Abstract
The discharge of ammonia–nitrogen (NH3–N), total nitrogen (TN), chemical oxygen demand (COD), and total phosphorus (TP) in rural sewage usually exceeds the Pollutant Discharge Standard for Urban Sewage Treatment Plants (GB18918-2002). Efficient and cost-effective removal of these pollutants cannot be simultaneously realized using conventional rural sewage treatment methods. Thus, an assembled biological filter (D50 × W50 × H113 cm), including a phosphorus removal layer filled with solid polymeric ferric sulfate and alternating aerobic-anaerobic layers, is proposed herein. The aerobic (anerobic) layers were filled with zeolite (zeolite and composite soil) at different intervals. This system was used for the treatment of synthetic sewage having COD: 122.0–227.0 mg/L; NH3–N: 29.1–47.0 mg/L; TN: 28.0–58.0 mg/L; and TP: 2.0–3.8 mg/L. Based on optimal operation conditions (40 L/h reflow rate, without artificial aeration, and 12-h operation cycle), the system showed NH3–N, TN, COD, and TP removal efficiencies of 87.1 ± 8.1, 83.4 ± 7.9, 91.0 ± 9.4, and 80.0 ± 6.4%, respectively. Further, in the pilot-scale test, under the same optimal parameters, the removal efficiencies of NH3–N, TN, COD, and TP were 78.9 ± 8.1, 75.4 ± 7.9, 82 ± 9.4, and 76 ± 6.4%, respectively. Furthermore, in the different functional units of the system, a large number of functional bacteria capable of efficiently facilitating the simultaneous removal of the different pollutants from sewage were identified. Therefore, this proposed system, which complies with current environmental discharge regulations, can be a more sustainable approach for the treatment of unattended rural sewage.
Graphic abstract
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
Data availability
I certify that this manuscript is original and has not been published and will not be submitted elsewhere for publication while being considered by Biodegradation. Additionally, the study has not split up into several parts to increase the number of submissions and submitted to various journals or to one journal over time. No data have been fabricated or manipulated (including images) to support your conclusions. No data, text, or theories by others are presented as if they were our own.
References
Bhowmick GD, Chakraborty I, Ghangrekar MM, Mitra A (2019a) TiO2/activated carbon photo cathode catalyst exposed to ultraviolet radiation to enhance the efficacy of integrated microbial fuel cell-membrane bioreactor. Bioresour Technol Rep 7:100303. https://doi.org/10.1016/j.biteb.2019.100303
Bhowmick GD, Das S, Ghangrekar MM, Mitra A, Banerjee R (2019b) Improved wastewater treatment by combined system of microbial fuel cell with activated carbon/TiO2 cathode catalyst and membrane bioreactor. J Inst Eng India Ser A 100:675–682. https://doi.org/10.1007/s40030-019-00406-7
Chan YJ, Chong MF, Law CL (2012) An integrated anaerobic-aerobic bioreactor (IAAB) for the treatment of palm oil mill effluent (POME): start-up and steady state performance. Process Biochem 47:485–495. https://doi.org/10.1016/j.procbio.2011.12.005
Cheng P, Jin Q, Jiang H, Hua M, Ye Z (2020) Efficiency assessment of rural domestic sewage treatment facilities by a slacked -based DEA model. J Clean Prod. https://doi.org/10.1016/j.jclepro.2020.122111
Cieslik B, Konieczka P (2017) A review of phosphorus recovery methods at various steps of wastewater treatment and sewage sludge management. The concept of “no solid waste generation” and analytical methods. J Clean Prod 142:1728–1740. https://doi.org/10.1016/j.jclepro.2016.11.116
Di Capua F, Mascolo MC, Pirozzi F, Esposito G (2020) Simultaneous denitrification, phosphorus recovery and low sulfate production in a recirculated pyrite-packed biofilter (RPPB). Chemosphere. https://doi.org/10.1016/j.chemosphere.2020.126977
Edgar RC (2013) UPARSE: highly accurate OTU sequences from microbial amplicon reads. Nat Methods. https://doi.org/10.1038/nmeth.2604
Eveborn D, Kong D, Gustafsson JP (2012) Wastewater treatment by soil infiltration: long-term phosphorus removal. J Contam Hydrol 140:24–33. https://doi.org/10.1016/j.jconhyd.2012.08.003
Fierer N, Lauber CL, Ramirez KS, Zaneveld J, Bradford MA, Knight R (2012) Comparative metagenomic, phylogenetic and physiological analyses of soil microbial communities across nitrogen gradients. ISME J 6:1007–1017. https://doi.org/10.1038/ismej.2011.159
Gonzalez-Tineo PA, Duran-Hinojosa U, Delgadillo-Mirquez LR, Meza-Escalante ER, Gortares-Moroyoqui P, Ulloa-Mercado RG, Serrano-Palacios D (2020) Performance improvement of an integrated anaerobic-aerobic hybrid reactor for the treatment of swine wastewater. J Water Process Eng. https://doi.org/10.1016/j.jwpe.2020.101164
Gu B et al (2016) Socioeconomic constraints on the technological choices in rural sewage treatment. Environ Sci Pollut Res 23:20360–20367. https://doi.org/10.1007/s11356-016-7267-z
Guan Y, Chen X, Zhang S, Luo A (2012) Performance of multi-soil-layering system (MSL) treating leachate from rural unsanitary landfills. Sci Total Environ 420:183–190. https://doi.org/10.1016/j.scitotenv.2011.12.057
Guo J, Zhou Y, Jiang S, Chen C (2019) Feasibility investigation of a multi soil layering bioreactor for domestic wastewater treatment. Environ Technol 40:2317–2324. https://doi.org/10.1080/09593330.2018.1441331
Ho C-C, Wang P-H (2015) Efficiency of a multi-soil-layering system on wastewater treatment using environment-friendly filter materials. Int J Environ Res Public Health 12:3362–3380. https://doi.org/10.3390/ijerph120303362
Igbinosa EO, Okoh AI (2009) Impact of discharge wastewater effluents on the physico-chemical qualities of a receiving watershed in a typical rural community. Int J Environ Sci Technol 6:175–182
Konneke M, Bernhard AE, de la Torre JR, Walker CB, Waterbury JB, Stahl DA (2005) Isolation of an autotrophic ammonia-oxidizing marine archaeon. Nature 437:543–546. https://doi.org/10.1038/nature03911
Kuronen M, Harjula R, Jernstrom J, Vestenius M, Lehto J (2000) Effect of the framework charge density on zeolite ion exchange selectivities. Phys Chem Chem Phys 2:2655–2659. https://doi.org/10.1039/b001353f
Larsen P, Nielsen JL, Otzenj D, Nielsen PH (2008) Amyloid-like adhesins produced by floc-forming and filamentous bacteria in activated sludge. Appl Environ Microbiol 74:1517–1526. https://doi.org/10.1128/aem.02274-07
Latrach L, Masunaga T, Ouazzani N, Hejjaj A, Mahi M, Mandi L (2015) Removal of bacterial indicators and pathogens from domestic wastewater by the multi-soil-layering (MSL) system. Soil Sci Plant Nutr 61:337–346. https://doi.org/10.1080/00380768.2014.974480
Latrach L, Ouazzani N, Hejjaj A, Zouhir F, Mahi M, Masunaga T, Mandi L (2018) Optimization of hydraulic efficiency and wastewater treatment performances using a new design of vertical flow multi-soil-layering (MSL) technology. Ecol Eng 117:140–152. https://doi.org/10.1016/j.ecoleng.2018.04.003
Li P, Zheng T, Li L, Ma Y, Sun X, Liu J (2020) An appropriate technique for treating rural wastewater by a flow step feed system driven by wind-solar hybrid power. Environ Res. https://doi.org/10.1016/j.envres.2020.109651
Liu C et al (2018) Nitrogen removal performance and microbial community changes in subsurface wastewater infiltration systems (SWISs) at low temperature with different bioaugmentation strategies. Bioresour Technol 250:603–610. https://doi.org/10.1016/j.biortech.2017.11.089
Luanmanee S, Attanandana T, Masunaga T, Wakatsuki T (2001) The efficiency of a multi-soil-layering system on domestic wastewater treatment during the ninth and tenth years of operation. Ecol Eng 18:185–199. https://doi.org/10.1016/s0925-8574(01)00077-5
Luanmanee S, Boonsook P, Attanandana T, Wakatsuki T (2002) Effect of organic components and aeration regimes on the efficiency of a multi-soil-layering system for domestic wastewater treatment. Soil Sci Plant Nutr 48:125–134. https://doi.org/10.1080/00380768.2002.10409182
Ma L, He F, Huang T, Zhou Q, Zhang Y, Wu Z (2016) Nitrogen and phosphorus transformations and balance in a pond-ditch circulation system for rural polluted water treatment. Ecol Eng 94:117–126. https://doi.org/10.1016/j.ecoleng.2016.05.051
Mahmoud N, van Lier JB (2011) Enhancement of a UASB-septic tank performance for decentralised treatment of strong domestic sewage. Water Sci Technol 64:923–929. https://doi.org/10.2166/wst.2011.690
Mehrani MJ, Sobotka D, Kowal P, Ciesielski S, Makinia J (2020) The occurrence and role of nitrospira in nitrogen removal systems. Bioresour Technol. https://doi.org/10.1016/j.biortech.2020.122936
Pan J et al (2016) Pollutants removal in subsurface infiltration systems by shunt distributing wastewater with/without intermittent aeration under different shunt ratios. Biores Technol 218:101–107. https://doi.org/10.1016/j.biortech.2016.06.079
Quast C et al (2013) The SILVA ribosomal RNA gene database project: improved data processing and web-based tools. Nucleic Acids Res 41:D590–D596. https://doi.org/10.1093/nar/gks1219
Ramirez KS, Craine JM, Fierer N (2012) Consistent effects of nitrogen amendments on soil microbial communities and processes across biomes. Glob Change Biol 18:1918–1927. https://doi.org/10.1111/j.1365-2486.2012.02639.x
Sato K, Masunaga T, Wakatsuki T (2005) Characterization of treatment processes and mechanisms of COD, phosphorus and nitrogen removal in a multi-soil-layering system. Soil Sci Plant Nutr 51:213–221. https://doi.org/10.1111/j.1747-0765.2005.tb00025.x
Sklenickova K, Kolousek D, Pecenka M, Vejmelkova D, Slouf M, Ruzickova I (2020) Application of zeolite filters in fish breeding recirculation systems and their effect on nitrifying bacteria. Aquaculture. https://doi.org/10.1016/j.aquaculture.2019.734605
Su C et al (2020) Removal efficiency and pathways of phosphorus from wastewater in a modified constructed rapid infiltration system. J Clean Prod. https://doi.org/10.1016/j.jclepro.2020.122063
Tourna M et al (2011) Nitrososphaera viennensis, an ammonia oxidizing archaeon from soil. Proc Natl Acad Sci U S A 108:8420–8425. https://doi.org/10.1073/pnas.1013488108
Xing W, Li D, Li J, Hu Q, Deng S (2016) Nitrate removal and microbial analysis by combined micro-electrolysis and autotrophic denitrification. Biores Technol 211:240–247. https://doi.org/10.1016/j.biortech.2016.03.044
Yuan Y et al (2014) Fine-tuning key parameters of an integrated reactor system for the simultaneous removal of COD, sulfate and ammonium and elemental sulfur reclamation. J Hazard Mater 269:56–67. https://doi.org/10.1016/j.jhazmat.2013.12.014
Zhang T, Shao MF, Ye L (2012) 454 pyrosequencing reveals bacterial diversity of activated sludge from 14 sewage treatment plants. ISME J 6:1137–1147. https://doi.org/10.1038/ismej.2011.188
Zhang Y, Cheng Y, Yang C, Luo W, Zeng G, Lu L (2015) Performance of system consisting of vertical flow trickling filter and horizontal flow multi-soil-layering reactor for treatment of rural wastewater. Biores Technol 193:424–432. https://doi.org/10.1016/j.biortech.2015.06.140
Acknowledgements
This work was financially supported by the National Science and Technology Major Project of China (Grant Number 2017ZX07206004).
Author information
Authors and Affiliations
Contributions
Investigation: ZF, YM, YZ, XL, SP, RJ, YZ; Data curation and Visualization: ZL; Methodology: AL; Writing – original draft preparation: ZL; Writing – reviewing and editing: AL, YW, YM, YZ; Supervision and Funding: YW.
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper.
Ethical approval
Approval for submission has been received explicitly from all co-authors, and authors whose names appear on the submission have contributed sufficiently to the scientific work and therefore share collective responsibility and accountability for the results.
Informed consent
Informed consent was obtained from all the individual participants included in the study.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Fan, Z., Liang, Z., Luo, A. et al. Effect on simultaneous removal of ammonia, nitrate, and phosphorus via advanced stacked assembly biological filter for rural domestic sewage treatment. Biodegradation 32, 403–418 (2021). https://doi.org/10.1007/s10532-021-09928-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10532-021-09928-z