Abstract
Safe disposal of contaminated tailings is recognized as the single largest environmental challenge facing the mining industry worldwide. Because suitable land for a new tailings pond is becoming rare and expensive, more and more mine operators tend to heighten the existing tailings dams to improve their storage capacity. However, this could lead to a decrease in the stability of the tailings dams. Based on comprehensive geotechnical investigations of a tailings dam in China, this paper presents a successful case study on heightening an existing tailings dam and extending its operational lifetime using a new drainage technique named the upward bending drain pipes system. The proposed system has 60 upward bending drain pipes arranged in the dam wall. The drain pipes are designed with combinations of slots and holes. With this arrangement, seepage on the hole surfaces changes to seepage on the slot surface, which increases the seepage capability by about 20 times compared with traditional drain systems. Based on a dam stability analysis, it is found that the value of the factor of safety of the dam can be improved around 20 % after slope drainage at an elevation of 2015 m. By using the proposed drainage system, the height of the tailings dam of this mine can be increased from 45 m (elevation 2015 m) up to 60 m (elevation 2030 m), which will increase by 8 million cubic meters the wet tailings storage and will satisfy mine operation for 5 years.
Similar content being viewed by others
References
Hardy D, Engels J (2007) Guidelines and recommendations for the safe operation of tailings management facilities. Environ Eng Sci 24(5):625–637
Luo K, Zhang J (2005) Status quo of the disposal of acidic mining waste water. Resour Environ Eng 19(1):45–49 (in Chinese)
Ozcan N, Ulusay R, Isik N (2013) A study on geotechnical characterization and stability of downstream slope of a tailings dam to improve its storage capacity (Turkey). Environ Earth Sci 69:1871–1890
Priscu C (1999) Behavior of mine tailings dams under high tailings deposition rates. McGill University, Montreal
Reid C, Becaert V, Aubertin M, Rosenbaum R, Deschenes L (2009) Life cycle assessment of mine tailings management in Canada. J Clean Prod 17:471–479
Rico M, Benito G, Salguerio AR, Diez-Herrero A, Pereira HG (2008) Reported tailings dam failures: a review of the European Incidents in the worldwide context. J Hazard Mater 152(2):846–852
Sharma RS, Al-Busaidi TS (2001) Groundwater pollution due to a tailings dam. Eng Geol 60:235–244
Vick S (1996) Tailings dam failure at Omai in Guyana. Min Eng 11:34–37
Wei Z, Yin G, Li G, Wang J, Wan L (2009) Reinforced terraced fields method for fine tailings disposal. Miner Eng 22(1):1053–1059
Wei Z, Yin G, Wang J, Wan L, Li G (2013) Design, construction and management of tailings storage facilities for surface disposal in China: case studies of failures. Waste Manage Res 31(1):106–112
Yin G, Li G, Wei Z, Wan L, Shui G, Jing X (2011) Stability analysis of a copper tailings dam via laboratory model tests: a Chinese case study. Miner Eng 24(2):122–130
Zandarín M, Oldecop L, Rodríguez R, Zabala F (2009) The role of capillary water in the stability of tailing dams. Eng Geol 105:108–118
Acknowledgments
The authors are very grateful to Dr. Shen Jiayi and the anonymous reviewers for their valuable comments and suggestions. This research has been funded by the National Natural Science Foundation of China (No. 11372363) and the Ganpo (Jiangxi Province) 555 Elites Prize.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Wei, Z., Yin, G., Wan, L. et al. A case study on a geotechnical investigation of drainage methods for heightening a tailings dam. Environ Earth Sci 75, 106 (2016). https://doi.org/10.1007/s12665-015-5029-8
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s12665-015-5029-8