Skip to main content
SpringerLink
Log in

Sugarcane bagasses sewage sludge compost as a plant growth substrate and an option for waste management

  • Original Paper
  • Published:
Clean Technologies and Environmental Policy Aims and scope Submit manuscript

Abstract

The possible utilization of sugarcane bagasses sewage sludge-based compost (BSC) as a substitution for widely using expensive peat in growth media for a horticultural crop, lettuce (Lactuca sativa L.), was evaluated. Five different treatments having different percentages of BSC and peat were established. Percentages of BSC addition to peat were 0, 10, 25, 40, and 60% v/v, respectively. Physical and chemical characteristics of different growth media were undertaken. Plant growth parameters and nutrient composition of lettuce plants were determined. In general, the proposed growing media created with peat and BSC had adequate physical and chemical properties and notable contents of plant nutrients, mainly P, K, Ca, and Mg. Moreover, BSC addition to peat enhanced the nutrient content in lettuce plants compared to plants grown in peat-only substrate. The highest increases of growth and yield parameters were obtained in the treatment having BSC and peat at 25 and 75% of the total volume, respectively. The shoot fresh weight, shoot dry weight, root fresh weight, and root dry weight obtained from the media having BSC and peat at 25 and 75% were increased by 53.25, 43.32, 36.27, and 56.88%, respectively, compared to peat control. In addition, the mixture with the most BSC (60%) gave the greatest contents of K, Mg, Ca, Cu, Zn, Cr, and Pb. Trace element concentrations in plant tissues grown in media with BSC and peat were far below than the ranges considered phytotoxic for plants. These results indicate that these BSC-based media is a viable alternative to expensive peat for cultivation of lettuce.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

Abbreviations

BSC:

Bagasses sewage sludge-based compost

OM:

Organic matter

EC:

Electrical conductivity

References

  • Abad M, Martınez PF, Martınez MD, Martınez J (1993) Evaluacion agronomica de los sustratos de cultivo (Agronomic evaluation of substrates). Acta Hortic 11:141–154

    Google Scholar 

  • Abad M, Noguera P, Bures S (2001) National inventory of organic wastes for use as growing media for ornamental potted plant production: case study in Spain. Bioresour Technol 77:197–200

    Article  CAS  Google Scholar 

  • Abad M, Fornes F, Carrion C, Noguera V, Noguera P, Maquieira A (2005) Physical properties of various coconut coir dusts compared to peat. HortScience 40:2138–2144

    Google Scholar 

  • Adriano DC (2001) Trace elements in terrestrial environment. Biogeochemistry, bioavailability, and risks of metals. Springer, New York

    Google Scholar 

  • Andrés P, Mateos E, Tarrasón D, Cabrera C, Figuerola B (2011) Effects of digested, composted, and thermally dried sewage sludge on soil micro biota and mesofauna (2011). Appl Soil Ecol 48(2):236–242

    Article  Google Scholar 

  • Atiyeh RM, Edwards CA, Subler S, Metzger JD (2001) Pig manure vermicompost as a component of a horticultural bedding plant medium: effects on physicochemical properties and plant growth. Biores Technol 78:11–20

    Article  CAS  Google Scholar 

  • Begum A (2011) Evaluation of municipal sewage sludge vermicompost on two cultivars of tomato (Lycopersicon esculentum) plants. Int J ChemTech Res 3(3):1184–1188

    Google Scholar 

  • Benito M, Masaguer A, De Antonio R, Moliner A (2005) Use of pruning waste compost as a component in soil-less growing media. Bioresour Technol 96:597–603

    Article  CAS  Google Scholar 

  • Bragg NC, Walter J, Stentiford E (1993) The use of composted refuse and sewage as substrate additives for container grown plants. Acta Hortic 342:155–165

    Google Scholar 

  • Bugbee GJ, Frink CR (1996) Growth of Rhododendron, Rudbeckia and Thujia and the leaching of nitrates as affected by the pH of potting media amended with biosolids compost. Compos Sci Util 4:53–59

    Google Scholar 

  • Bunt AC (1988) Media and mixes for container-grown plants. Unwin Hyman Ltd., London, p 309

    Book  Google Scholar 

  • Bures S (1997) Sustratos (substrates). Ediciones Agrotecnicas S.L, Madrid

    Google Scholar 

  • Chandra M, Sathiavelu S (2009) Waste management in the olive oil industry in the Mediterranean region by composting. Clean Technol Environ Policy 11:293–298

    Article  CAS  Google Scholar 

  • Chapman HP (1966). Diagnostic criteria for plants and soils, University of California. Division of Agricultural and Natural Science. Oakland, CA, USA

  • De Boodt M, Verdonck O (1972) The physical properties of the substrates in horticulture. Acta Hortic 26:37–44

    Google Scholar 

  • Eklind Y, Ramert B, Wivstad M (2001) Evaluation of growing media containing farmyard manure compost, household waste compost or chicken manure for the propagation of lettuce (Lactuca sativa L.) transplants. Biol Agric Hortic 19:157–181

    Article  Google Scholar 

  • Gallardo-Lara F, Nogales R (1987) Effect of application of town refuse compost on the soil-plant system: a review. Biol Wastes 19:35–62

    Article  CAS  Google Scholar 

  • Garcia-Gomez A, Bernal MP, Roig A (2002) Growth of ornamental plants in two composts prepared from agro-industrial wastes. Bioresour Technol 83:81–87

    Article  CAS  Google Scholar 

  • Glenn J (1999) 11th Annual biocycle nationwide survey, the state of garbage in America. Biocycle 40(4):60–71

    Google Scholar 

  • Grigatti M, Ciavatta C, Gessa C (2004) Evolution of organic matter from sewage sludge and garden trimming during composting. Bioresour Technol 91:163–169

    Article  CAS  Google Scholar 

  • Guerrero F, Gasco JM, Hernandez-Apaolaza L (2002) Use of pine bark and sewage sludge compost as components of substrates for Pinus pinea and Cupressus arizonica production. J Plant Nutr 25(1):129–141

    Article  CAS  Google Scholar 

  • Ingelmo F, Canet R, Ibanez MA, Pomares F, Garcia J (1998) Use of MSW compost, dried sewage sludge and other wastes as partial substitutes for peat and soil. Bioresour Technol 63:123–129

    Article  CAS  Google Scholar 

  • Kumar PR, Jayaram A, Somashekar RK (2009) Assessment of the performance of different compost models to manage urban household organic solid wastes. Clean Technol Environ Policy 11(4):473–484

    Article  CAS  Google Scholar 

  • Lakhdar A, Rabhi M, Ghnaya T, Montemurro F, Jedidi N, Abdelly C (2009) Effectiveness of compost use in salt-affected soil. J Hazard Mater 171:29–35

    Article  CAS  Google Scholar 

  • Loneragan JF, Snowball K (1969) Calcium requirements of plants. Aus J Agric Res 20:465–478

    Article  CAS  Google Scholar 

  • Madejon E, Perez de Mora A, Felipe E, Burgos P, Cabrera F (2006) Soil amendments reduce trace element solubility in a contaminated soil and allow regrowth of natural vegetation. Environ Pollut 139:40–52

    Article  CAS  Google Scholar 

  • Marschner H (1995) Mineral nutrition of higher plants. Academic Press, London

    Google Scholar 

  • Matsuoka M (2006) Sugarcane cultivation and sugar industry in Japan. Sugar Technol 8:3–9

    Article  Google Scholar 

  • Murillo JM, Cabrera F, Lopez R, Martın-Olmedo P (1995) Testing low-quality urban composts for agriculture: germination and seedling performance of plants. Agric Ecosyst Environ 54:127–135

    Article  Google Scholar 

  • Nappi P, Barberis R (1993) Compost as growing medium: chemical, physical and biological aspects. Acta Hortic 342:249–256

    Google Scholar 

  • Navarro AF, Cegarra J, Roig A, Garcıa D (1993) Relationships between organic matter and carbon contents of organic wastes. Bioresour Technol 44:203–207

    Article  CAS  Google Scholar 

  • Noguera P, Abad M, Puchades R, Maquieira A, Noguera V (2003) Influence of particle size on physical and chemical properties of coconut coir dust as a container medium. Commun Soil Sci Plant Anal 34:593–605

    Article  CAS  Google Scholar 

  • Perez-Murcia MD, Moral R, Moreno-Caselles J, Perez-Espinosa A, Paredes C (2006) Use of composted sewage sludge in growth for broccoli. Bioresour Technol 97:123–130

    Article  CAS  Google Scholar 

  • Pill WG, Tilmon HD, Taylor RW (1995) Nitrogen enriched ground Canaf stem core as a component of soil less growth media. J Hortic Sci 70(4):673–681

    Google Scholar 

  • Pinamonti F, Stringari G, Zorzi G (1997) Use of compost in soilless cultivation. Compos Sci Util 5:38–46

    Google Scholar 

  • Poole RT, Conover CA, Joiner JN (1981) Soils and potting mixtures. In: Joiner JN (ed) Foliage plant production. Pretince-Hall, Engle-wood Cliffs, pp 179–202

    Google Scholar 

  • Raviv M, Chen Y, Inbar Y (1986) Peat and peat substitutes as growth media for container-grown plants. In: Chen Y, Avnimelech Y (eds) The role of organic matter in modern agriculture. Martinus Nijhoff Publishers, Dordrecht, pp 257–287

    Chapter  Google Scholar 

  • Ribeiro HM, Vasconcelos E, Dos Santos JQ (2000) Fertilization of potted geranium with municipal solid waste compost. Bioresour Technol 73:247–249

    Article  CAS  Google Scholar 

  • Richards D, Lane M, Beardsell DV (1986) The influence of particle size distribution in pinebark:sand:brown coal potting mixes on water supply, aeration and plant growth. Sci Hortic 29:1–14

    Article  Google Scholar 

  • Romheld V, Marschner H (1991) Functions of micronutrients in plants. In: Mordvedt JJ, Cox FR, Shuman LM, Welch RM (eds) Micronutrient in agriculture, SSSA Book Series No. 4. Madison, pp 297–328

  • Rynk RM, Van der Kamp GG, Wilson ME, Singley ME, Richard TI, Kolega JJ, Gouin FR, Laliberty I Jr, Kay D, Murphy DW, Hoitink HAJ, Brinton WF (1992) On farm composting handbook. Northeast Regional Agricultural Engineering Service, Ithaca

    Google Scholar 

  • Sanchez-Monedero MA, Bernal MP, Anton A, Noguera P, Abad A, Roig A, Cegarra J (1997).Utilizacion del compost como sustratos para semilleros de plantas horticolas en cepellon. In: Proceedings of the I congreso iberico y III nacional de fertirrigacion, SEFV Ed., Murcia, pp 78–85

  • Sanchez-Monedero M, Roig A, Cegarra J, Bernal M, Noguera P, Abad M, Anton A (2004) Composts as media constituents for vegetable transplant production. Compos Sci Util 12:161–168

    Google Scholar 

  • SAS Institute (1990) SAS User’s Guide, Version 6, 4th edn. SAS Institute, Cary

    Google Scholar 

  • Song U, Lee EJ (2010) Environmental and economical assessment of sewage sludge compost application on soil and plants in a landfill. Recycling 54(12):1109–1116

    Article  Google Scholar 

  • Spomer LA (1990) Evaluating drainage in container and other shallow drained horticultural soils. Commun Soil Sci Plant Anal 21(3–4):221–235

    Article  Google Scholar 

  • Teres V, Sainz de la Maza E, Lezaum M, Leunza A, Artetxe A, Zabala A (1997) Characterizatio fisica de distintos sustratosen base a compost de lode de depuradora. Act Hortic 19:338–348

    Google Scholar 

  • United States Environmental Protection Agency (1996) Method 3051, Microwave assisted acid digestion. In: Test methods for evaluating solid waste, physical/chemical methods, 3rd edn. US Environmental Protection Agency, Office of Solid Waste and Emergency Response. US Government Printing Office, Washington, DC, USA

  • United States Environmental Protection Agency (1999) Solid waste and emergency response. 5306W. Biosolids, generation, use, and disposal in the United States. EPA 530-R-99-009

  • Wilson SB, StoVella PJ, Graetz DA (2001) Use of compost as media amendment for containerized production of two subtropical perennials. J Environ Hortic 19:37–42

    Google Scholar 

  • Zhang J, Zeng G, Chen Y, Yu M, Yu Z, Li H, Yu Y, Huang H (2011) Effects of physico-chemical parameters on the bacterial and fungal communities during agricultural waste composting. Bioresour Technol 102:2950–2956

    Article  CAS  Google Scholar 

Download references

Acknowledgments

Most sincere thanks and appreciation are extended to the Higher Education Ministry Japan (Monbukagakusho) for the financial support granted to conduct this study. Thanks are also due to all members of Department of Environmental Science and Technology, Faculty of Agriculture, University of the Ryukyus, Japan for their assistance given through out the period of study.

Author information

Authors and Affiliations

  1. The United Graduate School of Agricultural Sciences, Kagoshima University, 1-21-24, Korimoto, Kagoshima, 890-0065, Japan

    G. Y. Jayasinghe

  2. Department of Agricultural Engineering, Faculty of Agriculture, University of Ruhuna, Mapalana, Sri Lanka

    G. Y. Jayasinghe

Authors
  1. G. Y. Jayasinghe
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to G. Y. Jayasinghe.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Jayasinghe, G.Y. Sugarcane bagasses sewage sludge compost as a plant growth substrate and an option for waste management. Clean Techn Environ Policy 14, 625–632 (2012). https://doi.org/10.1007/s10098-011-0423-8

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10098-011-0423-8

Keywords

Search

Navigation