Abstract
Pentaerythritol tetranitrate (PETN) powders are used to initiate other explosives. During long-term storage, changes in powder properties can cause changes in the initiation performance. Changes in the morphology and surface area of aging powders are observed due to sublimation and growth of PETN crystals through coarsening mechanisms, (e.g. Ostwald ripening, sintering, etc.). In order to alleviate the sublimation of PETN crystals under service conditions, stabilization methods such as thermal cycling and doping with certain impurities during or after the crystallization of PETN have been proposed.
In this report we present our work on the effect of impurities on the morphology and activation energy of the PETN crystals. The pure and impurity doped crystals of PETN were grown from supersaturated acetone solution by solvent evaporation technique at room temperature. The difference in the morphology of the impurity-doped PETN crystal compared to pure crystal was examined by optical microscopy. The changes in the activation energies and the evaporation rates are determined by thermogravimetry (TG). Our activation energies of evaporation agree with earlier reported enthalpies of vaporization. The morphology and activation energy of PETN crystals doped with Ca, Na, and Fe cations are similar to that for pure PETN crystal, whereas the Zn-ion-doped PETN crystals have different morphology and decreased activation energy.
Similar content being viewed by others
References
H. E. Buckley, Crystal growth, Wiley, New York 1951.
R. J. Davey, in Industrial Crystallization 78, E. J. de Jong and S. J. Jancic (Eds), North-Holland, Amsterdam (1979) p. 169.
B. Simon and R. J. Boistelle, J. Cryst. Growth, 52 (1981) 779.
K. Sangwal, J. Cryst. Growth, 128 (1993) 1236.
K. Sangwal, Prog. Cryst. Growth Charact., 32 (1996) 3.
I. Weissbuch, L. J. W. Shimon, E. M. Landau, R. Popovitz-Biro, Z. Berkovitch-Yellin, L. Addadi, M. Lahav and L. Leiserowitz, Pure Appl. Chem., 58 (1986) 947.
Z. Berkovitc-Yellin, J. van Mil, L. Addali, M. Idelson, M. Lahav and L. Leiserowitz, J. Am. Chem. Soc., 107 (1985) 3111.
G. Clydesdale, K. J. Roberts and R. Docherty, J. Cryst. Growth, 135 (1994) 331.
G. Clydesdale, K. J. Roberts, K. Lewtas and R. Docherty, J. Cryst. Growth, 141 (1994) 443.
R. N. Rogers and R. H. Dinegar, Thermochim. Acta, 3 (1972) 367.
G. A. Eiceman, D. Preston, G. Tiano, J. Rodriguez and J. E. Parmeter, Talanta, 45 (1997) 57.
K. H. Lau, D. L. Hilderbrand, S. Crouch-Baker, A. Sanjurjo, J. Chem. Eng. Data, 49 (2004) 544.
R. Behrens, ’Update on the Analysis of Thermally and Chemically Stabilized PETN powders’, Presented at JOWOG Focused Exchange Meeting, May 12–14, 2003, Albuquerque, NM, Sandia National Laboratories.
R. Meyer, J. Kohler and A. Homburg, Explosives, 5th Ed., Wiley 2002, p. 253.
L. Li, K. Tsukamoto and I. Sunagawa, J. Cryst. Growth, 99 (1990) 150.
A. J. Gratz and P. E. Hillner, J. Cryst. Growth, 129 (1993) 789.
G. M. Bliznakov, Bull. Acad. Sci. Bulg. Ser. Phys., 4 (1954) 135.
G. Bliznakov and E. Kirkova, Krist. Tech., 4 (1969) 331.
N. Canbrera and D. A. Vermilyea in Growth and Perfection of Crystals, R. H. Doremus, B. W. Roberts and D. Turnbull (Eds), Wiley, New York, 1958, p. 393.
B. C. Dionne, D. P. Rounbehler, E. K. Achter, J. R. Hobbs and D. H. Fine, J. Energetic Mater., 4 (1986) 447.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Pitchimani, R., Zheng, W., Simon, S.L. et al. Thermodynamic analysis of pure and impurity doped pentaerythritol tetranitrate crystals grown at room temperature. J Therm Anal Calorim 89, 475–478 (2007). https://doi.org/10.1007/s10973-006-8462-9
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10973-006-8462-9