Abstract
In this study the thermal characteristics of horizontal mantle heat exchangers are investigated for application in active solar water heaters. Some important parameters such as flow rate, thermal short circuit, average temperature, and convection heat transfer coefficient and inlet velocity have been investigated too. The results show that the thermal efficiency of the storage tank is critically impaired by the effect of short circuit phenomenon and mixing caused by turbulence.
Similar content being viewed by others
Abbreviations
- \( A \) :
-
The area between tank and mantle (m2)
- \( C_{p} \) :
-
Specific heat at constant pressure (J/kg K)
- \( \overline{{h_{o} }} \) :
-
Mean convective heat transfer coefficient of mantle wall (W/m2 K)
- \( \dot{m}_{m} \) :
-
Inlet mass flow rate into mantle (L/min)
- \( t \) :
-
Time (s)
- \( \overline{{T_{in} }} \) :
-
Average temperature of inlet to mantle (°C)
- \( \overline{{T_{out} }} \) :
-
Average temperature of outlet from mantle (°C)
- \( \overline{{T_{m} }} \) :
-
Average water temperature in mantle (°C)
- \( \overline{{T_{s} }} \) :
-
Average temperature of inner surface of the tank (°C)
- \( T_{ci} \) :
-
Temperature of inlet water into tank (°C)
- \( V \) :
-
Volume of hot water drawn off (L)
- \( v_{j} \) :
-
Volume of j th layer (m3)
- \( E_{out} \) :
-
Storage energy into the tank before draw offs
- \( E_{st} \) :
-
Used energy of tank during draw offs
- ρ :
-
Density (kg/m3)
- η :
-
Efficiency
- m :
-
Mantle
- in :
-
Inlet
- out :
-
Outlet
- s :
-
Surface wall
- T out :
-
Temperature of outlet water from tank (°C)
- T j :
-
Average temperature of j th thermocouples (°C)
- t :
-
Required time for water draw-offs (s)
References
Consul R, Rodrıguez I, Perez-Segarra CD, Soria M (2004) Virtual prototyping of storage tanks by means of three-dimensional CFD and heat transfer numerical simulations. Sol Energy 77:179–191
Collares-Pereira M, Gordon JM, Rabl A, Zarmi Y (1984) Design and optimization of solar industrial hot water systems with storage. Sol Energy 32:121–133
Alizadeh S (1999) An experimental and numerical study of thermal stratification in a horizontal cylindrical solar storage tank. Sol Energy 66(6):409–421
Lavan Z, Thompson J (1977) Experimental study of thermally stratified hot water storage tanks. Sol Energy 19:519–524
Zurigat YH, Maloney KJ, Ghajar AJ (1989) Comparison study of one-dimensional models for stratified thermal storage tanks. ASME J Sol Energy Eng 111:205–210
Shyu RJ, Lin JY, Fang LJ (1989) Thermal analysis of stratified storage tanks. ASME J Sol Energy Eng 111:54–61
Wildin MW, Mackie EI, Harrison WE (1990) Stratified thermal storage: a new/old technology. ASHRAE J 32(4):29–40
Altuntop N, Kilik Z, Ozceyhan V, Kincay O (2006) Effect of water inlet velocity on thermal stratification in a mantled hot water storage tank. Int J Energy Res 30:163–176
Young MF, Baughn JW (1981) An investigation of thermal stratification in horizontal storage tanks. ASME J Sol Energy Eng 103:286–290
Shah LS and Furbo S (1996) Optimization of mantle tanks for low flow solar heating systems. Euro Sun (special issue S-9601)
Ghaddar NK, Al-Marafie AM, Al-Kandari A (1989) Numerical simulation of stratification behavior in thermal storage tanks. Appl Energy 32:225–239
Andersen E and Furbo S (1999) Thermal destratification in small standard solar tanks due to mixing during tapping. In: Proceedings of the ISES solar world congress, vol III, Jerusalem, Israel, pp 111–119
Taherian H and Aghajani M (2004) Analysis of the effect of width of the mantle on heat transfer in hot water storage horizontal tank. 12th Annual Mechanical Engineering Conference of the Iranian Society for Mechanical Engineers, Tehran, Iran
Taherian H and Rahimi M (2006) Experimental study of heat transfer coefficient and thermal stratification in horizontal mantle tanks. 14th Annual Mechanical Engineering Conference of the Iranian Society for Mechanical Engineers, Isfahan, Iran
Taherian H and Jannatabadi M (2007) Experimental study of heat transfer in horizontal storage tank with hot water consumption. 2nd Annual Mechanical Engineering Conference of Azad University, Rey, Iran
Sezai I, Aldabbagh LBY, Atikol U, Hacisevki H (2005) Performance improvement by using dual heaters in a storage-type domestic electric water-heater. Appl Energy 81:291–305
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Jannatabadi, M., Taherian, H. An experimental study of influence of hot water consumption rate on the thermal stratification inside a horizontal mantle storage tank. Heat Mass Transfer 48, 1103–1112 (2012). https://doi.org/10.1007/s00231-011-0958-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00231-011-0958-6