Two models are considered for propagation of acoustic waves in the water conduits of Francis turbines at hydroelectric power plants (HPP). Transfer functions are cited for a dynamic “pressure-conduit/turbine/draft-tube” system during a pressure disturbance beyond the turbine. Fulfillment of the Nyquist criterion for the above-mentioned system indicates its stability at any openings of the final-control element. Analysis of analytical relationships between frequency characteristics and parameters characterizing the wave properties of sections of the water conduit makes it possible to isolate frequency regions in which manifestation of resonance is possible, and also evaluate its amplitude. The frequency response of the water conduit at the Sayano-Shushenskaya HPP, for which three resonances are isolated in the ultra-low acoustic region is given in the conclusion. A mathematical model of the process is developed and investigated. Oscillograms of pressure pulsation during pressure disturbances in the final third of the draft tube are presented. Results of the investigation are compared with published data derived from full-scale tests.
Similar content being viewed by others
References
V. I. Kazanov, “Are technogenic failures inevitable?,” Élektro, No. 2 (2011).
Report on Technical Investigation of Causes of the Failure at the Sayano-Shushenskaya HPP.
M. A. Kolosov, “Reliability of the vane guide in the turbine at the Sayano-Shushskoe HPP,” Gidrotekhnika. XXI Vek, 4(1) (March 2011).
V. Kh. Arm, V. L. Okulov, and I. M. Pylev, “Instability of pressure systems in water-power units,” Izv. Akad. Nauk Ser. Énergetika, No. 3, 122–131 (1996).
N. E. Zhukovskii, Water Hammers in Water-Supply Pipes [in Russian], Gostekhizdat, Moscow – Leningrad (1949).
K. A. Shramkov, “Flow in a conduit with a Francis turbine,” Énergomashinostroenie, No. 8 (1965).
L. G. Pazi, “Periodic pressure pulsations in the draft tubes of hydraulic turbines,” Tr. VNIIGidromasha, No. 37 (1968).
R. K. Karavosov and A. G. Prozorov, “Unusual disturbance of hydroacoustic resonance in a hydraulic-turbine run of the Sayano-Shushenskaya HPP,” Inzh.-Fiz. Zh., 84(3) (2011).
M. Yu. Zaitsev, V. F. Kop’ev, A. G. Munin, and A. A. Potokin, “Noise emission by a turbulent vortex ring,” Dokl. AN SSSR, 312(5), 1080–1083 (1990).
M. Yu. Zaitsev and V. F. Kop’ev, “Mechanics of noise emission by a vortex ring,” Akust. Zh., 39(6), 1068–1074 (1993).
F. A. Garaev, “Universality of the synchronization principle,” Paropsikhol. Psikhofiz., No. 1 (2000).
O. I. Bashnin, N. P. Pasynkova, and V. V. Semenov, One Means of Analog Simulation of Kaplan Turbines, Control and Monitoring Systems [in Russian], Nauka, Leningrad (1968), pp. 105–111.
V. A. Pivovarov, Design and Analysis of Control Systems for Hydraulic Turbines [in Russian], Mashinostroenie, Leningrad (1973).
O. I. Bashnin, Process of Elastic Water Hammer in HPP Conduits, Automated Control of Generating Sets [in Russian], Izd. VNIIÉlektomash, Leningrad (1980).
V. V. Berlin and O. A. Murav’ev, Transitional Processes at HPP with Compensating Reservoirs [in Russian], Énergoatomizdat, Moscow (1991).
M. A. Lavren’t’ev and B. V. Shabat, Methods of the Theory of Complex-Variable Functions [in Russian], Nauka, Moscow (1965).
V. I. Bryzgalov, From Experience Acquired with the Building and Operation of the Krasnoyarsk and Sayano-Shushenskaya Hydroelectric Power Plants. Industry Publication [in Russian].
Internet-Forum “SShHPP — opinions within and without,” Post #10856.
V. V. Semenov, “Modeling of hydraulic turbines, pipelines, and speed regulators,” in: M. P. Kostenko (ed.), Electrodynamic Modeling of Power-Generating Systems [in Russian], Nauka, Moscow – Leningrad (1959).
Author information
Authors and Affiliations
Additional information
Translated from Gidrotekhnicheskoe Stroitel’stvo, No. 7, July 2012, pp. 29 – 45.
Rights and permissions
About this article
Cite this article
Bashnin, O.I. Sayano-Shushenskaya catastrophe — synchronous hydroacoustic resonance?. Power Technol Eng 46, 331–345 (2013). https://doi.org/10.1007/s10749-013-0359-8
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10749-013-0359-8