Abstract
When a longwall face approaches the finish-off line, 1 month is normally required to relocate the longwall equipment and seal the longwall panel, during which time the goaf gas atmosphere changes and the risk of spontaneous combustion and gas explosion considerably increases. To minimise the occurrence of these hazards, an improved insight into gas flow dynamics within the longwall panel is essential during the panel sealing-off process. Based on mining conditions of an Australian underground coal mine, three-dimensional computational models were developed and calibrated with onsite gas monitoring data, allowing for evaluating ventilation arrangements and understanding methane dispersion in the longwall workings during the six-stage panel sealing-off process with confidence. The simulation results indicate that nitrogen should be injected on the travel road side at a distance of 120 m behind the longwall face at a rate of 0.75 m3/s and the rear of the travel road should be tightly sealed at the final sealing-off stage, resulting in oxygen levels lowering than 5% in the longwall workings and producing desired panel sealing-off performance. In addition, gas sensors should be employed and positioned at the appropriate locations to reliably monitor goaf atmosphere change. This study sheds improved insights into evaluating ventilation arrangements and understanding gas flow dynamics during the panel sealing-off process and provides critical knowledge of effective proactive goaf inertisation strategies, thus minimising the risk of spontaneous heating and gas explosion and reducing environmental pollution induced by these hazards.
Similar content being viewed by others
Data availability
The data used to support the findings of this study are available from the corresponding author upon request.
References
ANSYS I (2018) ANSYS Meshing User’s Guide. Canonsburg, PA, p 15317
Beamish BB, Theiler J (2019) Coal spontaneous combustion: examples of the self-heating incubation process. Int J Coal Geol 215. https://doi.org/10.1016/j.coal.2019.103297
Chen L, Yang J, Ding P (2020) Dynamic evolution of negative pressure impact of cross-cut on oxygen concentration field in coal mine goaf. Heat Mass Transf 1–13. https://doi.org/10.1007/s00231-020-02981-z
Cliff D, Brady D, Watkinson M (2015) Spontaneous combustion in Australian coal mines. Simtars
Deng J, Lei C, Xiao Y, Cao K, Ma L, Wang W, Laiwang B (2018) Determination and prediction on “three zones” of coal spontaneous combustion in a gob of fully mechanized caving face. Fuel 211:458–470. https://doi.org/10.1016/j.fuel.2017.09.027
Guo H, Yuan L, Shen B, Qu Q, Xue J (2012) Mining-induced strata stress changes, fractures and gas flow dynamics in multi-seam longwall mining. Int J Rock Mech Min Sci 54:129–139. https://doi.org/10.1016/j.ijrmms.2012.05.023
Kang H, Lv H, Zhang X, Gao F, Wu Z, Wang Z (2016) Evaluation of the ground response of a pre-driven longwall recovery room supported by concrete cribs. Rock Mech Rock Eng 49:1025–1040. https://doi.org/10.1007/s00603-015-0782-2
Li L, Qin B, Liu J, Leong Y-K, Li W, Zeng J, Ma D, Zhuo H (2021a) Influence of airflow movement on methane migration in coal mine goafs with spontaneous coal combustion. Process Saf Environ Prot 156:405–416. https://doi.org/10.1016/j.psep.2021.10.015
Li Z, Xu Y, Liu H, Zhai X, Zhao S, Yu Z (2021b) Numerical analysis on the potential danger zone of compound hazard in gob under mining condition. Process Saf Environ Prot 147:1125–1134. https://doi.org/10.1016/j.psep.2021.01.043
Liang Y, Zhang J, Wang L, Luo H, Ren T (2019) Forecasting spontaneous combustion of coal in underground coal mines by index gases: a review. J Loss Prev Process Ind 57:208–222. https://doi.org/10.1016/j.jlp.2018.12.003
Liu H, Wang F, Ren T, Qiao M, Yan J (2021) Influence of methane on the prediction index gases of coal spontaneous combustion: a case study in Xishan coalfield. China Fuel 289:119852
Liu Q, Lin B, Zhou Y, Li Y, Ting L (2022) Experimental verification of permeability and inertial resistance coefficient model in the goaf. Energy Sources Part Recover Utilization Environ Eff 1–20. https://doi.org/10.1080/15567036.2022.2028036
Liu W, Qin Y, Shi C, Guo D (2019) Dynamic evolution of spontaneous combustion of coal in longwall gobs during mining-stopped period. Process Saf Environ Prot 132:11–21. https://doi.org/10.1016/j.psep.2019.09.027
Liu Y, Wen H, Guo J, Jin Y, Wei G, Yang Z (2020) Coal spontaneous combustion and N2 suppression in triple goafs: a numerical simulation and experimental study. Fuel 271. https://doi.org/10.1016/j.fuel.2020.11762
Ma L, Guo R, Wu M, Wang W, Ren L, Wei G (2020) Determination on the hazard zone of spontaneous coal combustion in the adjacent gob of different mining stages. Process Saf Environ Prot 142:370–379. https://doi.org/10.1016/j.psep.2020.06.035
Martin ST, Clough A (2021) Queensland coal mining board of inquiry-PartII. Queensland Coal Mining Board, State of Queensland
Mishra DP, Kumar P, Panigrahi DC (2016) Dispersion of methane in tailgate of a retreating longwall mine: a computational fluid dynamics study. Environ Earth Sci 75:475.https://doi.org/10.1007/s12665-016-5319-9
Qiao M (2022) Applications of advanced computational modelling for principal underground mining hazards management and control. University of Wollongong, University of Wollongong, p 265
Qiao M, Ren T, Roberts J, Li Z, Wu J (2023) Studies on the impact of seam gas composition on proactive goaf inertization strategies for spontaneous combustion management—a computational modeling approach. Min Metall Explor 1–20. https://doi.org/10.1007/s42461-023-00849-4
Qiao M, Ren T, Roberts J, Liu H, Yang X, Tan L, Wu J (2022a) Improved computational fluid dynamics modelling of coal spontaneous combustion control and gas management. Fuel 324:124456.https://doi.org/10.1016/j.fuel.2022.124456
Qiao M, Ren T, Roberts J, Yang X, Li Z, Wu J (2022b) New insight into proactive goaf inertisation for spontaneous combustion management and control. Process Saf Environ Prot 161:739–757.https://doi.org/10.1016/j.psep.2022.03.074
Qiao M, Ren T, Roberts J, Yang X, Li Z, Wu J (2023b) Insight into proactive inertisation strategies for spontaneous combustion management during longwall mining of coal seams with various orientations. Energy Sources Part A Recover Utilization Environ Eff 45:2788–2810. https://doi.org/10.1080/15567036.2023.2191062
Ren T, Balusu R (2005) CFD modelling of goaf gas migration to improve the control of spontaneous combustion in longwalls, 2005 Coal Operators’ Conference, University of Wollongong, pp 259–264. https://ro.uow.edu.au/coal/170
Ren T, Balusu R, Humphries P (2005) Development of innovative goaf inertisation practices to improve coal mine safety, 2005 Coal Operators’ Conference, University of Wollongong, pp 315–322. https://ro.uow.edu.au/coal/181
Ren T, Wang Z, Nemcik J, Aziz N, Wu J (2012) Investigation of spontaneous heating zones and proactive inertisation of longwall goaf in Fenguangshan Mine, 12th Coal Operators' Conference. University of Wollongong & the Australasian Institute of Mining and Metallurgy, University of Wollongong, pp 212–220. https://ro.uow.edu.au/coal/409
Ren W, Guo Q, Yang H (2018) Analyses and prevention of coal spontaneous combustion risk in gobs of coal mine during withdrawal period. Geomat Nat Haz Risk. https://doi.org/10.1080/19475705.2018.1523237
Shi G, Ding P, Guo Z, Wang Y (2019) Modeling temperature distribution upon liquid-nitrogen injection into a self heating coal mine goaf. Process Saf Environ Prot 126:278–286. https://doi.org/10.1016/j.psep.2019.03.033
Shi G, Wang G, Ding P, Wang Y (2021) Model and simulation analysis of fire development and gas flowing influenced by fire zone sealing in coal mine. Process Saf Environ Prot 149:631–642. https://doi.org/10.1016/j.psep.2021.03.010
Si G, Belle B (2019) Performance analysis of vertical goaf gas drainage holes using gas indicators in Australian coal mines. Int J Coal Geol 216:103301. https://doi.org/10.1016/j.coal.2019.103301
Tanguturi K, Balusu R (2015) Fundamental understanding of goaf gas displacement in longwall goaf. J Min Environ 6 191–203. https://doi.org/10.22044/jme.2015.455
Taraba B, Michalec Z (2011) Effect of longwall face advance rate on spontaneous heating process in the gob area–CFD modelling. Fuel 90:2790–2797. https://doi.org/10.1016/j.fuel.2011.03.033
Tim F, Jennie S (2012) Investigation report: Fire and explosion on longwall No.1 Tailgate at the Blakefield South Mine-5 January 2011, Trade & Investment, NSW Trade & Investment. https://www.resourcesandgeoscience.nsw.gov.au/__data/assets/pdf_file/0010/457354/Blakefield-South-Investigation-report-060213.pdf
Tutak M, Brodny J (2017a) Analysis of influence of goaf sealing from tailgate on the methane concentration at the outlet from the Longwall. IOP Conf Ser: Earth Environ Sci 95:042025. https://doi.org/10.1088/1755-1315/95/4/042025
Tutak M, Brodny J (2017b) Determination of particular endogenous fires hazard zones in goaf with caving of longwall. IOP Conf Ser: Earth Environ Sci 95:042026. https://doi.org/10.1088/1755-1315/95/4/042026
Wang G, Shi G, Wang Y, Shen H (2021) Numerical study on the evolution of methane explosion regions in the process of coal mine fire zone sealing. Fuel 289:119744. https://doi.org/10.1016/j.fuel.2020.119744
Wang Y, Si G, Xiang Z, Oh J, Belle B, Webb D (2022) A theoretical goaf resistance model based on gas production analysis in goaf gas drainage. Int J Coal Geol 264:104140. https://doi.org/10.1016/j.coal.2022.104140
Xia T, Zhou F, Wang X, Zhang Y, Li Y, Kang J, Liu J (2016) Controlling factors of symbiotic disaster between coal gas and spontaneous combustion in longwall mining gobs. Fuel 182:886–896. https://doi.org/10.1016/j.fuel.2016.05.090
Xiang Z, Si G, Wang Y, Belle B, Webb D (2021) Goaf gas drainage and its impact on coal oxidation behaviour: a conceptual model. Int J Coal Geol 248:103878. https://doi.org/10.1016/j.coal.2021.103878
Yang S, Hu X, Liu WV, Cai J, Zhou X (2018) Spontaneous combustion influenced by surface methane drainage and its prediction by rescaled range analysis. Int J Min Sci Technol 28:215–221.https://doi.org/10.1016/j.ijmst.2017.12.004
Yuan L, Smith AC (2014) CFD modelling of nitrogen injection in a longwall gob area. Int J Min Miner Eng 5:164–180.https://doi.org/10.1504/IJMME.2014.060220
Zhang J, An J, Wang Y, Al Mamun NA, Pan R (2019) Philosophy of longwall goaf inertisation for coal self-heating control, proactive or reactive? Int J Heat Mass Transf 141:542–553.https://doi.org/10.1016/j.ijheatmasstransfer.2019.07.004
Zhang J, An J, Wen Z, Zhang K, Pan R, Al Mamun NA (2020) Numerical investigation of coal self-heating in longwall goaf considering airflow leakage from mining induced crack. Process Saf Environ Prot 134:353–370. https://doi.org/10.1016/j.psep.2019.12.025
Zhu H, Liu X (2012) Theoretical investigation on the relationship between tail roadway methane drainage and distribution of easily spontaneous combustible region in gob. Saf Sci 50:618–623. https://doi.org/10.1016/j.ssci.2011.09.002
Zhuo H, Qin B, Qin Q (2021) The impact of surface air leakage on coal spontaneous combustion hazardous zone in gob of shallow coal seams: a case study of Bulianta Mine. China Fuel 295:120636. https://doi.org/10.1016/j.fuel.2021.120636
Zuo Q, Li J (2021) Simulation of fire smoke disaster in a goaf during the closure process. Therm Sci 25:3399–3407. https://doi.org/10.2298/TSCI200630323Z
Funding
The research was supported by China Scholarship Council (CSC: No. 201806420023), the International Postgraduate Tuition Award (IPTA) of the University of Wollongong, Australian Coal Association Research Program (ACARP) C33029 and the Research funding provided by the underground coal mine introduced in this study.
Author information
Authors and Affiliations
Contributions
MQ: conceptualisation, software, methodology and writing—original draft; TR: funding acquisition, project administration, supervision and writing—review and editing; JR: supervision and writing—review and editing; ZL: software, visualisation, data curation and writing—review and editing; JW: formal analysis and writing—review and editing.
Corresponding author
Ethics declarations
Ethics approval
Not applicable.
Consent to participate
Not applicable.
Consent for publication
Not applicable.
Conflict of interest
The authors declare no competing interests.
Additional information
Responsible Editor: Philippe Garrigues
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Qiao, M., Ren, T., Roberts, J. et al. Ventilation arrangement evaluation and proactive goaf inertisation for spontaneous combustion and gas explosion management during longwall panel sealing-off process. Environ Sci Pollut Res 30, 115199–115227 (2023). https://doi.org/10.1007/s11356-023-30575-9
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-023-30575-9