Abstract
Iron mining residue was evaluated as a potential catalyst for heterogeneous Fenton/photo-Fenton degradation of sulfonamide antibiotics. The residue contained 25% Fe2O3 and 8% CeO2, as determined by X-ray fluorescence spectroscopy, as well as other minor phases such as P2O5, SiO2, and TiO2. X-ray photoelectron spectroscopy analysis revealed a lower content of iron oxides on the surface, which restricted interaction of the residue with H2O2. Despite this limitation and the relatively low specific surface area (26 m2 g-1) of the crude iron mining residue (without any pretreatment), the material presented high catalytic activity for Fenton degradation of sulfonamide antibiotics. The degradation was strongly dependent on the initial pH, showing the highest efficiency at pH 2.5. For this condition, a concentration of sulfathiazole below the detection limit was obtained within 30 min, under black light irradiation and using 0.3 g L-1 residue, with low H2O2 consumption (0.2 mmol L-1). The residue also provided highly efficient sulfathiazole degradation in the dark, with the concentration of the antibiotic decreasing to an undetectable level after 45 min. Simultaneous degradation of two sulfonamide antibiotics revealed higher recalcitrance of sulfamethazine, compared to sulfathiazole, but the levels of both antibiotics decreased to below the detection limit after 45 min. The residue was very stable, since no significant concentration of soluble iron was detected after the degradation process. Furthermore, high catalytic activity was maintained during up to five cycles, showing the potential of this material for use as a low-cost and environmentally compliant catalyst in Fenton processes.
Similar content being viewed by others
References
Amorim CC, Leão MMD, Moreira RFPM (2009) Comparison of various advanced oxidation processes for azo dye degradation. Eng Sanit Ambient 14:543–550
Araujo FVF, Yokoyama L, Teixeira LAC, Campos JC (2011) Heterogeneous Fenton process using the mineral hematite for the discolouration of a reactive dye solution. Braz J Chem Eng 28:605–616
Bai Z, Yang Q, Wang J (2017) Degradation of sulfamethazine antibiotics in Fenton-like system using Fe3O4 magnetic nanoparticles as catalyst. Environ Prog Sustain Energy 00:1–11
Barbosa IA, Zanatta LD, Espimpolo DM, Silva DL, Nascimento LF, Zanardi FB, Sousa Filho PC, Serra OA, Iamamoto Y (2017) Magnetic diatomite(Kieselguhr)/Fe2O3/TiO2 composite as an efficient photo-Fenton system for dye degradation. Solid State Sci 72:14–20
Chen S, Wu Y, Li G, Wu J, Meng G, Guo X, Liu Z (2017) A novel strategy for preparation of an effective and stable heterogeneous photo-Fenton catalyst for the degradation of dye. Appl Clay Sci 136:103–111
Cui C, Jin L, Jiang L, Han Q, Lin K, Lu S, Zhang D, Cao G (2016) Removal of trace level amounts of twelve sulfonamides from drinking water by UV-activated peroxymonosulfate. Sci Total Environ 572:244–251
Daughton CG (2016) Pharmaceuticals and the environment (PiE): evolution and impact of the published literature revealed by bibliometric analysis. Sci Total Environ 562:391–426
Deng Y, Li B, Zhang T (2018) Bacteria that make a meal of sulfonamide antibiotics: blind spots and emerging opportunities. Environ Sci Technol 52:3854–3868
Dias FF, Oliveira AAS, Arcanjo AP, Moura FCC, Pachecho JGA (2016) Residue-based iron catalyst for the degradation of textile dye via heterogeneous photo-Fenton. Appl Catal B Environ 186:136–142
Gao Y, Guo Y, Zhang H (2016) Iron modified bentonite: enhanced adsorption performance for organic pollutant and its regeneration by heterogeneous visible light photo-Fenton process at circumneutral pH. J Hazard Mater 302:105–113
Garrido-Ramírez EG, Theng BKG, Mora ML (2010) Clays and oxide minerals as catalysts and nanocatalysts in Fenton-like reactions - A review. Appl Clay Sci 47:182–192
Glaze WH, Kang JW, Chapin DH (1987) The chemistry of water-treatment processes involving ozone, hydrogen peroxide and ultraviolet radiation. Ozone Sci Eng 9:335–352
Gomes MA, Pereira CA, Clark Peres AE (2011) Technological characterization of iron ore tailing. REM: R Esc Minas 64:233–236
Guo S, Yang Z, Wen Z, Fida H, Zhang G, Chen J (2018) Reutilization of iron sludge as heterogeneous Fenton catalyst for the degradation of rhodamine B: role of sulfur and mesoporous structure. J Colloid Interface Sci 532:441–448
Guo S, Zhang GK, Wang JQ (2014) Photo-Fenton degradation of rhodamine B using Fe2O3-Kaolin as heterogeneous catalyst: characterization, process optimization and mechanism. J Colloid Interface Sci 433:1–8
He K, Hain E, Timm A, Tarnowski M, Blaney L (2019) Occurrence of antibiotics, estrogenic hormones, and UV-filters in water, sediment, and oyster tissue from the Chesapeake Bay. Sci Total Environ 650:3101–3109
Jain B, Singh AK, Kim H, Lichtfouse E, Sharma VK (2018) Treatment of organic pollutants by homogeneous and heterogeneous Fenton reaction processes. Environ Chem Lett 16:947–967
Ji WD, Li MM, Zhang GK, Wang P (2017) Controlled synthesis of Bi25FeO40 with different morphologies: growth mechanism and enhanced photo-Fenton catalytic properties. J Dalton Trans 46:3770–3770
Jia J, Guan Y, Cheng M, Chen H, He J, Wang S, Wang Z (2018) Occurrence and distribution of antibiotics and antibiotic resistance genes in Ba River, China. Sci Total Environ 642:1136–1144
Jiang L, Wang J, Wu X, Zhang G (2017) A stable Fe2O3/expanded perlite composite catalyst for degradation of rhodamine B in heterogeneous photo-Fenton system. Water Air Soil Pollut 228:463
Kaur M, Verma A, Rajput H (2015) Potential use of foundry sand as heterogeneous catalyst in solar photo-Fenton degradation of herbicide isoproturon. J Environ Res 9:85–92
Lian J, Qiang Z, Li M, Bolton JR, Qu J (2015) UV photolysis kinetics of sulfonamides in aqueous solution based on optimized fluence quantification. Water Res 75:43–50
Liang H, Zhou S, Chen Y, Zhou F, Yan C (2014) Diatomite coated with Fe2O3 as an efficient heterogeneous catalyst for degradation of organic pollutant. J Taiwan Inst Chem Eng 24:105–112
Lin Z-R, Zhao L, Dong Y-H (2015) Quantitative characterization of hydroxyl radical generation in a goethite-catalyzed Fenton-like reaction. Chemosphere 141:7–12
Martins ALS, Teixeira LAC, Fonseca FV, Yokoyama L (2017) Evaluation of the mercaptobenzothiazole degradation by combined adsorption process and Fenton reaction using iron mining residue. Environ Technol 38:2032–2039
Milling AJ (1999) Surface characterization methods: principles, techniques, and applications. CRC Press
Mura J, Gama F, Paradella W, Negrão P, Carneiro SOC, Brandão W (2018) Monitoring the vulnerability of the dam and dikes in Germano iron mining area after the collapse of the tailings dam of Fundão (Mariana-MG, Brazil) using DInSAR techniques with TerraSAR-X data. Remote Sens 10:1507–1528
Nidheesh PV (2015) Heterogeneous Fenton catalysts for the abatement of organic pollutants from aqueous solution: a review. RSC Adv 5:40552–40577
Nogueira RFP, Oliveira MC, Paterlini WC (2005) Simple and fast spectrophotometric determination of H2O2 in photo-Fenton reactions using metavanadate. Talanta 66:86–91
Nogueira RFP, Trovó AG, Silva MRD, Villa R (2007) Fundaments and environmental applications of Fenton and photo-Fenton processes. Quím Nova 30:400–408
Pignatello JJ, Oliveros E, MacKay A (2006) Advanced oxidation processes for organic contaminant destruction based on the Fenton reaction and related chemistry. Crit Rev Environ Sci Technol 36:1–84
Prado RM, Corrêa MCM, Cintra ACO, Natale W (2003) Response of guava plants to basic slag application as corrective of soil acidity. Rev Bras Frutic 25:160–163
Pu S, Xianga C, Zhua R, Ma H, Zinchenko A, Chu W (2017) An efficient heterogeneous Fenton catalyst based on modified diatomite for degradation of cationic dye simulated wastewater. Desalin Water Treat 79:378–385
Reddy BM, Yamada Y, Kobayashi T, Loridant S, Volta JC (2003) Structural characterization of CeO2 − TiO2 and V2O5/CeO2 − TiO2 catalysts by Raman and XPS techniques. J Phys Chem B 107:5162–5167
Sandell EB (1959) Colorimetric determination of trace metals, 3rd edn. Interscience, New York
Sobral MF, Nascimento CWA, Cunha KPV, Ferreira HA, Silva AJ, Silva FBV (2011) Basic slag and its effects on the concentration of nutrients and heavy metals in sugarcane. Rev Bras Eng Agríc Ambient 15:867–872
Sun Z, Xiao C, Fida H, Zhang G (2018) Synthesis of stable and easily recycled ferric oxides assisted by rhodamine B for efficient degradation of organic pollutants in heterogeneous photo-Fenton system. J Clean Prod 196:1501–1507
Thai PK, Ky LX, Binh VN, Nhung PH, Nhan PT, Hieu NQ, Dang NTT, Tam NKB, Anh NTK (2018) Occurrence of antibiotic residues and antibiotic-resistant bacteria in effluents of pharmaceutical manufacturers and other sources around Hanoi, Vietnam. Sci Total Environ 645:393–400
Thommes M, Kaneko K, Neimark AV, Oliver JP, Rodriguez-Reinoso F, Roquerol J, Sing KSW (2015) Physisorption of gases, with special reference to the evaluation of surface area and pore size distribution (IUPAC Technical Report). Pure Appl Chem 87:1051–1069
USGS (2019) Mineral commodity summaries 2019: U.S. Geological Survey, 200 pp. https://doi.org/10.3133/70202434
Wang C, Liu H, Sun Z (2012) Heterogeneous photo-Fenton reaction catalyzed by nanosized iron oxides for water treatment. Int J Photoenergy 1–10.
Wang JL, Xu LJ (2012) Advanced oxidation processes for wastewater treatment: formation of hydroxyl radical and application. Crit Rev Environ Sci Technol 42:251–325
Wei Z, Yin G, Wang JG, Wan L, Li G (2012) Design, construction and management of tailings storage facilities for surface disposal in China: case studies of failures. Waste Manag Res 31:106–112
Wolff AP, Costa GM, Dutra FC (2010) A comparative study of ultra-fine iron ore tailings from Brazil. Miner Process Extr Metall Rev 32:47–59
Xavier S, Gandhimathi R, Nidheesh PV, Ramesh TS (2016) Comparative removal of magenta MB from aqueous solution by homogeneous and heterogeneous photo-Fenton processes. Desalin Water Treat 57:12832–12841
Zang C, Yu K, Hu S, Chen F (2018) Adsorption-depended Fenton-like reaction kinetics in CeO2-H2O2 system for salicylic acid degradation. Colloids Surf A Physicochem Eng Asp 553:456–463
Zheng J, Gao Z, He H, Yang S, Sun C (2016) Efficient degradation of acid orange 7 in aqueous solution by iron ore tailing Fenton-like process. Chemosphere 45:40–48
Acknowledgments
Financial support for this work was provided by FAPESP (research project number 2015/21732-5) and CAPES (scholarship awarded to S.C.A.D.). We are grateful to Prof. Denise Bevilaqua for providing the iron mining residue.
Author information
Authors and Affiliations
Corresponding author
Additional information
Responsible editor: Vítor Pais Vilar
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Electronic supplementary material
ESM 1
(DOCX 746 kb)
Rights and permissions
About this article
Cite this article
Ayala-Durán, S.C., Hammer, P. & Pupo Nogueira, R.F. Surface composition and catalytic activity of an iron mining residue for simultaneous degradation of sulfonamide antibiotics. Environ Sci Pollut Res 27, 1710–1720 (2020). https://doi.org/10.1007/s11356-019-06662-1
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-019-06662-1