Skip to main content

Advertisement

SpringerLink
Log in

Numerical Simulation of Photocatalytic Reduction of Gas Phase CO2 in Optofluidic Microreactor

  • Published:
Catalysis Letters Aims and scope Submit manuscript

Abstract

Emission reduction of CO2 is an urgent global environmental problem. The photocatalytic reduction of CO2 has attracted lots of interest as a novel method for producing organic fuel, and this technology does not require the consumption of additional energy. So in this paper, the photocatalytic reduction processes of gas phase CO2 in the different optofluidic microreactors were simulated to analyze the reaction mechanism and the reactants transfer process. Firstly, the applicability of the classical Langmuir–Hinshelwood equilibrium adsorption model and the self-defined dynamic mass transfer model for the numerical simulation of optofluidic planar reactor were initially verified. The results of the simulation based on the Langmuir–Hinshelwood model were not consistent with the experimental results when the flow rate were high, while those of the simulation based on the self-defined dynamic mass transfer model were consistent with the experimental results. The result indicates that the mass transfer process of the reactants is the dominant factor which affects the reaction efficiency of the photocatalytic process in the microreactor. Then, the corresponding Sherwood number was calculated according to the mass transfer coefficient under different inlet flow rates, and the mass transfer characteristic correlation was established. Finally, the planar microreactor was optimized to be an inverted convex cylinders microreactor, and the numerical simulation of photocatalytic reduction process of gas phase CO2 was carried out by using self-defined dynamic mass transfer model. It was found that the inverted convex cylinders in the microreactor could significantly enhance the transfer effect of reactants during the reaction process and improve the conversion efficiency of CO2.

Graphical Abstract

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12
Fig. 13
Fig. 14
Fig. 15
Fig. 16

Similar content being viewed by others

References

  1. PCC fifth assessment report: climate change 2013[EB/OL]. http://www.ipcc.ch/report/ar5/ (2013)

  2. Furler P, Scheffe JR, Steinfeld A (2012) Syngas production by simultaneous splitting of H2O and CO2 via ceria redox reactions in a high temperature solar reactor. Energy Environ Sci 5(3):6098–6103

    Article  CAS  Google Scholar 

  3. Murugananthan M, Kumaravel M, Katsumata H et al (2015) Electrochemical reduction of CO2 using Cu electrode in methanol/LiClO4 electrolyte. Int J Hydrog Energy 40(21):6740–6744

    Article  CAS  Google Scholar 

  4. Razzak SA, Hossain MM, Lucky RA et al (2013) Integrated CO2 capture, wastewater treatment and biofuel production by microalgae culturing: a review. Renew Sustain Energy Rev 27(6):622–653

    Article  CAS  Google Scholar 

  5. Seng ST, Linda Z (2006) Photocatalytic reduction of carbon dioxide into gaseous hydrocarbon using TiO2 pellets. Catal Today 115(1–4):269–273

    Google Scholar 

  6. Roy SC, Varghese OK, Paulose M et al (2010) Toward solar fuels: photocatalytic conversion of carbon dioxide to hydrocarbons. ACS Nano 4(3):1259–1278

    Article  CAS  PubMed  Google Scholar 

  7. Dhakshinamoorthy A, Navalon S, Corma A et al (2012) Photocatalytic CO2 reduction by TiO2 and related titanium containing solids. Energy Environ Sci 5(11):9217–9233

    Article  CAS  Google Scholar 

  8. Koci K, Obalova L, Lacny Z (2008) Photocatalytic reduction of CO2 over TiO2 based catalysts. Chem Pap 62(1):1–9

    Article  CAS  Google Scholar 

  9. Shown I, Hsu HC, Chang YC et al (2014) Highly efficient visible light photocatalytic reduction of CO2 to hydrocarbon fuels by Cu-nanoparticle decorated graphene oxide. Nano Lett 14(11):6097–6103

    Article  CAS  PubMed  Google Scholar 

  10. Li Z, Zhou Y, Zhang J et al (2012) Hexagonal nanoplate-textured micro-octahedron Zn2SnO4: combined effects toward enhanced efficiencies of dye-sensitized solar cell and photoreduction of CO2 into hydrocarbon fuels. Cryst Growth Des 12(3):1476–1481

    Article  CAS  Google Scholar 

  11. Kimfung L, Handoko AD, Majeda K et al (2014) Photocatalytic reduction of CO2 and protons using water as an electron donor over potassium tantalate nanoflakes. Nanoscale 6(16):9767–9773

    Article  Google Scholar 

  12. Tahir B, Tahir M, Amin NAS (2015) Gold-indium modified TiO2 nanocatalysts for photocatalytic CO2 reduction with H2 as reductant in a monolith photoreactor. Appl Surf Sci 338:1–14

    Article  CAS  Google Scholar 

  13. Campbell TJ (2013) Photochemical reduction of carbon dioxide in aqueous and ionic liquid solutions in a microreactor with TiO2 catalyst: experiment and modeling. Oregon State University

  14. Tahir M, Amin NAS (2013) Photocatalytic CO2 reduction and kinetic study over In/TiO2 nanoparticles supported microchannel monolith photoreactor. Appl Catal A 467(10):483–496

    Article  CAS  Google Scholar 

  15. Cheng X, Chen R, Zhu X et al (2016) Optofluidic membrane microreactor for photocatalytic reduction of CO2. Int J Hydrog Energy 41(4):2457–2465

    Article  CAS  Google Scholar 

  16. Cheng X, Chen R, Zhu X et al (2016) An optofluidic planar microreactor for photo catalytic reduction of CO2 in alkaline environment. Energy 11(081):1–7

    Article  Google Scholar 

  17. Zou L (2011) Numerical simulation of photocatalytic degradation of benzene with carbon nanotubes-titanium dioxide chitosan. Civil Engineering, Hunan University, Hunan

    Google Scholar 

  18. Serge C, Nidhal B, Orfan Z et al (2012) Modelling and design of microchannel reactor for photocatalysis. Virtual Phys Prototyp 07(03):203–209

    Article  Google Scholar 

  19. Serge C, Nidhal B, Orfan Z et al (2014) Mass transfer measurements and modeling in a microchannel photocatalytic reactor. Chem Eng Res Des 92(4):657–662

    Article  Google Scholar 

  20. Wang X (2014) Numerical simulation of light radiation field and photocatalytic surface reaction in photocatalytic reactor. Chemical Engineering, Tianjin University, Tianjin

    Google Scholar 

  21. Ignasi SE, Alberto B, Gianluca LP (2007) Two-dimensional modeling of a flat-plate photocatalytic reactor for oxidation of indoor air pollutants. Ind Eng Chem Res 46(23):7489–7496

    Article  Google Scholar 

  22. Serpone N, Pelizzetti E (1989) Adsorption desorption, related mobility and reactivity in photocatalysis. Photocatalysis: fundamentals and applications. Wiley, New York, pp 217–250

    Google Scholar 

  23. Peral J, Domenech X, Oilis DF (1997) Heterogeneous photocatalysis for purification, decontamination and deodorization of air. J Chem Technol Biotechnol 70(2):117–140

    Article  CAS  Google Scholar 

  24. Fu X, Shen W, Yao T (1990) Physical chemistry, 4th edn. Higher Education Press, Beijing, pp 971–978

    Google Scholar 

  25. Cheng M, Yang S, Chen R et al (2017) Copper-decorated TiO2 nanorod thin films in optofluidic planar reactors for efficient photocatalytic reduction of CO2. Int J Hydrog Energy 42(15):9722–9732

    Article  CAS  Google Scholar 

  26. Zhu G, Sun Y (2009) Transmission principle, 1st edn. Metallurgical Industry Press, Beijing

    Google Scholar 

  27. Xu Y, Zhu H (2013) The role of Kn number in the study of micro-scale similar flow characteristics. J Aeronaut Dyn 28(8):1752–1758

    Google Scholar 

  28. Zhao J, Yang X (2003) Photocatalytic oxidation for indoor air purification: a literature review. Build Environ 38(5):645–654

    Article  Google Scholar 

  29. Sang BK, Sung CH (2002) Kinetic study for photocatalytic degradation of volatile organic compounds in air using thin film TiO2 photocatalyst. Appl Catal B 35(2):305–315

    Google Scholar 

  30. Liu J, Wang Z, Shen J et al (2009) The L–H model in the photocatalytic oxidation kinetics of volatile organicpollutants. Progress Chem 21(10):2037–2043

    CAS  Google Scholar 

  31. Wang H, Iovenitti P, Harvey E (2002) Optimizing layout of obstacles for enhanced mixing in microchannels. Smart Mater 11:662–667

    Article  CAS  Google Scholar 

Download references

Acknowledgement

The authors gratefully acknowledge the financial support of the National Science Foundation for Young Scientists of China (No. 51606019).

Author information

Authors and Affiliations

  1. Key Laboratory of Low-Grade Energy Utilization Technologies and Systems (Chongqing University), Ministry of Education, Chongqing, 400044, China

    Min Cheng, Yi Huang, Rui Gao & Shuxia Bai

  2. Institute of Engineering Thermophysics, Chongqing University, Chongqing, 400044, China

    Min Cheng, Yi Huang, Rui Gao & Shuxia Bai

Authors
  1. Min Cheng
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Yi Huang
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Rui Gao
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Shuxia Bai
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Min Cheng.

Ethics declarations

Conflict of interest

All authors declare that there are no other relationships or activities that could appear to have influenced the submitted work.

Additional information

Publisher's Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Cheng, M., Huang, Y., Gao, R. et al. Numerical Simulation of Photocatalytic Reduction of Gas Phase CO2 in Optofluidic Microreactor. Catal Lett 149, 3000–3011 (2019). https://doi.org/10.1007/s10562-019-02838-z

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10562-019-02838-z

Keywords

Search

Navigation