Skip to main content
SpringerLink
Log in

Carbon footprint reduction in the textile process chain: Recycling of textile materials

  • Published:
Fibers and Polymers Aims and scope Submit manuscript

Abstract

It is an important task of people connected with the textiles and clothing sector to work on the feasible ways to trim down the carbon footprint in each phase of a textile product’s life cycle. One of the possible ways to decipher the reduction of carbon footprint of textiles and clothing sector is to recycle the textile process waste and also to recycle at the end-of-life of textile products and these aspects are exemplified in this paper in detail. Detailed investigation of the possibilities, barriers, challenges to recycle textile waste materials are discussed in this paper with relevant case studies. For recycling of process waste, an example was modelled by recycling the process waste and the carbon footprint results were demonstrated with the aid of 7.3 version of SIMAPRO LCA (Life cycle assessment) software. From the results of this case study, it was understood that recycling of process waste would contribute to the direct reduction of carbon footprint. For the second case of recycling at the end-of-life, there are many barriers and challenges to the textile products to be recycled, which are discussed in detail. For this case, two hypothetical situations were defined and the carbon footprint results of them were modeled and demonstrated with the aid of 7.3 version of SIMAPRO software to illustrate the benefits of recycling to reduce the carbon footprint. Designers need to conisder, “Ecological Design” in design phase to address most of the difficulties faced by recycling of textile products at the end-of-life, which will of certain help to reduce the carbon footprint of the textile products.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Carbon Footprint, Retrieved from: http://www.carbonfootprint.com/carbonfootprint.html

  2. E. G. Hertwich and G. P. Peters, Environ. Sci. Technol., 43, 6414 (2009).

    Article  CAS  Google Scholar 

  3. Documentation for Emissions of Greenhouse Gases in the United States 2003, Retrieved from: http://www.eia.doe.gov/emeu/aer/txt/ptb1204.html

  4. Carbon Footprint of Textiles, Dev Vivek, April 3, 2009, Retrieved from: http://www.domain-b.com/environment/20090403_carbon_footprint.html.

  5. S. S. Muthu, Y. Li, J. Y. Hu, and P. Y. Mok, Atmospheric Environment, 45, 469 (2011).

    Article  CAS  Google Scholar 

  6. S. S. Muthu, Y. Li, J. Y. Hu, and P. Y. Mok, Ecological Indicators, 18, 58 (2012).

    Article  CAS  Google Scholar 

  7. J. Michaud, L. Farrant, O. Jan, B. Kjær, and I. Bakas, Environmental Benefits of Recycling-2010 Update, Final Report, WRAP, UK, March 2010.

  8. Global Warming, Retrieved from: http://en.wikipedia.org/wiki/Globalwarming.

  9. Global Warming Potential, Retrieved from: http://en.wikipedia.org/wiki/Globalwarmingpotential.

  10. IPCC, “Intergovernmental Panel on Climate Change” (T. Houghton et al. Eds.), Climate Change 2001: the Scientific Basis. Contribution of Working Group I to the 3rd Assessment Report of the Intergovernmental Panel on Climate Change. Cambridge University Press, Cambridge, 2001.

    Google Scholar 

  11. J. B. Guinée, M. Gorrée, A. R. Heijungs, A G. Huppes, A R. Kleijn, A A. de Koning, A. Lv. Oers, A. A. Wegener Sleeswijk, S. Suh, A. H. A. Udo de Haes, H. de Bruijn, A. R. van Duin, and M. A. J. Huijbregts, “Handbook on Life Cycle Assessment. Operational Guide to the ISO Standards. I: LCA in Perspective. IIa: Guide. IIb: Operational Annex. Iii: Scientific Background”, p.692, Kluwer Academic Publishers, ISBN 1-4020-0228-9, Dordrecht, 2002.

  12. ISO 14040, Environmental Management-Life Cycle Assessment-Principles and Frame Work. International Organisation for Standardisation, Geneva, 2006.

    Google Scholar 

  13. ISO 14044, Environmental Management -Life Cycle Assessment e. International Organisation for Standardisation, Geneva, 2006.

    Google Scholar 

  14. PAS 2050, Guide to PAS 2050: How to Assess the Carbon Footprint of Goods and Services, British Standards Institution, UK.

  15. Y. Wang, Y. Zhang, M. Polk, S. Kumar, and J. Muzzy, “Recycling of Carpet and Textile Fibers” in “Plastics and the Environment: A Handbook” (A. L. Andrady Ed.), pp.697–725, John Wiley & Sons, New York, 2003.

    Google Scholar 

  16. IPCC Method, Retrieved from: http://www.pre.nl/simapro/impact_assessment_methods.htm#IPCC

  17. Y. Li, S. S. Muthu, J. Y. Hu, P. Y. Mok, X. Ding, L. Wang, and W. Chen, Journal of Sustainable Development, 3, 71 (2010).

    CAS  Google Scholar 

  18. A. Jeihanipour, PhD Dissertation, Department of Chemical and Biological Engineering, Chalmers University of Technology, Gothenburg, Sweden, 2011.

  19. Y. Wang, “Recycling in Textiles” Woodhead Publishing, UK, 2006.

    Book  Google Scholar 

  20. Y. Wang, Waste and Biomass Valorization, 1, 135 (2010).

    Article  Google Scholar 

  21. M. I. Tobler-Rohr, “Handbook of Sustainable Textile Production”, Woodhead Publishing Series in Textiles No. 124, Woodhead Publishing, UK, 2011.

    Book  Google Scholar 

  22. D. Palm, “Improved Waste Management of Textiles, Project 9 Environmentally Improved Recycling”, IVL Swedish Environmental Research Institute Ltd., SE-400 14, Göteborg.

  23. G. M. EI-Nouby, H. A. Azzam, S. T. Mohamed, and M. N. El-Sheikh, “Textile Waste-Material Recycling, Part I: Ways and Means, Textile Processing: State of the Art & Future Developments”, Vol. 2, pp.394–407, 2nd International Conference of Textile Research Division, NRC, Cairo, Egypt, April 11–13, 2005.

    Google Scholar 

  24. M. Jacob, H. Bryan, P. Shahila, S. Sarah, and A. Simon, “Mapping of Evidence on Sustainable Development Impacts that Occur in Life Cycles of Clothing: A Report to the Department for Environment, Food and Rural Affairs”, Environmental Resources Management [ERM] Ltd. Defra, London, 2007.

    Google Scholar 

  25. DEPA, Environmental Assessment of Textiles, Environmental Project No. 369. Danish Environmental Protection Agency, 1997.

  26. K. J. Kooistra, R. Pyburn, and A. J. Termorshuizen, “The Sustainability of Cotton: Consequences for Man and Environment”, Science Shop Wageningen University & Research Centre, Report 223, ISBN: 90-6754-90-8585-000-2, 2006.

  27. N. J. Morley, C. Bartlett, and I. McGill, “Maximising Reuse and Recycling of UK Clothing and Textiles: A Report to the Department for Environment, Food and Rural Affairs”, Oakdene Hollins Ltd., 2009.

  28. N. Morley, S. Slater, S. Russel, M. Tipper, and G. D. Ward, “Recycling of Low Grade Clothing Waste”, Oakdene Hollins Ltd., Salvation Army Trading Company Ltd., Nonwovens Innovation and Research Institute Ltd., 2006.

  29. J. M. Hawley, Cloth. Text. Res. J., 24, 262 (2006).

    Article  Google Scholar 

  30. M. Collins and S. Gandy, “Streamlined Life Cycle Assessment of Textile Recycling”, Salvation Army Trading Company Ltd., 2002.

  31. M. Larney and A. M. van Aardt, Journal of Family Ecology and Consumer Sciences, 32, 60 (2004).

    Google Scholar 

  32. N. Bhalla, “Market Transformation Programme — Waste Clothing Textiles”, Environmental Resources Management, October, 2005.

  33. S. Sahni, A. Boustani, T. Gutowski, and S. Graves, Textile Manufacturing and Energy Savings, MITEI-1-g-2010, January 28th, 2010, Environmentally Benign Laboratory, Laboratory for Manufacturing and Productivity, Sloan School of Management.

  34. A. C. Woolridge, G. D. Ward, P. S. Phillips, M. Collins, and S. Gandy, Resources, Conservation and Recycling, 46, 94 (2005).

    Article  Google Scholar 

  35. K. Laitala and I. G. Klepp, “Environmental Improvement by Prolonging Clothing Use Period, Towards Sustainability in the Textile and Fashion Industry”, Copenhagen, 26–27 April, 2011.

  36. N. Daneshvary, R. Daneshvary, and R. K. Schwer, Environment and Behaviour, 30, 144 (1998).

    Article  Google Scholar 

  37. T. Domina and K. Koch, Journal of Fashion Marketing and Management, 3, 346 (1999).

    Article  Google Scholar 

  38. M.-R. Korhonen and H. Dahlbo, The Finnish Environment, 30, 1 (2007).

    Google Scholar 

  39. J. M. Allwood, S. E. Laursen, C. M. de Rodríguez, and N. M. P. Bocken, “Well Dressed?”, University of Cambridge, 2006.

Download references

Author information

Authors and Affiliations

  1. Institute of Textiles & Clothing, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong

    Subramanian SenthilKannan Muthu, Yi Li, Jun Yan Hu & Li Ze

Authors
  1. Subramanian SenthilKannan Muthu
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Yi Li
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Jun Yan Hu
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Li Ze
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Yi Li.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Muthu, S.S., Li, Y., Hu, J.Y. et al. Carbon footprint reduction in the textile process chain: Recycling of textile materials. Fibers Polym 13, 1065–1070 (2012). https://doi.org/10.1007/s12221-012-1065-0

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s12221-012-1065-0

Keywords

Search

Navigation