Skip to main content

Advertisement

SpringerLink
Log in

Comparison of structural and electric properties of ZnO-based n-type thin films with different dopants for thermoelectric applications

  • Original Paper: Sol–gel and hybrid materials for energy, environment and building applications
  • Published:
Journal of Sol-Gel Science and Technology Aims and scope Submit manuscript

Abstract

This paper presents a study on ZnO-based n-type thin films doped with Al, Ga, and Sn deposited on the glass substrates, using the solution derived by sol–gel reactions. The basic material properties associated with using the alternative chemical substances in synthesis process and different dopants to generate n-type conductivity in ZnO-based thin films which are transparent oxides, are investigated and discussed. Namely, the crystal structure and surface morphology of the obtained films were examined by means of XRD analysis and field-effect scanning electron microscope (FESEM). The electric properties of those films were characterized by Hall-effect measurements and temperature dependence of electrical conductivity, as well as Seebeck coefficients. The remarkable advantages corresponding to the certain characterization of each material composition were compared together. The aim is to fully understand the performance limitation of known materials and to set the scene for a suitable synthesis condition to get optimized materials for thermoelectric applications.

Highlights

  • ZnO thin films doped with Al, Ga and Sn in the range from 1 to 3 mol % were fabricated by dip coating technique using the solutions derived by sol–gel reactions.

  • The grain sizes and shapes together with the grain boundary were affected by doping contents and different size of doping ions. Namely, the grain size of AZO and GZO samples is smaller than that of ZnO and SZO ones, meanwhile it is scarcely changed with increasing Sn concentration for SZO films.

  • Among samples, Ga doped ZnO demonstrate most improved thermoelectric properties as compared to the Al- and Sn-doped ZnO. Introduction of Sn into ZnO lattice also remarkably increases the electrical parameters at room tempertature and the transport property throughout its temperature-dependent electrical conductivity and Seebeck coefficient.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6

Similar content being viewed by others

References

  1. Zemskov VS, Shelimova LE, Konstantinov PP, Avilov ES, Kretova MA, Nikhezina IYu (2012) Thermoelectric materials based on layered chalcogenides of bismuth and lead. Inorg Mater: Appl Res 3(1):61–68

    Article  Google Scholar 

  2. Powell A, Vaqueiro P (2016) Chalcogenide thermoelectric materials. In: Iris Nandhakumar, White Neil M, Stephen Beeby (ed), Thermoelectric materials and devices, RSC energy & environment series (Ch. 2). Royal Society of Chemistry, Thomas Graham House, Science Park, Milton Road, Cambridge, CB4 0WF, UK: 27–59

  3. Li S, Li X, Ren Z, Zhang Q (2018) Recent progress towards high performance of tin chalcogenide thermoelectric materials. J Mater Chem A 6:1–33

    Article  Google Scholar 

  4. Tsubota T, Ohtaki M, Eguchi K, Arai H (1997) Thermoelectric properties of Al-doped ZnO as a promising oxidematerial for high-temperature thermoelectric conversion. J Mater Chem 7(1):85–90

    Article  CAS  Google Scholar 

  5. Kim KH, Shim SH, Shim KB, Niihara K, Hojo J (2005) Microstructural and thermoelectric characteristics of zinc oxide‐based thermoelectric materials fabricated using a spark plasma sintering process. J Am Ceram Soc 88(3):628–632

    Article  CAS  Google Scholar 

  6. Wang C, Wang Y, Zhang G, Peng C (2013) Electronic structure and thermoelectric properties of ZnO single-walled nanotubes and nanowires. J Phys Chem C 117(41):21037–21042

    Article  CAS  Google Scholar 

  7. Abutaha AI, Sarath Kumar SR, Alshareef HN (2013) Crystal orientation dependent thermoelectric properties of highly oriented aluminum doped zinc oxide thin films. Appl Phys Lett 102:053507

    Article  Google Scholar 

  8. Saini S et al. (2016) Effect of self-grown seed layer on thermoelectric properties of ZnO thin films. Thin Solid Films 605:289–294

    Article  CAS  Google Scholar 

  9. Mohammed MA, Sudin I, Noor AM, Rajoo S, Uday MB, Obayes NH, Omar MF(2018) A review of thermoelectric ZnO nanostructured ceramics for energy recovery J Int J Eng Technol 2:6649–6655

    Google Scholar 

  10. Mele P et al. (2013) Effect of substrate on thermoelectric properties of Al-doped ZnO thin films Appl Phys Lett 102:253903

    Article  Google Scholar 

  11. Cai K, Müller E, Drašar C, Mrotzek A (2003) Preparation and thermoelectric properties of Al-doped ZnO ceramics. Mater Sci Eng: B 104(1):45–48

    Article  Google Scholar 

  12. Cai KF et al. (2003) Preparation and thermoelectric properties of Al-doped ZnO ceramics. Mater Sci Eng B 104(–2):45–48

    Article  Google Scholar 

  13. Fujishiro Y et al. (2003) Effect of microstructural control on thermoelectric properties of hot-pressed aluminum-doped zinc oxide. J Am Ceram Soc 86(12):2063–2066

    Article  CAS  Google Scholar 

  14. Qu XR et al. (2011) Thermoelectric properties and electronic structure of Al-doped ZnO. Solid State Commun 151(4):332–336

    Article  CAS  Google Scholar 

  15. Yamaguchi H, Chonan Y, Oda M, Komiyama T, Aoyama T, Sugiyama S (2011) Thermoelectric properties of ZnO ceramics co-doped with Al and transition metals. J Electron Mater 4(5):723–727

    Article  Google Scholar 

  16. Zhang L, Tosho T, Okinaka N, Akiyama T (2008) Thermoelectric properties of solution combustion synthesized Al-doped ZnO. Mater Trans 49(12):2868–2874

    Article  CAS  Google Scholar 

  17. Jood P et al. (2011) Al-doped zinc oxide nanocomposites with enhanced thermoelectric properties. Nano Lett 11(10):4337–4342

    Article  CAS  Google Scholar 

  18. Nam WH, Lim YS, Choi S-M, Seo W-S, Lee JY (2012) High-temperature charge transport and thermoelectric properties of a degenerately Al-doped ZnO nanocomposite. J Mater Chem 22(29):14633–14638

    Article  CAS  Google Scholar 

  19. Jun M-C, Park S-U, Koh J-H (2012) Comparative studies of Al-doped ZnO and Ga-doped ZnO transparent conducting oxide thin films. Nanoscale Res Lett 7:639

    Article  Google Scholar 

  20. Trinh TQ, Nguyen TT, Vu DV, Le DH (2017) Structural and thermoelectric properties of Al-doped ZnO thin films grown by chemical and physical methods. J Mater Sci: Mater Electron 28(1):236–240

    CAS  Google Scholar 

  21. Paul GK, Sen SK (2002) Sol–gel preparation, characterization and studies on electrical and thermoelectrical properties of gallium doped zinc oxide films. Mater Lett 57:742–746

    Article  CAS  Google Scholar 

  22. Ahn BD, Oh SH, Hong DU, Shin DH, Moujoud A, Kim HJ (2008) Transparent Ga-doped zinc oxide-based window heaters fabricated by pulsed laser deposition. J Cryst Growth 310:3303–3307

    Article  CAS  Google Scholar 

  23. Barasheed AZ, Sarath Kumar SR, Alshareef HN (2013) Temperature dependent thermoelectric properties of chemically derived gallium zinc oxide thin films. J Mater Chem C 1:4122–4127

    Article  CAS  Google Scholar 

  24. Sim KU, Shin SW, Moholkar AV, Yun JH, Moon JH, Kim JH (2010) Effects of dopant (Al, Ga, and In) on the characteristics of ZnO thin films prepared by RF magnetron sputtering system. Curr Appl Phys 10:S463–S467

    Article  Google Scholar 

  25. Jood P, Peleckis G, Wang X, Dou SX (2012) Effect of gallium doping and ball milling process on the thermoelectric performance of n-type ZnO. J Mater Res 27(17):2278–2285

    Article  CAS  Google Scholar 

  26. Kazeoka M et al. (1998) Improvement in thermoelectric properties of (ZnO)/In2O3 through partial substitution of yttrium for indium. J Mater Res 13(3):523–526

    Article  CAS  Google Scholar 

  27. Ohta H, Seo WS, Koumoto K (1996) Thermoelectric properties of homologous compounds in the ZnO–In2O3 system. J Am Ceram Soc 79(8):2193–2196

    Article  CAS  Google Scholar 

  28. Kaga H, Asahi R, Tani T (2004) Thermoelectric properties of doped (ZnO)(m)In2O3. Jpn J Appl Phys Pt 1 43(6A):3540–3543

    Article  CAS  Google Scholar 

  29. Park K et al. (2009) Zn1−xBixO (0 < x < 0.02) for thermoelectric power generations. J Alloys Compd 485(1–2):532–537

    Article  CAS  Google Scholar 

  30. Park K, Seong JK, Kim GH (2009) NiO added Zn1−xNixO (0 < x < 0.05) for thermoelectric power generation. J Alloys Compd 473(1–2):423–427

    Article  CAS  Google Scholar 

  31. Colder H et al. (2011) Preparation of Ni-doped ZnO ceramics for thermoelectric applications. J Eur Ceram Soc 31(15):2957–2963

    Article  CAS  Google Scholar 

  32. Park K, Seong JK, Nahm S (2008) Improvement of thermoelectric properties with the addition of Sb to ZnO. J Alloys Compd 455(1–2):331–335

    Article  CAS  Google Scholar 

  33. Park K et al. (2008) Influence of SnO2 addition on the thermoelectric properties of Zn1−xSnxO (0.01 ≤ x ≤ 0.05). Mater Res Bull 43(1):54–61

    Article  CAS  Google Scholar 

  34. Park K, Seong JK (2008) Influence of simultaneous addition of Sb2O3 and SnO2 on thermoelectric properties of Zn1-x-ySbxSnyO prepared by tape casting. J Alloys Compd464(1–2):1–5

    Article  CAS  Google Scholar 

  35. Seo DK et al. (2011) Drastic improvement of oxide thermoelectric performance using thermal and plasma treatments of the InGaZnO thin films grown by sputtering. Acta Mater 59(17):6743–6750

    Article  CAS  Google Scholar 

  36. Wu Z-H, Xie H-Q, Zhai Y-B (2015) Preparation and thermoelectric properties of Co-doped ZnO synthesized by sol–gel. J Nanosci Nanotechnol 15:3147–3150

    Article  CAS  Google Scholar 

  37. Colder H, Guilmeau E, Harnois C, Marinel S, Retoux R, Savary E (2011) Preparation of Ni-doped ZnO ceramics for thermoelectric applications. J Eur Ceram Soc 31(15):2957–2963

    Article  CAS  Google Scholar 

  38. Koresh I, Amouyal Y (2017) Effects of microstructure evolution on transport properties of thermoelectric nickel-doped zinc oxide. J Eur Ceram Soc 37(11):3541–3550

    Article  CAS  Google Scholar 

  39. Majumdar A (2004) Thermoelectricity in semiconductor nanostructures. Science 303(5659):777–778

    Article  CAS  Google Scholar 

  40. Dresselhaus MS et al. (2007) New directions for low-dimensional thermoelectric materials. Adv Mater 19(8):1043–1053

    Article  CAS  Google Scholar 

  41. Lan Y et al. (2010) Enhancement of thermoelectric figure-of-merit by a bulk nanostructuring approach. Adv Funct Mater 20(3):357–376

    Article  CAS  Google Scholar 

  42. Koumoto K et al. (2010) Oxide thermoelectric materials: a nanostructuring approach. Annu Rev Mater Res 40:363–394

    Article  CAS  Google Scholar 

  43. Kanatzidis MG (2009) Nanostructured thermoelectrics: the new paradigm. Chem Mater 22(3):648–659

    Article  Google Scholar 

  44. Venkatasubramanian R et al. (2001) Thin-film thermoelectric devices with high room-temperature figures of merit. Nature 413(6856):597–602

    Article  CAS  Google Scholar 

  45. Chhatrasal Ga, Kamal KKar (2016) Recent advances in thermoelectric materials. Prog Mater Sci 83:330–382

    Article  Google Scholar 

Download references

Acknowledgements

This work has been funded by Hanoi University of Science and Technology (HUST) under Grant number T2017-LN-07.

Author information

Authors and Affiliations

  1. Faculty of Chemistry, Hanoi National University of Education, 136 Xuan Thuy Rd., Hanoi, Vietnam

    Doanh Viet Vu & Dang Hai Le

  2. School of Engineering Physics, Hanoi University of Science and Technology, 1 Dai Co Viet Rd., Hanoi, Vietnam

    Chien Xuan Nguyen & Thong Quang Trinh

Authors
  1. Doanh Viet Vu
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Dang Hai Le
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Chien Xuan Nguyen
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Thong Quang Trinh
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Thong Quang Trinh.

Ethics declarations

Conflict of interest

The author declares the following: “In accordance with Springer nature policy and my ethical obligation as a researcher, I am reporting that I received funding from the Hanoi University of Science and Technology by the research reported in the enclosed paper. I have disclosed those interests fully to Springer Nature and I have in place an approved plan for managing any potential conflicts arising from that involvement.”

Additional information

Publisher’s note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Viet Vu, D., Hai Le, D., Xuan Nguyen, C. et al. Comparison of structural and electric properties of ZnO-based n-type thin films with different dopants for thermoelectric applications. J Sol-Gel Sci Technol 91, 146–153 (2019). https://doi.org/10.1007/s10971-019-05024-0

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10971-019-05024-0

Keywords

Search

Navigation