50 mM sodium citrate and 50 mM Tris–HCl (pH 7.5). The microcapsules were then dissolved with shaking at room temperature for 30 min [21, 23, 24]. Afterwards, 100 µL samples were collected and diluted ten-fold, and the phage titre in the solution was determined by double-layer agar. The phage encapsulation efficiency was calculated as follows: encapsulation efficiency (%) = (quantity of phage released from the dissolved microcapsules/quantity of phage initially placed in the prepared microcapsules) × 100% [21]. The results are presented as the mean encapsulation efficiency ± standard deviation (SD) of the microcapsule preparations. The experiment was repeated three times.
Orthogonal design for phage microencapsulation analysis
To find a preparation method with high encapsulation efficiency and investigate the optimal parameters of the microencapsulation procedure, five main factors were examined: the concentration of sodium alginate (Factor A, set at 1%, 1.5%, 2%, 2.5% and 3%); the ratio of phage to sodium alginate (Factor B, set at 4:1, 2:1, 1:1, 1:2 and 1:4); syringe needle diameter (Factor C, set at 0.5 mm, 0.6 mm, 0.7 mm, 0.9 mm and 1.2 mm); the concentration of CaCl2 (Factor D, set at 1%, 2%, 3%, 4% and 5%), and the speed of stirring (Factor E, set at 0 rpm, 100 rpm, 200 rpm, 300 rpm and 500 rpm) (Table 1). All of the factor levels were set according to consulted references and empirical experience. In addition, there was no interaction between each factor and level. Therefore, a five-factor five-level orthogonal table was designed using SPSS 19.0 (IBM, USA). The assay was repeated three times.
Morphology of the microencapsulated phages
The size and surface morphology of the microcapsules were examined by optical microscopy (Leica DM500, Germany).
Stability of the free and microencapsulated phages in simulated gastric fluid (SGF)
SGF was composed of 0.2% (wt/vol) NaCl and 3.2 mg/mL pepsin (Sigma–Aldrich, USA), with pH values of 2.0 and 2.4 [21]. For the free phage, 100 µL of free phage was mixed with 9.9 mL of prewarmed SGF (pH 2.0 or 2.4) and incubated with shaking at 100 rpm and 37 °C. At each time point (0, 5, 15, 30 and 60 min), a 100 µL sample was collected, ten-fold dilution was made, and the phage titre was determined with double-layer agar. For the microencapsulated phages, 1 g of microencapsulated phage was added to 10 mL of prewarmed SGF (pH 2.0 or 2.4) and incubated at 37 °C with shaking at 100 rpm. At 0, 15, 30, 60, 90, 120, 150, 180 and 240 min, the SGF was aspirated, and 10 mL of SM buffer (pH 7.5) was immediately added to terminate the reaction. The samples were collected, the microencapsulated phage was dissolved at room temperature to release the free phage into MBS as previously described, and the phage titre in the solution was quantified. SM buffer was used as a control. The experiment was repeated three times.
Stability of free and microencapsulated phages in BSs
BS solution consisted of 1% or 2% (wt/vol) porcine bile extract from Sigma–Aldrich [21]. For the free phages, 100 µL of free phage was placed into 9.9 mL of prewarmed BS and incubated with constant agitation at 100 rpm and 37 °C. Afterwards, a 100-µL sample was added to 900 µL of SM buffer at each predetermined time point (0, 15, 30, 45, 60, 90, 120, 150 and 180 min), and the phage titre was determined by double-layer agar.
For the microencapsulated phages, 1 g of microcapsules was added to test tubes containing 10 mL of prewarmed BS and incubated with constant agitation at 100 rpm at 37 °C. At 0, 15, 30, 45, 60, 90, 120, 150 and 180 min, samples were collected and washed with SM buffer three times, and the microcapsules were cracked to release the free phages into MBS to determine the phage titre. Distilled water (pH 7.0) was used as a control. This experiment was repeated three times.
Stability of the free phages and release rate of the microencapsulated phages in simulated intestinal fluid (SIF)
SIF was composed of 10 mg/mL pancreatin (Sigma–Aldrich) in 50 mM KH2PO4 at pH 6.8 [21]. To determine the stability of the free phages in SIF, 100 µL of free phage was mixed with 9.9 mL of prewarmed SIF and incubated with shaking at 100 rpm and 37 °C. At each time point (0, 1, 2, 3, 4, 5, 6, 12 and 24 h), a 100 µL sample was collected, tenfold dilution was made, and phage titre was determined by double-layer agar. To quantify the release rate of the microencapsulated phages, 1 g of microencapsulated phage was placed into conical tubes containing 50 mL of prewarmed SIF and incubated with constant agitation at 100 rpm and 37 °C. At each time point (0, 1, 2, 3, 4, 5, 6, 12 and 24 h), a 100 µL aliquot was removed, and the phage titre was determined after appropriate gradient dilution. The volume of the withdrawn sample was replaced by the same volume of fresh medium. The assay was carried out in triplicate.
Evaluation of the therapeutic effects of microencapsulated phages in vivo
Female Sprague–Dawley rats (200 ± 20 g) were purchased from SPF Biotechnology Co., Ltd., (China). The rats were allowed free access to water and feed for the first week for acclimation. The rats were then randomly divided into four groups (10 rats/group) as follows: negative control group, positive control group, free phage group and microencapsulated phage group. Streptomycin (5 g/L) was fed to all rats for 24 h to remove the intestinal flora, followed by food and water fasting for 24 h. Then, the rats were pretreated with 1 mL of 5% NaHCO3 to neutralize the gastric acid. After 20 min, each rat in the positive control group, free phage group and microencapsulated phage group was administered 2 mL of E. coli O157:H7 (109 CFU/mL, 1 mL/100 g) by gavage, while rats in the negative control group received 2 mL of PBS. The concentration of E. coli O157:H7 was determined in preliminary experiments. Eight hours after intragastric administration, each rat in the free phage group, microencapsulated phage group and positive control group was given 1 mL of free phage (108 PFU/rat), 1 g of microencapsulated phage (108 PFU/rat), or 1 mL PBS, respectively. During the week after administration, locomotor activity, clinical manifestations, food intake, weight change and death of the rats were observed and recorded; blood was collected to detect the levels of white blood cells (WBCs) and inflammatory markers (TNF-α, IL-6, IL-1β) (Abmart, China); and faeces were collected to detect the concentrations of E. coli O157:H7 and phage. E. coli O157:H7 in faeces was detected using sorbitol MacConkey agar plates (Hepobiol, China) and a PCR method (rfbE and fliC were used as specific target genes; Table 2) [25, 26].
Stability of the microencapsulated phages during storage
Microencapsulated phages were packed in sterile centrifuge tubes and stored at 4 °C. Microencapsulated samples were withdrawn, and the titre was determined each week. Free phages were used as a control.
Statistical analysis
A five-factor five-level orthogonal table was designed using SPSS version 19.0 for Windows. Statistical analyses were performed using the GraphPad Prism software package (GraphPad Software, USA). Significant differences were evaluated using Student’s t test for single group comparisons and one-way ANOVA for multiple comparisons. Figures show mean values ± standard deviations. Differences were considered significant at P < 0.05.
Results
Optimum parameters for phage microencapsulation
The results of the orthogonal experiments showed that the highest encapsulation efficiency of 77.767 ± 2.636% was achieved when the concentration of sodium alginate was 3%, the ratio of phage to sodium alginate was 4:1, the needle diameter of the syringe used for extrusion dropping was 0.6 mm, the concentration of CaCl2 was 2%, and the speed of stirring was set at 100 rpm (Table 1).
The appearance and microstructure of the microencapsulated phages
The appearance of the microencapsulated phages was uniform, with a shape close to that of a sphere (Figure 1A, B). When observed under a microscope, the surface of the microcapsule was nearly smooth with a few slight wrinkles. The average size of the microencapsulated phage particles was 1.759 mm (range 1.746–1.772 mm; Figure 1C).
Microencapsulated phages are more resistant to SGF than free phages
As the activity of free phages is easily destroyed by gastric acid, we hypothesized that microencapsulated phages would have increased stability in SGF. To test this hypothesis, both free and microencapsulated phages were exposed to SGF. The results showed that the free phage PNJ1901 was sensitive to this acidic environment (Figure 2A) and was mostly inactivated after 15 min or 30 min of incubation in SGF at pH 2 or pH 2.4 (Figure 2A). In contrast to the free phages, microencapsulated phages were quite stable in SGF. After incubation in SGF at pH 2.4 or pH 2 for 240 min, the titres of the microencapsulated phages decreased by only 0.242 ± 0.049 log10PFU/g and 0.528 ± 0.053 log10PFU/g, respectively (Figure 2B).
Stability of microencapsulated phages under simulated gastrointestinal conditions. Effects of SGF on A free phages and B microencapsulated phages. Stability of C free phages and D microencapsulated phage in BSs. Stability of E free phages and F the release of microencapsulated phages in SIF. Each value in the figure represents the mean ± SD (n = 3). The stability of the free and microencapsulated phages in SGF, BSs or SIF and the release rate of the microencapsulated phages in SIF were tested by calculating the titre of the phages at different time points after incubation in SGF, BSs or SIF. Each assay was carried out in triplicate.
Microencapsulated phages are more resistant to BSs than the free phages
After passing through gastric acid, orally administered phages need to pass through the duodenum with a high concentration of bile acids, so we next determined the stability of the microencapsulated phages in BSs. The titres of the free phages decreased by only 0.202 ± 0.124 log10 PFU/mL and 0.371 ± 0.109 log10 PFU/mL after incubation for 60 min in 1% and 2% BSs, respectively, while after 180 min of incubation, the titres decreased by 0.915 ± 0.022 log10 PFU/mL and 1.787 ± 0.029 log10 PFU/mL, respectively (Figure 2C). These results indicated that BSs had little short-term effects on free phages but did great harm after long exposure. The titres of the microencapsulated phages decreased by only 0.012 ± 0.012 log10 PFU/g and 0.099 ± 0.058 log10 PFU/g in 1% and 2% BSs, respectively, after 180 min of incubation (Figure 2D), indicating that the microencapsulated phages were more stable in BSs compared with the free phages.
Microencapsulated phages are efficiently released into SIF
Microencapsulated phages not only need to maintain their activity in gastric acid and bile acid but also require quick release in the intestinal tract to clear the target pathogenic bacteria efficiently. Therefore, we subsequently tested the release rate of the microencapsulated phages into SIF. To exclude the effects of SIF on the titre of the released phages, we first detected the stability of the free phages in SIF, and the results showed that the titre of the free phages remained stable without significant loss after 24 h of incubation (Figure 2E). Thus, the free phages had good tolerance to SIF. In the next release experiment, we observed that the release of the phages from the microcapsules in SIF increased with time. After incubation in SIF for 6 h, the titre of the released phages was 6.653 ± 0.020 log10 PFU/mL, suggesting a cumulative release of 70.313% of the starting titre (Figure 2F). After incubation in SIF for 24 h, the titre of the released phages reached 6.761 ± 0.012 log10 PFU/mL, representing a release rate of 90.104%, which was close to complete release (6.806 log10 PFU/mL) (Figure 2F).
Microencapsulated phages show better therapeutic effects than free phages in vivo
Since the microencapsulated phages performed better than free phages in vitro, we next tested their effects in vivo. Rats infected with E. coli O157:H7 received microencapsulated or free phages 8 h post-infection. Rats receiving E. coli or PBS alone were used as positive and negative controls, respectively. The rats were monitored for 7 days. In the free phage group, the rats were less active, huddled together and ate less in the first 5 days after infection, but their condition improved during the last 2 days. Rats in the microencapsulated phage group had similar symptoms as those in the free phage group, but they began to recover on Day 4, which was 2 days earlier than the free phage group. To assess survival, 30% of rats in the free phage group survived, while the survival rate of the rats in the microencapsulated phage group increased to 60% (P < 0.05; Figure 3A). In contrast, all of the rats receiving E. coli alone died, while the rats in the negative control group receiving PBS all survived (P < 0.05; Figure 3A).
Therapeutic effects of microencapsulated phages in vivo. A Survival curves of rats within one week after administration of E. coli. Rats challenged with E. coli O157:H7 (109 CFU/mL, 1 mL/100 g) were gavaged with free or microencapsulated phages (108 PFU/rat) 8 h after infection. Rats in the positive control group were gavaged with E. coli O157:H7 and PBS. Rats in the negative control group received only 2 mL of PBS. Survival rates of the rats in all groups were monitored. B Changes in the weights of the rats within one week after administration of E. coli. The weights of the rats in the free phage, microencapsulated phage and negative control groups were monitored for 1 week. Statistical analysis was used to compare the microencapsulated phage group and the free phage group. ns, no significant difference; *P < 0.05; **P < 0.01.
As shown in Figure 3B, the rats in the negative control group gained weight continuously throughout the week of observation. The weights of the rats in both the free phage group and microencapsulated phage group first decreased and then increased. However, the weights of the rats in the microencapsulated phage group increased earlier and to a greater extent (P < 0.05) than the weights of the rats in the free phage group, which was consistent with the behavioural symptoms, indicating that the rats in the microencapsulated phage group recovered faster and more completely than the rats in the free phage group. The fluctuation in WBC count and TNF-α, IL-6 and IL-1β content in rat blood during the first week after infection were also monitored. As shown in Figure 4A, the WBC counts of the rats in the negative control group were in the normal range. The WBC counts in the free phage group were higher than the normal range during the first 2 days, then decreased to the normal range and continued to decline but were still higher than the counts in the negative control group. The WBC counts in the microencapsulated phage group decreased to the normal range after the first day, displaying a faster decrease than that of the free phage group. By Day 7, the WBC counts were closer to those of the negative control group than to those of the free phage group. As shown in Figure 4B–D, the changes in TNF-α, IL-6 and IL-1β contents were similar in both phage groups. Although the cytokines in both the free phage group and microencapsulated phage group were initially much higher than those in the negative control group, they continued to decline during the first week after infection. Cytokines in the microencapsulated phage group decreased faster (P < 0.05) than in the free phage group, dropping to nearly the same level as the negative control group on Day 5, while the concentrations of cytokines in the free phage group remained higher than the negative control group on Day 7, indicating that the microencapsulated phages had a more potent effect on inflammation.
The concentration of WBCs and inflammatory factors in vivo. A Changes in WBCs in rats within 1 week after administration of E. coli. The two dashed lines represent the normal range of WBCs in rats. Changes in B TNF-α, C IL-6 and D IL-1β in rats within one week after administration of E. coli. Each value in the figure represents the mean ± SD (n = 3) with the exception of Figure 4A. Statistical analysis was used to compare the microencapsulated phage group and the free phage group. ns, no significant difference; *P < 0.05; **P < 0.01.
To determine whether the better therapeutic effects of the microencapsulated phages were due to their stability in vivo, the concentrations of phages and bacteria in the faeces of rats was tested for one week after infection. As shown in Figure 5A, the phage titre in the rat faeces from the microencapsulated phage group was significantly higher (P < 0.05) than the titre in the faeces from the free phage group. Additionally, phages were detected for 5 consecutive days in the faeces from the microencapsulated phage group, while phages were not detected at all in faeces from the free phage group on Day 4. E. coli O157:H7 in faeces was identified using sorbitol MacConkey agar plates and PCR. As shown in Figure 5B, the bacterial concentration in the faeces from the microencapsulated phage group was significantly lower (P < 0.01) than its concentration in the faeces from the free phage group. E. coli O157:H7 was not detected on Day 4 in faeces from the microencapsulated phage group, while it was detected in faeces from the free phage group for 7 consecutive days. These results suggested that the microencapsulated phages were more stable in vivo, which led to the greater bactericidal effects than those of the free phages.
Phage and bacterial load in faeces. A Phage titre in the faeces of rats within 1 week after administration of E. coli. B Bacterial concentration in the faeces of rats within 1 week after administration of E. coli. Faeces of rats from the free phage, microencapsulated phage and negative control groups were collected to detect the concentrations of E. coli O157:H7 and phage. E. coli O157:H7 in faeces was detected using sorbitol MacConkey agar plates and the PCR method (rfbE and fliC were used as specific target genes). Phage titre was determined by double-layer agar. Each value in the figure represents the mean ± SD (n = 3). Statistical analysis was used to compare the microencapsulated phage group and the free phage group. ns, no significant difference; *P < 0.05; **P < 0.01.
Microencapsulated phages are more stable than free phages during storage
Preserving the stability of therapeutic agents during storage is very important, so we compared the stabilities of microencapsulated and free phages during storage. The titre of the free phages decreased nearly 3 log units when it was stored at 4 °C for 15 weeks, while the titre of the microencapsulated phages decreased only 1 log unit when stored for the same period (P < 0.01; Figure 6). These results demonstrated that microencapsulated phages were more stable than free phages when stored at 4 °C.
Stability of free and microencapsulated phages during storage. Free and microencapsulated phages were stored at 4 °C, and the titre was measured every week. Each value in the figure represents the mean ± SD (n = 3). Statistical analysis was used to compare the microencapsulated phage group and the free phage group. ns, no significant difference; *P < 0.05; **P < 0.01.
Discussion
Viruses (including phages) easily lose their activity in the presence of acid, heat and organic solvents and in the absence of water [21]. Encapsulation technologies are the most common methods to protect phages from adverse conditions. Extrusion dropping methods, spray drying, emulsion and polymerization techniques are the most popular techniques and methods for encapsulating microorganisms [27]. The extrusion dropping method was adopted in this study because it is relatively simple for the production of microcapsules. In addition, the preparation conditions are mild, and the size of the prepared microcapsules is uniform. Cellulose, liposomes, alginate, whey protein and gelatine are the most common biomaterials for phage encapsulation and have been applied by different technologies [27, 28]. Sodium alginate is a good microencapsulation material with good biocompatibility that utilizes a mild gel process and does not show toxicity [21]. In addition, the molecular chain of sodium alginate shrinks at low pH and stretches at high pH, showing clear pH sensitivity that makes it suitable for encapsulating oral phages. Sodium alginate can react with Ca2+ to form a gel [23, 29]. The reaction mechanism involves Ca2+ and two GG fragments on the molecular chain of sodium alginate interacting through four coordination bonds to form the so-called “egg-box” structure, which causes the adjacent molecular chain of sodium alginate to transform from random line clusters into curved band structures cross-linked by Ca2+ that intertwine to form a three-dimensional gel network. The sodium alginate/CaCl2 system was used for phage microencapsulation in this study.
The concentration of sodium alginate affects not only the encapsulation efficiency of the microencapsulated phages but also the shape, mechanical strength and difficulty of forming microencapsulated phages [30,31,32,33]. When the concentration of sodium alginate is low, it cannot fully react with CaCl2, resulting in the formation of a thin microcapsule membrane with a soft texture and an irregular shape that damages easily, leading to a low encapsulation efficiency. The encapsulation efficiency increases with increasing sodium alginate concentration. However, when the concentration of sodium alginate is greater than 3%, the viscosity of the solution becomes too high, making passage through the pinhole of the syringe difficult and leading to atypically shaped microcapsules (with tails). The ratio of phage to sodium alginate affects the retention rate of the phage and the encapsulation efficiency of the microcapsules [34]. Different needle diameters used for extrusion dropping will directly lead to different volumes of extruded droplets. During the process of preparing microcapsules, Ca2+ acts as a cross-linking agent, which makes the independent linear molecules connect with each other to form a space network structure that is conducive to the formation of microcapsules [35]. When the concentration of CaCl2 is too low, there is not enough Ca2+ to cross-link with the Na+ in sodium alginate, so the microcapsules are slow to form and show a trailing phenomenon, increased adhesion and a soft texture. With increasing CaCl2 concentration, the degree of cross-linking between Ca2+ and sodium alginate increases, causing the hardness of the microcapsule to increase. However, when the concentration of CaCl2 is too high, the outer layer of CaCl2 and sodium alginate solidifies rapidly, forming a dense cross-linked structure before the inner layer solidifies. This makes the capsule wall thicker and brittle and hinders both the continuous diffusion of Ca2+ and the full encapsulation of phage into the inner layer of the microcapsule, resulting in a hard microencapsulated phage with low encapsulation efficiency. Stirring speed is also very important because it affects the solidification of the microcapsules. A low stirring speed is not conducive to full phage encapsulation, resulting in low encapsulation efficiency, while high stirring speed will lead to phage loss.
The primary requirement for oral phage therapy to treat intestinal diseases is phage survival in gastric acid, but most free phages are extremely sensitive to low pH conditions and are easily inactivated when the pH value is below 3.5 [36]. A study has shown that solutions and small pellets (less than 2 mm in size) empty from the stomach quite rapidly and are not greatly affected by individual digestive states [37]. The average half-emptying time of liquids and pellet systems in vivo is approximately 0.5–1.5 h [37]. Another study showed that the average passage time through the small intestine in a healthy body is 3–4 h, with a maximum time of 6 h [37]. In the present study, the particle size of the microencapsulated phages was less than 2 mm, so it could be emptied from the stomach in a short time; moreover, sodium alginate can shrink in the stomach to protect the phage from damage caused by gastric acid and digestive enzymes, ensuring that the activity of microencapsulated phage will not be greatly affected at pH 2 or pH 2.4. In contrast, the free phages were completely inactivated within 30 min and clearly could not survive well in gastric acid.
Bile acids are synthesized by the liver and stored in the gallbladder when digestion is not occurring and then are discharged in large quantities from the liver or the gallbladder [38, 39] directly into the duodenum during digestion. After passing through gastric acid, the oral phage needs to pass through the duodenum with a high concentration of bile acids. Our results showed that the stability of phages in bile salts was significantly improved after microencapsulation. Compared with gastric acid, bile salts have less of an effect on the activity of free phages. The reason for this may be that the phages do not contain lipid components, so they are tolerant to amphoteric molecules such as bile salts.
Microencapsulated phages need to not only maintain their activity in gastric acid and bile salts but also be released in the intestinal tract in a timely manner. Nearly 70.313% of the total amount of microencapsulated phages were released into SIF within 6 h, and almost all were released within 24 h, leading to bacterial elimination. We also investigated the stability of the free phage PNJ1901 into SIF before we performed the microencapsulated phage release experiment. Ramirez et al. [40] conducted release experiments of microencapsulated phages in SIF in vitro and found that the release rate was significantly slower than that of phages incubated in PBS. However, due to the lack of stability experiments with the free phages in SIF, they could not determine whether this phenomenon was due to phage release failure or the inactivation of the released phages caused by enzymes in the SIF [40]. In the present study, our results showed that the free phages had good tolerance to SIF, ensuring their stability when the microencapsulated phages were released into SIF.
Based on the superiority of the microencapsulated phages over their free counterparts, we were very interested in the therapeutic effects of the microencapsulated phages in vivo. This experiment was conducted in Sprague Dawley rats. We found that high doses of E. coli O157:H7 could lead directly to the death of rats, with obvious pathological changes such as a yellowing and odorous intestinal cavity, enlargement of the stomach, thinning and adhesion of the intestinal wall, and damage to the duodenal villi. We selected 109 CFU/mL E. coli O157:H7 as the optimal gavage dose, as this dose caused the death of all rats in our preliminary experiment. In the therapeutic experiment, 5 g/L streptomycin was fed for 24 h to the rats 2 days in advance of E. coli exposure to clear the intestinal flora and reduce their later impact. Fasting 1 day in advance allowed the emptying of residual food from the intestinal tract and increased the likelihood of E. coli O157 contacting the intestinal mucosa; furthermore, 1 mL of 5% NaHCO3 was given by gavage 20 min before E. coli challenge, which neutralized gastric acid and reduced the possible damage to E. coli O157. The survival curves of the rats during the week after E. coli administration thus directly reflected the therapeutic effect. In this study, the survival rates of the rats in the free phage group and microencapsulated phage group were 30% and 60%, respectively, which indicated that the protective effect of the microcapsule was substantial. Moreover, the change in weight within one week after administration of the phages may reflect rat recovery. In this study, the weight gain of the rats in the microencapsulated phage group occurred earlier than the weight gain of the rats in the free phage group, suggesting that the recovery of the rats in the microencapsulated phage group was faster than the recovery of the rats in the free phage group.
TNF-α is a cytokine that can activate and aggregate inflammatory cells and promote the release of a variety of inflammatory mediators, such as IL-6 and IL-1β, in a variety of cells [41]. As proinflammatory cytokines, IL-1β and IL-6 are widely involved in many pathological injury processes, such as tissue destruction and oedema formation. When inflammation occurs in the body, a variety of cells can secrete these cytokines after stimulation. The levels of inflammatory cytokines thus reflect the conditions of body injury and inflammation. In the present study, the levels of TNF-α, IL-6 and IL-1β in the serum of rats were detected by ELISA during the week after bacteria and phage administration. The decrease in cytokines in the microencapsulated phage group occurred earlier and faster than the decrease in the free phage group, indicating that the microencapsulated phage had a greater effect on the elimination of inflammation. As the microencapsulated phages were more resistant to SGF and BSs and showed good release in SIF in vitro, we hypothesized that the greater therapeutic effect was due to the increased stability of the microencapsulated phages in vivo compared to the free phages. Therefore, we examined the titre of the phages and the concentration of bacteria in faeces. The results showed that the titre of the microencapsulated phages was significantly higher and lasted longer than that of the free phages, which led to a lower concentration of pathogenic bacteria in faeces. The higher titre of the phage in faeces was likely due to the prolonged survival of more phages in gastric acid and bile. The long duration of phage titre detection in faeces from the microencapsulated phage group was likely the result of slow phage release from the microcapsules. The results of the above experiments show that the therapeutic effects of microencapsulated phages in vivo are better than those of free phages, indicating that the stability of phages is important for therapeutic efficiency in vivo.
It should be noted that rats were gavaged with streptomycin (5 g/L) to remove the intestinal flora and with 5% NaHCO3 to neutralize gastric acid before bacterial infection. This pretreatment aimed to facilitate colonization of E. coli O157:H7 in the intestine, but the side effect was that the intestinal microbiota was destroyed. Although the microbiota will recover over time, it will not be the same as that in a truly infected animal with a full microbiome. The gut microbiota has several physiological effects on the host immune system, both locally and systemically, which consequently influences the efficacy of drugs and vaccinations [42, 43]. Future studies should be performed to evaluate the therapeutic effects of microencapsulated phages in truly infected animals.
In summary, in this study, we prepared microencapsulated phages and evaluated their stability in vitro and their therapeutic effects in vivo. We showed that compared to free phages, microencapsulation could protect phages from gastric acid and bile acid and that they could be released in the intestinal tract under simulated gastrointestinal conditions in vitro. In addition, microencapsulated phages had longer stability during storage. More importantly, animal experiments demonstrated that the therapeutic effects of microencapsulated phages in vivo were better than those of free phages. All of these results confirm the feasibility and effectiveness of phage microencapsulation, suggesting that microencapsulated phages have the potential to protect against E. coli O157 infections in animals. Although there are still many problems and obstacles in phage therapy, especially in gastrointestinal therapy, phage microencapsulation can improve the resistance of phages in the gastrointestinal tract and enhance their activity in vivo, which may improve the effectiveness of phage therapy as a substitute for antibiotics.
Availability of data and materials
The datasets used and/or analysed during the current study are available from the corresponding author upon reasonable request.
Abbreviations
- E. coli :
-
Escherichia coli
- EHEC:
-
Enterohemorrhagic Escherichia coli
- BSs:
-
bile salts
- SGF:
-
simulated gastric fluid
- SIF:
-
simulated intestinal fluid
- WBCs:
-
white blood cells
- TNF:
-
tumour necrosis factor
- IL:
-
interleukin
- MBS:
-
microcapsule-broken solution
- SD:
-
standard deviation
References
Robinson C, Sinclair J, Smith M, O’Brien A (2006) Shiga toxin of enterohemorrhagic Escherichia coli type O157:H7 promotes intestinal colonization. Proc Natl Acad Sci USA 103:9667–9672. https://doi.org/10.1073/pnas.0602359103
Fathi J, Ebrahimi F, Nazarian S, Hajizade A, Malekzadegan Y, Abdi A (2020) Production of egg yolk antibody (IgY) against shiga-like toxin (stx) and evaluation of its prophylaxis potency in mice. Microb Pathog 145:104199. https://doi.org/10.1016/j.micpath.2020.104199
Albanese A, Sacerdoti F, Seyahian E, Amaral M, Fiorentino G, Fernandez Brando R, Vilte D, Mercado E, Palermo M, Cataldi A, Zotta E, Ibarra C (2018) Immunization of pregnant cows with Shiga toxin-2 induces high levels of specific colostral antibodies and lactoferrin able to neutralize E. coli O157:H7 pathogenicity. Vaccine 36:1728–1735. https://doi.org/10.1016/j.vaccine.2018.02.060
Batz M, Hoffmann S, Morris J (2012) Ranking the disease burden of 14 pathogens in food sources in the United States using attribution data from outbreak investigations and expert elicitation. J Food Prot 75:1278–1291. https://doi.org/10.4315/0362-028x.Jfp-11-418
Fan C, Tie D, Sun Y, Jiang J, Huang H, Gong Y, Zhao C (2021) Characterization and genomic analysis of Escherichia coli O157:H7 bacteriophage FEC14, a new member of genus Kuttervirus. Curr Microbiol 78:159–166. https://doi.org/10.1007/s00284-020-02283-x
Dominey-Howes D, Bajorek B, Michael C, Betteridge B, Iredell J, Labbate M (2015) Applying the emergency risk management process to tackle the crisis of antibiotic resistance. Front Microbiol 6:927. https://doi.org/10.3389/fmicb.2015.00927
Streicher L (2021) Exploring the future of infectious disease treatment in a post-antibiotic era: a comparative review of alternative therapeutics. J Glob Antimicrob Resist 24:285–295. https://doi.org/10.1016/j.jgar.2020.12.025
Tang Q, Song P, Li J, Kong F, Sun L, Xu L (2016) Control of antibiotic resistance in China must not be delayed: the current state of resistance and policy suggestions for the government, medical facilities, and patients. Biosci Trends 10:1–6. https://doi.org/10.5582/bst.2016.01034
Qiao M, Ying G, Singer A, Zhu Y (2018) Review of antibiotic resistance in China and its environment. Environ Int 110:160–172. https://doi.org/10.1016/j.envint.2017.10.016
Yen M, Cairns LS, Camilli A (2017) A cocktail of three virulent bacteriophages prevents Vibrio cholerae infection in animal models. Nat Commun 8:14187. https://doi.org/10.1038/ncomms14187
Panos G, Betsi G, Falagas M (2006) Systematic review: are antibiotics detrimental or beneficial for the treatment of patients with Escherichia coli O157:H7 infection? Aliment Pharmacol Ther 24:731–742. https://doi.org/10.1111/j.1365-2036.2006.03036.x
Monteiro R, Pires D, Costa A, Azeredo J (2019) Phage therapy: going temperate? Trends Microbiol 27:368–378. https://doi.org/10.1016/j.tim.2018.10.008
Gordillo Altamirano F, Barr J (2019) Phage Therapy in the postantibiotic era. Clin Microbiol Rev 32:e00066-e118. https://doi.org/10.1128/cmr.00066-18
Ferriol-Gonzalez C, Domingo-Calap P (2021) Phage therapy in livestock and companion animals. Antibiotics 10:559. https://doi.org/10.3390/antibiotics10050559
Prazak J, Valente L, Iten M, Federer L, Grandgirard D, Soto S, Resch G, Leib SL, Jakob SM, Haenggi M, Cameron DR, Que YA (2021) Benefits of aerosolized phages for the treatment of pneumonia due to methicillin-resistant Staphylococcus aureus (MRSA): an experimental study in rats. J Infect Dis. https://doi.org/10.1093/infdis/jiab112
Hesse S, Malachowa N, Porter AR, Freedman B, Kobayashi SD, Gardner DJ, Scott DP, Adhya S, DeLeo FR (2021) Bacteriophage treatment rescues mice infected with multidrug-resistant Klebsiella pneumoniae ST258. mBio 12:e00034-21. https://doi.org/10.1128/mBio.00034-21
Kortright K, Chan B, Koff J, Turner P (2019) Phage therapy: a renewed approach to combat antibiotic-resistant bacteria. Cell Host Microbe 25:219–232. https://doi.org/10.1016/j.chom.2019.01.014
Acar Soykut E, Tayyarcan E, Evran Ş, Boyacı İ, Çakır İ, Khaaladi M, Fattouch S (2019) Microencapsulation of phages to analyze their demeanor in physiological conditions. Folia Microbiol 64:751–763. https://doi.org/10.1007/s12223-019-00688-1
Cui H, Yuan L, Lin L (2017) Novel chitosan film embedded with liposome-encapsulated phage for biocontrol of Escherichia coli O157:H7 in beef. Carbohydr Polym 177:156–164. https://doi.org/10.1016/j.carbpol.2017.08.137
Yao M, Xie J, Du H, McClements D, Xiao H, Li L (2020) Progress in microencapsulation of probiotics: a review. Compr Rev Food Sci Food Saf 19:857–874. https://doi.org/10.1111/1541-4337.12532
Ma Y, Pacan JC, Wang Q, Xu Y, Huang X, Korenevsky A, Sabour PM (2008) Microencapsulation of bacteriophage felix O1 into chitosan-alginate microspheres for oral delivery. Appl Environ Microbiol 74:4799–4805. https://doi.org/10.1128/AEM.00246-08
Colom J, Cano-Sarabia M, Otero J, Aríñez-Soriano J, Cortés P, Maspoch D, Llagostera M (2017) Microencapsulation with alginate/CaCO: a strategy for improved phage therapy. Sci Rep 7:41441. https://doi.org/10.1038/srep41441
Boggione D, Batalha L, Gontijo M, Lopez M, Teixeira A, Santos I, Mendonça R (2017) Evaluation of microencapsulation of the UFV-AREG1 bacteriophage in alginate-Ca microcapsules using microfluidic devices. Colloids Surf B Biointerfaces 158:182–189. https://doi.org/10.1016/j.colsurfb.2017.06.045
Liu X, Yu W, Zhang Y, Xue W, Yu W, Xiong Y, Ma X, Chen Y, Yuan Q (2002) Characterization of structure and diffusion behaviour of Ca-alginate beads prepared with external or internal calcium sources. J Microencapsul 19:775–782. https://doi.org/10.1080/0265204021000022743
Garcia-Sanchez A, Sanchez S, Rubio R, Pereira G, Alonso JM, Hermoso de Mendoza J, Rey J (2007) Presence of Shiga toxin-producing E. coli O157:H7 in a survey of wild artiodactyls. Vet Microbiol 121:373–377. https://doi.org/10.1016/j.vetmic.2006.12.012
Sánchez S, Martínez R, García A, Blanco J, Echeita A, Hermoso de Mendoza J, Rey J, Alonso J (2010) Shiga toxin-producing Escherichia coli O157:H7 from extensive cattle of the fighting bulls breed. Res Vet Sci 88:208–210. https://doi.org/10.1016/j.rvsc.2009.07.014
Choińska-Pulit A, Mituła P, Śliwka P, Łaba W, Skaradzińska A (2015) Bacteriophage encapsulation: trends and potential applications. Trends Food Sci Technol 45:212–221. https://doi.org/10.1016/j.tifs.2015.07.001
Hussain M, Liu H, Wang Q, Zhong F, Guo Q, Balamurugan S (2017) Use of encapsulated bacteriophages to enhance farm to fork food safety. Crit Rev Food Sci Nutr 57:2801–2810. https://doi.org/10.1080/10408398.2015.1069729
Li R, Zhang X, Shi H (2011) Effect of manufacturing parameters on the release profiles of casein-loaded alginate microspheres prepared by emulsification/internal gelation. J Control Release 152:e154-155. https://doi.org/10.1016/j.jconrel.2011.08.058
Hajifathaliha F, Mahboubi A, Nematollahi L, Mohit E, Bolourchian N (2020) Comparison of different cationic polymers efficacy in fabrication of alginate multilayer microcapsules. Asian J Pharm Sci 15:95–103. https://doi.org/10.1016/j.ajps.2018.11.007
Davarcı F, Turan D, Ozcelik B, Poncelet D (2017) The influence of solution viscosities and surface tension on calcium-alginate microbead formation using dripping technique. Food Hydrocoll 62:119–127. https://doi.org/10.1016/j.foodhyd.2016.06.029
Kendall W, Darrabie M, El-Shewy H, Opara E (2004) Effect of alginate composition and purity on alginate microspheres. J Microencapsul 21:821–828. https://doi.org/10.1080/02652040400015452
Gansau J, Kelly L, Buckley C (2018) Influence of key processing parameters and seeding density effects of microencapsulated chondrocytes fabricated using electrohydrodynamic spraying. Biofabrication 10:035011. https://doi.org/10.1088/1758-5090/aacb95
Ortiz-Basurto R, Rubio-Ibarra M, Ragazzo-Sanchez J, Beristain C, Jiménez-Fernández M (2017) Microencapsulation of Eugenia uniflora L. juice by spray drying using fructans with different degrees of polymerisation. Carbohydr Polym 175:603–609. https://doi.org/10.1016/j.carbpol.2017.08.030
Khorshidian N, Mahboubi A, Kalantari N, Hosseini H, Yousefi M, Arab M, da Cruz A, Mortazavian A, Mahdavi F (2019) Chitosan-coated alginate microcapsules loaded with herbal galactagogue extract: formulation optimization and characterization. Iran J Pharm Res 18:1180–1195. https://doi.org/10.22037/ijpr.2019.1100776
Brüssow H (2005) Phage therapy: the Escherichia coli experience. Microbiology 151:2133–2140. https://doi.org/10.1099/mic.0.27849-0
Davis S, Hardy J, Fara J (1986) Transit of pharmaceutical dosage forms through the small intestine. Gut 27:886–892. https://doi.org/10.1136/gut.27.8.886
Begley M, Hill C, Gahan C (2006) Bile salt hydrolase activity in probiotics. Appl Environ Microbiol 72:1729–1738. https://doi.org/10.1128/aem.72.3.1729-1738.2006
Gotcheva V, Petrova G, Petkova M, Kuzmanova Y, Angelov A (2018) Lactobacillus plantarum molecular and in vitro assessment of some probiotic characteristics of amylolytic strains from Bulgarian fermented products. Eng Life Sci 18:820–830. https://doi.org/10.1002/elsc.201800054
Ramirez K, Cazarez-Montoya C, Lopez-Moreno H, Castro-Del Campo N (2018) Bacteriophage cocktail for biocontrol of Escherichia coli O157:H7: stability and potential allergenicity study. PLoS One 13:e0195023. https://doi.org/10.1371/journal.pone.0195023
Jiang G, Lei A, Chen Y, Yu Q, Xie J, Yang Y, Yuan T, Su D (2021) The protective effects of the Ganoderma atrum polysaccharide against acrylamide-induced inflammation and oxidative damage in rats. Food Funct 12:397–407. https://doi.org/10.1039/d0fo01873b
Hosomi K, Kunisawa J (2020) Impact of the intestinal environment on the immune responses to vaccination. Vaccine 38:6959–6965. https://doi.org/10.1016/j.vaccine.2020.08.079
Wahida A, Tang F, Barr JJ (2021) Rethinking phage-bacteria-eukaryotic relationships and their influence on human health. Cell Host Microbe 29:681–688. https://doi.org/10.1016/j.chom.2021.02.007
Acknowledgements
We thank International Science Editing for editing this manuscript.
Funding
The authors acknowledge financial support from the Natural Science Foundation of Jiangsu Province (BK20180075) and the Fund of Priority Academic Program Development of Jiangsu Higher Education Institutions (PAPD).
Author information
Authors and Affiliations
Contributions
FT designed the experiments and helped write the manuscript. HY wrote the manuscript and performed most of the experiments described in the manuscript. JL, HH, YW, XQ, JR and FX offered help during the experiments. JD provided valuable suggestions for the experiments. All authors read and approved the final manuscript.
Corresponding author
Ethics declarations
Ethics approval and consent to participate
All rats were housed individually in specific pathogen-free cages in the Laboratory Animal Center of Nanjing Agricultural University. The animal study protocol was approved by the Animal Ethics Committee at Nanjing Agricultural University, protocol number SYXK(SU)2011–0036, Nanjing, China. All experiments were performed according to the International Code of Practice for the care and use of animals for scientific purposes. Temperature and humidity were maintained at 21–23 °C and 60–65%, respectively.
Competing interests
The authors declare that they have no competing interests.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated in a credit line to the data.
About this article
Cite this article
Yin, H., Li, J., Huang, H. et al. Microencapsulated phages show prolonged stability in gastrointestinal environments and high therapeutic efficiency to treat Escherichia coli O157:H7 infection. Vet Res 52, 118 (2021). https://doi.org/10.1186/s13567-021-00991-1
Received:
Accepted:
Published:
DOI: https://doi.org/10.1186/s13567-021-00991-1