Skip to main content
SpringerLink
Log in

Dynamic Recrystallization Behavior of Bimodal Size SiCp-Reinforced Mg Matrix Composite during Hot Deformation

  • Published:
Acta Metallurgica Sinica (English Letters) Aims and scope

Abstract

The (submicron + micron) bimodal size SiCp-reinforced Mg matrix composite was compressed at the temperature of 270–420 °C and strain rate of 0.001–1 s−1. Then, dynamic recrystallization (DRX) behavior of the composite was investigated by thermodynamic method and verified by microstructure analysis. Results illustrated that the composite possess the lower critical strain and higher DRX ratio as compared to monolithic Mg alloys during hot deformation process. The predicted DRX ratio increased with the proceeding of compression, which was well consistent with the experimental value. Results from thermodynamic calculation suggested that the occurrence of DRX could be promoted by SiCp, which would be further proved by microstructure analysis. Formation of particle deformation zone around micron SiCp played a significant role in promoting DRX nucleation. Nevertheless, the distribution of submicron SiCp was increasingly uniform with the proceeding of compression, which could fully restrain grain growth. Therefore, the corporate effects of micron and submicron SiCp on DRX contributed to the improvement of DRXed ratio and the refinement of grain size for the composite during compression process.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11

Similar content being viewed by others

References

  1. K.K. Deng, C.J. Wang, X.J. Wang, K. Wu, M.Y. Zheng, Mater. Des. 38, 110 (2012)

    Article  Google Scholar 

  2. T. Al-samman, G. Gottstein, Mater. Sci. Eng. A 490, 411 (2008)

    Article  Google Scholar 

  3. H.T. Zhou, Q.B. Li, Z.K. Zhao, Z.C. Liu, S.F. Wen, Q.D. Wang, Mater. Sci. Eng. A 527, 2022 (2010)

    Article  Google Scholar 

  4. X.J. Wang, X.S. Hu, K. Wu, Mater. Sci. Eng. A 492, 481 (2008)

    Article  Google Scholar 

  5. T. Sakai, J.J. Jonas, Acta Metall. 32, 189 (1984)

    Article  Google Scholar 

  6. E.P. Busso, Int. J. Plast 14, 319 (1998)

    Article  Google Scholar 

  7. J.P. Sah, G.J. Richardson, C.M. Sellars, Met. Sci. 8, 325 (1974)

    Article  Google Scholar 

  8. E.I. Poliak, J.J. Jonas, Mater. Sci. Forum 57, 426 (2003)

    Google Scholar 

  9. S.M. Fatemi-Varzaned, A. Zarei-Hanzaki, H. Beladi, Mater. Sci. Eng. A 456, 52 (2007)

    Article  Google Scholar 

  10. J. Liu, Z. Cui, L. Rvan, Mater. Sci. Eng. A 529, 300 (2011)

    Article  Google Scholar 

  11. K.K. Deng, X.J. Wang, M.Y. Zheng, K. Wu, Mater. Sci. Eng. A 560, 824 (2013)

    Article  Google Scholar 

  12. X.J. Wang, X.S. Hu, Y.Q. Wang, K.B. Nie, K. Wu, M.Y. Zheng, Mater. Sci. Eng. A 559, 139 (2012)

    Article  Google Scholar 

  13. K.K. Deng, X.J. Wang, Y.W. Wu, X.S. Hu, K. Wu, W.M. Gan, Mater. Sci. Eng. A 543, 158 (2012)

    Article  Google Scholar 

  14. V. Laurent, P. Jarry, G. Regazzoni, D. Apelian, J. Mater. Sci. 27, 4447 (1992)

    Article  Google Scholar 

  15. R.D. Doherty, D.A. Hughes, F.J. Humphreys, J.J. Jonas, D.J. Jensen, M.E. Kassner, Mater. Sci. Eng. A 238, 219 (1997)

    Article  Google Scholar 

  16. K.K. Deng, J.Y. Shi, C.J. Wang, X.J. Wang, Y.W. Wu, K.B. Nie, K. Wu, Compos. A 43, 1280 (2012)

    Article  Google Scholar 

  17. H.J. McQueen, Encyclopedia of Materials: Science and Technology (Elsevier Science, Oxford UK, 2001), p. 2375

    Book  Google Scholar 

  18. S.E. Ion, F.J. Humphreys, S.H. White, Acta Metall. 30, 1909 (1982)

    Article  Google Scholar 

  19. E.I. Poliak, J.J. Jonas, Acta Mater. 44, 127 (1996)

    Article  Google Scholar 

  20. X.H. Fan, W.Q. Tang, S.R. Zhang, D.Y. Li, Y.H. Peng, Acta Metall. Sin. (Engl. Lett.) 23, 334 (2010)

    Google Scholar 

  21. S.S. Zhou, K.K. Deng, J.C. Li, S.J. Shang, W. Liang, J.F. Fan, Mater. Des. 63, 672 (2014)

    Article  Google Scholar 

  22. X.J. Wang, K. Wu, W.X. Huang, H.F. Zhang, M.Y. Zheng, D.L. Peng, Compos. Sci. Technol. 67, 2253 (2007)

    Article  Google Scholar 

  23. A. Luo, Metall. Mater. Trans. A 26, 2445 (1995)

    Article  Google Scholar 

  24. K. Wu, K.K. Deng, H. Chang, Y.W. Wu, X.S. Hu, Acta Metall. Sin. 23, 99 (2010)

    Google Scholar 

  25. J. Hashim, L. Looney, M.S.J. Hashmi, J. Mater. Process. Technol. 92–93, 1 (1999)

    Article  Google Scholar 

  26. J.A. Vreeling, V. Ocelik, G.A. Hamstra, Y.T. Pei, D.E. Hosson, Scr. Mater. 42, 589 (2000)

    Article  Google Scholar 

  27. D.H. Sastry, Y.V.R.K. Prasad, K.I. Vasu, Scr. Metall. 3, 927 (1969)

    Article  Google Scholar 

  28. J.C. Tan, M.J. Tan, Mater. Sci. Eng. A 339, 124 (2003)

    Article  Google Scholar 

  29. S.W. Xu, N. Matsumoto, S. Kamado, T. Honma, Y. Kojima, Mater. Sci. Eng. A 523, 47 (2009)

    Article  Google Scholar 

  30. M. Habibnejad-Korayem, R. Mahmudi, W.J. Poole, Mater. Sci. Eng. A 519, 198 (2009)

    Article  Google Scholar 

  31. D.H. Lin, L.F. Liu, W.J. Ding, K. Yo, Mater. Sci. Eng. A 452–453, 503 (2007)

    Google Scholar 

  32. K.K. Deng, K. Wu, X.J. Wang, X.S. Hu, M.Y. Zheng, W.M. Gan, Mater. Sci. Eng. A 527, 1630 (2010)

    Article  Google Scholar 

Download references

Acknowledgments

This work was financially supported by the National Natural Science Foundation of China (Nos. 51201112, 51274149 and 51474152), the Natural Science Foundation of Shanxi (No. 2013021013-3) and the Specialized Research Fund for the Doctoral Program of Higher Education (No. 20121402120004).

Author information

Authors and Affiliations

  1. Shanxi Key Laboratory of Advanced Magnesium-based Materials, College of Materials Science and Engineering, Taiyuan University of Technology, Taiyuan, 030024, China

    Cui-Ju Wang, Kun-Kun Deng, Shan-Shan Zhou & Wei Liang

Authors
  1. Cui-Ju Wang
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Kun-Kun Deng
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Shan-Shan Zhou
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Wei Liang
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding authors

Correspondence to Kun-Kun Deng or Wei Liang.

Additional information

Available online at http://link.springer.com/journal/40195

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Wang, CJ., Deng, KK., Zhou, SS. et al. Dynamic Recrystallization Behavior of Bimodal Size SiCp-Reinforced Mg Matrix Composite during Hot Deformation. Acta Metall. Sin. (Engl. Lett.) 29, 527–537 (2016). https://doi.org/10.1007/s40195-016-0415-0

Download citation

  • Received:

  • Revised:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s40195-016-0415-0

Keywords

Search

Navigation