Abstract
Activated carbon from sugarcane residues, bagasse and straw was obtained with phosphoric acid activation. All samples were characterized by N2 adsorption–desorption isotherm, scanning electron microscopy, coupled with energy dispersive microscopy, X-ray photoelectron spectroscopy and thermal analysis. The advantages of using a ball or hammer milling process were investigated, together with the effect of the impregnation ratio and its influence on the final activated carbon porosity. The results show that all samples exhibit a high surface area and well developed porosity, but those which were ball-milled have a greater gas adsorbed amount, especially those which had straw (1415 m2/g) as precursor material. Furthermore, the results suggest that the process may have an optimum impregnation ratio, which should be around 2 or 3, irrespectively of the lignocellulosic source material. The mechanochemical process seems to be more relevant than the percentage of cellulose in the raw material. According with spectroscopy results, the homogeneous distribution of phosphorus throughout the sample was verified, even after repeated washing steps. Surface phosphate linkages like C–O–PO3 and C–PO3 were also detected.
Similar content being viewed by others
References
Ferreira-Leitão, V.S., Gottschalk, L.M.F., Ferrara, M.A., Nepomuceno, A.L., Molinari, H.B.C., Bon, E.P.S.: Biomass residues in Brazil: availability and potential uses. Waste Biomass Valor 1, 65–76 (2010)
Ferreira Filho, J.B.S., Horridge, M.: Ethanol expansion and indirect land use change in Brazil. Land Use Policy 36, 595–604 (2014)
Brazilian Federal Law: Decreto no. 2.661, 8th of July of 1998. http://www.planalto.gov.br/cccivil_03/decreto/D2661.htm
Brazilian State of São Paulo Law: Lei no. 11.241/02. http://governo-sp.jusbrasil.com.br/legislacao/94008/lei-11241-02
Moutta, R.O., Silva, M.C., Corrales, R.C.N.R., Cerullo, M.A.S., Ferreira-Leitão, V.S., Bon, E.P.S.: Comparative response and structural characterization of sugarcane bagasse, straw and bagasse-straw 1:1 mixtures subjected to hydrothermal pretreatment and enzymatic conversion. J. Microbial Biochem. Technol. S12, 1–8 (2013)
Corrales, R.C.N.R., Mendes, F.M.T., Perrone, C.C., Sant’Anna, C., Sousa, W., Abud, Y., et al.: Structural evaluation of sugar cane bagasse steam pretreated in the presence of CO2 and SO2. Biotechnol. Biofuels 5, 36 (2012)
Rosas, J.M., Bedia, J., Rodrígues-Mirasol, J., Cordero, T.: Preparation of hemp-derived activated carbon monoliths: adsorption of water vapor. Ind. Eng. Chem. Res. 47, 1288–1296 (2008)
Chen, C.X., Huang, B., Li, T., Wu, G.F.: Preparation of phosphoric acid activated carbon from sugarcane bagasse by mechanochemical processing. BioResources 7(4), 5109–5116 (2012)
Rosas, J.M., Bedia, J., Rodrígues-Mirasol, J., Cordero, T.: HEMP-derived activated carbon fibers by chemical activation with phosphoric acid. Fuel 88, 19–26 (2009)
Castro, J.B., Bonelli, P.R., Cerrella, E.G., Cukierman, A.L.: Phosphoric acid activation of agricultural residues and bagasse from sugar cane: influence of the experimental conditions on adsorption characteristics of activated carbons. Ind. Eng. Chem. Res. 39, 4166–4172 (2000)
Devnarain, P.B., Arnold, D.R., Davis, S.B.: Production of activated carbon from south African sugarcane bagasse. Proc. S. Afr. Sug. Technol. Ass. 76, 477–489 (2002)
Wu, X., Radovic, L.R.: Inhibition of catalytic oxidation of carbon/carbon composites by phosphorus. Carbon 44, 141–151 (2006)
Qureshi, K., Bhatti, I., Kazi, R., Ansari, A.K.: Physical and chemical analysis of activated carbon prepared from sugarcane bagasse and use for sugar decolorisation. Int. J. Chem. Bio. Eng. 1, 145–149 (2008)
Demiral, I., Demiral, H.: Surface characterization of activated carbons obtained from olive bagasse by chemical activation. Surf. Interface Anal. 42, 1347–1350 (2010)
Carvalho, J., Araujo, J., Castro, F.: Alternative low-cost adsorbent for water and wastewater decontamination derived from eggshell waste: an overview. Waste Biomass Valor 2, 157–167 (2011)
Pippo, W.A., Luengo, C.A., Alberteris, L.A.M., Garzone, P., Cornacchia, G.: Energy recovery from sugarcane-trash in the light of 2nd generation biofuels. Part 1: Current situation and environmental aspects. Waste Biomass Valor 2, 1–16 (2011)
Altenor, S., Neibi, M.C., Brehm, N., Emmanuel, E., Gaspard, S.: Pilot-scale synthesis of activated carbons from vetiver roots and sugar cane bagasse. Waste Biomass Valor 4, 485–495 (2013)
Brinen, J.S., Schmitt, J.L., Doughman, W.R., Achorn, P.J., Siegel, L.A.: X-ray photoelectron spectroscopy studies of the rhodium on charcoal catalyst. J. Catal. 40, 295–300 (1975)
Pande, G., Selvakumar, S., Batra, V.S., Gardoll, O., Lamonier, J.F.: Unburned carbon from bagasse fly ash as a support for a VOC oxidation catalyst. Catal. Today 190, 47–53 (2012)
Guerrero-Pérez, M.O., Rosas, J.M., López-Medina, R., Bañares, M.A., Rodríguez-Mirasol, J., Cordero, T.: Lignocellulosic-derived catalysts for the selective oxidation of propane. Catal. Commun. 12, 989–992 (2011)
Clark, J., Macquarrie, D., Gronnow, M., Budarin, V.: Green chemistry principles. In: Boodhoo, K., Harvey, A. (eds.) Process intensification for green chemistry, vol. 1, pp. 35–55. Noida, India (2013)
Scheffer, K.: Activated carbon 2014 Market update or…the Carbon Cosmos. Spotlight. Water Conditioning and Purification. Features, 30–32, 06 June 2014. www.wcponline.com/pdf/June_2014_Schaeffer.pdf (2014)
Gupta, V.K., Ali, I., Saini, V.K., Van Gerven, T., Van der Bruggen, B., Vandecasteele, C.: Removal of dyes from wastewater using bottom ash. Ind. Eng. Chem. Res. 44(11), 3655–3664 (2005)
Gupta, V.K., Ali, I.: Removal of DDD and DDE from wastewater using bagasse fly ash, a sugar industry waste. Water Res. 35(1), 33–40 (2001)
Mittal, A., Mittal, J., Malviya, A., Kaur, D., Gupta, V.K.: Decoloration treatment of a hazardous triarylmethane dye, Light Green SF (Yellowish) by waste material adsorbents. J. Colloid Interface Sci. 342, 518–527 (2010)
Rosas, J.M., Ruiz-Rosas, R., Rodríguez-Mirasol, J., Cordero, T.: Kinetic study of the oxidation resistance of phosphorus-containing activated carbons. Carbon 50, 1523–1537 (2012)
Haber, J.: International Union of Pure and Applied Chemistry. Manual on catalyst characterization (Recommendations 1991). Pure Appl. Chem. 63, 1227–1246 (1991)
ASTM International. Standard test method for carbon black—total and external area by nitrogen adsorption. Designation D6556-10
Sun, M., Zhang, J., Putaj, P., Caps, V., Lefebvre, F., Pelletier, J., Basset, J.M.: Catalytic oxidation of light alkanes (C1–C4) by heteropoly compounds. Chem. Rev. 114, 981–1019 (2014)
Puziy, A.M., Poddubnaya, O.I., Martínez-Alonso, A., Suárez-García, F., Tascón, J.M.D.: Synthetic carbons activated with phosphoric acid III. Carbons prepared in air. Carbon 41, 1181–1191 (2003)
Acknowledgments
We acknowledge the financial support from Brazilian funding agency FAPERJ-APQ-1/2013-1 Proc. No. 111.405/2013, to the CIEE and Sisnano program.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Mendes, F.M.T., Marques, A.C.C., Mendonça, D.L. et al. High Surface Area Activated Carbon from Sugar Cane Straw. Waste Biomass Valor 6, 433–440 (2015). https://doi.org/10.1007/s12649-015-9356-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12649-015-9356-5